Craftsman 917.25552 инструкция обслуживания

OWNER'S MANUAL MODEL NO. 917.255520 Caution: Read and follow all Safety Rules and Instructions Before Operating This Equ=pment .................................. ::::iii,_ ........ ® o Assembly o Operation ° Maintenance ° Service and Adjustment ° Repair Parts ,,ll i , i I,IMll, II,l,lllllllll IIllll Sears, Roebuck and Co., Chicago, IL 6068[...]

SAFETY RULES CAUTION: ALWAYS DISCONNECT SPARK PLUG WtREAND PLACE WIRE WHERE IT CANNOT CONTACTSPARK & PLUG TO PREVENT ACCIDENTAL STARTING WHEN SETTING-UP, TRANSPORTING, ADJUSTING OR MAKING REPAIRS INPORTANT SAFETY STANDARDS REQUIRE O PERATOR PRESENCE CONTROLS TO MINIMIZE THE RISK OF INJURY, YOUR UNIT IS EQUIPPED WITH SU CH CONTROLS, DO NOT ATTEM[...]

CONGRATULATIONS on your purchase of a Sears Tractor. It has been designed, engineered and manu- factured to give you the best possible dependability and performance. Should you experience any problem you cannot easily remedy, please contact your nearest Sears Service Center!Department. We have competent, well-trained technicians and the proper tool[...]

TABLE OF CONTENTS SAFETY RULES ............................................................ 2 PRODUCT SPECIFICATIONS ....................................... 3 CUSTOMER RESPONSIBILITIES ................................ 3 WARRANTY ................................................................... 3 TABLE OF CONTENTS .................................[...]

................ • ill,ll,i i i1,111 ii ii1,11111111,1111. ,llllll i, ACCESSORIES AN ATTACH ENTS iii These accessories and attachments were available when the unit was purchased, They are also available at most Sears retail outlets, catalog and service centers. Most Sears stores can order these items for you when you provide the model number of y[...]

i , u n n n n n i,nll lul, ii ,, I, u un,I,,,,HW,I,,I CONTENTS OF Parts Bag contents shown full size , n,,, ,,i ,u,,,,,,, (2) Sheet Meta! Screws #10-16 x 1/2 (1) Locknut 1/2o20 (1) 2-t/4" Dis, Washer (I) Shoulder' Bolt 5/t6q8 (1) Hex Bolt 1/2-13 x 1 @ (1) Washer 17/32 x 1-3/16 x 12 Ga, (1) Lockwasher 1/2 @ (2) Hex Nuts 1/4-20 (2) Hex Bolt[...]

ASSEM ii iii iii, u., TOOLS REQUIRED FOR ASSEMBLY A socket wrench set will make assembly easier Standard wrench sizes are listed, (1) 5/16" wrench (2) 7118" wrenches (1) 1/2" wrench (1) 9/16" wrench (1) 3/4" wrench Tire pressure gauge Screwdriver Utility knife When right and left hand is mentioned in this manual, it means w[...]

AS E LY HOW TO SET UP YOUR TRACTOR PREPARE BATTERY (See Fig, 2) CAUTION: Wear eye and face shield. Wash hands or clothing immediately tf accldent ally In contact with battery acid, Do not smoke. Fumes from charged battery acid are explosive. Read the instructions included with the battery vent caps. Alwayswear gloves, clotMng and goggles to protect[...]

ASSEMBLY INSTALL BATTERY (See Figs. 4 & 5) CAUTION: Do not short battery termi- nals. Before Installing battery, remove metal bracelets, wristwatch bands, rings, etco Positive terminal must be connected first to prevent sparking from acciden- tal grounding, • Lift seat to raised position • Lower battery into fender welt with battery termina[...]

KNOW YOUR TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and adjustments, Save this manual for future reference, LIGHTSWITCH_ THROTTL_CHOKE CONTROL CLUTCH/BRAKE PEDAL PARKING BRAKE ATTACHMENT CLUTCH LEVER [...]

, , ,, ,,, , ,, i OPERATION your tractor or performing any adjustments or repairs We recommend wide vision safe_y mask for over the spectacles or standard safety glasses, available at Sears Retail or Catalog stores HOW TO USE YOUR TRACTOR TO SET PARKING BRAKE (See Fig. 7) • Depress clutch/brake pedal into full "BRAKE" position and hold [...]

OPERATUON TO OPERATE MOWER (See Fig. 8) Your' unit is equipped with an operator presence sensing switch. Any attempt by the operator to leave the seat with the engine running and the attachment clutch engaged will shut off the engine, • Select desired height of cut . Engagemower by slowly moving attachment clutch lever to ENGAGED' posit[...]

, =,,,= , , = =,, ,,,,,,,,,,,, ,, ,, m,m,L, OPERATION TO START ENGINE (See Fig. 7) When starting engine for the first time or if engine has run out of fuel, it will take extra cranking time to move fuel from the tank to the engine • Depress the clutch/brake pedal and set the parking brake. • Place gearshift lever in "NEUTRAL" position[...]

MAINTENANCE MAINTENANCE SCHEDULE _"___/_o_,,_._ '_ AS You COMPLETE REGU_R SERVICE ATES Check Brake Operation _ Check Tire Pressure ...... ,Check for Loose Fas!e,ners,, , Sharpen/Replace Mower Blades T Check Battery Level/Recharge 0 Clean Battery and Terminals R Check Transmission Cooling Adjust Blade Belt(s) Tension Adjust Motion Drive Be[...]

ii AINTENANCE i llll,ll i i i ...................... TRACTOR Always observe safety rules when performing any mainte- nance TIRES • Maintain proper air pressure in all tires (See "PROD- UCT SPECIFICATIONS" on page 3 of this manual), • Keep tires free of gasoline, oil, or insect control chemi- cals which can harm rubber • Avoid stumps[...]

MAINTENANCE , 111 ,, 11,,1,,1,, , ,, , ,,, ,1,,, ,, =H, = BATTERY (See Fig. 12) • Catch oil in a suitable container, • Remove oil fill dipstick° Be careful not to allow dirt to Your unit has a battery charging system which is sufficient for normal use. However, periodic charging of the battery with an automotive charger will extend it's l[...]

COVER KNOB _ T ,=, ,, ,,, MAINTENANCE MUFFLER Inspect and replace corroded muffler and spark arrester (if equipped) as it could create a fire hazard and/or damage. FIG. 14 AIR SCREEN (See Fig. 13) The engine air screen must be kept free of dirt and chaff to prevent engine damage from overheating. Clean with a wire brush or compressed air to remove [...]

...................................... I,,L= i i ,i i i ill,i ,,,,,, r ' i i_ , ERV CE A D ADJUSTMENTS CAUTION: BEFORE PERFORMING ANY SERVICE OR ADJUSTMENTS; . Depress clutch/brake pedal fully and set parking brake. • Place gearshift lever in "NEUTRAL" position. • Place attachment clutch in "DISENGAGED" position° • T[...]

BOTTOM OF CURL GROUND LINE FIG. 18 SIDE TO SIDE ADJUSTMENT TRUNNION REAR SUSPENSION ARM BOTTOM OF CURL D'['_ REAR SUSPENSION TRUNNION FIG. 2O NUT"E" REAR SUSPENSION TRUNNION NUT "F" =-t* D GR OU ND J LINE LIFTBRACKET FIG. 21 FIG. 19 FRONT-TO=BACK ADJUSTMENT(See Figs. 20 and 2I) - To obtain the best cutting results,[...]

w t S1ERVUCE AN ADJUSTMENTS TO ADJUST MOWER BLADE DRIVE BELT (See Fig. 22) Your tractor has been manufactured with the ability to readjust the mower blade drive belt to provide you with longer belt life. With the engine off and the lift lever in the highest po- sition, move clutch lever up slowly until resistance is felt. If distance from bottom of[...]

$ERVUCE i ii iii ill ii illll ,Ulllllllllll,l,,,i TO ADJUST BRAKE (See Fig. 24) Your unit is equipped with an adjustable brake system which is mounted on the right side of the transaxle if unit requires more than six (6) feet stopping distance at high speed in highest gear, then brake must be adjusted. • Depress clutch/brake pedal and engage park[...]

m SERVICE AN i i i i lll illllUlllllliHlll i i,!l,llll,ll,i TO ADJUST STEERING WHEEL ALIGNMENT If steering wheel crossbars are not horizontal (left to right) when wheels are positioned straight forward, remove steering wheel and reassemble per instructions in the Assembly section of this manual FRONT WHEEL TOE-IN/CAMBER The fiont wheel toe-in and c[...]

SERVICE AN TO REPLACE FUSE (See Fig. 29) Replace with 30 amp automotive-type plug-in fuse. The fuse holder is located in the engine compartment, directly in front of the dash. FUSE HOLDER ADJUSTMENTS ii iiii NIIIII, ,NN,, ,,,,,, ,,, I L ,,JJU L_ III JlJI,,UUL HOOD CONNECTOR HOOD SPRING HINGEBRACKET FIG. 30 FIG, 29 TO REPLACE HEADLIGHT BULB • Rais[...]

,.............................. ,i,J,J,J,J,,=,l in = u ,,, ,=it,,, _*twm SERVICE AND ADJUSTMENTS nil n = nln ENGINE TO ADJUST THROTTLE CONTROL CABLE (See Fig. 32) The throttle control has been preset at the factory and ad- _dustment should not be necessary Check adjustment as escribed below before loosening cable tf adjustment is necessary, proceed[...]

Immediately prepare your tractor forstorage at the end of . Drain thefueltank, the season or if the unit will not beused for30days or more, CAUTION: Never store the tractor with gasoline in the tank inside a building where fumes may reach an open flame or spark, Allow the engine to cool before storing In any enclosure, TRACTOR Remove mower from tra[...]

TROUBLESHOOTING POmNTS PROBLEM CAUSE CORRECTION Will not start Hard to start Engfhe will not turn over Engine clicks but will not start Loss of power Excessive vibration iiiii n iiii nnl i UUll 1. Out of fuel. 2. Engine not"CHOKED"properly. 3. Engine flooded. 4 Bad sparkplug. 5. Dirty a{r filter. 6. Ditty fuel filter. 7. Water In fuel. &a[...]

_: ii HIIIIIIIIll I TROUBLESHOOTING POBNT$ PROBLEM CORRECTION Engine contlnuas to run when operator leaves seat with attachment clutch engaged Poorcut-uneven CAUSE 1 Faulty ope_to_sa_ p_sence cont_l system 1. Worn, bent or loose blade 2, Mower deck nottevel. 3_ Build-up of grass, leaves, and trash under mower 1 Check widng, switches and connections[...]

i ill illlll i illlllllll SERVICE NOTES ill i lllllllllllllll,ll i, ii, 28[...]

REPAIR PARTS 12.5 HP 38" RIDING LAWN TRACTOR -- MODEL NUMBER 917.255520 SCHEMATIC ÷Ill-- BATTERY RED [ ! WHITE IGNITION SWITCH cello FUSE 30 AMP RED 1 ?OLENO,O | '%. Of,' '- ,_J --_ ,O"_---O, i ...... ] BLACK CLUTCH/BRAKE (PEDAL UP) BLACK STARTER ATT'MENT CLUTCH (CLUTCH OFF) I L I I I I BLACK ..__.._ - , 8LAC4K - _ SE[...]

30[...]