Dacor OBS52 инструкция обслуживания

PLANNING GUIDE www .Dacor .com Phone: (800) 793-0093 Specifications are subject to change without notice. See installation instructions for additional details. 13.1 36”, 52” Wide Outdoor Grills 16” Wide Side Burner OB36, OB52, OBS36, OBS52, OBSB162 9 1/8" (232mm) 23 3/4" (603mm) 26 1/2" (673mm) 27” * (686mm) 36" (914mm) [...]

PLANNING GUIDE www .Dacor .com Phone: (800) 793-0093 Specifications are subject to change without notice. See installation instructions for additional details. 13.2 36”, 52” Wide Outdoor Grills 16” Wide Side Burner OB36, OB52, OBS36, OBS52, OBSB162 OBSB162 & OB/OBS/36/52 CUTOUT DIMENSIONS, FRONT VIEW (OBAD 36” Accessory Door Shown) 3/4&[...]

PLANNING GUIDE www .Dacor .com Phone: (800) 793-0093 Specifications are subject to change without notice. See installation instructions for additional details. 13.3 36”, 52” Wide Outdoor Grills 16” Wide Side Burner OB36, OB52, OBS36, OBS52, OBSB162 OBSB162 CUTOUT DIMENSIONS SIDE VIEW Junction Box T rim frame (accessory) 3/4" (19mm) Min. [...]

Installa tion Inst ru ctions Epi c ure ® Outdo or G r i ll Models: OB36, OBS36, OB52, OBS52 and OBSB162 Part No. 102032 Rev . J TESTED IN ACCORDANCE WITH THE LA TEST EDITION OF            ?[...]

Before Y ou Begin... Customer Ser vice Information All specifications subject to change without notice. Dacor assumes no liability for changes to specifications. Impor tant: Installer: • In the interest of safety and to minimize problems, read these installation instructions completely and care- fully before you begin the installation process.[...]

1 Impor tant Information About Safety Instructions The • Important Safety Instructions and warnings in these instructions are not meant to cover all possible problems and conditions that can occur . Use common sense and caution when installing, maintaining or oper- ating this or any other appliance. Always contact Dacor Customer Service about [...]

2 Impor tant Safety Instructions Read the use and care manual completely before • using this appliance. Use this appliance only for its intended use as • described in the use and care manual. Use it only to cook food. It is not designed for commercial, indus- trial or laboratory use. If you receive a damaged product, immediately con- •?[...]

3 Impor tant Safety Instructions W ARNING Do not leave children alone or unattended in the area • around the appliance. Do not allow children to oper- ate it, play with the controls, pull on the handle or touch other parts. Do not store items of interest to children on top of • or above the appliance. Children could be burned or injured w[...]

4 9 1/8" (232mm) 23 3/4" (603mm) 26 1/2" (673mm) 27” * (686mm) 36" (914mm) 25 1/8" (638mm) Product Dimensions Planning the Installation 9 1/8" (232mm) 23 3/4" (603mm) 26 1/2" (673mm) 27" * (686mm) 52" (1321mm) 25 1/8" (638mm) * T otal depth from back to front of handles is 30” (762mm) OB36 [...]

5 Planning the Installation 9 1/8" *** (232mm) 23 3/4" (603mm) 26 1/2" (673mm) 27" ** (686mm) 16" (406mm) Cut-out for outdoor grill Overall height Overall width ** T otal depth from back to front of knobs is 28 5/8” (727mm) *** T otal height with cover is 12” (305mm) Door depth: 1/4” 6mm) OBSB162 OBAD SERIES ACCESSOR [...]

6 Planning the Installation Location Planning - General Gas and Electric Power Requirements Prior to installation, the gas supply for natural gas or • whole house LP installations must meet the specifica- tions below . For natural gas or whole house LP installations, have a • qualified plumber or gas fitter install a 3/4 inch (19mm) or 1/[...]

7 Planning the Installation Location Planning - Enclosed Cabinets Maintain all minimum clearances specified on pages 7 • and 8. For proper outdoor grill operation, provide a flat, level • mounting surface with minimum 3/4” thickness. All models are designed to allow installation in combus- • tible or non-combustible base material s[...]

8 Planning the Installation Location Planning - Enclosed Cabinets (continued) 3/8" (10mm)ø Both sides 6" x 7" (152mm x 178mm) utility cutout Coutertop 25" (635mm) 24" (610mm) 8" (203mm) Min. to combustibles above the countertop surface, both sides 1 1/2" (38mm) 12 1/4" (31 1mm) 2" (51mm) OB(S)36 - 33 1/[...]

9 Planning the Installation Location Planning - Car t Installations Example of Grill Cart Location Maintain all minimum clearances shown between the • appliance and all surfaces behind and to the side of the appliance. Allow 26 inches minimum in front to open and close the • cabinet drawers. For proper grill and drawer operation, use the [...]

10 Par ts List Models OB36, OBS36, OB52 and OBS52: A Drip tray G Rotisserie rod and forks B Smoker box H Rotisserie motor C Warming rack J Light lens pry stick D Regulator assembly Match holder E Grills Cleaning cream F Flame spreaders Models OB52, OBS52 and OBSB162 K Side burner grate M Side burner heads (2) L Side burner cover N Side burner caps [...]

11 Installation Instructions D E H L N M P R J K F G D D Whole house natural gas or LP regulator* LP cylinder regulator OBS162, OB36 and OBS36 (PN 72310) LP cylinder regulator OB52 and OBS52 (PN 101578) * A whole house gas regulator comes standard with natural gas models. For whole house LP installations, replace the standard LP tank regulator and [...]

12 Car t Installation W ARNING Attach the appliance to the cart with all of the supplied • bolts before use. All gas and electrical connections should be made • after the grill is installed and bolted to the cart. T o avoid an explosion hazard, do not connect the cart • or appliance(s) to electrical power until after the gas supply s[...]

13 Optional Side Shelf Installation Install the front mounting bracket for the right side 1. shelf. Use two (2) of the provided button head fasten- ers and two (2) lock washers. T ighten into place using a 5/32” Allen wrench. Slide the slot on the inside of the shelf over the pin on 2. the mounting bracket. While holding the shelf in place, inser[...]

14 Install an approved flexible gas line from the regulator 3. to the gas shut-off valve. Gas Connection - LP Gas Cylinder Hose Connect the supplied 3/4” coupling and nipple to the 1. gas inlet at the back right bottom corner of the unit. Connect the included LP cylinder hose to the nipple. 2. Connecting the Gas Gas Connection - Natural Gas NOTE [...]

15 Installation Instructions Final Assembly and T est Assemble the Grill Open the canopy on the unit. 1. Insert the drip tray completely into the slot on the front 2. of the unit. Put the flame spreaders on the floor of the appliance, 3. inside the canopy . The large holes go toward the front of the unit. The holes are used to light the burners in [...]

16 Installation Instructions Final Assembly and T est (cont.) LP Cylinder Installation - Some Models W ARNING The largest recommended LP cylinder size for the • rollout tank shelf on the cart is five gallons. A five gallon portable liquid propane cylinder should be approximately 12 inches (305mm) in diameter and 18 inches (457mm) high,. It mus[...]

17 If the second or third attempt to ignite the burner is 6. not successful then turn all burner controls to the OFF position. If the grill or cooktop fails to operate properly , make 7. sure that powe r to the electrical outlet and gas supply are turned on and that all installation steps have been carefully followed. Check also for a tripped groun[...]

18 W iring Diagrams   [...]

19 W iring Diagrams   [...]

20 Notes[...]

21[...]

Dacor ● Phone: (800) 793-0093 ● F AX: (626) 403-3130 ● www.Dacor .com[...]

Us e and C are M anual Part No. 102033 R ev . H Style varies. model OB52 shown. T able of Contents Important Safety Instructions ................................ 1 Getting to Know Y our Outdoor Grill ......................... 4 Setting Up Y our Outdoor Grill ................................. 6 Operating Y our Outdoor Grill .........................[...]

© 2007 Dacor . all rights reserved.[...]

1 Impor tant Safety Instructions INSTALLER: LEA VE THESE INSTRUCTIONS WITH THE APPLIANCE. CUSTOMER: READ THIS USE AND CARE MANUAL COMPLETEL Y BEFORE USING THIS APPLIANCE. SA VE IT FOR FUTURE REFER - ENCE. IT CONT AINS IMPORT ANT USE AND CARE INFORMA TION. KEEP YOUR SALES RECEIPT OR CANCELED CHECK IN A S AFE PLACE. PROOF OF ORIGINAL PURCHASE DA TE I[...]

2 A MINIMUM clearance of 1/4 inch (6 mm) must be • maintained, inside the base enclosure below the countertop material, from all vertical surfaces on the sides of the appliance, except on model OBSB162. On model OBSB162 a minimum clearance of 1/4 inch (6 mm) must be maintained in back and 1/16 inch on the sides. A MINIMUM clearance of 3/4 inch (1[...]

3 Impor tant Safety Instructions W ARNING W ARNING Use this gas cooking appliance only outdoors. Do not • use it inside a building, garage or any other enclosed area. Use this outdoor grill and the rotisserie motor only • for their intended use as described in this manual. Use them only to cook food. They are not designed for commercial, indust[...]

4 Getting to Know Y our Outdoor Grill Outdoor Grill Features A Illumina™ Burner Control Knobs: Use the knobs to light and adjust the heat level for the v arious burners. The matching knob illuminates when a burner is on. The trim rings B , located behind each knob, prev ent liquids from getting into the outdoor grill’ s internal parts. C Canopy[...]

5 H H Getting to Know Y our Outdoor Grill Models OB52 and OBS52 Models OB36 and OBS36 Grill Cart: Model OBC36 Shown Not Shown: Cart Models OBC52 and OBCW52 Locking wheels B B B A A A D D F F I I J J E E G G V U R R P P T T N N O O M M L L K K C C Q Grill compartment Grill compartment[...]

6 Assembling the Cooktop Grill Compar tment Assembly W ARNING F ailure to remov e the plastic coating and packing • materials from the appliance before use will result in a fire hazard. T o av oid a suffocation hazard, keep all plastic and • packing materials out of reach of children. T o av oid the risk of fire, explosion or carbon • monoxid[...]

7 Setting Up Y our Outdoor Grill Side burner assembly - OB52, OBS52 and OBSB162 only Side burner cover Side burner grate Side burner cap Side burner base Grill compartment grates Flame spreaders Drip tra y W arming rack Side burner head Outdoor Grill Assembly - Model OBS52 shown[...]

8 Operating Y our Outdoor Grill LP T ank Connection Instructions for LP tank connection and use for outdoor grills equipped for use with a portable LP tank. W ARNING Dacor outdoor grills are factory equipped for use with either LP or natural gas. DO NOT A TTEMPT FIELD • CONVERSIONS FROM LP TO NA TURAL GAS OR FROM NA TURAL GAS TO LP . Use only a U[...]

9 Operating Y our Outdoor Grill T ank-less Gas Supply W ARNING Dacor outdoor grills are factory equipped for use with either LP or natural gas. DO NOT A TTEMPT FIELD CONVERSIONS FROM LP TO NA TURAL GAS OR FROM NA TURAL GAS TO LP . Before using your outdoor grill for the first time: Make sure the gas line has been install and check ed • for leaks [...]

10 Operating Y our Outdoor Grill Lighting the Bur ners W ARNING Do not light the appliance if you smell gas. Call for • service. T o av oid a fire or explosion hazard, light the burners • only as instructed. Keep all body parts away from the burners during lighting and use. EXPLOSION HAZARD • - Do not light the outdoor grill with the canopy c[...]

11 Operating Y our Outdoor Grill Lighting the Side Burners (OB52, OBS52 and OBSB162 Only) Each side burner control knob has an icon next to it to tell you which burner it oper ates. Push in on the knob and turn it counter-clock - 1. wise to the LIGHT/HIGH position. The knob will illuminate and the igniter for the burner will spark (click) repeatedl[...]

12 T o manually light the optional sear burner: Make sure the drip tr ay is in place. 1. Make sure all control knobs are in the 2. OFF position. Make sure the gr ate above the sear burner is in place. 3. If using a LP tank, turn the v alve on the top of the 4. tank, counter-clockwise, to the fully open position. Use the provided match holder or a l[...]

13 Slide both forks toward the center , skewering the 6. meat. Tighten both forks using the attached thumb screws. Attach the rotisserie motor to the side of the outdoor 7. grill by slipping the edge of the brack et down into the slot on the right side of the frame. The canop y must be open. Make sure the motor switch is in the off position. Plug 8[...]

14 Operating Y our Outdoor Grill Manual Lighting Procedure - Rotisserie Make sure the drip tr ay is in place. 1. Make sure all control knobs are in the 2. OFF position. If using a LP tank, turn the v alve on the top of the 3. tank, counter-clockwise, to the fully open position. Use the provided match holder or a long stem match 4. to light the burn[...]

15 Operating Y our Outdoor Grill With the canopy closed, preheat the outdoor grill to 5. a temperature of 225 to 300ºF . Make sure the burner under the smoker box is lit. Once the outdoor grill reaches the above temper ature r ange, allow an addi - tional 15 to 20 minutes for smoke to gather inside the grill compartment. Open the canopy and place [...]

16 Operating Y our Outdoor Grill Using the Optional Sear Burner Models OBS36 and OBS52 Only The optional infrared (IR) sear burner is located on the right side of the grill compartment. It quickly sears meat to lock in avor and juices. The meat also absorbs smok e and food aroma the burner produces when it v aporizes the grease and drippings. On[...]

17 Care and Cleaning Cleaning Instructions T o keep your outdoor grill looking and operating its • best, clean it after every use. Spills that remain on the parts may be very difcult to clean, especially if allowed to burn on. Certain types of food, such as tomatoes, citrus juices, vinegar , alcohol and milk can damage the nishes if you all[...]

18 Care and Cleaning Cleaning the Porcelain Grates and Warming Rack The standard grates and w arming rack that come with • the appliance are coated with a porcelain nish. F or everyday cleaning, use a soft cloth or non- abr asive pad with warm soapy water to clean all of the porce - lain parts. If necessary , tough stains may be remov ed by ap[...]

19 Care and Cleaning Cleaning the Optional Side Burners IMPORT ANT Cover the side burners with the included stainless • steel burner cover when they are not in use and cool. Doing so will protect them and help keep them clean. The igniter will not work properly if the burner cap, • burner head, burner base or the igniter itself are not clean. A[...]

20 To replace a light bulb, follow these steps: Disconnect the outdoor grill power cord from the elec - 1. trical outlet. Remo ve the lens from the housing by pulling str aight 2. out. In some cases the lens may be tight enough to require the use of the included lens pry stick. Use the lens pry stick with caution. Do not cause uneven stress on the [...]

21 T esting/Resetting the Ground Fault Interrupter (GFI) The optional outdoor grill cart is equipped with a GFI to minimize the risk of injury due to an electric shock in the event of a short circuit. If your outdoor grill is connected to a GFI outlet that is not part of a Dacor grill cart, the following instructions still apply . A GFI detects the[...]

22 Par ts and Accessories Description Dacor Part Number Dacor Stainless Steel Cleaner A302 Replacement halogen light bulb (12 V ac, 20 W att) 100429 Lens pry stick 62974 Vinyl cov er for built-in 36” outdoor grill OVBC36 Vinyl cov er for built-in 52” outdoor grill OVBC52 Vinyl cov er for 36” outdoor grill and cart OVCC36 Vinyl cov er for 52?[...]

23 Before Y ou Call for Ser vice Problem Solution Guide Problem May be caused by What to do Nothing works. Igniters do not spark (no clicking sound). Outdoor grill not connected to electrical power . Connect power plug to electrical outlet . Power to electrical outlet is off . Check for tripped circuit breaker or blown fuse. Check also for tripped [...]

24 W arranty and Ser vice Getting Help Before you request service, please review the Before You Call for Service section on page 23. If you hav e per - formed the checks in the Problem Solution Guide and the problem has not been remedied, please contact us at one of the numbers below . Prior to requesting service, it is helpful to be familiar with [...]

NO POST AGE NECESSAR Y IF MAILED IN THE UNITED ST A TES DACOR A TTN: W ARRANTY PROCESSING DEPT PO BOX 6532 DIAMOND BAR CA 91765-9861 BUSINESS REPL Y MAIL PERMIT NO. 4507 POST AGE WILL BE P AID BY ADDRESSEE FIRST -CLASS MAIL DIAMOND BAR CA fold here[...]

Web site: www .Dacor .com Corporate phone: (800) 793-0093 W ARRANTY INFORMA TION IMPORT ANT : Y our warranty will not be activated until you activate it online or return this form to Dacor. If you have purchased more than one Dacor product, please return all forms in one envelope or activate the warranty for each product online. Please rest assured[...]