Dell 5100 инструкция обслуживания

Dell™Inspiron™1100,5100,and5150ServiceManual Before You Begin System Components Memory, CD or DVD Drive, Modem, and Mini PCI Card Hard Drive Keyboard Display EMI Shield, Video Card, and Palm Rest Microprocessor Thermal - Cooling Assembly Microprocessor Module Speakers System Board Flashing the BIOS Base Plastics Pinout Assi[...]

Back to Contents Page  Base Plastics Dell™Inspiron™1100,5100,and5150ServiceManual   1.  Follow the instructions in " Preparing to Work Inside the Computer ." 2.  Remove the hard drive . 3.  Remove the CD or DVD drive . 4.  Remove the memory module(s) . 5.  Remove the modem . 6.  Remove t[...]

Back to Contents Page  Before You Begin Dell™Inspiron™1100,5100,and5150ServiceManual  Preparing to Work Inside the Computer  Recommended Tools  Computer Orientation  Screw Identification  Preparing to Work Inside the Computer     1.  Ensure that the work surface is flat and clean[...]

8.  Disconnect all other external cables from the computer. 9.  Remove any installed PC Cards from the PC Card slot.  Recommended Tools  The procedures in this manual require the following tools: l  #1 Phillips screwdriver l ¼ - inch flat - blade screwdriver l  Small plastic scribe l  Hex nut driver l  Flash BIOS update [...]

 Hard Drive Door:  (2 each)    Modem to System Board:  (2 each)    Optical Drive:  (1 each)    Keyboard to Computer Base:  (4 each)    Display Assembly to Back Panel:  (2 each)    Hinge Bracket to Computer Base:  (4 each)    Display Bezel:  (5 each)   Screw Covers ([...]

Back to Contents Page     (2 each)  [...]

Back to Contents Page  Flashing the BIOS Dell™Inspiron™1100,5100,and5150ServiceManual 1.  Ensure that the AC adapter is plugged in and that the main battery is installed properly. 2.  Insert the BIOS update program CD and turn on the computer.  Follow the instructions that appear on the screen. The computer cont[...]

Back to Contents Page  Microprocessor Module Dell™Inspiron™1100,5100,and5150ServiceManual  Removing the Microprocessor Module     1.  Follow the instructions in " Preparing to Work Inside the Computer ." 2.  Remove the keyboard . 3.  Remove the EMI shield . 4.  For the Inspiron 5150, [...]

Installing the Microprocessor Module   1.  Align the pin - 1 corner of the microprocessor module so that it points to the triangle on the system board, and insert the microprocessor module into the ZIF socket.  When the microprocessor module is correctly seated, all four corners are aligned at the same height. If one or more corners of [...]

Back to Contents Page  Display Dell™Inspiron™1100,5100,and5150ServiceManual  Display Assembly  Display Bezel  Display Panel  Display Latch Assembly  Display Assembly   1.  Follow the instructions in " Preparing to Work Inside the Computer ." 2.  Remove the hard drive . 3. [...]

9.  Pull straight up on the pull - tab that is attached to the display - feed flex cable to disconnect the cable from the system board.  10.  Lift the display assembly up and out of the computer base.    Display Bezel 2  M2.5 x 5 - mm screws (4) 3  hinge brackets (2) 4  computer base 1  screw covers (2) display bumpers[...]

  1.  Follow the instructions in " Preparing to Work Inside the Computer ." 2.  Remove the keyboard . 3.  Remove the display assembly . 4.  Use a plastic scribe to pry the five screw covers out of the screw holes located on the front of the bezel. 5.  Remove the five M2.5 x 5 - mm screws located on the front of the be[...]

  Installing the Display Panel 1.  Connect the top flex - cable connector to the display panel connector. 2.  Connect the bottom flex - cable connector to the inverter connector. 3.  Lay the display panel in the top cover. 4.  Route the display - feed flex cable so that it rests in the notch located in the bottom edge of the top c[...]

  Installing the Display Latch Assembly 1.  Attach one end of the spring to the spring hook on the left edge of the display latch, and attach the other end of the spring to the spring hook in the top cover. 2.  Align the screw holes in the display latch assembly with the screw holes in the top cover. 3.  Replace the two M2.5 x 5 - mm[...]

Back to Contents Page  Hard Drive Dell™Inspiron™1100,5100,and5150ServiceManual  Removing the Hard Drive      1.  Follow the instructions in " Preparing to Work Inside the Computer ." 2.  Turn the computer over, and remove the two M2.5 x 5 - mm hard drive screws.    3.  Slide [...]

3.  Replace and tighten the two M2.5 x 5 - mm screws. 4.  Use the Operating System CD to install the operating system for your computer. 5.  Use the Drivers and Utilities CD to install the drivers and utilities for your computer. Back to Contents Page [...]

Back to Contents Page  Keyboard Dell™Inspiron™1100,5100,and5150ServiceManual  Removing the Keyboard   1.  Follow the instructions in " Preparing to Work Inside the Computer ." 2.  Use a small flat - blade screwdriver or plastic scribe to lift the notched right edge of the hinge cover, and pry the[...]

 5.  Lift the top of the keyboard out of the computer base, and pull the keyboard out at an angle (towards the display). Rest the keyboard face down on the palm rest. 6.  Grasp the keyboard flex cable near the connector, and pull up on the flex cable to disconnect it from the interface connector on the system board.   7.  Remove t[...]

 Ensure that all four securing tabs are engaged before trying to completely seat the keyboard. 3.  Replace the four M2 x 3 - mm keyboard screws. 4.  To replace the hinge cover, first insert the left side of the hinge cover into the notches. Snap down the hinge cover, and ensure that it is flush with the palm rest. Back to Contents Page [...]

Back to Contents Page  EMI Shield, Video Card, and Palm Rest Dell™Inspiron™1100,5100,and5150ServiceManual  EMI Shield  Video Card  Palm Rest  EMI Shield   1.  Follow the instructions in " Preparing to Work Inside the Computer ." 2.  Remove the keyboard . 3.  Pull up on the pu[...]

  5.  Pull straight up on the attached pull - tab to lift the video card off of the system board.  Installing the Video Card 1.  Align the posts on the video card with the screw holes in the system board. 2.  Press down on the two areas on the video card that are labeled "PUSH" until you feel the video card click into pl[...]

9.  Turn the computer back over and remove the two M2.5 x 5 - mm screws from the top of the palm rest.  10.  Disconnect the touch pad connector from the system board.   11.  Starting at the back center of the palm rest, use your fingers to separate the palm rest from the base plastics by lifting the inside edge of the palm rest. B[...]

Back to Contents Page  Pinout Assignments for I/O Connectors Dell™Inspiron™1100,5100,and5150ServiceManual  S- Video TV - Out Connector  USB Connector  Video Connector  IEEE 1394 Connector  S- Video TV - Out Connector     USB Connector   S- Video Pin Signal 1  GND 2  GND [...]

 Video Connector    IEEE 1394 Connector   Back to Contents Page  4  GND Pin Signal Pin Signal 1  CRT_R 9  5V+ 2  CRT_G 10  GND 3  CRT_B 11  MONITOR_DETECT – 4  NC 12  DDC_DATA 5  GND 13  CRT_HS 6  GND 14  CRT_VS 7  GND 15  DDC_CLK 8  GND   Pin Signal 1  TPB - 2 ?[...]

Back to Contents Page  Speakers Dell™Inspiron™1100,5100,and5150ServiceManual  Removing the Speakers    The speakers are located on the left and right corners of the front of the base plastics. Take note of the speaker cable routing so that you can replace the cables properly under or between their routing cli[...]

 Installing the Speakers 1.  Slide the speakers down into the base plastics.    2.  Route the speaker cables under or between their routing clips. 3.  Connect the speaker connector to the system board. Back to Contents Page  NOTICE: Ensure that the speaker cables are under or between their routing clips. NOTE: Speakers face [...]

Back to Contents Page  System Board Dell™Inspiron™1100,5100,and5150ServiceManual  Removing the System Board    The system board's BIOS chip contains the Service Tag sequence, which is also visible on a barcode label on the bottom of the computer. The replacement kit for the system board includes a CD tha[...]

16.  Remove the three M2.5 x 5 - mm system board screws from the hard drive cage. 17.  Remove the two M2.5 x 5 - mm system board screws from the optical drive cage.   18.  Remove the two M2.5 x 5 - mmscrewsthatsecuretheleftantennatotheharddriveandopticaldrivecages(Inspiron™5100and?[...]

20.  Lift the front of the system board out and away from the base plastics.  Installing the System Board 1.  Insert the video connector on the replacement system board through the back of the base plastics. 2.  Replace the two hex nuts that secure the video connector to the base plastics. 3.  Replace the two M2.5 x 5 - mm screws tha[...]

Back to Contents Page  System Components Dell™Inspiron™1100,5100,and5150ServiceManual     CAUTION: Only a certified service technician should perform repairs on your computer. Damage due to servicing that is not authorized by Dell is not covered by your warranty. NOTICE: Unless otherwise noted, each procedure[...]

Back to Contents Page [...]

Back to Contents Page  Microprocessor Thermal - Cooling Assembly Dell™Inspiron™1100,5100,and5150ServiceManual  Removing the Microprocessor Thermal - Cooling Assembly   1.  Follow the instructions in " Preparing to Work Inside the Computer ." 2.  Remove the keyboard . 3.  Remove the EMI shield [...]

2.  Place the back of the microprocessor thermal - cooling assembly under the palm rest, and lower the assembly onto the system board. 3.  Connect the fan power cable to the system board. 4.  Tighten the four captive screws, labeled "1" through "4," in consecutive order. 5.  For the Inspiron 5150, replace the palm re[...]

Back to Contents Page Dell™Inspiron™1100,5100,and5150ServiceManual Information in this document is subject to change without notice. © 2003DellComputerCorporation.Allrightsreserved. Reproduction in any manner whatsoever without the written permission of Dell Computer Corporation is strictly forbidden. [...]

Back to Contents Page  Memory, CD or DVD Drive, Modem, and Mini PCI Card Dell™Inspiron™1100,5100,and5150ServiceManual  Memory  CD or DVD Drive  Modem  MiniPCICard(Inspiron™5100and5150Only)  Memory  Removing the Memory Modules    1.  Follow the instructions [...]

  Installing the Memory Modules  1.  Align the notch in the module edge connector with the tab in the connector slot. 2.  Slide the module firmly into the slot at a 45 - degree angle, and rotate the module down until it clicks into place. If you do not feel the click, remove the module and reinstall it.  3.  Replace the cover a[...]

 4.  Press the lever next to the memory module connectors in the direction of the arrow on the lever (towards the drive) to release the drive.   5.  Pull the drive out of the bay.  Installing the CD or DVD Drive 1.  Slide the new drive into the bay until the drive is fully seated. 2.  Replace the memory module cover and tigh[...]

1.  Follow the instructions in " Preparing to Work Inside the Computer ." 2.  Turn the computer over, loosen the captive screw (labeled "circle C") in the modem/Mini PCI card cover, and lift the cover away from the computer.   3.  Remove the two M2 x 3 - mm screws securing the modem to the system board, and set th[...]

4.  Replace the cover and tighten the captive screw.  MiniPCICard(Inspiron™5100and5150Only)  Removing the Mini PCI Card   1.  Follow the instructions in " Preparing to Work Inside the Computer ." 2.  Turn the computer over, loosen the captive screw (labeled "circle C") in the modem/Min[...]

4.  UseyourfingertipstocarefullyspreadapartthesecuringtapsoneachendoftheMiniPCIcardconnectoruntilthecardpopsup. 5.  Lift the Mini PCI card out of its connector.  Installing the Mini PCI Card   1.  Align the Mini PCI card with the connector at a 45 - degree ang[...]