Desa CGCDV42NR инструкция обслуживания

DIRECT -VENT FIREPLACE OWNER’S OPERA TION AND INST ALLA TION MANU AL W ARNING: If the information in this manual is not fol-           [...]

www .desatech.com 1 16236-01G 2 SAFETY INFORMA TION          chemicals known to the State of California to cause cancer or     ?[...]

www .desatech.com 1 16236-01G 3                      [...]

www .desatech.com 1 16236-01G 4 1. For propane/LP replace, do not place pro - pane/LP supply tank(s) inside any structure. Locate propane/LP supply tank(s) outdoors. T o prevent performance problems, do not use propane/LP fuel tank of less than 100 lbs. capacity . 2. If you smell gas • shut off gas supply • do not try to light any appliance [...]

www .desatech.com 1 16236-01G 5 PRODUCT FEA TURES These are a few facts that can help you understand and enjoy your direct-vent replace: • The venting system may be routed to the out - side of your home in several ways. It may vent through the roof (vertical) or it may vent to an outside/exterior wall (horizontal). The vent pipe installation i[...]

www .desatech.com 1 16236-01G 6 • Y our replace is designed to be used in zero clea ranc e ins tall atio ns. W all or fr amin g mate rial can be placed directly against any exterior sur - face on the back, sides or top of your replace, except where standoff spacers are integrally atta ched . If st ando ff space rs are attac hed to your r[...]

www .desatech.com 1 16236-01G 7 A B E F G H D C Nailing T abs Figure 4 - Framing Clearances for Installation Against an Exterior Wall 40 1 / 8 " 48 1 / 4 " 23" Horizontal V ent 26 1 / 2 " V ertical V ent C B A D E F G T op of Louver Opening 3 2 1 4 5 6 7 W all Figure 5 - Framing Clearances for Corner Installation Ref. Mantel Dep[...]

www .desatech.com 1 16236-01G 8 Figure 7 - Minimum Clearances for T ermination Cap LOCA TION OF TERMINA TION CAP Fixed Closed Op en a bl e Fixed Closed V V V V V V V V X X V X G G J F B B K N H I A N E L D B M A C B V V A G G B TERMINA TION CAP AIR SUPPL Y INLET GAS METER RESTRICTED AREA (TERMINA TION PROHIBITED) A = clearance above grade, veranda,[...]

www .desatech.com 1 16236-01G 9 VENT ING INST ALLA TION INSTRUCTIONS NOTICE: Read these instruc-                           -  Thes e m odel s ar e te sted and ap prov ed f or u se with DESA (direct-vent) pi[...]

www .desatech.com 1 16236-01G 10 INST ALLA TION PLANNING There are two basic types of direct-vent in - stallation: • Horizontal T ermination • V ertical T ermination Horizontal T ermination Installation IMPORTANT : Horizontal square terminations require only inner portion of wall restop. Hori - zon tal i nsta lla tio ns us ing r ound term in[...]

www .desatech.com 1 16236-01G 1 1 VENTING INST ALLA TION INSTRUCTIONS Continued W ARNING: Do not recess       6.  ?[...]

www .desatech.com 1 16236-01G 12 VENTING INST ALLA TION INSTRUCTIONS Continued Figure 13 - T ypical Horizontal T ermination Cap Mounting with Additional Siding Standoff Installed Siding Standoff Screws High Wind T ermination Apply Mastic to Outside Edge of Standoff Exterior W all with Vinyl Siding 10 3 / 4 " x 10 3 / 4 " Framed Opening Ma[...]

www .desatech.com 1 16236-01G 13 CORNER INST ALLA TION Recommended Applications: • Corner ground oor installation • Gr ou nd oo r in st al la ti on whe re pip e ven ts hor i - zo nt al ly t hr ou gh w al l (o ve r 12" ho rizo nt al p ip e) • Basement install ation where one foot clearance from ground to termination is possible VENT[...]

www .desatech.com 1 16236-01G 14 VENTING INST ALLA TION INSTR UCTIONS Continued      Horizontal (H 1  Horizontal (H 1  Horizontal (H 2  5' min. 2' max. 6' max. 6' min. 4' max. 12' max. [...]

www .desatech.com 1 16236-01G 15 INST ALLA TION FOR VERTICAL TERMINA TION Note: V ertical restrictor must be installed in all vertical installations. 1. Determine the route your vertical venting will take. If ceiling joists, roof rafters or other framing will obstruct the venting system, consi der an of fset (se e Figure 19) to avoid cu t - ting lo[...]

www .desatech.com 1 16236-01G 16 5. Pla ce t he as hing ov er t he pip e se ctio n(s ) extendin g through the roof. Secure the base of the ashing to the roof and framing with roof - ing na ils. Be sure ro ong ma teri al over laps the top edge of the ashing as sho wn in Figure 19, page 15. There must be a 1" clearance from the vent [...]

www .desatech.com 1 16236-01G 17 VENTING INST ALLA TION INSTR UCTIONS Continued Note : Install restrictor into inner collar of replace as shown.     V ertical (V 1   5' min. 6' max. 6' min. 12' max. 7&[...]

www .desatech.com 1 16236-01G 18   AND COMPONENTS                 P58-6 6" Section Double W all Pipe, Galvanized P58-12 12&[...]

www .desatech.com 1 16236-01G 19 FIREPLACE INST ALLA TION  Use proper gas type for the replace unit you are installi ng. If you have conicting gas types, do not install replace. See retailer where you purchased the replace for proper replace according to your gas type or to purchase gas conve[...]

www .desatech.com 1 16236-01G 20 C AU TI ON: Nev e r to uc h th e                 9. Check to make sure that the power cord is completely clear of the blower wheel and that there are no other foreign objects in blower wheel. Turn blower on and check for [...]

www .desatech.com 1 16236-01G 21 7. Check to make sure that the power cord is completely clear of the blower wheel and that there are no other foreign objects in blower wheel. Also double check all wire leads and make sure wire routing is not pinched or in a precarious position. Correct accordingly . 8. T urn on power to duplex outlet if previ - ou[...]

www .desatech.com 1 16236-01G 22 Figure 31 - External Regulator with V ent Pointing Down (Propane/LP Only) Propane/LP Supply T ank External Regulator with V ent Pointing Down CAUTION: Use only new ,       - ?[...]

www .desatech.com 1 16236-01G 23 Figure 33 - Connecting Flexible Gas Line to Millivolt V alve Flexible Gas Line Do NOT Kink Equipment Shutoff V alve T o Gas Supply (Natural) T o External Regulator (Propane/LP) Control V alve FIREPLACE INST ALLA TION Continued    [...]

www .desatech.com 1 16236-01G 24 PRESSURE TESTING FIREPLACE GAS CONNECTIONS 1. Open equipment shutoff valve (see Figure 34, page 23). 2. Open propane/LP supply tank valve or main gas valve located on or near gas meter for natural gas. 3. Make sure control knob of replace is in the OFF position. 4. Check all joints from equip ment shutof f valve [...]

www .desatech.com 1 16236-01G 25    Held Remote Control Unit 1. Remove battery cover on back of remote control unit. 2. Attach terminal wires to a 9-volt alkaline battery (not included). Place battery into the battery hou[...]

www .desatech.com 1 16236-01G 26 4. Remount the new frame at the hinge with ve new scr ews bef ore clo sin g do or. Th is will ensure seating of the gasket. 5. Cl os e g la ss do or fr am e. Lo ck la tc he s b y p la ci ng the ba r un der the ta b on doo r an d pu sh ing dow n and back on lat ch ( see Figu re 4 2, p age 25). 6. Replace screen/ro[...]

www .desatech.com 1 16236-01G 27 6. Install rear brick panel rst. Rest bottom edge of panel on back edge of burner assembly (see Figure 44). 7. Install left side brick panel by sliding it be - tween the burner assembly and the side of the rebox (see Figure 44). 8. Install the right brick panel using the same me th od d es cr ib ed i n st ep 6[...]

www .desatech.com 1 16236-01G 28 7. T urn gas control knob counterclockwise to PILOT (see Figur e 45). 8. Push in gas control knob all the way and hold. Immediately light the pilot by repeat- edly depr ess ing t he pie zo spa rk ign itor unt il a ame appe ars. Con tinue to hol d for about one (1) minute after the pilot is lit. Release gas contro[...]

www .desatech.com 1 16236-01G 29 OPERA TING FIREPLA CE Continued  Hold the control button on the hand-held remote until burner turns on. Hold the con- trol button again until burner turns off (see Figure 47).   press both buttons on hand-held remot[...]

www .desatech.com 1 16236-01G 30  This feature allows the user to lock/unlock the keypad on the hand-held remote in the MANU or AUTO mode to prevent inadvertent opera tion (i. e. chil dre n operat ing the ha nd-hel d remote control, etc.). The keypad is locked in either on or off. Press th[...]

www .desatech.com 1 16236-01G 31 INSPECTING B URNERS Continued    Burn er a mes wi ll be st eady ; not l ifti ng or o atin g. Flame patterns will be different from unit to unit and will vary depending on installation type and weather conditions. If the vent conguration is installe[...]

www .desatech.com 1 16236-01G 32 CAUTION: Do not vacuum if  Use only the tempered glass door replacement intende d for this replace (see Replaceme nt Parts , page 37 for detail on ordering). No substitutions may be made. See Removing/Replacing Glass Door , p a g e 2 5 f or i n st r u ct i o n s f o r [...]

www .desatech.com 1 16236-01G 33 TROUBLESHOO TING       [...]

www .desatech.com 1 16236-01G 34  Pilot lights but ame goes out when control knob is released Burner does not light after pilot is lit Delayed ignition burner Burner backring during com - bustion Slight smoke or odor during initial operation REMEDY 1 . Press in gas control knob fully 2. After pi[...]

www .desatech.com 1 16236-01G 35 TROUBLESHOO TING Continued  Heat er produce s a whistli ng noise when burner is lit Glass soots Fireplace produces a clicking/ ticking noise just after burners are lit or shut off Remote does not function Fireplace shuts off in use REMEDY 1. T urn gas control knob to L[...]

www .desatech.com 1 16236-01G 36 TROUBLESHOO TING Continued         [...]

www .desatech.com 1 16236-01G 37 REPLACEMENT P ARTS Note : Use only original replacement parts. This will protect your warranty coverage for parts replaced under warranty . P ARTS UNDER W ARRANTY Contact authorized retailers of this product. If they can not supply original replacement part(s), call DESA ’ s Customer Service Department at 1-866-67[...]

www .desatech.com 1 16236-01G 38 ILL USTRA TED P ARTS BREAKDOWN     6 7 22 19 20 15 2 14 21 8 1 4 13 9 16 3 18 5 17 23 10 1 1 12 24[...]

www .desatech.com 1 16236-01G 39 P ARTS LIST     This list contains replaceable parts used in your replace. When ordering parts, follow the instructi[...]

www .desatech.com 1 16236-01G 40 7 15 10 12 1 12 2 3 13 9 1 1 21 22 TPTH TP TH 6 12 14 18 17 17 18 19 20 16 14 8 4 5 ILL USTRA TED P ARTS BREAKDOWN       ?[...]

www .desatech.com 1 16236-01G 41 P ARTS LIST         This list contains replaceable parts[...]

www .desatech.com 1 16236-01G 42  Man ual vari abl e con tro l blo wer acce sso ry pr ovi des better heat distribution. Complete installation and operation instructions included in this manual. ACCESSORIES NOTICE: All accessories may  ?[...]

www .desatech.com 1 16236-01G 43 ACCESSORIES Continued RECEIVER AND HAND-HELD   Al l ow s t h e f ir ep l ac e t o b e t ur n ed on an d o ff con ve nie ntl y . A w all -m oun ted d ock in g s tat io n is included. RECEIVER AND HAND-[...]

2701 Industrial Drive P .O. Box 90004 Bowling Green, KY 42102-9004 www .desatech.com NOT A UPC 1 16236-01 Rev . G 03/06 WARRANTY INFORMA TION KEEP THIS WARRANTY Always specify model and serial numbers when communicating with the factory . W e reserve the right to amend these specications at any time without notice. The only warranty applicable i[...]