Desa VN6C инструкция обслуживания

Save this manual for future reference. INFRARED VENT -FREE NA TURAL GAS HEA TER OWNER’S OPERATION AND INSTALLATION MANUAL ® MODELS: VN6C AND VN10 ® WARNING: If the information in this manual is not followed exactly, a fire or explosion may result causing property damage, personal injury, or loss of life. — Do not store or use gasoline or othe[...]

2 101851 NA TURAL GAS HEA TER V ANGUARD VN6C AND VN10 Carbon Monoxide Poisoning: Early signs of carbon monoxide poisoning re- semble the flu, with headaches, dizziness, or nausea. If you have these signs, the heater may not be working properly. Get fresh air at once! Have heater serviced. Some people are more affected by carbon monoxide than others[...]

3 101851 OWNER’S MANUAL PRODUCT IDENTIFICA TION LOCAL CODES Install and use heater with care. Follow all local codes. In the absence of local codes, use the latest edition of National Fuel Gas Code ANSI Z223.1, also known as NFPA 54*. *Available from: American National Standards Institute, Inc. 1430 Broadway New York, NY 10018 National Fire Prote[...]

4 101851 NA TURAL GAS HEA TER V ANGUARD VN6C AND VN10 WARNING: If the area in which the heater may be operated is smaller than that defined as an unconfined space, provide ad- equate combustion and ventila- tion air by one of the methods described in the National Fuel Gas Code, ANSI Z223.1, 1992, Section 5.3 or applicable local codes. AIR FOR COMBU[...]

5 101851 OWNER’S MANUAL Figure 3 - Ventilation Air from Outdoors Outlet Air Ventilated Attic Outlet Air Inlet Air Inlet Air Ventilated Crawl Space To Crawl Space To Attic Ventilation Air From Outdoors Provide extra fresh air by using ventilation grills or ducts. You must provide two per- manent openings: one within 12" of the ceiling and one[...]

6 101851 NA TURAL GAS HEA TER V ANGUARD VN6C AND VN10 2. Mark two mounting screw locations on wall (see Figure 5). INSTALLING HEATER TO WALL Marking Screw Locations 1. Determine where you will locate heater . Figure 5 - Mounting Screw Locations WARNING: Maintain minimum clearances shown in Figure 5. If you can, provide greater clear- ances from flo[...]

7 101851 OWNER’S MANUAL PLACING HEATER ON MOUNTING SCREWS 1. Locate two keyhole slots on back panel of heater (see Figure 9). 2 . Place lar ge openings of slots over screwheads. Slide heater down until screws are in small portion of slots. Figure 11 - Installing Bottom Mounting Screw Figure 9 - Location Of Keyhole Slots On Back Panel Of Heater Ke[...]

8 101851 NA TURAL GAS HEA TER V ANGUARD VN6C AND VN10 IMPORTANT: Hold pressure regulator with wrench when connecting it to gas piping and/ or fittings. Figure 12 - Gas Connection * An A.G.A. design-certified manual shutoff valve with 1/8" NPT tap is an acceptable alternative to test gauge connection. Purchase the optional A.G.A. design-certifi[...]

9 101851 OWNER’S MANUAL PRESSURE TESTING HEATER GAS CONNECTIONS 1. Open manual shutoff valve (see Figure 13). 2. Open main gas valve located on or near gas meter . 3. Make sure control knob of heater is in the OFF position. 4. Check all joints from manual shutoff valve to control valve (see Figure 14). Apply mixture of liquid soap and wa- ter to [...]

10 101851 NA TURAL GAS HEA TER V ANGUARD VN6C AND VN10 TO SELECT HEATING LEVEL 1. Slightly press in control knob and turn counterclockwise C-clockwise to the LOW or HIGH positions (VN10) or ON position (VN6C). IMPORT ANT : Release downward pressur e while turning control knob. Control knob will lock at the desir ed position. Figure 17 - Burner Patt[...]

11 101851 OWNER’S MANUAL BURNER FLAME PATTERN Figure 20 shows a correct burner flame pattern. Figure 21 shows an incorrect burner flame pattern. Figure 20 - Correct Burner Flame Pattern (Model VN10 Shown) Figure 21 - Incorrect Burner Flame Pattern (Model VN10 Shown) If burner flame pattern is incorrect, as shown in Figure 21 • turn heater off ([...]

12 101851 NA TURAL GAS HEA TER V ANGUARD VN6C AND VN10 POSSIBLE CAUSE 1. Ignitor electrode positioned wrong 2. Ignitor electrode broken 3. Ignitor electrode not connected to igni- tor cable 4. Ignitor cable pinched or wet 5. Piezo ignitor nut is loose 6. Broken ignitor cable 7. Bad piezo ignitor 1. Gas supply turned off or manual shutof f valve clo[...]

13 101851 OWNER’S MANUAL TROUBLESHOOTING Continued OBSERVED PROBLEM Burner(s) does not light after ODS/pilot is lit Delayed ignition of burner(s) Burner backfiring during combustion Burner plaque(s) does not glow Slight smoke or odor during initial opera- tion Heater produces a clicking/ticking noise just after burner is lit or shut off REMEDY 1.[...]

14 101851 NA TURAL GAS HEA TER V ANGUARD VN6C AND VN10 OBSERVED PROBLEM Gas odor even when control knob is in OFF position Gas odor during combustion Moisture/condensation noticed on windows REMEDY 1. Locate and correct all leaks (see Check- ing Gas Connections , page 9) 2. Replace control valve 1. T ake apart gas tubing and remove for- eign matter[...]

15 101851 OWNER’S MANUAL You may have further questions about in- stallation, operation, or troubleshooting. If so, contact DESA International’s Techni- cal Service Department at 1-800-323-5190. TECHNICAL SER VICE SPECIFICA TIONS VN10 VN6C Btu (Variable) 5,500/10,000 6,000 Type Gas Natural Only Natural Only Ignition Piezo Piezo Pressure Regulat[...]

16 101851 NA TURAL GAS HEA TER V ANGUARD VN6C AND VN10 P AR TS LIST VN6C This list contains replaceable parts used in your heater. When ordering parts, follow the instructions listed under Replacement Parts on page 15 of this manual. HEATER EXPLODED VIEW 7-1 7-2 ODS/PILOT KEY PART NO. NUMBER DESCRIPTION QTY. 1 098304-01 Screw, #10 x 3/8" 2 2 0[...]

17 101851 OWNER’S MANUAL KEY PART NO. NUMBER DESCRIPTION QTY. 15 099057-01 Pressure Tap Fitting 1 16 098276-01 1/8 Pipe Plug 1 17 099468-08 Cabinet Assembly 1 18 099415-01 Gas Regulator 1 19 098303-02 Screw, #6 x 5/16" 2 20 098508-01 Valve Retainer Nut 1 21 099393-02 Control Knob 1 22 M11084-26 Screw, #10 x 3/8" 2 23 099818-01 Internal [...]

18 101851 NA TURAL GAS HEA TER V ANGUARD VN6C AND VN10 NOTES _______________________________________________________________________________________________ _______________________________________________________________________________________________ _______________________________________________________________________________________________ _[...]

19 101851 OWNER’S MANUAL NOTES _______________________________________________________________________________________________ _______________________________________________________________________________________________ _______________________________________________________________________________________________ _____________________________[...]

LIMITED WARRANTY VANGUARD VENT-FREE RESIDENTIAL GAS HEATERS DESA International warrants this product to be free from defects in materials and components for three (3) years from the date of first purchase, provided that the product has been properly installed, operated and maintained in accordance with all applicable instructions. To make a claim u[...]