Desa (V)T32EN инструкция обслуживания

NA TU RA L GA S “ T U D O R ” M O D E L ( V ) T 3 2 EN , ( V ) T 3 6 EN S E R I E S P R O P A N E / L P G A S “ T U D O R ” M O D E L ( V ) T 3 2 EP , ( V ) T 3 6 EP S E R I E S W ARNING: Improper installation, adjust- ment, alteration, service, or maintenan ce can cause injury or property damage. Refer to this manual for correct installati[...]

www .desatech.com 108860-01D 2 SAFETY INFORMA TION W ARNING: This product contains and/or generates          cancer or birth defects, or other reproductive harm. IMPORT ANT : Read this owner ’[...]

www .desatech.com 108860-01D 3 12. Do not use this replace to cook food or burn paper or other objects. 13. Do not use any solid fuels (wood, coal, paper , cardboard, etc.) in this replace. Use only the gas type indicated on replace nameplate. 14. This appliance, when installed, must be electrically grounded in accordance with local codes [...]

www .desatech.com 108860-01D 4 PRE-INST ALLA TION PREP ARA TION    Determine the safest and most efcient location for your DESA direct-vent replace. Make sure that rafters and wall studs are not in the way of the venting system. Choose a location wher[...]

www .desatech.com 108860-01D 5 B C A FRAMING AND FINISHING Fig ure 4 sh ows typ ica l fr ami ng o f th is r ep lac e. F igu re 5 show s fr am - ing fo r c or ner in sta lla ti on. All mi nim um cl ear anc es mu st be met . For available accessories for this replace, see Accessories on page 29. If you are using a separate combustible mantel pi[...]

www .desatech.com 108860-01D 6 Fixed Closed O p en a b l e Fixed Closed Openable V V V V V V V V X X V X G G J F B B K N H I A N E L D B M A C B V V A G G B TERMINA TION CAP AIR SUPPL Y INLET GAS METER RESTRICTED AREA (TERMINA TION PROHIBITED) A = clearance above grade, veranda, porch, deck, or balcony [*12" (30.5 cm) minimum] B = clearance to[...]

www .desatech.com 108860-01D 7 VENTING INST ALLA TION INSTR UCTIONS       attempting installation. These models are tested and approved for use with DESA (direct- vent) pipe components and termination[...]

www .desatech.com 108860-01D 8 Fig ure 10 - Installing Horizontal V ent Cap Wood Screw V ent Cap Apply Mastic to All Four Sides VENTING INST ALLA TION INSTR UCTIONS Continued 2. Direct vent pipe sections and components are designed with special twist-lock connections.    The female ends[...]

www .desatech.com 108860-01D 9 VENTING INST ALLA TION INSTR UCTIONS Continued Figure 1 1 - Installing Siding Standoff V ent Cap (Horizontal T ermination) Interior W all Surface W all Firestop Horizontal V ent Pipe Figure 12 - Connecting V ent Cap with Horizontal V ent Pipe Screw Cut Siding Away to Fit Standoff Wood Screw Screws Standoff V ent Cap A[...]

www .desatech.com 108860-01D 10 V ertical (V) Required Horizontal (H) 32" 36" V ertical Pipe (32"/36")  40 1 / 2 " min. 43 1 / 4 " min. None 30" max. 51 1 / 2 " min. 54 1 / 4 " min. 1 ft. 48" max. 63 1 / 2 " min. 66 1 / 4 " min. 2 ft. 60" max. 75 1 / 2 " min. 78 1 / 4 " m[...]

www .desatech.com 108860-01D 1 1 SNORKEL TERMINA TION INST ALLA TION Recommended Applications: • Installations requiring a vertical rise on building exterior • Any installation using snorkel termination to achieve one foot above ground Snorkel terminations are available for installations requiring a vertical rise on the exterior of the building[...]

www .desatech.com 108860-01D 12                 No t e: V er ti c al re s tr i ct or m us t b e i n st all e d in a ll ve rti c al in s ta l la tio n s. 1. Determine the route your vertical venting will take. If ceiling joists, roof rafter[...]

www .desatech.com 108860-01D 13 VENTING INST ALLA TION INSTR UCTIONS Continued    Figures 21 through 24 show four dif ferent congurations for verti - cal termination. V enting with T wo 90° Elbow s V ertical (V) Horizontal (H 1 ) + Horizontal ([...]

www .desatech.com 108860-01D 14 VENTING INST ALLA TION INSTR UCTIONS Continued HIGH AL TITUDE INST ALLA TION Y our DESA direct-vent replace has been CSA tested and approved for elevations from 0-2000 feet (USA) and elevations from 0-4500 feet (Canada). When installing this replace at an elevation above 2000 feet (in the USA), you may need to [...]

www .desatech.com 108860-01D 15 3. Place the bl ower a gainst the lo wer rea r wall of the rebox outer wrap per wit h th e ex hau st p ort direct ed upward. The blo wer wil l t inside the back opening and be held in position against the back wall by the magnets (see Figure 25). 4. Be certain that all wire terminals are securely attached to te[...]

www .desatech.com 108860-01D 16 FIREPLA CE INST ALLA TION Continued Figure 29 - Blower Wiring Diagram for Thermostat-Controlled Models Blower Wiring Diagram         when servicing controls. Wiring errors[...]

www .desatech.com 108860-01D 17 FIREPLA CE INST ALLA TION Continued For propane/LP connection only , the installer must supply an external regulator . The external regulator will reduce incoming gas pressure. Y ou must reduce incoming gas pressure to between 1 1" and 14" of water . If you do not reduce incoming gas pressure, replace re[...]

www .desatech.com 108860-01D 18 Open FIREPLA CE INST ALLA TION Continued  W ARNING: T est all gas piping and connections for       [...]

www .desatech.com 108860-01D 19 FIREPLA CE INST ALLA TION Continued           -   ?[...]

www .desatech.com 108860-01D 20 FIREPLA CE INST ALLA TION Continued Figure 38 - Installing Rear Brick Panel Figure 39 - Installing Left Side and T op Brick Panels Rear Brick Panel Left Side Brick Panel T op Brick Panel (T36 Series Only)      GLOWING EMBERS [...]

www .desatech.com 108860-01D 21 FIREPLA CE INST ALLA TION Continued 3. Place log #3 (crossover log) onto the rear and front logs. Make sure it is seated properly on the smooth surface on the front log and on the pin on the back log as shown in Figure 42. 4. Place log #4 (right log) on the pin on the right side of front log as shown in Figure 43. 5.[...]

www .desatech.com 108860-01D 22 FIREPLA CE INST ALLA TION Continued     The installation of a wall switch allows you to activate the gas control valve and turn the replace on and off. The wall switch is to be connected to the incoming 120 volt regular household wir - ing tha[...]

www .desatech.com 108860-01D 23 OPERA TING FIREPLACE FOR YOUR SAFETY READ BEFORE LIGHTING TO TURN OFF GAS   1. T urn off the wall switch. 2. T urn off all electric power to the appliance if service is to be performed. 3. Open lower louver panel. 4. T urn equipment shutoff valve clockwise to OFF . Do not force. 5.[...]

www .desatech.com 108860-01D 24 INSPECTING B URNERS Check pilot ame pattern and burner ame patterns often. PILOT ASSEMBL Y The pilot assembly is factory preset for the proper ame. Altera - tions may have occurred during shipping and handling. The pilot is located on the back right hand side of the burner . The ame must envelope 1/4"[...]

www .desatech.com 108860-01D 25  Use only the tempered glass door replacement intended for this replace (see Replacement Parts , page 28 for detail on ordering). No substitutions may be made. See Removing/Replacing Glass [...]

www .desatech.com 108860-01D 26 TR OUBLESHOO TING Note: All troubleshooting items are listed in order of operation. The two most common causes of a malfunctioning gas appliance are: 1. Loose wiring connections 2. Construction debris clogging the pilot and/or gas control valve lter W ARNING: T urn off heater and let cool before ser- ?[...]

www .desatech.com 108860-01D 27 TR OUBLESHOO TING Continued W ARNING: If you smell gas • Shut off gas supply . • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building. • Immediately call your gas supplier from a neighbor ’ s phone. Follow the gas supplier ’ s instructions.  [...]

www .desatech.com 108860-01D 28 SPECIFICA TIONS (V)T32EN(R) (V)T36EN(R) (V)T32EP(R) (V)T36EP(R) Btu 12,000/18,000 Btu/hr 18,000/26,000 Btu/hr 1 1,000/17,000 Btu/hr 17,000/24,000 Btu/hr Gas T ype Natural Natural Propane/LP Propane/LP Ignition Electronic Electronic Electronic Electronic Manifold Pressure 3.5" w .c. 3.5" w .c. 10.0" w .[...]

www .desatech.com 108860-01D 29 A CCESSORIES           Purchase these replace accessories from your local retailer . If they can not supply [...]

www .desatech.com 108860-01D 30 ILL USTRA TED P ARTS BREAKDO WN MODELS (V)T32EN, (V)T32ENB, (V)T32ENR, (V)T32ENRB, (V)T32EP , (V)T32EPB, (V)T32EPR AND (V)T32EPRB 6 7 21 18 19 10 13 2 12 20 8 1 1 1 14 9 17 15 4 16 5 16 3 22-2 22-6 22-4 22-5 22-3 22-1[...]

www .desatech.com 108860-01D 31 P ART NUMBER KEY NO. (V)T32EN (V)T32EP (V)T32ENB (V)T32EPB (V)T32ENR (V)T32EPR (V)T32ENRB (V)T32EPRB    1 ** ** Firebox Assembly 1 2 ** ** Face Weldment 1 3 108892-01 108892-01 Door Assembly (T Models Only) 1 108892-02 108892-02 Door Assembly (VT Models Only) 1 4 1089 03-0[...]

www .desatech.com 108860-01D 32 ILL USTRA TED P ARTS BREAKDO WN BURNER ASSEMBL Y MODELS (V)T32EN, (V)T32ENB, (V)T32ENR, (V)T32ENRB, (V)T32EP , (V)T32EPB, (V)T32EPR AND (V)T32EPRB IGN P V GND P V /M V T R T H M V 21 23 24 26 25 27 17 22 16 14 20 12 9 8 10 13 15 19 18 28 29 1 1 2 1 7 3 5 4 6[...]

www .desatech.com 108860-01D 33 P ARTS LIST BURNER ASSEMBL Y MODELS (V)T32EN, (V)T32ENB, (V)T32ENR, (V)T32ENRB, (V)T32EP , (V)T32EPB, (V)T32EPR AND (V)T32EPRB This list contains replaceable parts used in your replace. When ordering parts, follow the instructions listed under Replacement Parts on page 28 of this manual. KEY NO. P ART NO. ?[...]

www .desatech.com 108860-01D 34 ILL USTRA TED P ARTS BREAKDO WN MODELS (V)T32EN, (V)T32ENB, (V)T32ENR, (V)T32ENRB, (V)T32EP , (V)T32EPB, (V)T32EPR AND (V)T32EPRB 6 7 21 18 19 10 13 2 1 1 20 8 12 23-1 23-4 23-3 23-6 23-5 23-2 1 14 9 22 17 3 15 4 16 5 16[...]

www .desatech.com 108860-01D 35 P ARTS LIST MODELS (V)T32EN, (V)T32ENB, (V)T32ENR, (V)T32ENRB, (V)T32EP , (V)T32EPB, (V)T32EPR AND (V)T32EPRB This list contains replaceable parts used in your replace. When ordering parts, follow the instructions listed under Replacement Parts on page 28 of this manual. (V)T36EN, (V)T36EP (V)T36ENR, (V)T36EPR T36[...]

www .desatech.com 108860-01D 36 ILL USTRA TED P ARTS BREAKDO WN BURNER ASSEMBL Y MODELS (V)T36EN, (V)T36ENB, (V)T36ENR, (V)T36ENRB, (V)T36EP , (V)T36EPB, (V)T36EPR AND (V)T36EPRB IG N P V GND P V /M V T R T H M V 21 23 24 26 25 27 17 22 16 14 20 12 9 2 1 8 10 13 15 7 3 4 6 5 19 18 28 29 11 30[...]

www .desatech.com 108860-01D 37 P ARTS LIST BURNER ASSEMBL Y MODELS (V)T36EN, (V)T36ENB, (V)T36ENR, (V)T36ENRB, (V)T36EP , (V)T36EPB, (V)T36EPR AND (V)T36EPRB This list contains replaceable parts used in your replace. When ordering parts, follow the instructions listed under Replacement Parts on page 28 of this manual. KEY NO. P ART NO. ?[...]

LIMITED WARRANTY DIRECT -VENT FIREPLACE DESA warrants this product to be free from defects in materials and components for two (2) years from the date of rst purchase, provided that the product has been properly installed, operated and maintained in accordance with all applicable instructions. T o make a claim under this warranty the Bill of Sal[...]