Desa (V)T36NA инструкция обслуживания

For more information, visit www .desatech.com DIRECT -VENT FIREPLACE OWNER’S OPERA TION AND INST ALLA TION MANU AL NA TURAL GAS “TUDOR” MODELS (V)T36NA SERIES AND CTD V36NRA PROP ANE/LP GAS “TUDOR” MODELS (V)T36P A SERIES W ARNING: If the information in this manual is not fol-     ?[...]

www .desatech.com 1 1 1250-01E 2 SAFETY INFORMA TION T ABLE OF CONTENTS Safety Information ............................................... 2 Local Codes......................................................... 4 Product Identication ........................................... 4 Product Features ................................................. 4[...]

www .desatech.com 1 1 1250-01E 3 SAFETY INFORMA TION Continued This replace must be installed by a qualied (cer - tied or licensed) service person. It has a sealed gas combustion chamber that uses a coaxial pipe (pipe within a pipe and having the same center) venting system. It brings in fresh air for combus - tion through the outer pipe a[...]

www .desatech.com 1 1 1250-01E 4 SAFETY INFORMA TION Continued 2. If you smell gas • shut off gas supply • do not try to light any appliance • do not touch any electrica l switch; do not use any phone in your building • immediately call your gas supplier from a neighbor ’ s phone. Follow the gas supplier's instructions • if you can[...]

www .desatech.com 1 1 1250-01E 5 Figure 2 - Common Fireplace Locations Flush with a wall Through exterior wall enclosed in a chase Corner installation • This replace requires a wall switch, hand-held remote or wall thermostat (millivolt) for opera - tion (see Accessories , page 36). • This replace does not require electricity to operate. [...]

www .desatech.com 1 1 1250-01E 6 PRE-INST ALLA TION PREP ARA TION Continued Figure 4 - Framing Clearances for Installation Against an Exterior Wall Figure 5 - Framing Clearances for Corner Installation C B A D E F G T op of Louver Opening 3 2 1 4 5 6 7 Wall Ref. Mantel Depth Ref. Mantel from T op of Louver Opening 1 14" A 16" 2 12" B[...]

www .desatech.com 1 1 1250-01E 7 Figure 7 - Minimum Clearances for T ermination Cap LOCA TION OF TERMINA TION CAP Fixed Closed Op en ab le Fixed Closed V V V V V V V V X X V X G G J F B B K N H I A N E L D B M A C B V V A G G B TERMINA TION CAP AIR SUPPL Y INLET GAS METER RESTRICTED AREA (TERMINA TION PROHIBITED) A = clearance above grade, veranda,[...]

www .desatech.com 1 1 1250-01E 8 VENT ING INST ALLA TION INSTRUCTIONS NOTICE: Read these instruc-                           -  These models are tested and approved for use with DESA (dire ct-ven t) pipe com[...]

www .desatech.com 1 1 1250-01E 9 INST ALLA TION PLANNING There are two basic types of direct-vent in - stallation: • Horizontal T ermination • V ertical T ermination Horizontal T ermination Installation IMPORTANT : Horizontal square terminations require only inner portion of wall restop. Hori - zon tal inst all atio ns using rou nd termi nat[...]

www .desatech.com 1 1 1250-01E 10 VENTING INST ALLA TION INSTRUCTIONS Continued W ARNING: Do not recess       6.  ?[...]

www .desatech.com 1 1 1250-01E 1 1 VENTING INST ALLA TION INSTRUCTIONS Continued Figure 13 - T ypical Horizontal T ermination Cap Mounting with Additional Siding Standoff Installed Siding Standoff Screws High Wind T ermination Apply Mastic to Outside Edge of Standoff Exterior W all with Vinyl Siding 10" x 10" Framed Opening Maintain 1&quo[...]

www .desatech.com 1 1 1250-01E 12 CORN ER AND AL TERNA TE INST ALL A TIO N Recommended Applications: • Corner ground oor installation • G ro un d  o or in st a l la ti on w he re pi p e v en ts ho ri zo n - ta lly th rou gh wal l ( ove r 12" horizontal pipe) • Basement installation where one foot clearance from ground to terminatio[...]

www .desatech.com 1 1 1250-01E 13 VENTING INST ALLA TION INSTRUCTIONS Continued      Horizontal (H 1  Horizontal (H 1  Horizontal (H 2  5' min. 2' max. 6' max. 6' min. 4' max. 12' max. [...]

www .desatech.com 1 1 1250-01E 14 INST ALLA TION FOR VERTICAL TERMINA TION Note: V ertical restrictor must be installed in all vertical installations. 1. Determine the route your vertical venting will take. If ceiling joists, roof rafters or other framing will obstruct the venting system, consi der an offse t (see Figure 19) to avoid cut - ting loa[...]

www .desatech.com 1 1 1250-01E 15 5. Pla ce the  ash in g o ver t he pi pe sec tio n( s) extendin g through the roof. Secure the base of the ashing to the roof and framing with roof - ing nails. Be sure roong materi al overlap s the top edge of the ashing as shown in Figure 19, page 14. There must be a 1" clearance from the vent pi[...]

www .desatech.com 1 1 1250-01E 16 VENTING INST ALLA TION INSTRUCTIONS Continued Note : Install restrictor into inner collar of replace as shown.    V ertical (V 1   5' min. 6' max. 6' min. 12' max. 7&a[...]

www .desatech.com 1 1 1250-01E 17   AND COMPONENTS      P47-6 6" Section Coaxial Pipe, Galvanized P47-12 12" Section Coaxial Pipe, Galvanized [...]

www .desatech.com 1 1 1250-01E 18 FIREPLACE INST ALLA TION  Use proper gas type for replace unit you are installing. If your gas supply is not correct, do not install replace. See retailer where you purchased the replace for proper replace according to your gas type or to purchase gas conversion[...]

www .desatech.com 1 1 1250-01E 19 FIREPLACE INST ALLA TION Continued Figure 27 - Location of Wiring Diagram Decal (Model May V ary from Illustration) Wiring Diagram Decal 12" in Front of Burner 9. Check to make sure power cord is completely clear of blower wheel and there are no other foreign objects in blower wheel. Turn blower on and check f[...]

www .desatech.com 1 1 1250-01E 20 1 1. Peel off backing paper and stick supplied wiring diagram decal on rebox bottom ap - proxima tely 12" in front of blower (see Figure 27, page 19).       ?[...]

www .desatech.com 1 1 1250-01E 21 FIREPLACE INST ALLA TION Continued Figure 31 - Gas Connection CSA Design-Certied Equipment Shutoff V alve with 1/8" NPT T ap* 3" Minimum Approved Flexible Gas Line Cap Pipe Nipple T ee Joint Sediment T rap/Drip Leg Natural - From Gas Meter (5.5" W .C. to 10.5" W .C. Pressure) * The CSA design[...]

www .desatech.com 1 1 1250-01E 22 PRESSURE TESTING GAS SUPPL Y PIPING SYSTEM T est Pressures In Excess Of 1/2 PSIG  1. Dis conne ct rep lac e and i ts indiv idual equ ip - ment shutoff valve from gas supply piping sy st em . Pr es su res in exc es s of 1/ 2 ps ig (3. 5 kPa ) wil l dam age  repla ce ga s reg ul ato r[...]

www .desatech.com 1 1 1250-01E 23 INST ALLING OPTIONAL W ALL MOUNT SWITCH - GWMS2 1. Connect one terminal of 25 ft. wire for wall switch to TPTH terminal on the valve. Con - nect remaining wire terminal to the TH termi - nal on the valve. Make sure wire terminals are in positions on unit as pictured in Figure 36. If wires are not connected as shown[...]

www .desatech.com 1 1 1250-01E 24 REMOVING/REPLACING GLASS DOOR                   ?[...]

www .desatech.com 1 1 1250-01E 25        [...]

www .desatech.com 1 1 1250-01E 26 6. Place log #6 (left log) onto two pins on left side of back and front log. See Figure 48. 7. Pla ce lava rock alon g sid es and front of rebox bottom in areas that are visible only . It is not necessary to use all of lava rock provided.     ?[...]

www .desatech.com 1 1 1250-01E 27 4. Push in gas control knob slightly and turn clockwise to OFF . 5. W ait ve (5) minutes to clear out any gas. Then smell for gas, including near the oor . Ifyousmell gas,STOP!Follow“B” inthe safe ty info rmati on in[...]

www .desatech.com 1 1 1250-01E 28 OPERA TING FIREPLACE Continued MANUAL LIGHTING PROCEDURE 1. Rem ove  gla ss doo r (se e Remo vin g/R epl aci ng Glass Door ,page24.) 2. Follow steps 1 through 7 under Lighting Instructions, page27 . 3. Depress gas control knob and light pilot with[...]

www .desatech.com 1 1 1250-01E 29 4.  Press the POWER and LOCK buttons togethertoturnoffther eplace Note:  Do not leave the hand-held remote in the AUT O mode close to the replace. The radiant heat from the replace willturn offthe[...]

www .desatech.com 1 1 1250-01E 30 INSPECTING B URNERS Check pilot ame pattern and burner ame pat - terns often.    The pilot assembly is factory preset for the proper ame. Alt erations may have occurred during ship - ping and handling. The pilot is located on the back right hand side of the burner [...]

www .desatech.com 1 1 1250-01E 31        -                     ?[...]

www .desatech.com 1 1 1250-01E 32 TROUBLESHOO TING      [...]

www .desatech.com 1 1 1250-01E 33  Pilot lights but ame goes out when control knob is released Burner does not light after pilot is lit Delayed ignition burner Burner backring during com - bustion Slight smoke or odor during initi al operation  1. G as c[...]

www .desatech.com 1 1 1250-01E 34  Heater produces a whistling noise when burner is lit Glass soots Fire plac e produc es a cl icki ng/t ick - ing noise just after burners are lit or shut off Remote does not function Fireplace shuts off in use  1. T urn ing ga[...]

www .desatech.com 1 1 1250-01E 35 TROUBLESHOO TING Continued         ?[...]

www .desatech.com 1 1 1250-01E 36 REPLACEMENT P ARTS Note: Use only original replacement parts. This will protect your warranty coverage for parts replaced under warranty . P ARTS UNDER W ARRANTY Contact authorized retailers of this product. If they can not supply original replacement part(s), call DESA ’ s Customer Service Department at 1-866-67[...]

www .desatech.com 1 1 1250-01E 37      - Rolled Louver , Black  - Filligree, Black  - Filligree, Brushed Brass  - Filligree, Platinum  - Filligree, Polished Brass ?[...]

www .desatech.com 1 1 1250-01E 38 ILL USTRA TED P ARTS BREAKDOWN     ?[...]

www .desatech.com 1 1 1250-01E 39 P ARTS LIST     [...]

www .desatech.com 1 1 1250-01E 40 ILL USTRA TED P ARTS BREAKDOWN   ?[...]

www .desatech.com 1 1 1250-01E 41     DESCRIPTION   1 1 1 102 Screw #8-32 x 3/8 PPH Zinc 2 2 1 1 105 Screw #10 x 1/2 Zinc 9 3 1 1 179 Screw #10-24 x 1/4 Zinc 4 4 1 1237 Screw , T rilab M4 x 8 mm 1 5 14389 Millivolt V alve (Natural) 1 14390 Millivolt V alve (Propane/LP) 1 6 14492 Piezo Ignitor[...]

www .desatech.com 1 1 1250-01E 42 NO TES _____________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ___________________________________[...]

www .desatech.com 1 1 1250-01E 43 NO TES _____________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ___________________________________[...]

2701 Industrial Drive P .O. Box 90004 Bowling Green, KY 42102-9004 www .desatech.com NOT A UPC 1 1 1250-01 Rev . E 03/06 WARRANTY INFORMA TION KEEP THIS WARRANTY Model Serial No. Date Purchased Always specify model and serial numbers when communicating with the factory . W e reserve the right to amend these specications at any time without notic[...]