Desa (V)VC36PE SERIES, (V)VC36NE SERIES инструкция обслуживания

For more information, visit www .desatech.com W ARNING: If the information in this manual is not fol-           ?[...]

www .desatech.com 1 16235-01G 2 SAFETY INFORMA TION T ABLE OF CONTENTS Safety Information ............................................... 2 Product Identication ........................................... 4 Local Codes......................................................... 4 Product Features ................................................. 5 [...]

www .desatech.com 1 16235-01G 3 This replace must be installed by a qualied (cer - tied or licensed) service person. It has a sealed gas combustion chamber that uses a coaxial pipe (pipe within a pipe and having the same center) venting system. It brings in fresh air for combus - tion through the outer pipe and combustion gases are exhaust[...]

www .desatech.com 1 16235-01G 4 2. If you smell gas • shut off gas supply • do not try to light any appliance • do not touch any electrica l switch; do not use any phone in your building • immediately call your gas supplier from a neighbor ’ s phone. Follow the gas supplier's instructions • if you cannot reach your gas supplier, ca[...]

www .desatech.com 1 16235-01G 5 PRODUCT FEA TURES These are a few facts that can help you understand and enjoy your direct-vent replace: • The venting system may be routed to the out - side of your home in several ways. It may vent through the roof (vertical) or it may vent to an outside/exterior wall (horizontal). The vent pipe installation i[...]

www .desatech.com 1 16235-01G 6 • Y our replace is designed to be used in zero clea ranc e install atio ns. W all or fram ing mater ial can be placed directly against any exterior sur - face on the back, sides or top of your replace, except where standoff spacers are integrally atta ched . If stand of f spac ers are attach ed to your rep[...]

www .desatech.com 1 16235-01G 7 A B E F G H D C Nailing T abs Figure 4 - Framing Clearances for Installation Against an Exterior Wall 36 1 / 8 " 41 1 / 4 " 21" Horizontal V ent 24 1 / 2 " V ertical V ent C B A D E F G T op of Louver Opening 3 2 1 4 5 6 7 W all Figure 5 - Framing Clearances for Corner Installation  Ma[...]

www .desatech.com 1 16235-01G 8 Figure 7 - Minimum Clearances for T ermination Cap LOCA TION OF TERMINA TION CAP Fixed Closed Op en ab le Fixed Closed V V V V V V V V X X V X G G J F B B K N H I A N E L D B M A C B V V A G G B TERMINA TION CAP AIR SUPPL Y INLET GAS METER RESTRICTED AREA (TERMINA TION PROHIBITED) A = clearance above grade, veranda, [...]

www .desatech.com 1 16235-01G 9 VENT ING INST ALLA TION INSTRUCTIONS NOTICE: Read these instruc-                           -  Thes e mod els a re te sted and app roved f or us e with DESA (direct-vent) pipe[...]

www .desatech.com 1 16235-01G 10 INST ALLA TION pLANNING There are two basic types of direct-vent in - stallation: • Horizontal T ermination • V ertical T ermination Horizontal T ermination Installation IMPORTANT : Horizontal square terminations require only inner portion of wall restop. Hori - zon tal inst all atio ns using rou nd termi nat[...]

www .desatech.com 1 16235-01G 1 1 VENTING INST ALLA TION INSTRUCTIONS Continued W ARNING: Do not recess       6.  ?[...]

www .desatech.com 1 16235-01G 12 VENTING INST ALLA TION INSTRUCTIONS Continued Figure 13 - T ypical Horizontal T ermination Cap Mounting with Additional Siding Standoff Installed Siding Standoff Screws High Wind T ermination Apply Mastic to Outside Edge of Standoff Exterior W all with Vinyl Siding 10 3 / 4 " x 10 3 / 4 " Framed Opening Ma[...]

www .desatech.com 1 16235-01G 13 CORNER INST ALLA TION Recommended Applications: • Corner ground oor installation • G ro un d  o or in st a ll at io n w he re pi p e ve nt s ho ri zo n - ta lly th rou gh wal l ( ove r 12" horizontal pipe) • Basement installation where one foot clearance from ground to termination is possible VENTIN[...]

www .desatech.com 1 16235-01G 14 VENTING INST ALLA TION INSTRUCTIONS Continued      Horizontal (H   Horizontal (H   Horizontal (H   5' min. 2' max. 6' max. 6' min. 4' max. 12' [...]

www .desatech.com 1 16235-01G 15    TERMINA TION Note: V ertical restrictor must be installed in all vertical installations. 1. Determine the route your vertical venting will take. If ceiling joists, roof rafters or other framing will obstruct the venting system, consi de[...]

www .desatech.com 1 16235-01G 16 5. Pla ce th e as hing ov er th e pip e sec tion( s) extendin g through the roof. Secure the base of the ashing to the roof and framing with roof - ing nails. Be sure roo ng materia l over laps the top edge of the ashing as shown in Figure 19, page 15. There must be a 1" clearance from the vent pipe[...]

www .desatech.com 1 16235-01G 17 VENTING INST ALLA TION INSTRUCTIONS Continued Note : Install restrictor into inner collar of replace as shown.         5' min. 6' max. 6'[...]

www .desatech.com 1 16235-01G 18   AND COMpONENTS                 P58-6 6" Section Double W all Pipe, Galvanized P58-12 12&[...]

www .desatech.com 1 16235-01G 19 FIREPLACE INST ALLA TION  Us e pro per ga s typ e for the r ep la ce un it yo u are in st al li ng . If you hav e co n ic ti ng gas typ es , do not in st al l re plac e. See reta ile r whe re yo u pur chas ed th e re plac e f or p ro pe r re plac e a cc or di [...]

www .desatech.com 1 16235-01G 20 CA UTI ON: Nev er to uc h th e            9. Ch ec k to mak e sure th at the pow er cor d is com - pl et el y cl ea r of t he b lo we r wh ee l an d t hat t he re ar e no oth er for ei gn obj ect s in bl ow er whe el. Tu [...]

www .desatech.com 1 16235-01G 21 7. Che ck to ma ke su re t ha t th e po we r co rd is c om - pl ete ly c lea r of th e b low er w he el a nd t ha t th ere a re no ot he r f or ei gn o bj ec ts i n b lo we r wh ee l . A ls o do ubl e c he ck al l w ir e l ea ds an d m ak e s ur e w ir e ro uti ng is no t pi nc he d or in a p re car iou s pos it io [...]

www .desatech.com 1 16235-01G 22 Figure 30 - External Regulator with V ent Pointing Down (Propane/LP Only) Propane/LP Supply T ank External Regulator V ent Pointing Down CAUTION: Use only new ,       - ?[...]

www .desatech.com 1 16235-01G 23 FIREPLACE INST ALLA TION Continued             and connections , internal and external to unit, for leaks after  [...]

www .desatech.com 1 16235-01G 24 pRESSURE TESTING FIREpLACE GAS CONNECTIONS 1. Open equipment shutof f valve (see Figure 33, page 23). 2. O pe n p ro p a ne / L P s u p pl y t an k v al v e f o r propane/LP fireplace or main gas valve located on or near gas meter for natural gas replace. 3. Make sure control knob of replace is in the OFF posi[...]

www .desatech.com 1 16235-01G 25 4. Remount the new frame at the hinge with ve new s crew s bef ore c losin g do or . Th is wi ll ensure seating of the gasket. 5. Cl os e g la ss d oo r fr am e. L oc k l at che s by p la ci ng th e ba r u nd er t he ta b on do or a nd p us hi ng do wn an d bac k on la t ch ( se e Fi gu re 37, p age 24). 6. Repla[...]

www .desatech.com 1 16235-01G 26 6. Install rear brick panel rst. Rest bottom edge of panel on back edge of burner assembly (see Figure 39). 7. Install left side brick panel by sliding it be - tween the burner assembly and the side of the rebox (see Figure 39). 8. Install the right brick panel using the same method described in step 6 for lef[...]

www .desatech.com 1 16235-01G 27 EV2 EV1 ORANGE IGNITOR LEAD GREEN PILOT TRANSFORMER IS1070B SYNETEK CONTROLS INC 24V AC E4 E2 E3 E6 RED E8 E12 BLUE 120V AC GROUND BLACK WHITE WIRING DIAGRAM[...]

www .desatech.com 1 16235-01G 28 6. W ait ve (5)minutes toclear outany gas. Then smell for gas, including near the oor . Ifyousmell gas,STOP!Follow“B”inthe safet y inform ation in cloumn  1. If you don't smellgas,gotot[...]

www .desatech.com 1 16235-01G 29 OpTIONAL REMOTE OpERA TION Not e:  The WRC receiver and hand-held r e - motecontr olkitmust bepurchased separately (see Accessories , page 35). Follow installation instructionsonpage26. 1. T u r n e qu ip me n t s hu to ff v al ve t o ?[...]

www .desatech.com 1 16235-01G 30 C L E A N IN G AN D M A I N T EN AN C E                           ?[...]

www .desatech.com 1 16235-01G 31  Conduct annual inspection of the venting system following these guidelines: 1. Check areas of venting system that are ex - posed to the weather for corrosion (rust spots or streaks and, in extreme cases, holes). Have these items replaced immediately by a quali - ed servi[...]

www .desatech.com 1 16235-01G 32  Pilot will not stay lit No gas to burner , although wall switch and valve are set to the ON position Frequent pilot outage Fir epla ce produ ces a clicki ng/t ick - ing noise just after burner is lit or shut off Slight smoke or odor during initial operation REMEDY 1 .[...]

www .desatech.com 1 16235-01G 33 TROUBLESHOO TING Continued         [...]

www .desatech.com 1 16235-01G 34 REPLACEMENT P ARTS Note : Use only original replacement parts. This will protect your warranty coverage for parts replaced under warranty . p ARTS UNDER W ARRANTY Contact authorized retailers of this product. If they can not supply original replacement part(s), call DESA ’ s Customer Serv ice Department at 1-866-6[...]

www .desatech.com 1 16235-01G 35    - Black  - Brushed Brass  - Platinum  - Polished Brass  Ma nu al va ri abl e c ont ro l blo we r acce[...]

www .desatech.com 1 16235-01G 36 ILL USTRA TED P ARTS BREAKDOWN   6 7 22 19 20 15 2 14 21 8 1 4 13 9 16 3 18 5 17 23 10 1 1 12 24[...]

www .desatech.com 1 16235-01G 37 P ARTS LIST   This list contains replaceable parts used in your replace. When ordering parts, follow the instructions listed under Replacement Parts on page 34 of this[...]

www .desatech.com 1 16235-01G 38 7 15 10 12 3 2 13 9 23 24 22 21 1 1 25 27 26 29 30 28 33 32 31 6 12 14 18 17 17 18 19 20 16 14 8 4 5 1 12 ILL USTRA TED P ARTS BREAKDOWN     ?[...]

www .desatech.com 1 16235-01G 39 P ARTS LIST      This list contains replaceable parts used in your replace. When ordering parts, follow the instructions listed [...]

2701 Industrial Drive P .O. Box 90004 Bowling Green, KY 42102-9004 www .desatech.com NOT A UPC 1 16235-01 Rev . G 03/06 WARRANTY INFORMA TION KEEP THIS WARRANTY Model Serial No. Date Purchased Always specify model and serial numbers when communicating with the factory . W e reserve the right to amend these specications at any time without notice[...]