Drolet 45109A инструкция обслуживания

REA D A ND KEEP THIS MA NUA L FOR REFERENC E 45109A 2010 - 09 - 22 INSTRUCTIONS & OPERATIONS MANUAL DROLET COMPAK EPA EXEMPT US ENVIRONMENTAL PROT ECTION AGENCY 28A CERTIFIED W OODST OVES Verified and tested follow ing UL 1482 Standards by : Manufactured by : S T OVE BUILDER INTERNA T IONA L INC. 1700, Leon -Harm el, Quebec (Quebec) G1N 4R9 Tel[...]

1 TA BLE OF CONTENTS INTRODUCTION ................................................................................................................. 2 ASSEMBLY ................................................................ ......................................................... 3 INSTALLA TION ....................................................[...]

2 IN TR OD UC TI ON ST OVE BUILDER INTERNATIONAL INC., one of th e most imp ortant wood stove an d fireplace manuf acturers in Canada, congratulates you on your purchase an d wishes to help you get maximum satisf action from your wood stove. In th e pages that f ollow, we will give you ad vice on wood heating and controlled co mbustion as well as t[...]

3 A S SE MB LY Legs installation: Position the stove on its back and screw the legs in place with 8 screws, 8 bolts, an d 8 washers; A sh lip Install ation: Screw in place w ith 2 bolts, 2 screws, and 2 washers.[...]

4 Cast iron flue collar i nstallation: 1. Peel of f the tape from the back of the gasket and attac h the gasket to the rope groove at the back o f the f lue collar; 2. Mount flue collar on top of the stove. Make sure tha t the damper ho les on each side o f the f lue collar are parallel to th e back of the stove; 3. Fix the flue collar with the har[...]

5 IN ST A LLA TIO N SA FETY NOTICE I F THIS S TOVE IS NOT PROPERLY INSTALLE D , A HOUSE FIRE MAY RESULT . T O REDUCE THE RISK OF FIRE , FOLLOW THE INSTALLATION INSTRUCTIONS . F AILURE TO FOLLOW INSTRUCTIONS MAY RESULT IN PROPERTY DAMAGE , BODILY INJURY , OR EVEN DEATH . C O NSULT YOUR MUNICIPAL BUILDING DEPARTMENT OR FIRE OFFICIALS A BOUT RESTRICTI[...]

6 C LE A R A N CE S FR OM C OMB US T IB LE S It is o f outmost importan ce tha t the clearanc es to com bustible m aterials be scrupulously respected up on installation of the stove you have selected. Refer to the t ables below : Single pipe / Double pipe A B C D E F 29” 30” 39” 34- 3/4” 22” 32” Floor to ceiling height m ust be at lea s[...]

7 C HI MNE Y Your wood stove may be hooked up with a factory built or m asonry chimney. If you are using a f actory built chimney, it must comply with UL 103 sta ndards; th erefore it must be a Type HT (210 0°F). It is extremely imp ortant that it b e installed according to the manuf acturer's specification s. If you are using a ma sonry chim[...]

8 C HI MNE Y CO NN E CT OR ( ST OV E PI PE ) The stove pipe must be made of aluminized or cold roll steel with a minimum thickness of 0.021" o r 0.53 mm. I t is strictly forbidden to u se galvaniz ed steel. Your smoke pipe should be assembled in such a way th at the mal e section of the pipe faces down. Attach each of the sections to o ne ano [...]

9 T YP IC A L IN ST A LL A T IO NS FA CTORY BUILT CHIMNEY: ROOF FLASH ING 18 " CL EARAN CE WAL L SU PPORT WAL L RADI AT ION SHIE LD RAIN CAP Wall installa tion CEIL ING SUP PORT RADI AT ION S HIEL D Vertical install ation[...]

10 MA SONRY CHIMNEY: Cl a y li ne r T hi m b le Cl e an out door[...]

11 FA CTORY BUILT THIMBLE:[...]

12 BRICK THIMBLE:[...]

13 WO OD S TO VE U TIL IS A TI ON Your h eating unit was designed to b urn wood only; no other m aterials should be b urnt. W aste s and othe r f lammable materials should not be burnt in your wood stove. Any type of wood may be used in your sto ve, b ut specific vari e ties have better e nergy yields than others. Plea se consult the f ollowing tab[...]

14 Smaller piece s of wood will dry faste r. All logs exceeding 6" in diam eter should be split. The wood sho uld not be sto red directly on the ground. Air should circulate through the cord. A 24 " to 48" a ir space sh ould be left between each row of logs, which should be placed in the su nniest location possible. Th e u pper lay e[...]

15 A SH D IS PO SA L Ashes sh ould be remo ved from the stove every few days or when ashes get to 2 to 3 inches deep . Alway s e mpty the stove when it is cold, such a s in the morning. Always dispose of ashes in a metal containe r with a tight fitting lid. Place this con tainer on a non combustible floo r or on the ground, well a w a y f rom a ll [...]

16 A IR C IR CU LA TI ON S YS T EM In order to improve air circulation in the room where the wood sto ve is installed, certain options are a vailable for specific sto ve models. Blowe r: A variable spe ed-control blower is available. T he part numbe r is AC02050. Thermodisc: The thermod isc is installed on th e blower's electrical supply cord,[...]

17 WA RNING: N EVERS OPERATE THE STOVE W ITHOUT A GASKET OR W ITH A BROKEN ONE . D AMAGE TO THE STOVE OR EVEN HOUSE FIRE MAY RESULT PA IN T Only clean your stove with a dry soft clothe th at will not harm the paint f inish. If the paint beco mes scrat ched or damaged, it is p ossible to give your wood stove a brand new loo k, by repainting it with [...]

18 DR O LE T LI MI TE D LI FE TI ME WA RRA N TY The w arr anty of the m anufacturer e xtends only to the original consumer purchaser and is not transferable. T his warranty covers brand new products only, which have not been alter ed, modified nor repaired since shipmen t from factory. Proof o f purchase (dated bill of sale), model name and ser ial[...]