Henny Penny OFE/OFG-342 инструкция обслуживания

Model OFE/OFG/OEA/OGA-341, 342 Henny Penny High Volume Open Fryer Model OFE/OFG-341 Model OFE/OFG-342 Model OEA/OGA-341 Model OEA/OGA-342 TECHNICAL MANUAL[...]

Model OFE/OFG/OEA/OGA-341, 342[...]

Model OFE/OFG/OEA/OGA-341, 342 This manual should be retained in a c onvenient location for future reference. A wiring diagram for this appliance is locat ed on the inside of the right side panel. Post in a prominent location, instructions to be follo wed in event user smells gas. This inform ation shall be obtained by consulting the local gas supp[...]

Model OFE/OFG/OEA/OGA-341, 342 TABLE OF CONTENTS Section Page Section 1. TROUBLESHOOTING ................................................................................................... 1-1 1-1. Introduction ............................................................................................................ .1-1 1-2. Safety .............[...]

Model OFE/OFG/OEA/OGA-341, 342 1-1. INTRODUCTION This section provides troubleshooting information in the form of an easy to read table. If a problem occurs during the first operation of a new fryer, recheck the Installation Section of the Operator’s Manual. Before troubleshooting, always recheck the Operation Section of the Operator’s Manual. [...]

Model OFE/OFG/OEA/OGA-341, 342 1-3. TROUBLESHOOTING To isolate a malfunction, proceed as follows: 1. Clearly define the problem or symptom and when it occurs. 2. Locate the problem in the Troubleshooting table. 3. Review all possible causes, then one at a time work through the list of corrections until the problem is solved. If maintenance procedur[...]

Model OFE/OFG/OEA/OGA-341, 342 1-3. TROUBLESHOOTING(Continued) PROBLEM CAUSE CORRECTION Heating of • Low or improper • Use a meter and check the receptacle shortening too voltage (elec. unit) voltage against the data plate slow • Weak or burnt out • Check heating elements per Heating elements (elec. unit) Elements Section • Wire(s) loose [...]

Model OFE/OFG/OEA/OGA-341, 342 1-2. TROUBLESHOOTING (Continued) PROBLEM CAUSE CORRECTION Shortening will not • Drain valve clogged • Open valve, force cleaning brush through drain from frypot with crumbs drain • Drain valve will not • Replace cotter pins in valve coupling open by turning handle Filter motor runs • Pump clogged • Remove [...]

Model OFE/OFG/OEA/OGA-341, 342 1-4. ERROR CODES In the event of a control system failure, the digital display shows An error message. These messages are coded: “E4”, “E5”, “E6”, “E10”, “E15”, “E20”, “E31”, “E41”, “E46”, and “E92”. A Constant tone is heard when an error code is displayed, and to silence this t[...]

Model OFE/OFG/OEA/OGA-341, 342 1-4. ERROR CODES (Continued) DISPLAY CAUSE PANEL BOARD CORRECTION “E-20 A” Vacuum Press the timer button to try the ignition process again, switch failure and if “E-20 A” persists, check the air switch per Vacuum (stuck closed) Switch Section “E-20 B” Draft fan or Press the timer button to try the ignition[...]

Model OFE/OFG/OEA/OGA-341, 342 2-1. INTRODUCTION This section provides procedures for the check out and replacement of the various parts used within the fryer. Before replacing any parts refer to the Troubleshooting Section. It will aid you in determining the cause of the malfunction. 2-2. MAINTENANCE HINTS 1. You may need to use a multim eter to c[...]

Model OFE/OFG/OEA/OGA-341, 342 1-3. HIGH TEMPERATURE 2. Using a Phillip’s head screwdriver, remove the screws securing LIMIT CONTROL the inner heat shield and remove from unit. Figure 2-3. (Gas Units) (Continued) Figure 2-3 3. Remove the screw securing the high limit bracket to the fram e and remove the high limit and bracket from unit. Figure 2-[...]

Model OFE/OFG/OEA/OGA-341, 342 2-3. HIGH TEMPERATURE LIMIT CONTROL (Gas Units) (Continued) Replacement To avoid electrical shock or property damage, move the power switch to OFF and disconnect main circuit breaker, or unplug cord at wall receptacle. 1. If the tube is broken or cracked, the control opens, shutting off electrical power to the heat ci[...]

Model OFE/OFG/OEA/OGA-341, 342 2-4. COMPLETE CONTROL Should the control board become inoperative, follow these PANEL REPLACEMENT instructions for replacing the board. 1. Remove electrical power supplied to the unit. To avoid electrical shock or property damage, move the power switch to OFF and disconnect main circuit breaker, or unplug cord at wall[...]

Model OFE/OFG/OEA/OGA-341, 342 2-5. POWER SWITCH (Continued) 4. With control panel removed, and the wires off the switch, push in on tabs on the switch to remove from panel. Figure 2-12. 5. Replace with new switch, and reconnect wires to switch. 6. Replace the control panel. Figure 2-12 2-6. TEMPERATURE PROBE The temperature probe relays the actual[...]

Model OFE/OFG/OEA/OGA-341, 342 2-6. TEMPERATURE PROBE 5. Remove the probe from the frypot, and disconnect wire REPLACEMENT (GAS) connector from the control panel. Figure 2-15. (Continued) 6. Place the nut and new ferrule on the new probe and insert the probe into the compression fitting until it extends one (1) inch (2.54cm) into the frypot. Figure[...]

Model OFE/OFG/OEA/OGA-341, 342 2-7. TEMPERATURE PROBE 4. Using a ½ inch wrench, remove the nut on the compression REPLACEMENT fitting. Figure 2-18. (ELECTRIC) (Continued) 5. Remove the probe from the frypot, and disconnect probe. 6. Place the nut and new ferrule on the new probe and insert the probe into the compression fitting until it extends on[...]

Model OFE/OFG/OEA/OGA-341, 342 2-8. FLAME SENSOR/ PILOT / IGNITOR ASSEMBLY (Gas) (Continued) 2. Remove the control panel and heat shield from control area. Figure 2-19. Figure 2-19 3. Disconnect the flame sense wire from ignition module. Figure 2-20. Figure 2-20 4. Using a 7/16” wrench, loosen the nut on the pilot tube and pull tube from assembly[...]

Model OFE/OFG/OEA/OGA-341, 342 2-9. IGNITION MODULE During normal operation, the ignition m odules send 24 volts to the ignitors and gas valve. If a module does not sense a pilot flame, the module starts the ignition process again. But, if a pilot light goes out for longer that 10 seconds, or it goes out 3 times within 10 seconds, the module keeps [...]

Model OFE/OFG/OEA/OGA-341, 342 2-10. TRANSFORMER The transformer reduces voltage down (to 24V) to accommodate REPLACEMENT those components with low voltage. 1. Remove electrical power supplied to the unit. To avoid electrical shock or property damage, move the power switch to OFF and disconnect main circuit breaker, or unplug cord at wall receptacl[...]

Model OFE/OFG/OEA/OGA-341, 342 2-12. VACUUM SWITCH This switch senses the airflow from the induction blower. If REPLACEMENT the airflow is reduced below a set amount, the switch opens and the I/O board cuts power to the gas control valve, which shuts the p i l o t f l a m e o f f . 1. Remove electrical power supplied to the unit. To avoid electrica[...]

Model OFE/OFG/OEA/OGA-341, 342 2-13. DRAIN MICROSWITCH Upon turning the drain handle, the drain microswitch should REPLACEMENT “open”, cutting off the pilot flam e. This will prevent the fryer from heating while shortening is being drained from the frypot. 1. Remove electrical power supplied to the unit. To avoid electrical shock or property da[...]

Model OFE/OFG/OEA/OGA-341, 342 2-14. FILTER SWITCH 3. Label and remove the wires from the switch. With test REPLACEMENT instrument check across the term inals of the switch. With the (Continued) switch in the on position, the circuit should be closed. With the switch in the off position, the circuit should be open. If the switch is defective, repla[...]

Model OFE/OFG/OEA/OGA-341, 342 2-15. GAS CONTROL VALVE REPLACEMENT (Continued) 1. Remove right side panel. Figure 2-37. Figure 2-37 2. Label and remove wires from gas valve. Figure 2-38 Figure 2-38 3. Using a 7/16 wrench, remove the pilot line from the gas valve. Figure 2-39. Figure 2-39 4. Using a 1-inch wrench, loosen the nut securing the main ga[...]

Model OFE/OFG/OEA/OGA-341, 342 2-15. GAS CONTROL VALVE REPLACEMENT (Continued) 5. Using a pipe wrench, loosen the outlet fitting to the burner. Figure 2-41. Figure 2-41 6. Using a Phillips screwdriver, remove the 2 screws securing the gas valve to the bracket and remove gas valve from unit. Figure 2-42. 7. Remove the fittings from the gas valve and[...]

Model OFE/OFG/OEA/OGA-341, 342 2-16. BLOWER MOTOR REPLACEMENT (Continued) 3. Remove the wire cover from the blower motor housing. Figure 2-44. Figure 2-44 4. Remove wire nuts connecting blower motor wires to wires in conduit. Figure 2-45. Figure 2-45 5. Loosen conduit from blower motor. Figure 2-46. Figure 2-46 7. Remove screws connecting flue to b[...]

Model OFE/OFG/OEA/OGA-341, 342 2-16. BLOWER MOTOR REPLACEMENT (Continued) 8. Using 3/8 inch nut driver, remove nuts securing blower to the unit. Figure 2-48. Pull blower from unit. Figure 2-48 9. Install new blower in reverse order. 2-17. HEATING ELEMENTS (ELECTRIC) Heating elements are available for 208 and 230 voltage. Check data plate to determi[...]

Model OFE/OFG/OEA/OGA-341, 342 2-17. HEATING ELEMENTS 4. Perform an ohm check on one elem ent at a time, with wires (ELECTRIC) disconnected. The 2 elements actually have 3 small heating (Continued) elements inside the outer plate. It’s im portant to check between the correct wires to obtain an accurate ohm reading. The wires are labeled for your [...]

Model OFE/OFG/OEA/OGA-341, 342 2-18. HEATING Each well of an electric fryer requires two switching contactors. CONTACTORS The first in line is the primary contactor and the second in line is (ELECTRIC) the heat contactor. When open, the primary contactor does not allow power to flow to the heat contactor. When closed, the primary supplies voltage t[...]

Model OFE/OFG/OEA/OGA-341, 342 2-18. HEATING CONTACTORS (ELECTRIC) (Continued) To avoid electrical shock, make connections before applying power, take reading, and remove power before removing meter leads. The following checks are performed with the wall circuit breaker closed and the main power switch in the ON position. 1. Re-apply power to unit [...]

Model OFE/OFG/OEA/OGA-341, 342 2-18. HEATING CONTACTORS (ELECTRIC) Continued) 2. Remove the screws securing the contactor to the shroud, and remove contactor. Figure 2-55. 3. Install new contactor, and see steps 4 and 5. Figure 2-55 Replacement (Primary Contactor) 1. Remove only the wires directly connected to the contactor being replaced. Label th[...]

Model OFE/OFG/OEA/OGA-341, 342 2-19. SPEAKER ASSEMBLY The speaker assembly emits audible signals to let the operator know when cooking and hold times are finished. 1. Remove electrical power supplied to unit. To avoid electrical shock or property damage, move the power switch to OFF and disconnect main circuit Figure 2-58 breaker, or unplug cord at[...]

Model OFE/OFG/OEA/OGA-341, 342 2-20. HIGH TEMPERATURE This high temperature control is a safety, manual reset control, LIMIT CONTROL which senses the temperature of the shortening. If the short- (ELECTRIC) ening temperature exceeds 425 ° F (218 ° C), this switch opens and shuts off heat to the frypot, and E10 shows in control display. When the te[...]

Model OFE/OFG/OEA/OGA-341, 342 2-20. HIGH TEMPERATURE LIMIT CONTROL (ELECTRIC) (Continued) 4. Pull back cardboard cover and remove the two electrical wires from the high temperature lim it control. Figure 2-66. Figure 2-66 5. Manually reset the control, then check for continuity between the two terminals after resetting the control. If the circuit [...]

Model OFE/OFG/OEA/OGA-341, 342 2-20. HIGH TEMPERATURE LIMIT CONTROL (ELECTRIC) (Continued) 4. Straighten the capillary tube, and pull capillary tube through the hole in the element hinge, from the rear of the fryer. 5. Remove the defective control from the fryer. Figure 2-69 6. Straighten the capillary tube on the new high limit, and thread the cap[...]

Model OFE/OFG/OEA/OGA-341, 342 2-21. FILTER PUMP AND 1. Remove electrical power supplied to unit. MOTOR REMOVAL To avoid electrical shock or property damage, move the power switch to OFF and disconnect main circuit breaker, or unplug cord at wall receptacle. 2. Open the door (left door on 2 well units), and remove the 2 screws securing the switch b[...]

Model OFE/OFG/OEA/OGA-341, 342 2-21. FILTER PUMP AND 7. Remove left side panel. MOTOR REMOVAL (Continued) 8. Using 9/16” socket or wrenches, remove the bolts and nuts securing the motor to the bracket and pull pump, motor, and piping from unit. Figure 2-74. Figure 2-74 2-22. AUTOLIFT 1. Remove electrical power supplied to unit. TRANSFORMER REPLAC[...]

Model OFE/OFG/OEA/OGA-341, 342 2-23. AUTOLIFT PC BOARD 1. Remove electrical power supplied to unit. REPLACEMENT (if applicable) Autolift PC Board To avoid electrical shock or property damage, move the power switch to OFF and disconnect main circuit breaker, or unplug cord at wall receptacle. 2. Remove control panel 3. Disconnect connectors from PC [...]

Model OFE/OFG/OEA/OGA-341, 342 2-24. AUTOLIFT ACTUATOR (MOTOR) REPLACEMENT (if applicable) 5. Disconnect actuator connector. Figure 2-80. Figure 2-80 6. Remove female connector from plate. Figure 2-81. Figure 2-81 Figure 2-82 7. Using 7/16” socket, remove the 4 nuts securing the support plate. 2 nuts are behind the insulation. Figures 2-82 & [...]

Model OFE/OFG/OEA/OGA-341, 342 2-24. AUTOLIFT ACTUATOR (MOTOR) REPLACEMENT (if applicable) 8. Remove the 2 top screws securing the support plate and remove the plate from the unit. Figure 2-84. Figure 2-84 9. Using a 15T torx driver, remove the 2 torx screws from the back shroud, and pull the actuator from the unit. Figure 2-85. Figure 2-85 10. Ins[...]

Model OFE/OFG/OEA/OGA-341, 342 Drain switch wired N/C 106 2-31[...]

Model OFE/OFG/OEA/OGA-341, 342 Drain switch wired N/C 2-32 106[...]

Model OFE/OFG/OEA/OGA-341, 342 Drain switch wired N/C 106 2-33[...]

Model OFE/OFG/OEA/OGA-341, 342 Drain switch wired N/C 2-34 106[...]

Model OFE/OFG/OEA/OGA-341, 342 Drain switch wired N/C 106 2-35[...]

Model OFE/OFG/OEA/OGA-341, 342 Drain switch wired N/C 2-36 106[...]

Model OFE/OFG/OEA/OGA-341, 342 Drain switch wired N/C 106 2-37[...]

Model OFE/OFG/OEA/OGA-341, 342 Drain switch wired N/C 2-38 106[...]

Model OFE/OFG/OEA/OGA-341, 342 Drain switch wired N/O 106 2-39[...]

Model OFE/OFG/OEA/OGA-341, 342 Drain switch wired N/O 2-40 106[...]

Model OFE/OFG/OEA/OGA-341, 342 Drain switch wired N/O 707 2-41[...]

Model OFE/OFG/OEA/OGA-341, 342 Drain switch wired N/O 2-42 106[...]

Model OFE/OFG/OEA/OGA-341, 342 Drain switch wired N/O 707 2-43[...]

Model OFE/OFG/OEA/OGA-341, 342 Drain switch wired N/O 2-44 707[...]

Model OFE/OFG/OEA/OGA-341, 342 Drain switch wired N/O 707 2-45[...]

Model OFE/OFG/OEA/OGA-341, 342 Drain switch wired N/O 2-46 106[...]

Model OFE/OFG/OEA/OGA-341, 342 SECTION 3. PARTS INFORMATION 3-1. INTRODUCTION This section list the replaceable parts of the Henny Penny OFE/OFG- 32X Open Fryers. 3-2. GENUINE PARTS Use only genuine Henny Penny parts in your fryer. Using a part of lesser quality or substitute design may result in damage to the unit or personal injury. 3-3. WHEN ORD[...]

Model OFE/OFG/OEA/OGA-341, 342 1 2 3 4 5 Item No. Part No. Description Qty. per Well √ 1 60207 Transformer – 120-24V 1 √ 1 60536 Transformer – 230-24V 1 √ 2 50290 Autolift PC Board 1 √ 3 54561 Speaker Assy. 1 √ 4 72515 Vacuum Switch (Gas Only) 1 √ 5 TS22-012 Transformer-Autolift 1 √ recommended parts 3-2 807[...]

Model OFE/OFG/OEA/OGA-341, 342 Gas Components 1 2 3 4 5 Item No. Part No. Description Qty. per Well √ 1 77602 Ignition Module – CE (OFG-SN: BR0804001 & Above) 2 (OGA-SN: BS0805001 & Above) √ 1 77839 Ignition Module – Non -CE 2 (OFG-SN: BR0804001 & Above) (OGA-SN: BS0805001 & Above) √ 1 14933 Kit - Ignition Module – Non-C[...]

Model OFE/OFG/OEA/OGA-341, 342 Gas Burner Assembly Item No. Part No. Description Qty. per Well 1 FP01-091 Union – ½ NPT Fem ale - BI 1 2 FP01-088 Elbow – Street ½ x 90 BI 2 3 NS03-067 Nut – Locking ½-20 x 3/16 LON 3 4 23389 Weldment - Manifold 1 5 64055-03 Orifices – Burner - LP 3 5 64055-16 Orifices – Burner – Nat. 3 6 21629 Bracket[...]

Model OFE/OFG/OEA/OGA-341, 342 Electric Components 1 2 3 4 5 Item No. Part No. Description Qty. per Well √ 1 29510 Mercury Contactor – 24V 1 √ 2 51795 Standard Contactor – 24V 1 √ 2 65075 Assy.-240v E/M Heat Contactor-CE-240V (UK) 1 √ 2 65074 Assy.-240v E/M Heat Contactor-CE-230V 1 √ 3 18364 Fuse and Holder Assembly (SN: BC0707002 &am[...]

Model OFE/OFG/OEA/OGA-341, 342 1 2 Item No. Part No. Description Qty. per Well 1 60367 Guard - High Limit 1 √ 2 14849 Temperature Probe Assembly (Gas units) 1 √ recommended parts 3-6 806[...]

Model OFE/OFG/OEA/OGA-341, 342 806 3-7[...]

Model OFE/OFG/OEA/OGA-341, 342 Item No. Part No. Description Qty. per Unit 1 14671 Screen Assembly, Filter 1 2 65211 Crumb Catcher 1 3 use 14671 Top Filter Screen 1 4 use 14671 Bottom Filter Screen - SN: BR0502006 & below) 1 4 65447 Bottom Filter Screen - SN: BR0502007 & above) 1 5 17505 Filter Envelope Clips 2 √ 6 12102 Filter Envelope P[...]

Model OFE/OFG/OEA/OGA-341, 342 1 2 3 4 5 6 7 8 9 15 10 14 11 12 13 Item No. Part No. Description Qty. per Unit 1 52064 Caster-4 inch – swivel w/brake 2 √ 2 43768 Switch - Power DPST 125-250V (Filter) 1 √ 2 52224 Covered Power Switch - CE 1 3 17334 Quick Disconnect – Male - 341 1 3 17333 Quick Disconnect – Female - 342 1 4 21800 Valve-3/4 [...]

Model OFE/OFG/OEA/OGA-341, 342 Item No. Part No. Description Qty. per Unit √ 12 52129 Gas Valve - 24V - Nat. 1 (per well) √ 12 60632 Gas Valve - 24V - Nat. - CE 1 (per well) √ 12 21332 Gas Valve - 24 V - LP 1 (per well) √ 12 60633 Gas Valve - 24V - LP - CE 1 (per well) 13 23443 Weld Assy. – Drain Extension – Elec. 1 (per well) 13 24420 [...]

Model OFE/OFG/OEA/OGA-341, 342 1 2 3 4 5 6 7 8 9 Item No. Part No. Description Qty. per Well √ 1 60207 Transformer – 120-24V 1 √ 1 60536 Transformer – 230-24V 1 √ 2 74127RB Control Panel Assy. less transformers 1 √ 3 71029RB Control Board Assy – China 1 √ 4 58790RB I/O Board w/Power Supply Assy. 1 5 21645 Assy -Wire-Tem p Interconne[...]

Model OFE/OFG/OEA/OGA-341, 342 6 1 2 3 4 5 Item No. Part No. Description Qty. per Unit 1 33501 Gas Line – ¾ in. w/Double Swivel – 341 1 1 33167 Gas Line – 1 in. w/Double Swivel – 342 1 √ 2 64197 Blower Motor Assy – 120V 1 (per well) √ 2 21037 Blower Motor Assy – 220V-50 Hz 1 (per well) 3 33353 120V Coiled Power Cord 1 4 63602 Actua[...]

Model OFE/OFG/OEA/OGA-341, 342 5 6 1 2 3 7 4 10 8 9 Item No. Part No. Description Qty. per Well √ 1 43768 Power Switch 1 √ 1 52224 Covered Power Switch - CE 1 2 21687 Decal - Control - 34X 1 3 21008 Door Assembly - 341- Before Jan. 1, 2006 1 3 70207 Door Assembly - 341-Jan. 1, 2006 & After 1 3 21086 Door Assembly - LH - 342 - Before Jan. 1,[...]

Model OFE/OFG/OEA/OGA-341, 342 1 2 3 4 5 6 7 8 Item No. Part No. Description Qty. per Well √ 1 64210-01 Element – OFE34X – 208V 2 √ 1 64210-02 Element – OFE34X – 220V 2 √ 1 64210-03 Element – OFE34X – 230V 2 √ 1 64210-04 Element – OFE34X – 240V 2 √ 1 64210-07 Element – OFE34X – 480V 2 2 24194 Spreader - Front - 34X 1 3[...]

Model OFE/OFG/OEA/OGA-341, 342 1 3 2 Item No. Part No. Description Qty. per Well √ 1 60266 Pilot - Tee Style & Ignitor Assy. 1 23735 Orifice – Pilot – Nat. 1 60614 Orifice – Pilot – LP 1 √ 2 60292 Sensor - Flame - Pilot 1 3 21827 Tube – Pilot 1 3 67817 Tube – Pilot – CE 1 √ recommended parts 106 3-15[...]

Model OFE/OFG/OEA/OGA-341, 342 Electric Components 1 2 3 4 Item No. Part No. Description Qty. per Well  1 60241 High Limit - 425º F 1 2 23823 Assy-Heater Terminal Block 1  3 14973 Temperature Probe Assembly 1  4 18227 Microswitch 1  5* 32497 EMC Filter Board - CE 1  6* 32498 Assy – 4 Inch Terminal Block 1  recommended parts/*no[...]

Model OFE/OFG/OEA/OGA-341, 342 Item No. Part No. Description Qty. per Unit 1 16336 Elbow – Male 1 2 FP02-050 Nipple – ½ x 24 LG BI 1 3 FP01-090 Elbow – ½ NPT x 90 Fem ale - BI 4 4 FP02-051 Nipple – ½ x 17 LG BI 1 5 FP02-052 Nipple – ½ x 4 LG BI 1 6 16335 Male Connector – 37 Flare 2 7 FP01-089 Bushing – Reducing – 3/4M to 1/2F BL[...]

Model OFE/OFG/OEA/OGA-341, 342 Item No. Part No. Description Qty. per Well 1 24809 Hook – Basket Hanger – ½-Size (before 06/01/05) 1 1 70102 Hook – Basket Hanger – ½-Size (06/01/05 & after) 1 2 36030 Bracket – 1/3-Size Basket 1 3 38912 Bracket – 1/2-Size Basket (before 06/01/05) 1 3-18 106[...]

Model OFE/OFG/OEA/OGA-341, 342 OFG/OFE ELECTRO MECHANICAL PARTS LIST PART NUMBER DESCRIPTION √ 60816 Adjustable Relay Base √ 60817 Adjustable Time Delay Relay √ 60818 24VAC Coil Relay √ 60765 24V Dual Face Timer √ 14851 Thermostat Kit 60814 E/M Bulb Mounting Clip (Gas) √ 35916 Transformer 120V to 24V (Gas) √ 60536 Transformer 24V/230V[...]

Model OFE/OFG/OEA/OGA-341, 342 OVER-THE-TOP PUMBING W/O D.C. PARTS (March 1, 2006 & After) Item No. Part No. Description Qty. 1 73370 HANGER-ACTUATOR CONDUIT 1 2 SC06-013 U BOLT 1/4-20 FOR 3/4 DIA 3 3 71185 BRACKET-TUBE 1 4 SC03-001 SCREW #10 X 1/2 PH PHD TEK 2 C 4 5 71139 ASSY-TUBE RETURN LINE 1 6 16807 FITTING CONNECTOR MALE 2 7 FP01-090 ELBO[...]

Model OFE/OFG/OEA/OGA-341, 342 OVER-THE-TOP FAUCET ASSY. (March 1, 2006 & After) Item No. Part No. Description Qty. 1 71899 ASSY. – 341 FAUCET 1 17333 FEMALE DISCONNECT 1 1 71665 ASSY. – 342 FAUCET 1 17334 MALE DISCONNECT 1 2 71830 HANDLE – DIVERTER VALVE ( Direct-Connect units) 1 1209 3-21[...]

Model OFE/OFG/OEA/OGA-341, 342 341 DIRECT-CONNECT PARTS LIST (Before March 1, 2006) Part No. Description Qty. 16282 NIPPLE 3/4 X CLOSE 1 21611 DISCONNECT-MALE 1 21612 DISCONNECT-FEMALE 1 21753 HOSE-SHORTENING DISCARD 1 21800 VALVE-3/4 CHECK 1 23430 VALVE-3/4 INLET-E34X 1 67850 BRACKET-34X D/C REAR SUPPORT 1 FP01-140 PLUG-3/4 PIPE-BI 2 FP01-142 CROS[...]

Model OFE/OFG/OEA/OGA-341, 342 341 W/DIRECT-CONNECT PARTS LIST (March 1, 2006 & After) Item No. Part No. Description Qty. 1 71139 ASSY-TUBE RETURN LINE 1 2 73370 HANGER-ACTUATOR CONDUIT 1 3 SC06-013 U BOLT 1/4-20 FOR 3/4 DIA 3 4 71070 ROD – EXTENSION FILTER VALVE 1 5 SC03-001 SCREW #10 X 1/2 PH PHD TEK 2 C 4 6 71185 BRACKET-TUBE 1 7 17255 COT[...]

Model OFE/OFG/OEA/OGA-341, 342 341 AUTO-LIFT W/DIRECT-CONNECT PARTS LIST (March 1, 2006 & After) Part No. Description Qty. 16807 FITTING CONNECTOR MALE 3 17255 PIN-COTTER 1 19811 1/2" 90 STRT ELL,S.S. 1 21613 VALVE-DIVERTER 1 21800 VALVE-3/4 CHECK 1 67492 STOP-D/C EXTENSION ROD 1 71063 ASSY-PUMP RETURN TUBE 1 71142 BRACKET-TUBE REAR SUPPOR[...]

Model OFE/OFG/OEA/OGA-341, 342 342 AUTO-LIFT W/DIRECT-CONNECT PARTS LIST (March 1, 2006 & After) Part No. Description Qty. 16807 FITTING CONNECTOR MALE 4 17255 PIN-COTTER 2 17407 CONNECTOR 1/2 MALE ELBOW 3 19811 1/2" 90 STRT ELL,S.S. 1 21613 VALVE-DIVERTER 2 21800 VALVE-3/4 CHECK 1 67492 STOP-D/C EXTENSION ROD 2 71063 ASSY-PUMP RETURN TUBE[...]

Model OFE/OFG/OEA/OGA-341, 342 342 AUTO-LIFT W/O DIRECT-CONNECT PARTS LIST (March 1, 2006 & After) Part No. Description Qty. 16807 FITTING CONNECTOR MALE 4 17255 PIN-COTTER 1 17407 CONNECTOR 1/2 MALE ELBOW 1 21613 VALVE-DIVERTER 1 71063 ASSY-PUMP RETURN TUBE 1 71142 BRACKET-TUBE REAR SUPPORT 1 71185 BRACKET-TUBE 1 71652 ASSY-TUBE RETURN LINE A/[...]