Herrmidifier Co G-200/300 инструкция обслуживания

G-200/300 Duct Mount Bypass Humidifier Installation • Operation • Maintenance CAUTION: READ INST ALLA TION, OPERA TION, AND MAINTENANCE INSTRUCTIONS CAREFULL Y FOR SAFE OPERA TION. EXERCISE EXTREME CAUTION WHEN WORKING WITH ELECTRICITY . 254429-001 9/04[...]

T able of Contents Introduction ..........................................1 Specifications ........................................2 Capacity Selection Guide ......................3 Operation ..............................................3 Installation ............................................5 Mounting Locations ........................6 Mainte[...]

1 Introduction Introduction The benefits of a properly humidified environment (35-50%, Relative Humidity) are many . They include both personal comfort as well as the preservation of furniture, draperies, carpets, wooden floors and cabinets, paintings, pianos, etc.. Y our home will be more comfortable at a lower temperature (i.e.: 68° F) at 30-40%[...]

2 Specifications To improve the efficiency of your humidifier , and to reduce the possibility of a health hazard, it is recommended that you take the following precautions: • Follow the manufacturer’ s recommended cleaning and maintenance instructions. • The amount of minerals and other impurities in a water source can vary greatly , therefor[...]

3 Capacity Selection Guide Operation This humidifier operates using the evaporative principle in a quiet, efficient and automatic manner . It is constructed of the highest quality , engineering grade materials to assure superior performance and durability . This humidifier is controlled so that it operates only when the furnace blower is operating [...]

4 Operation Start Up 1. Open the saddle valve and check for leaks at the connections. 2. Open the bypass damper if installed 3. T urn the furnace on and check for proper operation. 4. T urn the humidistat to the highest level (past 60%) and the humidifier should begin to operate (the humidifier should stop when the humidistat is turned off, or when[...]

5 Installation Read the instructions in the furnace installation manual carefully before attempting installation or operation of the humidifier . Failure to follow these instructions may result in improper installation and therefore, void the manufacturer’ s warranty . W ARNING Improper electrical wiring can cause personal injury , death, or prop[...]

6 Mounting Locations 1. This humidifier may be installed on either the supply or return plenum. The supply plenum is the preferred location because of higher evaporative capacity results. When there is insufficient space on the warm air plenum, the unit can be installed on the return duct. It is recommended that when the unit is installed in this l[...]

7 Maintenance Maintenance of Y our Humidifier Y our humidifier , as all appliances, requires periodic cleaning and maintenance to ensure efficient and safe operation. The necessity to clean your humidifier is substantially the result of impurities coming in through your water supply , which feeds the humidifier . Other household dust, containing bi[...]

8 Maintenance To Inspect and Replace the Evaporator Pad: It is recommended that the evaporator pad in the humidifier be replaced annually to maintain efficient operation. However , more frequent replacement may be necessary in areas of poor water quality . 1. Disconnect the power supply to the furnace.T urn OFF the water supply at the saddle valve [...]

9 Tr oubleshooting Common Questions & Answers Q. My humidity is too low . Why isn’t the humidifier working? A. This is one of the most common questions from homeowners with new humidifiers. There are many factors that decide how well a home will be humidified. The primary factors are the size of the home and how well it is insulated (assuming[...]

10 Tr oubleshooting Symptom Humidity level is not being maintained Humidifier will not turn on W ater flows through the humidifier constantly Rust is developing around the humidifier Possible causes Evaporator pad is clogged with mineral deposits W ater line is clogged with mineral deposits or debris Humidistat setting is too low Saddle V alve is n[...]

11 Description of Parts Description of Parts Solenoid V alve All brass construction, controls the flow of water to the humidifier . The solenoid valve will make a clicking sound as the plunger pin opens and closes. If this part fails to operate correctly , water will flow continuously through the humidifier and down the drain. Conical Mesh Filter T[...]

12 Parts list Item - 1 2 3 4 5 6 7 8 9 10 10a 11 12 13 14 Model part number Base Brass solenoid assembly 24V AC Conical mesh filter (12 pack only) Drain tray assembly Evaporator pad (6 pack only) Fluid restrictors (12 pack only) Grommet Side panel Side panel with collar T ransformer 120/24v T ransformer 240/24v Unit cover W ater distribution tray S[...]

13 Unit Diagram 1 2 3 4 5 6 8 9 10 12 14 13 11 7[...]

14 Wa rranty Humidifier Limited T wo Y ear Warranty This limited warranty covers Herrmidifier Residential T ype Humidifiers, excluding duct work, wiring and installation. The manufacturer warrants that all new Herrmidifier Humidifiers are free from defects in material and workmanship under normal, non-commercial use and service. The manufacturer wi[...]