Lennox Hearth CI1500DVF инструкция обслуживания

FREEST ANDING VENTED GAS FIRED ROOM HEA TERS HOMEOWNERS CARE AND OPERA TION INSTRUCTIONS Report No. 116-S-08-5 Model CI1500DVF Series Model CI2500DVF Series Serefi na Series Direct V ent Gas Stoves P/N 775,148M Rev . B, 11/04 A VERTISSEMENT : ASSUREZ-VOUS DE BIEN SUIVRE LES INSTRUCTIONS DONNÉ DANS CETTE NOTICE POUR RÉDUIRE AU MINIMUM LE RISQUE D[...]

NOTE: DIAGRAMS & ILLUSTRA TIONS NOT TO SCALE. 2 These appliances are designed to operate on natural or propane gas only . Input of millivolt models is variable. These rates are shown in the following table: INTRODUCTION The Stove models covered in this manual are Direct-Vent sealed combustion vented gas stove heaters designed for residential ap[...]

NOTE: DIAGRAMS & ILLUSTRA TIONS NOT TO SCALE. 3 H I L O W TPTH TP TH P I L O T P I L O T O N it O F F HI / LO Knob Variable Flame Height Adjustment Manifold Pressure Port Inlet Pressure Port Main Gas Control Knob Piezo Igniter IN OUT CARBON MONOXIDE POISONING: EARLY SIGNS OF CARBON MONOXIDE POISONING ARE SIMILAR TO THE FLU WITH HEADACHES, DIZZI[...]

NOTE: DIAGRAMS & ILLUSTRA TIONS NOT TO SCALE. 4 CAUTION: DO NOT A TTEMPT TO TOUCH THE FRONT ENCLOSURE GLASS WITH YOUR HANDS WHILE THE STOVE IS IN USE. Variable Flame Height Adjustment All Millivolt appliances are equipped with a variable gas control valve. Flame height for these models may be adjusted through a range between fi xed low and hig[...]

NOTE: DIAGRAMS & ILLUSTRA TIONS NOT TO SCALE. 5 Maintenance T ask Accomplishing Person Procedure Inspecting/Cleaning Burner , Logs and Controls Qualifi ed Ser vice T echnician Inspect valve and ensure it is properly operating. Check piping for leaks. Vacuum the control compartment, fi replace logs and burner area. Check Flame Patterns and Fla[...]

NOTE: DIAGRAMS & ILLUSTRA TIONS NOT TO SCALE. 6 Front Glass Enclosure Panel, Removal and Installation. T o install the front glass enclosure panel, proceed as follows: 1. Retrieve the glass door frame. Visually inspect the gasket on the backside of the panel. The gasket surface must be clean, free of irregularities and seated fi rmly . 2. With[...]

NOTE: DIAGRAMS & ILLUSTRA TIONS NOT TO SCALE. 7 ENSURE THA T THE FRONT GLASS P ANEL IS IN PLACE AND SEALED DURING ADJUSTMENT . Adjustment CAUTION: THE ADJUSTMENT ROD AND NEARBY APPLIANCE SURF ACES ARE HOT . EXERCISE CAUTION TO A VOID INJURY WHILE ADJUSTING FLAME APPEARANCE. Initially , always position the air shutter to the factory setting as s[...]

NOTE: DIAGRAMS & ILLUSTRA TIONS NOT TO SCALE. 8 Log Placement WARNING: THE SIZE AND POSITION ON THE LOG SET WAS ENGINEERED TO GIVE YOUR APPLIANCE A SAFE, RELIABLE AND A TTRACTIVE FLAME P A TTERN. ANY A TTEMPT TO USE A DIFFERENT LOG SET IN THE STOVE WILL VOID THE WARRANTY AND WILL RESUL T IN INCOMPLETE COMBUSTION, SOOTING, AND POOR FLAME QUALITY[...]

NOTE: DIAGRAMS & ILLUSTRA TIONS NOT TO SCALE. 9 With proper care and maintenance, your appli- ance will provide many years of enjoyment. If you should experience any problem, fi rst refer to the troubleshooting guide in this manual. If problem persists, contact your Lennox distributor. Embers Figure 17 9. Place the glowing embers on the burner[...]

NOTE: DIAGRAMS & ILLUSTRA TIONS NOT TO SCALE. 10 WIRING DIAGRAMS Wiring diagrams are provided here for reference purposes only . This information is also provided on schematics attached directly to the appliance on a pullout panel located within the control compartment. CAUTION: LABEL ALL WIRES PRIOR TO DISCONNECTION WHEN SERVICING CONTROLS. WI[...]

NOTE: DIAGRAMS & ILLUSTRA TIONS NOT TO SCALE. 11 Firescreen Kits These fi rescreens can be installed on the glass enclosure panel to provide protection from the hot glass surface. ACCESSORY COMPONENTS H0249 RCL Remote Control System (Standard) Standard Remote Control System The Model RCL (Standard) Remote Control System, features a simple On/O[...]

NOTE: DIAGRAMS & ILLUSTRA TIONS NOT TO SCALE. 12 Side View of Warming Shelf ACCESSORY COMPONENTS CONTINUED Brickaded Liner Kits The brickade liner kits include panels for the rear and side walls of the fi rebox. The panels have brick-like features in relief. These kits can be retrofi tted into previously installed appliances. Warming Shelves [...]

NOTE: DIAGRAMS & ILLUSTRA TIONS NOT TO SCALE. 13 6. Wait fi ve (5) minutes to clear out any gas. If you then smell gas, STOP! Follow “B” in the safety information above on this page. If you do not smell gas, go to the next step. 7. Push in gas control knob slightly and turn counterclockwise to “PILOT .” 8. Push in control knob all the [...]

NOTE: DIAGRAMS & ILLUSTRA TIONS NOT TO SCALE. 14 INSTRUCTIONS D’ALLUMAGE – V ANNE GAZ MILLIVOL T SIT INSTRUCTIONS D'ALLUMAGE 8. Enfoncez le bouton de réglage jusqu’au fond et gardez-le enfoncé. Allumez immédiatement la veilleuse en déclenchant l’allume-gaz à étincelle (en poussant le bouton) jusqu’à ce que la veilleuse s?[...]

NOTE: DIAGRAMS & ILLUSTRA TIONS NOT TO SCALE. 15 TROUBLESHOOTING THE MILLIVOL T GAS CONTROL SYSTEM Note: Before troubleshooting the gas control system, be sure external gas shut off valve (located at gas supply inlet) is in the “ON” position. Important: Valve system troubleshooting should only be accomplished by a qualifi ed service techni[...]

NOTE: DIAGRAMS & ILLUSTRA TIONS NOT TO SCALE. 16 Gas Controls Item # Part/Cat. No. Description Where Used 1 H1657 Valve Assembly – Natural Gas, SIT All 30 H2211 Gas Train Assembly, MV, Natural Gas (LP units will also require LB-102158A) CI1500DVF Series 30 H2212 Gas Train Assembly, MV, Natural Gas (LP units will also require LB-102158B) CI250[...]

NOTE: DIAGRAMS & ILLUSTRA TIONS NOT TO SCALE. 17 REPLACEMENT P ARTS LIST Cast Body Components (continued) Item # Part/Cat. No. Description Where Used 20 66M69 Door Casting, Left Front - Enamel Hunter Green, 1 ea. CI1506DVF 20 H1015 Door Casting, Left Front - Enamel Hunter Green, 1 ea. CI2506DVF 20 H2165 Door Casting, Left Front - Enamel Ivory W[...]

NOTE: DIAGRAMS & ILLUSTRA TIONS NOT TO SCALE. 18 Cast Body Components (continued) Item # Part/Cat. No. Description Where Used 25 H1007 Side Casting, Left - Enamel Hunter Green, 1 ea. CI1506DVF 25 H1031 Side Casting, Left - Enamel Hunter Green, 1 ea. CI2506DVF 25 H2174 Side Casting, Left - Enamel Ivory White, 1 ea. CI1508DVF-2 25 H2175 Side Cast[...]

NOTE: DIAGRAMS & ILLUSTRA TIONS NOT TO SCALE. 19 2 REPLACEMENT P ARTS 18 L E N N O X 7 5 8 3 6 9 11 12 13 14 17 1 19 25 L E N N O X 26 24 22 21 20 27 28 29 23 * * * Front View ****** 10 Front View 4 16 Log Set Does Not Include Ember Strip (purchased separately) 15 30 29b[...]

NOTE: DIAGRAMS & ILLUSTRA TIONS NOT TO SCALE. Printed in U.S.A. © 2003 Lennox Hearth Products P/N 775,148M REV . B 11/2004 REFERENCE INFORMA TION If Optional Warming Shelves are pur chased, install as follows: Optional Warming Shelves Kit Kit Contents: 2 ea. Warming Shelves 4 ea. Decorative Brackets 4 ea. Insets (CI1500 Series) 6 ea. Insets (C[...]