Lennox Hearth Radium-LP инструкция обслуживания

Report No. 317-S-04-5 IN ST AL LA TI ON AN D OP ER A TIO N MA NU AL Do not store or use gasoline or other flammable vapors or liquids in the vicinity of this or any other appliance. WHA T TO DO IF YOU SMELL GAS • Do not light any appliance. • Do not touch any electrical switches; do not use any phone in your building. • Immediately call your[...]

2 • Children and adults should be alerted to the hazard of high surface temperature and should stay away to avoid burns or clothing ignition. • Y oung children should be carefully super vised when they are in the same room with the heater . • Do not place clothing or other flammable material on or near the heater . • Any safety screen or g[...]

3 2.0 GENERAL INFORMA TION This appliance is a high efficiency , unvented, flame effect gas heater . It provides radiant and convected warmth both efficiently and safely utilizing the latest type catalytic convertor burner technology . The appliance does not require a flue system of any type as the catalytic converter cleans the flue products [...]

4 6.0 BURN-IN PERIOD On initial light up of a new appliance, the ‘newness’ will burn off within the first few hours of operation. During this period some smoke may be emitted from outlet grill, this should be no cause for concern. Accord- ingly , the room should be well ventilated with all windows and doors open during this period. Depending o[...]

5 8.0 COMBUSTION AND VENTILA TION AIR This heater shall not be installed in a confined space or unusually tight construction unless provisions are provided for adequate combustion and ventil ation air . The heater may be located in unusually tight construction provided the space is unconfined, or if confined, is provided with two permanent openi[...]

6 9.0 SITE REQUIREMENTS This appliance is designed to be wall-hung. Do not recess any part of the appliance into the wall. This appliance may be installed in any room in a home except bathrooms - or areas where large amounts of steam are likely to be generated. This appliance is approved for installation into a bedroom. It should be noted that heat[...]

7 After having selected the final mounting position of the appliance, taking into account the site requirements as specified in Section 8 of these instructions, the integrity of the wall, and the feasibility of the proposed supply pipe routing, the firebox of appliance may be secured to the wall.. 11.0 MOUNTING THE APPLIANCE Non-concealed gas co[...]

8 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE Insert the wall mounting screws into the top wall plugs, taking care to leave the screws protruding approximately 3/8” from the wall. Now hang the appliance onto these screws through the two keyhole shaped holes in the back panel of the appliance. Insert the lower mounting screws into the low[...]

NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE 9 14.0 CHECKING THE GAS CONNECTIONS T urn on gas supply and test for gas leaks using a gas leak test solution (also referred to as bubble leak solution). NOTE: using a soapy water solution (50% dish soap, 50% water) is an effective leak test solution, but it is not recommended, because the soap r[...]

10 16.0 SP ARK GAP 17.0 FITTING THE GLASS FACIA The glass panel is supported by two self-locking M6 screws, one on each side of the fireplace. The glass panel must be held in position while the screws are inserted on each side - it is recommended to seek assistance for this operation. See Figure 7a . The screws should be screwed in fully and then u[...]

11 20.0 SERVICING THE BURNER W ARNING Any chan ge to thi s hea ter or it s cont rols can be dan ger ous. First, remove the front glass facia as described in Section 17.0 only in reverse, remove the valve cover (4 screws) and disconnect the gas con - nection inside appliance. The gas connections to the gas valve can now be released. Undo the four sc[...]

12 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE 22.0 CA T AL YSTS W ARNING Do not blo ck the cat aly sts or the app lia nc e out le t gr ill . Blo cka ge may cau se hig h car bon mono xid e lev els and /or bre akag e o f th e gl ass fac ia p ane l. It is recommended that the catalysts are inspected for signs of damage and dirt during routin[...]

13 FOR YOUR SAFETY READ BEFORE LIGHTING WARNING: IF YOU DO NOT FOLLOW THESE INSTRUCTIONS EXACTL Y , A FIRE OR EXPLOSION MA Y RESUL T CAUSING PROPERTY DAMAGE, PERSONAL INJURY OR LOSS OF LIFE. A. This appliance has a pilot which must be lit with a piezo spark igniter . When lighting the pilot, follow these instructions exactly . B. BEFORE OPERA TING [...]

14 26.0 TROUBLESHOOTING GUIDE PROBLEM CORRECTIVE ACTION Igniter sparks but pilot does not light • No gas to Pilot, check the gas line connections. • Air not fully purged. Purge supply or wait longer . • Spark grounding to metal work, reset gap correctly . • Blocked pilot, clean out internally . Pilot lights but then goes out • Severe rest[...]

15 1 14 11 13 6 7 12 8 3 16 27.0 REPLACEMENT P ARTS - RADIUM™ Item # Cat. No. Description 1 H6055 Glass Door Assembly 2 H6060 Catalyst 3 H6061 Pilot Assembly, Natural Gas 4 H6999 Pilot Assembly, Propane Gas 5 H6056 Burner Assembly, Natural Gas 6 H7000 Burner Assembly, Propane Gas 7 H6062 Catalyst Gasket 8 H6066 Decorative Glass Facia 9 H6067 Deco[...]

16 Figure 12 28.0 POSITIONING OF FIELD REMOV ABLE P ARTS W ARNING Fai lur e to pos itio n th e pa rts in acc ord ance wi th the se diag ram s or fai lur e to use onl y pa rts spe cifi- cal ly appr ove d wit h thi s he ater may res ult in prop erty dama ge or per sona l in jury . Figure 13 4 off burner installation positions Figure 11 Removal and r[...]

NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE 17 29.0 SPECIFICA TIONS P r od u c t R e f e r en c e In f o r m at i o n Cat. No. Model S hi p . W t . Ship. Volume H 60 6 4 R ad i u m- N G 75 l b. 1 2. 9 c u . f t . H 60 7 0 R ad i u m- L P 7 5 l b . 12 . 9 c u . f t . OPEN CLOSED 27-3/16” 35-7/16” 7-3/16” 20-7/8” 23” 11-1/4” 3-1/[...]

Printed in U.S.A. © 2007 Lennox Hearth Products P/N 850,054M REV . E 11/2008 Lennox Hearth Products reser ves the right to make changes at any time, without notice, in design, materials, specifications, prices and also to discontinue colors, styles and products. Consult your local distributor for fireplace code information. WARRANTY Y our gas ap[...]