Lenovo 019726U инструкция обслуживания

T hinkP a d E dg e 1 3 ″ an d E 30 Hard w ar e M a i ntena n c e Ma n ua l[...]

[...]

T hinkP a d E dg e 1 3 ″ an d E 30 Hard w ar e M a i ntena n c e Ma n ua l[...]

Note Before using this information and the pr oduct it supports, be sure to read the general information under “Notices” on page 137. First Edition (December 2009) © Copyright Lenovo 2009. LENOVO products, data, computer softwar e, and services have been developed exclusively at private expense and are sold to governmental entities as commer c[...]

Contents About this manual .......... v Safety information .......... 1 General safety .............. 2 Electrical safety ............. 3 Safety inspection guide ........... 5 Handling devices that are sensitive to electr ostatic discharge ............... 6 Grounding r equirements .......... 6 Safety notices (multilingual translations) ..... 7 Impo[...]

W indows 7 Professional (64 bit) DVDs .... 1 3 5 Common service tools .......... 1 3 6 Notices .............. 1 3 7 T rademarks .............. 1 3 8 iv ThinkPad Edge 13 ″ and E30 Hardwar e Maintenance Manual[...]

About this manual This manual contains service and refer ence information for the following ThinkPad ® products. ThinkPad Edge 13 ″ MT 0196, 0197, and 0492 ThinkPad Edge E30 MT 0196 Use this manual along with the advanced diagnostic tests to troubleshoot problems. Important: This manual is intended only for trained service technicians who are fa[...]

vi ThinkPad Edge 13 ″ and E30 Hardwar e Maintenance Manual[...]

Safety information This chapter presents following safety information that you need to be familiar with before you service a ThinkPad Notebook. v “General safety” on page 2 v “Electrical safety” on page 3 v “Safety inspection guide” on page 5 v “Handling devices that are sensitive to electr ostatic discharge” on page 6 v “Groundin[...]

General safety Follow these rules to ensur e general safety: v Observe good housekeeping in the area of the machines during and after maintenance. v When lifting any heavy object: 1. Make sure that you can stand safely without slipping. 2. Distribute the weight of the object equally between your feet. 3. Use a slow lifting force. Never move suddenl[...]

Electrical safety Observe the following rules when working on electrical equipment. v Find the room emer gency power-off (EPO) switch, disconnecting switch, or electrical outlet. If an electrical accident occurs, you can then operate the switch or unplug the power cord quickly . v Do not work alone under hazardous conditions or near equipment that [...]

v Do not touch live electrical circuits with the r eflective surface of a plastic dental mirror . The surface is conductive; such touching can cause personal injury and machine damage. v Do not service the following parts with the power on when they are r emoved from their normal operating places in a machine: – Power supply units – Pumps – B[...]

Safety inspection guide The purpose of this inspection guide is to assist you in identifying potentially unsafe conditions. As each machine was designed and built, requir ed safety items were installed to pr otect users and service technicians from injury . This guide addresses only those items. Y ou should use good judgment to identify potential s[...]

Handling devices that are sensitive to electrostatic discharge Any computer part containing transistors or integrated circuits (ICs) should be considered sensitive to electr ostatic discharge (ESD.) ESD damage can occur when there is a dif ference in charge between objects. Pr otect against ESD damage by equalizing the charge so that the machine, t[...]

Safety notices (multilingual translations) The safety notices in this section are pr ovided in the following languages: v English v Arabic v Brazilian Portuguese v French v German v Hebrew v Japanese v Korean v Spanish v T raditional Chinese Safety information 7[...]

DANGER Before the computer is powered on after FRU replacement, make sure all screws, springs, and other small parts are in place and are not left loose inside the computer . V erify this by shaking the computer and listening for rattling sounds. Metallic parts or metal flakes can cause electrical shorts. DANGER Some standby batteries contain a sma[...]

DANGER Though the main batteries have low voltage, a shorted or grounded battery can produce enough current to burn personnel or combustible materials. DANGER Unless hot swap is allowed for the FRU being replaced, do as follows before removing it: power off the computer , unplug all power cords from electrical outlets, remove the battery pack, and [...]

10 ThinkPad Edge 13 ″ and E30 Hardwar e Maintenance Manual[...]

Safety information 11[...]

PERIGO Antes de ligar o computador após a substituição da FRU, certifique-se de que todos os parafusos, molas e outras peças pequenas estejam no lugar e não estejam soltos dentro do computador . V erifique isso sacudindo o computador e procurando ouvir sons de peças soltas. Peças metálicas ou lascas de metal podem causar curto-circuito. PER[...]

PERIGO Embora as principais baterias possuam baixa voltagem, uma bateria em curto-circuito ou aterrada pode produzir corrente o bastante para queimar materiais de pessoal ou inflamáveis. PERIGO A menos que uma hot swap seja permitida para a FRU que está sendo substituída, faça o seguinte antes de removê-la: desligue o computador , desconecte t[...]

DANGER A vant de remettre l’ordinateur sous tension après remplacement d’une unité en clientèle, vérifiez que tous les ressorts, vis et autres pièces sont bien en place et bien fixées. Pour ce faire, secouez l’unité et assurez-vous qu’aucun bruit suspect ne se produit. Des pièces métalliques ou des copeaux de métal pourraient caus[...]

DANGER Bien que le voltage des batteries principales soit peu élevé, le court-circuit ou la mise à la masse d’une batterie peut produire suffisamment de courant pour brûler des matériaux combustibles ou causer des brûlures corporelles graves. DANGER Si le remplacement à chaud n’est pas autorisé pour l’unité remplaçable sur site que [...]

VORSICHT Bevor nach einem FRU-Austausch der Computer wieder angeschlossen wird, muß sichergestellt werden, daß keine Schrauben, Federn oder andere Kleinteile fehlen oder im Gehäuse vergessen wurden. Der Computer muß geschüttelt und auf Klappergeräusche geprüft werden. Metallteile oder-splitter können Kurzschlüsse erzeugen. VORSICHT Die Ber[...]

VORSICHT Die Leuchtstoffröhre im LCD-Bildschirm enthält Quecksilber . Bei der Entsorgung die örtlichen Bestimmungen für Sondermüll beachten. Der LCD-Bildschirm besteht aus Glas und kann zerbrechen, wenn er unsachgemäß behandelt wird oder der Computer auf den Boden fällt. W enn der Bildschirm beschädigt ist und die darin befindliche Flüssi[...]

18 ThinkPad Edge 13 ″ and E30 Hardwar e Maintenance Manual[...]

Safety information 19[...]

20 ThinkPad Edge 13 ″ and E30 Hardwar e Maintenance Manual[...]

Safety information 21[...]

22 ThinkPad Edge 13 ″ and E30 Hardwar e Maintenance Manual[...]

Safety information 23[...]

PELIGRO Antes de encender el sistema despues de sustituir una FRU, compruebe que todos los tornillos, muelles y demás piezas pequeñas se encuentran en su sitio y no se encuentran sueltas dentro del sistema. Compruébelo agitando el sistema y escuchando los posibles ruidos que provocarían. Las piezas metálicas pueden causar cortocircuitos eléct[...]

PELIGRO Aunque las baterías principales tienen un voltaje bajo, una batería cortocircuitada o con contacto a tierra puede producir la corriente suficiente como para quemar material combustible o provocar quemaduras en el personal. PELIGRO Salvo que se permita el intercambio en caliente para la unidad sustituible localmente, realice lo siguiente a[...]

26 ThinkPad Edge 13 ″ and E30 Hardwar e Maintenance Manual[...]

Safety information 27[...]

28 ThinkPad Edge 13 ″ and E30 Hardwar e Maintenance Manual[...]

Important service information This chapter presents following important service information that applies to all machine types supported by this manual: v “Strategy for replacing FRUs” on page 30 – “Strategy for replacing a har d disk drive” on page 30 – “Important notice for replacing a system boar d” on page 31 – “How to use er[...]

Strategy for replacing FRUs Use the following strategy to prevent unnecessary expense for r eplacing and servicing FRUs: v If you are instructed to replace a FRU but the replacement does not correct the problem, reinstall the original FRU before you continue . v Some computers have both a processor boar d and a system board. If you are instructed t[...]

Important notice for replacing a system board Some components mounted on a system board ar e very sensitive. Improper handling of a system board can cause damage to those components, and may cause a system malfunction. Attention: When handling a system board: v Do not drop a system boar d or apply any excessive force to it. v A void rough handling [...]

Strategy for replacing FRUs for CT O, CMV , and GA V Product definition Dynamic Configure T o Order (CTO) This provides the ability for a customer to configur e an IBM ® or a Lenovo solution from an eSite, and have this configuration sent to fulfillment, wher e it is built and shipped directly to the customer . The machine label, Product Entitleme[...]

v Business Partners using Eclaim will access PEW when performing Entitlement Lookup. Business Partners will enter Loc ID, MT and Serial, and the key commodities will be returned in the Eclaim r ecord under SYSTEM DET AILS. v Authorized IBM Business Partners can access Eclaim at the following W eb site: https://wca.eclaim.com Using eSupport For Key [...]

34 ThinkPad Edge 13 ″ and E30 Hardwar e Maintenance Manual[...]

General checkout This chapter presents following information: v “What to do first” on page 36 v “Checkout guide” on page 37 – “Diagnostics using PC-Doctor for DOS” on page 37 – “Lenovo ThinkV antage T oolbox (Lenovo System T oolbox)” on page 40 – “PC-Doctor for Rescue and Recovery” on page 40 – “FRU tests” on page 41[...]

What to do first When you do return a FRU, you must include the following information in the parts exchange form or parts return form that you attach to it: __ 1. Name and phone number of service technician __ 2. Date of service __ 3. Date on which the machine failed __ 4. Date of purchase __ 5. Failure symptoms, err or codes appearing on the displ[...]

Checkout guide Use the following procedur es as a guide in identifying and correcting problems with the ThinkPad Notebook. Note: The diagnostic tests are intended to test only ThinkPad pr oducts. The use of non-ThinkPad products, pr ototype cards, or modified options can lead to false indications of errors and invalid system r esponses. 1. Identify[...]

T esting the computer In this product, you need an external optical drive to use the PC-Doctor diagnostic CD to test the hardwar e features. Note: The PC-Doctor diagnostic CD does not support any external optical drives connected through USB devices or any others. T o run the test, do as follows: 1. T urn off the computer . 2. Attach an external op[...]

The options on the test menu are as follows: Diagnostics Interactive T ests v Run Normal T est v Run Quick T est v CPU/Coprocessor v System board v V ideo Adapter v Fixed Disks v Diskette Drives v Other Devices v W ireless LAN v Advanced Memory T ests v Keyboard v V ideo v Internal Speaker v Mouse v Diskette v System Load v Optical Drive T est v In[...]

v Print Log v Save Log v Full Erase Hard Drive v Quick Erase Hard Drive Lenovo ThinkV antage T oolbox (Lenovo System T oolbox) Lenovo ThinkV antage ® T oolbox is a diagnostic program that works thr ough the W indows operating system. It enables you to view symptoms of computer problems and solutions for them, and includes automatic notification wh[...]

FRU tests The following table shows the test for each FRU. T able 1. FRU tests FRU Applicable test System board 1. Diagnostics --> CPU/Coprocessor 2. Diagnostics --> Systemboard Power Diagnostics --> ThinkPad Devices --> AC Adapter , Battery 1 (Battery2) LCD unit 1. Diagnostics --> V ideo Adapter 2. Interactive T ests --> V ideo A[...]

T able 1. FRU tests (continued) FRU Applicable test T ouch Pad If the T ouch Pad does not work, check the configuration as specified in the BIOS Setup Utility . If the T ouch Pad is disabled, select Automatic to enable it. If enabling the T ouch Pad does not correct the pr oblem, continue with the following: v Interactive T ests --> Mouse 42 Thi[...]

Power system checkout T o verify a symptom, do the following: 1. T urn off the computer . 2. Remove the battery pack. 3. Connect the AC adapter . 4. Check that power is supplied when you turn on the computer . 5. T urn off the computer . 6. Disconnect the AC adapter and install the charged battery pack. 7. Check that the battery pack supplies power[...]

Checking operational charging T o check whether the battery charges pr operly during operation, use a discharged battery pack or a battery pack that has less than 50% of the total power remaining when installed in the computer . Perform operational charging. If the battery status indicator or icon does not turn on, remove the battery pack and let i[...]

4. If the voltage is more than +1 1.0 V dc, measure the resistance between battery terminals 5 and 7. The resistance must be 4 to 30 K  . If the resistance is not corr ect, replace the battery pack. If the resistance is correct, r eplace the system board. Checking the backup battery Do the following: 1. Power off the computer , and unplug the AC[...]

46 ThinkPad Edge 13 ″ and E30 Hardwar e Maintenance Manual[...]

Related service information This chapter presents following information: v “Restoring the factory contents by using Recovery Disc Set” v “Passwords” on page 48 v “Power management” on page 52 v “Symptom-to-FRU index” on page 53 Restoring the factory contents by using Recovery Disc Set When the hard disk drive (HDD) or solid state dr[...]

1. Make the CD/DVD drive the first startup device in the startup sequence using the following procedur e: a. Press and hold down the F1 key , and then turn on the computer . When the logo screen is displayed or if you hear r epeating beeps, release the F1 key . The Setup Utility program opens. b. Use the arrow keys to select Startup → Boot . c. S[...]

Exception: If only an SVP is installed, the passwor d prompt does not appear when the operating system is booted. Power-on password A power-on password (POP) pr otects the system from being power ed on by an unauthorized person. The password must be enter ed before an operating system can be booted. For how to remove the POP , see “How to r emove[...]

After the POST ends, the password pr ompt does not appear . The POP has been removed. 5. Reinstall the backup battery and the battery pack. (B) If an SVP has been set and is known by the service technician: 1. T urn on the computer . 2. When the ThinkPad logo comes up, immediately press F1 to enter BIOS Setup Utility . For models supporting the Pas[...]

7. T ype the current master HDP in the Enter Current Password field. then leave the Enter New Password field blank, and press Enter twice. 8. Press F10. 9. Select Ye s in the Setup Configuration window . Both user HDP and master HDP will have been removed. Related service information 51[...]

Power management T o reduce power consumption, the computer has thr ee power management modes: screen blank, sleep, and hibernation. Screen blank mode T o put the computer into screen blank mode, do as follows: 1. Right-click the Power Manager Battery Gauge in the task bar . 2. Select Power off display . Sleep mode When the computer enters sleep mo[...]

Symptom-to-FRU index This section contains following information: v “Numeric error codes” v “Error messages” on page 56 v “No-beep symptoms” on page 56 v “LCD-related symptoms” on page 57 v “Intermittent problems” on page 58 v “Undetermined problems” on page 58 The symptom-to-FRU index in this section lists symptoms and erro[...]

T able 2. Numeric error codes (continued) Symptom or error (beeps, if any) FRU or action, in sequence 021 1 Keyboard err or (two short beeps) Run interactive tests of the keyboard and the auxiliary input device. 0230 Shadow RAM error—Shadow RAM fails at offset nnnn. (two short beeps) System board. 0231 System RAM error—System RAM fails at offse[...]

T able 2. Numeric error codes (continued) Symptom or error (beeps, if any) FRU or action, in sequence 02F0 CPU ID:xx Failed. 1. CPU. 2. System board. 02F5 DMA test failed. (two short beeps) 1. DIMM. 2. System board. 02F6 Software NMI failed (two short beeps) 1. DIMM. 2. System board. 02F7 Fail-safe timer NMI failed (two short beeps) 1. DIMM. 2. Sys[...]

Error messages T able 3. Error messages Symptom or error (beeps, if any) FRU or action, in sequence Bad CRC2. Enter BIOS Setup Utility , and load Setup defaults. (two short beeps) Press F1 to enter BIOS Setup Utility . Press F9, and Enter to load the default setting. Then save the current setting by pressing F10, and restart the computer . Fan erro[...]

LCD-related symptoms T able 5. LCD-related symptoms Symptom or error FRU or action, in sequence No beep, power-on indicator on, and a blank LCD during POST . System board . v LCD backlight not working. v LCD too dark. v LCD brightness cannot be adjusted. v LCD contrast cannot be adjusted. 1. Reseat the LCD connectors . 2. LCD assembly . 3. System b[...]

Intermittent problems Intermittent system hang problems can be due to a variety of causes that have nothing to do with a hardwar e defect, such as cosmic radiation, electrostatic discharge, or softwar e errors. FRU replacement should be consider ed only when a problem r ecurs. When analyzing an intermittent problem, do the following: 1. Run the dia[...]

Status indicators This chapter presents the system status indicators that show the status of the computer . 1 2 3 4 T able 6. Status indicators Indicator Meaning 1 On-screen indicators Caps lock: Caps Lock mode is enabled. Y ou can enter all alphabetic characters (A-Z) in uppercase without pr essing the Shift key . W ireless status: Press F9 [...]

T able 6. Status indicators (continued) Indicator Meaning 3 Sleep (standby) status The illumination dot in the ThinkPad logo on the outer lid of the computer and on the palm rest works as a system-status indicator: it shows whether the computer is in sleep (standby), hibernation, or normal model. Red: The computer is on (in normal mode). Fast[...]

Special keys This computer has several special keys at the upper row of the keyboar d. T o use each function, directly pr ess the desired key . Note: T o use F1 - F12 functions, press Fn and the desir ed function key simultaneously; this is the default setting. The following table shows the function of each special key . T able 7. Fn key combinatio[...]

T able 7. Fn key combinations (continued) Special key Description W ireless radio control (F9) Enable or disable the built-in wireless networking featur es. If you press this key , a list of wir eless features is displayed. Y ou can quickly change the power state of each feature in the list. Note: T o use this function, following device drivers mus[...]

FRU replacement notices This chapter presents notices r elated to removing and replacing parts. Read this chapter carefully befor e replacing any FRU. Screw notices Loose screws can cause a r eliability problem. In the ThinkPad Notebook, this problem is addr essed with special nylon-coated screws that have the following characteristics: v They main[...]

Retaining serial numbers This section includes the following descriptions: v “Restoring the serial number of the system unit” v “Retaining the UUID” v “Reading or writing the ECA information” on page 65 Restoring the serial number of the system unit When the computer was manufactured, the EEPROM on the system boar d was loaded with the [...]

The algorithm that generates the number is designed to provide unique IDs until the year A.D. 3400. No two computers in the world have the same number . When you replace the system boar d, you must set the UUID on the new system board as follows: 1. Install the LENOVO ThinkPad Hardwar e Maintenance Diskette V ersion 1.76 or later , and restart the [...]

66 ThinkPad Edge 13 ″ and E30 Hardwar e Maintenance Manual[...]

Removing and replacing a FRU This chapter presents dir ections and drawings for use in removing and replacing a FRU. Be sure to observe the following general r ules: 1. Do not try to service any computer unless you have been trained and certified. An untrained person runs the risk of damaging parts. 2. Before r eplacing any FRU, review “FRU repla[...]

1010 Battery pack T able 8. Removal steps of battery pack DANGER Use only the battery specified in the parts list for your computer . Any other battery could ignite or explode. Important notice for replacing a battery pack: ThinkV antage T oolbox has an automatic battery diagnostic that determines if the battery pack is defective. A battery pack FR[...]

T able 8. Removal steps of battery pack (continued) Unlock the battery latch 1 . Holding the battery latch in the unlocked position 2 , remove the battery pack in the dir ection shown by arrow 3 . 3 2 1 When installing: Install the battery pack in the slot, and then make sure that the battery latch is in the locked position. Remov[...]

1020 Bottom slot cover For access, remove this FRU: v “1010 Battery pack” on page 68 T able 9. Removal steps of bottom slot cover Note: Loosen the screws 1 , but do not r emove them. 2 1 1 1 1 1 When installing: Make sure that all the pr ojections of the cover are attached firmly to the frame. Then secure the scr ews. 70 ThinkPad Edge 13 [...]

Note: Applying label to the bottom slot cover When you replace the cover , following label needs to be peeled off fr om the old cover , and needs to be put on the new cover: 1 Asset tag label For the label location, refer the following figur e: 1 Removing and replacing a FRU 71[...]

1030 DIMM For access, remove these FRUs in or der: v “1010 Battery pack” on page 68 v “1020 Bottom slot cover” on page 70 T able 10. Removal steps of DIMM 1 a b 1 2 Note: If only one DIMM is used on the computer you are servicing, the car d must be installed in SLOT -0 ( a ), but not in SLOT -1 ( b ). When installing: Insert the[...]

1040 Hard disk drive (HDD) For access, remove these FRUs in or der: v “1010 Battery pack” on page 68 v “1020 Bottom slot cover” on page 70 T able 1 1. Removal steps of HDD 1 Step Screw (quantity) Color T orque 1 M2 × 3 mm, wafer-head, nylon-coated (1) Black 0.181 Nm (1.85 kgfcm) Attention: v Do not drop the drive or apply any physica[...]

T able 1 1. Removal steps of HDD (continued) 2 3 When installing: Make sure that the HDD connector is attached firmly . 74 ThinkPad Edge 13 ″ and E30 Hardwar e Maintenance Manual[...]

1050 PCI Express Mini Card for wireless LAN For access, remove these FRUs in or der: v “1010 Battery pack” on page 68 v “1020 Bottom slot cover” on page 70 T able 12. Removal steps of PCI Express Mini Card for wireless LAN In step 1 , unplug the jacks by using the removal tool antenna RF connector (P/N: 08K7159) or pick the connectors[...]

T able 12. Removal steps of PCI Express Mini Card for wireless LAN (continued) 3 When installing: Plug the gray cable into the jack marked MAIN or M , and the black cable into the jack marked AUX or A on the card. 76 ThinkPad Edge 13 ″ and E30 Hardwar e Maintenance Manual[...]

1060 PCI Express Mini Card for wireless W AN For access, remove these FRUs in or der: v “1010 Battery pack” on page 68 v “1020 Bottom slot cover” on page 70 T able 13. Removal steps of PCI Express Mini Card for wireless WAN In step 1 , unplug the jacks by using the removal tool antenna RF connector (P/N: 08K7159) or pick the connector[...]

T able 13. Removal steps of PCI Express Mini Card for wireless WAN (continued) 3 Note: Plug the red cable into the jack marked MAIN , and the blue cable into the jack marked AUX on the card. 78 ThinkPad Edge 13 ″ and E30 Hardwar e Maintenance Manual[...]

1070 Keyboard For access, remove these FRUs in or der: v “1010 Battery pack” on page 68 v “1020 Bottom slot cover” on page 70 T able 14. Removal steps of keyboard 1 1 Step Screw (quantity) Color T orque 1 M2 × 5 mm, wafer-head, nylon-coated (2) Black 0.181 Nm (1.85 kgfcm) In step 2 , by using a plastic pry tool, push the keyboa[...]

T able 14. Removal steps of keyboard (continued) 3 4 7 6 5 7 8 80 ThinkPad Edge 13 ″ and E30 Hardwar e Maintenance Manual[...]

T able 15. Installation steps of keyboard When installing the keyboard, do as follows: 1. Attach the keyboard connectors. 2. Attach the keyboard so that the keyboar d front edges are under the frame as shown in this figure. 3. Secure the keyboar d by tightening the screws from the bottom side of the computer . Removing and replacing a FRU 81[...]

1080 T op case assembly and microphone module For access, remove these FRUs in or der: v “1010 Battery pack” on page 68 v “1020 Bottom slot cover” on page 70 v “1040 Hard disk drive (HDD)” on page 73 v “1070 Keyboard” on page 79 Note: Microphone module is attached on the underside of the top case assembly . T able 16. Removal steps [...]

T able 16. Removal steps of top case assembly and microphone module (continued) 2 2 2 2 2 2 Step Screw (quantity) Color T orque 2 M2 × 3 mm, wafer-head, nylon-coated (6) Black 0.181 Nm (1.85 kgfcm) 3 3 3 Step Screw (quantity) Color T orque 3 M2 × 3 mm, wafer-head, nylon-coated (3) Black 0.181 Nm (1.85 kgfcm) Removing and replacing a F[...]

T able 16. Removal steps of top case assembly and microphone module (continued) 4 5 6 7 8 When installing: Make sure that the connectors ar e attached firmly . 84 ThinkPad Edge 13 ″ and E30 Hardwar e Maintenance Manual[...]

T able 16. Removal steps of top case assembly and microphone module (continued) In step 5 , push the top case assembly out from the frame by using a plastic pry tool as shown in this figure. 9 9 9 9 9 9 9 9 9 9 10 11 12 12 14 13 Removing and replacing a FRU 85[...]

1090 Backup battery For access, remove these FRUs in or der: v “1010 Battery pack” on page 68 v “1020 Bottom slot cover” on page 70 v “1070 Keyboard” on page 79 v “1080 T op case assembly and microphone module” on page 82 T able 17. Removal steps of backup battery DANGER Use only the battery specified in the parts list for your comp[...]

1 100 Bluetooth daughter card (BDC-2) v “1010 Battery pack” on page 68 v “1020 Bottom slot cover” on page 70 v “1070 Keyboard” on page 79 v “1080 T op case assembly and microphone module” on page 82 T able 18. Removal steps of BDC-2 1 2 Step Screw (quantity) Color T orque 1 M2 × 3 mm, wafer-head, nylon-coated (1) Black 0.181 [...]

1 1 10 Speaker assembly For access, remove these FRUs in or der: v “1010 Battery pack” on page 68 v “1020 Bottom slot cover” on page 70 v “1070 Keyboard” on page 79 v “1080 T op case assembly and microphone module” on page 82 T able 19. Removal steps of speaker assembly 1 1 1 1 Step Screw (quantity) Color T orque 2 M2 × 3 mm,[...]

T able 19. Removal steps of speaker assembly (continued) 2 3 3 Cable routing: Make sure that the connector is attached firmly and you r oute the cable as shown in this figure. Removing and replacing a FRU 89[...]

1 120 System board and fan assembly Important notices for handling the system board: When handling the system board, bear the following in mind. v The system board has an acceler ometer , which can be broken by applying several thousands of G-forces. Note: Dropping a system boar d from a height of as little as 6 inches so that it falls flat on a ha[...]

T able 20. Removal steps of system board and fan assembly Following components soldered on the top side of the system boar d are extremely sensitive. When you service the system boar d, avoid any kind of rough handling. For CUL V (Customer Ultra-Low V oltage) models: a Accelerometer chip for the HDD Active Protection System ™ b CPU ?[...]

T able 20. Removal steps of system board and fan assembly (continued) For AMD models: a CPU b North Bridge c South Bridge d Accelerometer chip for the HDD Active Protection System a b d c 92 ThinkPad Edge 13 ″ and E30 Hardwar e Maintenance Manual[...]

T able 20. Removal steps of system board and fan assembly (continued) 1 1 1 2 2 Step Screw (quantity) Color T orque 1 M2 × 3 mm, wafer-head, nylon-coated (3) Black 0.181 Nm (1.85 kgfcm) Note: Loosen the screws 2 , but do not r emove them. Removing and replacing a FRU 93[...]

T able 20. Removal steps of system board and fan assembly (continued) 3 4 When installing: Make sure that the connectors ar e attached firmly . 94 ThinkPad Edge 13 ″ and E30 Hardwar e Maintenance Manual[...]

T able 20. Removal steps of system board and fan assembly (continued) a 8 5 6 7 When installing: Attach the system board so that the battery pins of the system board ar e attached firmly to the guide hole of the base cover as shown in a in this figure. Make sure that the connectors ar e attached firmly . Removing and replacing a FRU 95[...]

T able 20. Removal steps of system board and fan assembly (continued) Note: Loosen the screws 9 , but do not r emove them. 9 9 11 10 96 ThinkPad Edge 13 ″ and E30 Hardwar e Maintenance Manual[...]

T able 20. Removal steps of system board and fan assembly (continued) When installing: v Before you attach the fan assembly to the computer , apply thermal grease, at an amount of 0.2 grams, on the part marked a as in the following figure. Either too much or too less application of grease can cause a thermal pr oblem due to imperfect contact [...]

1 130 I/O card assembly , audio cable, and I/O cable For access, remove these FRUs in or der: v “1010 Battery pack” on page 68 v “1020 Bottom slot cover” on page 70 v “1040 Hard disk drive (HDD)” on page 73 v “1050 PCI Express Mini Car d for wireless LAN” on page 75 v “1060 PCI Express Mini Car d for wireless W AN” on page 77 v [...]

T able 21. Removal steps of I/O card assembly , audio cable, and I/O cable (continued) 5 6 Cable routing: Make sure that the connectors ar e attached firmly and you route the cables as shown in this figure. Removing and replacing a FRU 99[...]

1 140 LCD unit For access, remove these FRUs in or der: v “1010 Battery pack” on page 68 v “1020 Bottom slot cover” on page 70 v “1040 Hard disk drive (HDD)” on page 73 v “1050 PCI Express Mini Car d for wireless LAN” on page 75 v “1060 PCI Express Mini Car d for wireless W AN” on page 77 v “1070 Keyboard” on page 79 v “10[...]

T able 22. Removal steps of LCD unit (continued) 3 3 Cable routing: Make sure that the cables ar e attached to the cable guides as shown in this figure. When you r oute the cables, make sure that they are not subjected to any tension. T ension could cause the cables to be damaged by the cable guides, or a wire to be br oken. Removing and replacing [...]

1 150 Base cover assembly and DC-in cable For access, remove these FRUs in or der: v “1010 Battery pack” on page 68 v “1020 Bottom slot cover” on page 70 v “1040 Hard disk drive (HDD)” on page 73 v “1050 PCI Express Mini Car d for wireless LAN” on page 75 v “1060 PCI Express Mini Car d for wireless W AN” on page 77 v “1070 Key[...]

T able 23. Removal steps of base cover assembly and DC-in cable (continued) Cable routing: Make sure that the cable is attached to the cable guides as shown in this figure. When you r oute the cables, make sure that they are not subjected to any tension. T ension could cause the cables to be damaged by the cable guides, or a wire to be br oken. Rem[...]

Note: Applying labels to the base cover The new base cover FRU is shipped with a kit containing labels of several kinds. When you replace the base cover , you need to apply the following labels: 4 Information label under battery 6 FCC label 7 Homologation label 13 Serial number blank label Following labels need to be peeled [...]

2010 LCD bezel assembly For access, remove this FRU: v “1010 Battery pack” on page 68 T able 24. Removal steps of LCD bezel assembly 1 1 1 1 Step Screw cap Screw (quantity) Color T orque 1 M2 × 3 mm, wafer-head, nylon-coated (4) Black 0.181 Nm (1.85 kgfcm) 2 2 2 2 2 2 2 2 2 2 Removing and replacing a FRU 105[...]

2020 Integrated camera For access, remove these FRUs in or der: v “1010 Battery pack” on page 68 v “2010 LCD bezel assembly” on page 105 T able 25. Removal steps of integrated camera 1 2 When installing: Make sure that the connector of the integrated camera is attached firmly . 106 ThinkPad Edge 13 ″ and E30 Hardwar e Maintenance Manual[...]

2030 LCD panel and LCD cable For access, remove these FRUs in or der: v “1010 Battery pack” on page 68 v “1020 Bottom slot cover” on page 70 v “1040 Hard disk drive (HDD)” on page 73 v “1050 PCI Express Mini Car d for wireless LAN” on page 75 v “1060 PCI Express Mini Car d for wireless W AN” on page 77 v “1070 Keyboard” on p[...]

T able 26. Removal steps of LCD panel and LCD cable (continued) 2 3 4 5 6 7 8 108 ThinkPad Edge 13 ″ and E30 Hardwar e Maintenance Manual[...]

T able 26. Removal steps of LCD panel and LCD cable (continued) 10 Removing and replacing a FRU 109[...]

2070 Hinge kit For access, remove these FRUs in or der: v “1010 Battery pack” on page 68 v “1020 Bottom slot cover” on page 70 v “1040 Hard disk drive (HDD)” on page 73 v “1050 PCI Express Mini Car d for wireless LAN” on page 75 v “1060 PCI Express Mini Car d for wireless W AN” on page 77 v “1070 Keyboard” on page 79 v “10[...]

T able 27. Removal steps of hinge kit (continued) 3 3 Removing and replacing a FRU 111[...]

2050 Wireless LAN antenna assembly , wireless W AN antenna assembly , and LCD rear cover assembly For access, remove these FRUs in or der: v “1010 Battery pack” on page 68 v “1020 Bottom slot cover” on page 70 v “1040 Hard disk drive (HDD)” on page 73 v “1050 PCI Express Mini Car d for wireless LAN” on page 75 v “1060 PCI Express [...]

T able 28. Removal steps of wireless LAN antenna assembly , wireless WAN antenna assembly , and LCD rear cover assembly (continued) 3 3 3 3 3 3 Cable routing: When you install the antenna assembly , route the cables as shown in the figures below . As you r oute the cables, make sure that they are not subjected to any tension. T ension could cause t[...]

11 4 ThinkPad Edge 13 ″ and E30 Hardware Maintenance Manual[...]

Locations This chapter presents the location of ThinkPad Edge 13 ″ featur es and hardware. Front view 1 Integrated camera (for some models) 2 Power switch 3 AC power connector 4 Status indicators Note: For the description of each indicator , see “Status indicators” on page 59. 5 Universal serial bus (USB) connect[...]

Bottom view 1 Battery pack latch 2 Battery pack 3 Security keyhole 4 External monitor connector 5 HDMI port 6 RJ-45 (Ethernet) connector 7 USB connector 8 Built-in stereo speakers 9 HDD slot door 1 1 2 3 4 5 6 7 8 9 11 6 ThinkPad Edge 13 ″ and E30 Hardware Maintenance Manual[...]

Parts list This chapter contains following lists of the service parts. v “Overall” on page 1 18 v “LCD FRUs” on page 126 v “Keyboard” on page 129 v “AC adapters” on page 130 v “Miscellaneous parts” on page 130 v “Power cords” on page 131 v “Recovery discs” on page 132 v “Common service tools” on page 136 Notes: v Eac[...]

Overall 1 2 5 3 4 6 7 9 8 10 11 12 13 14 15 16 17 18 19 20 21 11 8 ThinkPad Edge 13 ″ and E30 Hardware Maintenance Manual[...]

T able 29. Parts list—Overall No. FRU (Overall) FRU no. CRU ID 1 LCD unit (see “LCD FRUs” on page 126.) 2 Keyboard (see “Keyboar d” on page 129.) 3 T op case assembly 60Y5520 N — Microphone module 60Y5753 N 4 Qualcom Gobi-2000 WW AN v 0196-CTO, 22x, 2Ex, 2Gx, 2Jx, 2Lx, 2Qx, 2Tx, 2Ux, 2Vx, 34x, 36x, 38x, 3Ax, 3Cx, 4Ux v 0197-CTO, 22x, 23[...]

T able 29. Parts list—Overall (continued) No. FRU (Overall) FRU no. CRU ID 5 Intel Centrino W ireless-N 1000 v 0196-CTO, 23x, 24x, 25x, 26x, 2Ax, 2Bx, 2Dx, 2Ex, 2Fx, 2Gx, 2Kx, 2Lx, 2Px, 2Qx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 2Yx, 3Cx, 3Dx, 3Ex, 3Fx, 3Gx, 3Hx, 3Jx, 3Kx, 3Lx, 3Mx, 3Nx, 3Px, 3Qx, 3Rx, 3Sx, 3Tx, 3Ux, 4Cx, 4Dx, 4Ex, 4Fx, 4Gx, 4Jx, 4Lx, 4Mx, 4N[...]

T able 29. Parts list—Overall (continued) No. FRU (Overall) FRU no. CRU ID 10 Battery pack, Li-ion (4 cell) 73 v 0196-CTO, 23x, 27x, 2Cx, 2Ex, 2Fx, 2Hx, 2Jx, 2Ux, 2Xx, 3Jx, 3Nx, 3Px, 3Rx, 3Sx, 3Tx, 3Ux, 47x, 48x, 49x, 4Ax, 4Bx, 4Cx, 4Dx, 4Ex, 4Gx, 4Jx, 4Lx, 4Mx, 4Nx, 4Px, 4Yx v 0197-CTO, 27x, 29x, 2Mx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 3Tx, 3Ux, 3Vx, 3Wx,[...]

T able 29. Parts list—Overall (continued) No. FRU (Overall) FRU no. CRU ID 14 SA T A hard disk drive, 160 GB, 5,400 rpm v 0196-CTO, 3Cx, 3Ux, 4Fx v 0197-CTO, 2Mx, 2Nx, 2Ux, 3Bx, 3Hx v 0492-CTO, 2Hx 60Y4755 ** 14 SA T A hard disk drive, 160 GB, 5,400 rpm v 0196-CTO, 3Cx, 3Ux, 4Fx v 0197-CTO, 2Mx, 2Nx, 2Ux, 3Bx, 3Hx v 0492-CTO, 2Hx 60Y4747 ** 14 SA[...]

T able 29. Parts list—Overall (continued) No. FRU (Overall) FRU no. CRU ID 14 SA T A hard disk drive, 320 GB, 5,400 rpm v 0196-CTO, 22x, 28x, 2Ax, 2Bx, 2Cx, 2Ex, 2Fx, 2Hx, 2Jx, 2Lx, 2Mx, 2Px, 2Qx, 2Rx, 2Tx, 2Ux, 2Zx, 32x, 33x, 34x, 35x, 36x, 3Bx, 3Ex, 3Fx, 3Gx, 3Nx, 3Px, 3Rx, 3Sx, 3Tx, 3Yx, 3Zx, 42x, 43x, 47x, 4Bx, 4Cx, 4Lx, 4Nx, 4Qx, 4Rx, 4Sx, 4[...]

T able 29. Parts list—Overall (continued) No. FRU (Overall) FRU no. CRU ID 14 SA T A hard disk drive, 320 GB, 7,200 rpm v 0196-CTO, 24x, 25x, 26x, 37x, 45x, 46x v 0197-CTO, 23x, 24x, 2Ax, 2Cx, 2Dx, 2Ex, 33x, 63x, 66x, 69x, 73x v 0492-CTO 60Y4773 ** 14 SA T A hard disk drive, 320 GB, 7,200 rpm v 0196-CTO, 24x, 25x, 26x, 37x, 45x, 46x v 0197-CTO, 2[...]

T able 29. Parts list—Overall (continued) No. FRU (Overall) FRU no. CRU ID 18 System board assembly , AMD Athlon Neo X2 Single-Core MV -40 v 0197-CTO 60Y5707 N 19 Bluetooth daughter card (BDC-2.1) v 0196-CTO, 22x, 23x, 24x, 25x, 26x, 27x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx, 2Lx, 2Mx, 2Px, 2Qx, 2Rx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx,[...]

LCD FRUs 1 2 4 5 6 7 3 8 126 ThinkPad Edge 13 ″ and E30 Hardwar e Maintenance Manual[...]

T able 30. Parts list—13.3-inch HD LED-backlight LCD No. FRU (13.3-inch HD LED-backlight LCD) FRU no. CRU ID 1 LCD bezel assembly 60Y5527 N 2 Hinges, black v 0196-CTO, 22x, 24x, 25x, 26x, 27x, 28x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Mx, 2Px, 2Rx, 2Tx, 2Vx, 2Wx, 2Xx, 2Yx, 32x, 33x, 35x, 36x, 38x, 39x, 3Cx, 3Ex, 3Gx, 3Hx, 3Kx, 3Lx, 3Nx, 3Px, [...]

T able 30. Parts list—13.3-inch HD LED-backlight LCD (continued) No. FRU (13.3-inch HD LED-backlight LCD) FRU no. CRU ID 3 W ireless LAN antenna cable set v 0196-CTO, 23x, 24x, 25x, 26x, 27x, 28x, 29x, 2Ax, 2Cx, 2Ex, 2Fx, 2Hx, 2Jx, 2Qx, 2Rx, 2Tx, 2Ux, 2Vx, 2Xx, 2Zx, 32x, 33x, 34x, 35x, 36x, 37x, 38x, 39x, 3Ax, 3Bx, 3Cx, 3Dx, 3Ex, 3Fx, 3Gx, 3Hx, 3[...]

Keyboard T able 31. Parts list—Keyboard Language FRU no. CRU ID Arabic 60Y9513 60Y9443 N Belgian 60Y9514 60Y9444 Brazilian Portuguese 60Y9512 60Y9442 Bulgarian 60Y9515 60Y9445 Canadian French (058) 60Y9510 60Y9440 Canadian French (Acnor) 60Y9509 60Y9439 Czech 60Y9516 60Y9446 Danish 60Y9517 60Y9447 Dutch 60Y9527 60Y9457 Finnish, Swedish 60Y9534 60[...]

AC adapters T able 32. Parts list—2-pin AC adapters FRU FRU no. CRU ID 2-pin (65 W , 20 V) adapter (models CTO, xxE, xxF , xxJ, xxL, xxP , xxS, xxU, xxY) 42T5282 * 2-pin (65 W , 20 V) adapter (models CTO, xxE, xxF , xxJ, xxL, xxP , xxS, xxU, xxY) 42T4423 2-pin (65 W , 20 V) adapter (models CTO, xxE, xxF , xxJ, xxL, xxP , xxS, xxU, xxY) 42T4419 T [...]

Power cords A ThinkPad power cord for a specific country or region is usually available only in that country or region: T able 35. Parts list—2-pin power cords Country or region FRU no. CRU ID Argentina v models -CTO, xxY 42T5020 42T5105 * Brazil v models -CTO, xxP 42T5180 42T5183 Canada, U.S. v models -CTO, xxF , xxL, xxS, xxU 42T5008 42T5093 Ja[...]

Recovery discs Windows 7 Home Basic (32 bit) DVDs W indows 7 Home Basic (32 bit) is preinstalled as the operating system in the following models: v 0196-CTO, 2Zx, 3Hx, 4Fx, 4Gx, 4Jx, 4Lx, 4Nx, 4Px v 0197-CTO, 2Jx, 2Rx, 2Vx, 2Zx, 39x, 3Tx, 3Ux, 3Vx, 3Wx, 3Yx, 3Zx, 42x, 43x, 45x, 46x, 47x, 48x, 4Ax, 4Bx, 4Cx, 4Dx, 4Fx, 4Gx, 4Hx, 4Jx, 4Lx, 4Mx, 4Nx, 4[...]

Windows 7 Home Premium (64 bit) DVDs W indows 7 Home Premium (64 bit) is pr einstalled as the operating system in the following models: v 0196-CTO, 2Ux, 3Qx, 3Rx, 3Sx, 3Tx, 3Ux, 4Cx v 0197-CTO, 25x, 27x, 29x, 2Ax, 2Cx, 2Dx, 2Mx, 2Px, 4Xx, 4Zx, 53x, 55x, 57x, 59x, 5Bx, 5Dx, 5Fx, 5Hx, 5Kx, 5Mx, 5Px, 5Rx, 5Tx, 5Vx, 6Lx, 6Mx, 6Nx, 6Px v 0492-CTO, 2Ax, [...]

Windows 7 Professional (32 bit) DVDs W indows 7 Professional (32 bit) is pr einstalled as the operating system in the following models: v 0196-CTO, 24x, 29x, 2Cx, 2Ex, 2Fx, 2Hx, 2Jx, 2Xx, 35x, 36x, 3Bx, 3Ex, 3Fx, 3Gx, 3Jx, 3Kx, 3Px, 3Yx, 3Zx, 42x, 44x, 45x, 46x v 0197-CTO, 28x, 2Hx, 2Kx, 2Lx, 33x, 3Ax, 3Cx, 3Dx, 3Fx, 3Gx, 3Jx, 3Lx, 4Rx, 4Tx, 4Vx, 4[...]

Windows 7 Professional (64 bit) DVDs W indows 7 Professional (64 bit) is pr einstalled as the operating system in the following models: v 0196-CTO, 22x, 23x, 25x, 26x, 27x, 28x, 2Ax, 2Bx, 2Dx, 2Gx, 2Kx, 2Vx, 2Wx, 37x, 38x, 39x, 3Ax, 47x v 0197-CTO, 23x, 24x, 26x, 2Ex, 2Fx, 2Qx, 2Wx, 3Px, 3Qx, 3Sx, 4Sx, 4Ux, 4Wx, 6Qx, 6Rx, 6Yx v 0492-CTO, 23x, 25x, [...]

Common service tools T able 42. Parts list—Common service tools T ool P/N Screwdriver kit 95F3598 1/4 ″ drive spinner handle 1650840 1/4 ″ Sq. to 1/4 ″ hex torx adapter 93F2838 TR7-TR-10 tamper resistant torx bits 00P6967 Removal tool antenna RF connector 08K7159 USB 2.0 CD-R W/DVD-ROM combo drive II 40Y8687 USB cable 40Y8704 USB floppy dis[...]

Notices Lenovo may not offer the pr oducts, services, or features discussed in this document in all countries. Consult your local Lenovo repr esentative for information on the products and services curr ently available in your area. Any refer ence to a Lenovo product, program, or service is not intended to state or imply that only that Lenovo produ[...]

vary significantly . Some measurements may have been made on development-level systems and there is no guarantee that these measur ements will be the same on generally available systems. Furthermore, some measur ements may have been estimated through extrapolation. Actual results may vary . Users of this document should verify the applicable data f[...]

[...]

Part Number: 63Y0744 (1P) P/N: 63Y0744[...]