Lenovo T410I инструкция обслуживания

T hinkP a d T4 1 0 a n d T4 1 0i Hard w ar e M a i nte n a n c e M a n ua l[...]

[...]

T hinkP a d T4 1 0 a n d T4 1 0i Hard w ar e M a i nte n a n c e M a n ua l[...]

Note Before using this information and the pr oduct it supports, be sure to read the general information under “Notices” on page 193. First Edition (January 2010) © Copyright Lenovo 2010. LENOVO products, data, computer softwar e, and services have been developed exclusively at private expense and are sold to governmental entities as commer ci[...]

Contents About this manual .......... v Safety information .......... 1 General safety .............. 2 Electrical safety ............. 3 Safety inspection guide ........... 5 Handling devices that are sensitive to electr ostatic discharge ............... 6 Grounding r equirements .......... 6 Safety notices (multilingual translations) ..... 7 Lase[...]

Locations ............. 1 4 9 Front view .............. 1 4 9 Rear view .............. 1 5 1 Bottom view .............. 1 5 2 Parts list ............. 1 5 3 Overall ............... 1 5 4 LCD FRUs .............. 1 7 0 Keyboard ............... 1 7 8 Miscellaneous parts ........... 1 7 9 AC adapters .............. 1 8 1 Power cords .............. 1 8 [...]

About this manual This manual contains service and refer ence information for the following ThinkPad ® products. ThinkPad T410 and T410i MT 2516, 2518, 2519, 2522, 2537, 2538, and 2539 Use this manual along with the advanced diagnostic tests to troubleshoot problems. Important: This manual is intended only for trained service technicians who are f[...]

vi ThinkPad T410 Hardwar e Maintenance Manual[...]

Safety information This chapter presents following safety information that you need to be familiar with before you service a ThinkPad Notebook. v “General safety” on page 2 v “Electrical safety” on page 3 v “Safety inspection guide” on page 5 v “Handling devices that are sensitive to electr ostatic discharge” on page 6 v “Groundin[...]

General safety Follow these rules to ensur e general safety: v Observe good housekeeping in the area of the machines during and after maintenance. v When lifting any heavy object: 1. Make sure that you can stand safely without slipping. 2. Distribute the weight of the object equally between your feet. 3. Use a slow lifting force. Never move suddenl[...]

Electrical safety Observe the following rules when working on electrical equipment. v Find the room emer gency power-off (EPO) switch, disconnecting switch, or electrical outlet. If an electrical accident occurs, you can then operate the switch or unplug the power cord quickly . v Do not work alone under hazardous conditions or near equipment that [...]

v Do not touch live electrical circuits with the r eflective surface of a plastic dental mirror . The surface is conductive; such touching can cause personal injury and machine damage. v Do not service the following parts with the power on when they are r emoved from their normal operating places in a machine: – Power supply units – Pumps – B[...]

Safety inspection guide The purpose of this inspection guide is to assist you in identifying potentially unsafe conditions. As each machine was designed and built, requir ed safety items were installed to pr otect users and service technicians from injury . This guide addresses only those items. Y ou should use good judgment to identify potential s[...]

Handling devices that are sensitive to electrostatic discharge Any computer part containing transistors or integrated circuits (ICs) should be considered sensitive to electr ostatic discharge (ESD.) ESD damage can occur when there is a dif ference in charge between objects. Pr otect against ESD damage by equalizing the charge so that the machine, t[...]

Safety notices (multilingual translations) The safety notices in this section are pr ovided in the following languages: v English v Arabic v Brazilian Portuguese v French v German v Hebrew v Japanese v Korean v Spanish v T raditional Chinese Safety information 7[...]

DANGER Before the computer is powered on after FRU replacement, make sure all screws, springs, and other small parts are in place and are not left loose inside the computer . V erify this by shaking the computer and listening for rattling sounds. Metallic parts or metal flakes can cause electrical shorts. DANGER Some standby batteries contain a sma[...]

DANGER T o avoid shock, do not remove the plastic cover that protects the lower part of the inverter card. DANGER Though the main batteries have low voltage, a shorted or grounded battery can produce enough current to burn personnel or combustible materials. DANGER Unless hot swap is allowed for the FRU being replaced, do as follows before removing[...]

10 ThinkPad T410 Hardwar e Maintenance Manual[...]

Safety information 11[...]

PERIGO Antes de ligar o computador após a substituição da FRU, certifique-se de que todos os parafusos, molas e outras peças pequenas estejam no lugar e não estejam soltos dentro do computador . V erifique isso sacudindo o computador e procurando ouvir sons de peças soltas. Peças metálicas ou lascas de metal podem causar curto-circuito. PER[...]

PERIGO Para evitar choque elétrico, não remova a capa plástica que protege a parte inferior da placa inversora. PERIGO Embora as principais baterias possuam baixa voltagem, uma bateria em curto-circuito ou aterrada pode produzir corrente o bastante para queimar materiais de pessoal ou inflamáveis. PERIGO A menos que uma hot swap seja permitida [...]

DANGER A vant de remettre l’ordinateur sous tension après remplacement d’une unité en clientèle, vérifiez que tous les ressorts, vis et autres pièces sont bien en place et bien fixées. Pour ce faire, secouez l’unité et assurez-vous qu’aucun bruit suspect ne se produit. Des pièces métalliques ou des copeaux de métal pourraient caus[...]

DANGER Afin d’éviter tout risque de choc électrique, ne retirez pas le cache en plastique protégeant la partie inférieure de la carte d’alimentation. DANGER Bien que le voltage des batteries principales soit peu élevé, le court-circuit ou la mise à la masse d’une batterie peut produire suffisamment de courant pour brûler des matériau[...]

VORSICHT Bevor nach einem FRU-Austausch der Computer wieder angeschlossen wird, muß sichergestellt werden, daß keine Schrauben, Federn oder andere Kleinteile fehlen oder im Gehäuse vergessen wurden. Der Computer muß geschüttelt und auf Klappergeräusche geprüft werden. Metallteile oder-splitter können Kurzschlüsse erzeugen. VORSICHT Die Ber[...]

VORSICHT Die Leuchtstoffröhre im LCD-Bildschirm enthält Quecksilber . Bei der Entsorgung die örtlichen Bestimmungen für Sondermüll beachten. Der LCD-Bildschirm besteht aus Glas und kann zerbrechen, wenn er unsachgemäß behandelt wird oder der Computer auf den Boden fällt. W enn der Bildschirm beschädigt ist und die darin befindliche Flüssi[...]

18 ThinkPad T410 Hardwar e Maintenance Manual[...]

Safety information 19[...]

20 ThinkPad T410 Hardwar e Maintenance Manual[...]

Safety information 21[...]

22 ThinkPad T410 Hardwar e Maintenance Manual[...]

Safety information 23[...]

PELIGRO Antes de encender el sistema despues de sustituir una FRU, compruebe que todos los tornillos, muelles y demás piezas pequeñas se encuentran en su sitio y no se encuentran sueltas dentro del sistema. Compruébelo agitando el sistema y escuchando los posibles ruidos que provocarían. Las piezas metálicas pueden causar cortocircuitos eléct[...]

PELIGRO Para evitar descargas, no quite la cubierta de plástico que rodea la parte baja de la tarjeta invertida. PELIGRO Aunque las baterías principales tienen un voltaje bajo, una batería cortocircuitada o con contacto a tierra puede producir la corriente suficiente como para quemar material combustible o provocar quemaduras en el personal. PEL[...]

26 ThinkPad T410 Hardwar e Maintenance Manual[...]

Safety information 27[...]

Laser compliance statement (multilingual translations) The laser compliance statements in this section are pr ovided in the following languages: v English v Arabic v Brazilian Portuguese v French v German v Hebrew v Japanese v Korean v Spanish v T raditional Chinese Some models of ThinkPad Notebook are equipped fr om the factory with an optical sto[...]

Safety information 29[...]

Alguns modelos de computador ThinkPad são equipados na fábrica com um dispositivo de armazenamento ótico, como uma unidade de CD-ROM ou de DVD-ROM. T ais dispositivos também são vendidos separadamente como opcionais. Se uma dessas unidades estiver instalada, ela é certificada nos Estados Unidos em conformidade com os requisitos do Department [...]

Certains modèles d’ordinateur ThinkPad sont équipés d’origine d’une unité de stockage optique telle qu’une unité de CD-ROM ou de DVD-ROM. Ces unités sont également vendues séparément en tant qu’options. Si l’une de ces unités est installée, elle est certifiée conforme, aux Etats-Unis, aux normes indiquées dans le sous-chapi[...]

Einige ThinkPad-Modelle sind werkseitig mit einem CD-ROM- oder DVD-ROM-Laufwerk ausgestattet. CD- und DVD-Laufwerke können auch gesondert als Zusatzeinrichtung erworben werden. Die Laufwerke erfüllen die Anforder ungen gemäß IEC 60825-1 (International Electrotechnical Commission) und gemäß CENELEC EN 60825-1 für Laserprodukte der Klasse 1. B[...]

Safety information 33[...]

34 ThinkPad T410 Hardwar e Maintenance Manual[...]

Safety information 35[...]

Algunos modelos de sistemas ThinkPad están equipados de fábrica con un dispositivo de almacenamiento óptico, como una unidad de CD-ROM o de DVD-ROM. Estas unidades también se venden por separado como opciones. Si está instalada alguna de dichas unidades, se certifica que en los Estados Unidos cumple los requisitos del Department of Health and [...]

Safety information 37[...]

38 ThinkPad T410 Hardwar e Maintenance Manual[...]

Important service information This chapter presents following important service information that applies to all machine types supported by this manual: v “Strategy for replacing FRUs” – “Strategy for replacing a har d disk drive” on page 40 – “Important notice for replacing a system boar d” on page 40 – “How to use error message[...]

Use the following strategy to prevent unnecessary expense for r eplacing and servicing FRUs: v If you are instructed to replace a FRU but the replacement does not correct the problem, reinstall the original FRU before you continue . v Some computers have both a processor boar d and a system board. If you are instructed to r eplace either the proces[...]

Strategy for replacing FRUs for CT O, CMV , and GA V Product definition Dynamic Configure T o Order (CTO) This provides the ability for a customer to configur e an IBM ® or a Lenovo solution from an eSite, and have this configuration sent to fulfillment, wher e it is built and shipped directly to the customer . The machine label, Product Entitleme[...]

v Business Partners using Eclaim will access PEW when performing Entitlement Lookup. Business Partners will enter Loc ID, MT and Serial, and the key commodities will be returned in the Eclaim r ecord under SYSTEM DET AILS. v Authorized IBM Business Partners can access Eclaim at the following W eb site: https://wca.eclaim.com Using eSupport For Key [...]

General checkout This chapter presents following information: v “What to do first” on page 44 v “Checkout guide” on page 45 – “Diagnostics using PC-Doctor for DOS” on page 45 – “Lenovo ThinkV antage T oolbox (Lenovo System T oolbox)” on page 48 – “PC-Doctor for Rescue and Recovery” on page 48 – “FRU tests” on page 49[...]

What to do first When you do return a FRU, you must include the following information in the parts exchange form or parts return form that you attach to it: __ 1. Name and phone number of service technician __ 2. Date of service __ 3. Date on which the machine failed __ 4. Date of purchase __ 5. Failure symptoms, err or codes appearing on the displ[...]

Checkout guide Use the following procedur es as a guide in identifying and correcting problems with the ThinkPad Notebook. Note: The diagnostic tests are intended to test only ThinkPad pr oducts. The use of non-ThinkPad products, pr ototype cards, or modified options can lead to false indications of errors and invalid system r esponses. 1. Identify[...]

T esting the computer Note: The PC-Doctor diagnostic CD does not support any optical drives connected through USB devices or any others. It supports only the internal optical drive of the ThinkPad Notebook. T o run the test, do as follows: 1. T urn off the computer . 2. Make sure that the internal optical drive that is supported as a startup device[...]

The options on the test menu are as follows: Diagnostics Interactive T ests v Run Normal T est v Run Quick T est v CPU/Coprocessor v System board v V ideo Adapter v Fixed Disks v Diskette Drives v Other Devices v ThinkPad Devices v Communication v W ireless LAN v Advanced Memory T ests v Keyboard v V ideo v Internal Speaker v Mouse v Diskette v Sys[...]

v Battery Rundown v V iew T est Log v Print Log v Save Log v Full Erase Hard Drive v Quick Erase Hard Drive Lenovo ThinkV antage T oolbox (Lenovo System T oolbox) Lenovo ThinkV antage ® T oolbox (Lenovo System T oolbox in W indows V ista ® and W indows ® XP) is a diagnostic program that works thr ough the W indows operating system. It enables yo[...]

FRU tests The following table shows the test for each FRU. T able 1. FRU tests FRU Applicable test System board 1. Diagnostics --> CPU/Coprocessor 2. Diagnostics --> Systemboard 3. If the docking station or the port replicator is attached to the ThinkPad Notebook, detach it. 4. Place the computer on a horizontal surface, and run Diagnostics -[...]

T able 1. FRU tests (continued) FRU Applicable test Memory 1. If two DIMMs are installed, r emove one of them and run Diagnostics --> Advanced Memory T ests . 2. If the problem does not r ecur , r eturn the DIMM to its place, remove the other one, and r un the test again. T rackPoint or pointing device If the T rackPoint does not work, check the[...]

Power system checkout T o verify a symptom, do the following: 1. T urn off the computer . 2. Remove the battery pack. 3. Connect the ac adapter . 4. Check that power is supplied when you turn on the computer . 5. T urn off the computer . 6. Disconnect the ac adapter and install the charged battery pack. 7. Check that the battery pack supplies power[...]

Checking operational charging T o check whether the battery charges pr operly during operation, use a discharged battery pack or a battery pack that has less than 50% of the total power remaining when installed in the computer . Perform operational charging. If the battery status indicator or icon does not turn on, remove the battery pack and let i[...]

Checking the backup battery Do the following: 1. Power off the computer , and unplug the ac adapter from it. 2. T urn the computer upside down. 3. Remove the battery pack (see “1010 Battery pack” on page 85). 4. Remove the backup battery (see “1 100 Backup battery” on page 103). 5. Measure the voltage of the backup battery . See the followi[...]

54 ThinkPad T410 Hardwar e Maintenance Manual[...]

Related service information This chapter presents following information: v “Restoring the factory contents by using Recovery Disc Set” v “Passwords” on page 56 v “Power management” on page 60 v “Symptom-to-FRU index” on page 62 Restoring the factory contents by using Recovery Disc Set When the hard disk drive (HDD) or solid state dr[...]

1. Make the CD/DVD drive the first startup device in the startup sequence using the following procedur e: a. Press and hold down the F1 key , and then turn on the computer . When the logo screen is displayed or if you hear r epeating beeps, release the F1 key . The Setup Utility program opens. b. Use the arrow keys to select Startup → Boot . c. S[...]

Exception: If only an SVP is installed, the passwor d prompt does not appear when the operating system is booted. Power-on password A power-on password (POP) pr otects the system from being power ed on by an unauthorized person. The password must be enter ed before an operating system can be booted. For how to remove the POP , see “How to r emove[...]

After the POST ends, the password pr ompt does not appear . The POP has been removed. 5. Reinstall the backup battery and the battery pack. (B) If an SVP has been set and is known by the service technician: 1. T urn on the computer . 2. When the ThinkPad logo comes up, immediately press F1 to enter BIOS Setup Utility . For models supporting the Pas[...]

7. T ype the current master HDP in the Enter Current Password field. then leave the Enter New Password field blank, and press Enter twice. 8. Press F10. 9. Select Ye s in the Setup Configuration window . Both user HDP and master HDP will have been removed. Related service information 59[...]

Power management T o reduce power consumption, the computer has thr ee power management modes: screen blank, sleep (standby in W indows XP), and hibernation. Screen blank mode If the time set on the “T urn off monitor” timer in the operating system expir es, the LCD backlight turns off. T o put the computer into screen blank mode, do as follows[...]

Also, in either of the following events, the computer automatically returns fr om sleep (standby) mode and resumes operation: v The ring indicator (RI) is signaled by a serial device or a PC Card device. v The time set on the resume timer elapses. Note: The computer does not accept any input immediately after it enters sleep (standby) mode. W ait a[...]

Symptom-to-FRU index This section contains following information: v “Numeric error codes” v “Error messages” on page 66 v “Beep symptoms” on page 67 v “No-beep symptoms” on page 67 v “LCD-related symptoms” on page 68 v “Intermittent problems” on page 69 v “Undetermined problems” on page 69 The symptom-to-FRU index in thi[...]

T able 2. Numeric error codes (continued) Symptom or error FRU or action, in sequence 0187 EAIA data access error—The access to EEPROM is failed. System board. 0188 Invalid RFID Serialization Information Area. System board. 0189 Invalid RFID configuration information area—The EEPROM checksum is not corr ect. System board. 0190 Critical low-batt[...]

T able 2. Numeric error codes (continued) Symptom or error FRU or action, in sequence 0251 System CMOS checksum bad— Default configuration used. 1. Charge the backup battery for more than 8 hours by connecting the ac adapter . 2. Replace the backup battery and run BIOS Setup Utility to reset the time and date. 0252 Password checksum bad—The pas[...]

T able 2. Numeric error codes (continued) Symptom or error FRU or action, in sequence 1805 Unauthorized W ireless USB car d is plugged in—Power off and r emove the W ireless USB card. 1. Remove the W ireless USB card that you installed. 2. System board. 1820 More than one external fingerprint r eader is attached. Power off and r emove all but the[...]

Error messages T able 3. Error messages Symptom or error FRU or action, in sequence Device address conflict. 1. Load “Setup Defaults” in the BIOS Setup Utility . 2. Backup battery . 3. System board. Allocation error for device. 1. Load “Setup Defaults” in the BIOS Setup Utility . 2. Backup battery . 3. System board. Failing bits: nnnn. 1. D[...]

Beep symptoms T able 4. Beep symptoms Symptom or error FRU or action, in sequence One beep and a blank, unreadable, or flashing LCD. 1. Reseat the LCD connector . 2. LCD assembly . 3. External CR T . 4. System board. One long and two short beeps, and a blank or unreadable LCD. 1. System board . 2. LCD assembly . 3. DIMM. T wo short beeps with error[...]

LCD-related symptoms T able 6. LCD-related symptoms Symptom or error FRU or action, in sequence No beep, power-on indicator on, and a blank LCD during POST . System board . v LCD backlight not working. v LCD too dark. v LCD brightness cannot be adjusted. v LCD contrast cannot be adjusted. 1. Reseat the LCD connectors . 2. LCD assembly . 3. System b[...]

Intermittent problems Intermittent system hang problems can be due to a variety of causes that have nothing to do with a hardwar e defect, such as cosmic radiation, electrostatic discharge, or softwar e errors. FRU replacement should be consider ed only when a problem r ecurs. When analyzing an intermittent problem, do the following: 1. Run the dia[...]

70 ThinkPad T410 Hardwar e Maintenance Manual[...]

Status indicators This chapter presents the system status indicators that show the status of the computer . 7 1 2 3 4 5 6 8 9 © Copyright Lenovo 2010 71[...]

11 10 T able 7. Status indicators Indicator Meaning 1 Speaker mute Orange: The speaker is on mute. T o set the speakers on mute or unmute, press the speaker mute button. 2 Microphone mute Orange: The microphone is on mute. None of the r ecording devices is available while the microphone mute is on by default. 3 W ireless LAN, W ir[...]

T able 7. Status indicators (continued) Indicator Meaning 7 Numeric lock (On-screen indicator) By default, when the numeric lock is on, the numeric lock indicator is displayed on the screen. 8 Serial Ultrabay Slim device status Green: A Serial Ultrabay Slim device is installed and in use. Blinking green: A Serial Ultrabay Slim device is[...]

74 ThinkPad T410 Hardwar e Maintenance Manual[...]

Fn key combinations The following table shows the function of each combination of Fn with a function key . T able 8. Fn key combinations Key combination Description Fn+F1 Reserved. Fn+F2 Lock the computer . Fn+F3 Select a power plan (in W indows XP , power scheme) that has been created by Power Manager , or adjust the power level by using the slide[...]

T able 8. Fn key combinations (continued) Key combination Description Fn+F7 Apply a presentation scheme dir ectly , with no need to start Presentation Dir ector . T o disable this function and use the Fn+F7 key combination for switching a display output location, start Presentation Dir ector , and change the settings. Note: If the computer is an W [...]

T able 8. Fn key combinations (continued) Key combination Description Fn+F12 Put the computer into hibernation mode. T o return to normal operation, press the power button for less than four seconds. Notes: T o use this combination of the keys, ThinkPad PM device driver must have been installed on the computer . Though the screen fades out immediat[...]

78 ThinkPad T410 Hardwar e Maintenance Manual[...]

FRU replacement notices This chapter presents notices r elated to removing and replacing parts. Read this chapter carefully befor e replacing any FRU. Screw notices Loose screws can cause a r eliability problem. In the ThinkPad Notebook, this problem is addr essed with special nylon-coated screws that have the following characteristics: v They main[...]

Retaining serial numbers This section includes the following descriptions: v “Restoring the serial number of the system unit” v “Retaining the UUID” v “Reading or writing the ECA information” on page 81 Restoring the serial number of the system unit When the computer was manufactured, the EEPROM on the system boar d was loaded with the [...]

The algorithm that generates the number is designed to provide unique IDs until the year A.D. 3400. No two computers in the world have the same number . When you replace the system boar d, you must set the UUID on the new system board as follows: 1. Install the LENOVO ThinkPad Hardwar e Maintenance Diskette V ersion 1.76 or later , and restart the [...]

82 ThinkPad T410 Hardwar e Maintenance Manual[...]

Removing and replacing a FRU This chapter presents dir ections and drawings for use in removing and replacing a FRU. Be sure to observe the following general r ules: 1. Do not try to service any computer unless you have been trained and certified. An untrained person runs the risk of damaging parts. 2. Before r eplacing any FRU, review “FRU repla[...]

Before servicing ThinkPad T410 and T410i Some models of the ThinkPad T410 and T410i you are servicing might have the SIM card that the customer has installed. If the computer you are servicing has the SIM car d, remove it before you start the servicing. T o remove the SIM car d, you need to remove the battery pack first. (See “1010 Battery pack?[...]

1010 Battery pack T able 9. Removal steps of battery pack DANGER Use only the battery specified in the parts list for your computer . Any other battery could ignite or explode. Important notice for replacing a battery pack: ThinkV antage T oolbox (in W indows 7) and Lenovo System T oolbox (in W indows V ista and W indows XP) have an automatic batte[...]

T able 9. Removal steps of battery pack (continued) Unlock the battery latch 1 . Holding the battery latch in the unlocked position 2 , remove the battery pack in the dir ection shown by arrow 3 . 3 2 1 When installing: Install the battery pack in the slot, and then make sure that the battery latch is in the locked position. 86 Th[...]

1020 ExpressCard blank bezel T able 10. Removal steps of ExpressCard blank bezel When you press the Expr essCard blank bezel 1 , it pops out 2 . 1 2 When installing: Make sure that the bezel is corr ectly oriented as shown in this figure. Removing and replacing a FRU 87[...]

1030 Serial Ultrabay Slim device or travel bezel For access, remove this FRU: v “1010 Battery pack” on page 85 T able 1 1. Removal steps of Serial Ultrabay Slim device or travel bezel Holding the bay lock latch in the unlocked position 1 , slide the bay eject latch 2 , and then pull out the Ultrabay Slim Media Bay device or the trav[...]

1040 Hard disk drive (HDD) slot cover , HDD rubber rails and HDD or storage converter and solid state drive (SSD) For access, remove this FRU: v “1010 Battery pack” on page 85 T able 12. Removal steps of HDD slot cover , HDD rubber rails and HDD or storage converter and solid state drive (SSD) 2 1 Step Screw (quantity) Color T orque 1 M3 [...]

T able 12. Removal steps of HDD slot cover , HDD rubber rails and HDD or storage converter and solid state drive (SSD) (continued) 3 For HDD and HDD rubber rails: 4 4 For SSD and storage converter: 5 4 When installing: Make sure that the SSD connector or HDD connector is attached firmly . 90 ThinkPad T410 Hardwar e Maintenance Manual[...]

1050 DIMM slot cover For access, remove this FRU: v “1010 Battery pack” on page 85 T able 13. Removal steps of DIMM slot cover Note: Loosen the screw 1 , but do not r emove it. 1 2 Removing and replacing a FRU 91[...]

1060 DIMM (in bottom slot) For access, remove these FRUs in or der: v “1010 Battery pack” on page 85 v “1050 DIMM slot cover” on page 91 Note: This product has two DIMM slots: one under the keyboar d and another on the underside of the computer . If you install a DIMM in only one of the two slots, install it in the slot located under the ke[...]

1070 PCI Express Mini Card for wireless W AN For access, remove these FRUs in or der: v “1010 Battery pack” on page 85 v “1050 DIMM slot cover” on page 91 T able 15. Removal steps of PCI Express Mini Card for wireless WAN In step 3 , unplug the jacks by using the removal tool antenna RF connector (P/N: 08K7159) or pick the connectors [...]

T able 15. Removal steps of PCI Express Mini Card for wireless WAN (continued) 3 Note: Plug the red cable into the jack labeled MAIN , and the blue cable into the jack labeled AUX on the card. If the computer you are servicing is a wir eless W AN-ready model and does not have the wireless W AN card, route the antenna cables and secur e them with a [...]

1080 Keyboard For access, remove these FRUs in or der: v “1010 Battery pack” on page 85 v “1050 DIMM slot cover” on page 91 T able 16. Removal steps of keyboard 1 Step Screw (quantity) Color T orque 1 M2 × 10 mm, wafer-head, nylon-coated (1) Black 0.181 Nm (1.85 kgfcm) Removing and replacing a FRU 95[...]

T able 16. Removal steps of keyboard (continued) Push down the keyboard a little towar d the arrow 2 to detach the front edge of the keyboard fr om the frame. 2 96 ThinkPad T410 Hardwar e Maintenance Manual[...]

T able 16. Removal steps of keyboard (continued) Lift the keyboard a little in the dir ection shown by arrow 3 , and then detach the connector 4 . 4 3 Removing and replacing a FRU 97[...]

When installing the keyboard, do as follows: T able 17. Installation steps of keyboard 1. Attach the keyboard connector . 1 98 ThinkPad T410 Hardwar e Maintenance Manual[...]

T able 17. Installation steps of keyboard (continued) 2. Attach the keyboard so that the keyboar d edges a are under the frame as shown in this figure. a a 3. T o make sure that the fr ont edge of the keyboard is housed firmly , gently press the keys with your thumbs and try to slide the keyboar d toward you. Removing and replacing a FRU 99[...]

T able 17. Installation steps of keyboard (continued) 4. Make sure that fr ont edge of the keyboard b is attached firmly . b b b 5. Secure the keyboar d by tightening the screws from the bottom side of the computer . 100 ThinkPad T410 Hardwar e Maintenance Manual[...]

1090 DIMM (in slot under keyboard) For access, remove these FRUs in or der: v “1010 Battery pack” on page 85 v “1050 DIMM slot cover” on page 91 v “1080 Keyboard” on page 95 Note: This product has two DIMM slots: one under the keyboar d and another on the underside of the computer . If you install a DIMM in only one of the two slots, in[...]

T able 18. Removal steps of DIMM (in slot under keyboard) (continued) 2 2 3 When installing: Insert the notched end of the DIMM into the socket. Press the DIMM firmly , and pivot it until it snaps into the place. Make sure that it is firmly fixed in the slot and does not move easily . 102 ThinkPad T410 Hardwar e Maintenance Manual[...]

1 100 Backup battery For access, remove these FRUs in or der: v “1010 Battery pack” on page 85 v “1050 DIMM slot cover” on page 91 v “1080 Keyboard” on page 95 T able 19. Removal steps of backup battery DANGER Use only the battery specified in the parts list for your computer . Any other battery could ignite or explode. 2 1 Removing and[...]

T able 19. Removal steps of backup battery (continued) Cable routing: Attach the backup battery and route the cable as shown in the figure below and make sur e that the battery connector is attached firmly . 104 ThinkPad T410 Hardwar e Maintenance Manual[...]

1 1 10 PCI Express Mini Card for wireless LAN For access, remove these FRUs in or der: v “1010 Battery pack” on page 85 v “1050 DIMM slot cover” on page 91 v “1080 Keyboard” on page 95 T able 20. Removal steps of PCI Express Mini Card for wireless LAN In step 1 , unplug the jacks by using the removal tool antenna RF connector (P/N[...]

T able 20. Removal steps of PCI Express Mini Card for wireless LAN (continued) 3 When installing: v In models with wireless LAN car d that has two antenna connectors, plug the gray cable into the jack marked MAIN or M , and the black cable into the jack marked AUX or A on the card. If the computer you ar e servicing has three cables, put the white [...]

1 120 Keyboard bezel assembly , FPC cable, and Bluethooth daughter card (BDC-2.1) For access, remove these FRUs in or der: v “1010 Battery pack” on page 85 v “1020 ExpressCar d blank bezel” on page 87 v “1050 DIMM slot cover” on page 91 v “1080 Keyboard” on page 95 Note: FPC cable is attached on the underside of the keyboard bezel a[...]

T able 21. Removal steps of keyboard bezel assembly , FPC cable, and BDC-2.1 (continued) 3 3 3 3 Step Screw (quantity) Color T orque 3 M2 × 3 mm, wafer-head, nylon-coated (4) Black 0.181 Nm (1.85 kgfcm) 4 4 4 4 4 4 4 4 4 4 4 4 5 108 ThinkPad T410 Hardwar e Maintenance Manual[...]

T able 21. Removal steps of keyboard bezel assembly , FPC cable, and BDC-2.1 (continued) 6 7 When installing: Make sure that the connector is attached firmly . Removing and replacing a FRU 109[...]

T able 21. Removal steps of keyboard bezel assembly , FPC cable, and BDC-2.1 (continued) 8 9 9 10 12 11 12 13 When installing: Make sure that the connectors ar e attached firmly . 14 15 Step Screw (quantity) Color T orque 14 M2 × 3 mm, wafer-head, nylon-coated (1) Black 0.181 Nm (1.85 kgfcm) 11 0 ThinkPad T410 Hardwar e Maintenance Manual[...]

T able 21. Removal steps of keyboard bezel assembly , FPC cable, and BDC-2.1 (continued) 16 When installing: Make sure that the connector is attached firmly . Removing and replacing a FRU 111[...]

1 130 SmartCard or Contactless SmartCard For access, remove these FRUs in or der: v “1010 Battery pack” on page 85 v “1050 DIMM slot cover” on page 91 v “1080 Keyboard” on page 95 v “1 120 Keyboard bezel assembly , FPC cable, and Bluethooth daughter card (BDC-2.1)” on page 107 T able 22. Removal steps of SmartCard or Contactless Sma[...]

T able 22. Removal steps of SmartCard or Contactless SmartCard (continued) 2 3 When installing: Make sure that the connector is attached firmly . T able 23. Removal steps of SmartCard dummy spacer Some models have SmartCard dummy spacer as a miscellaneous part. For those models, remove the spacer as follows: 1 2 1 1 1 Step Screw (quantity) Color T [...]

1 140 Modem daughter card (MDC) For access, remove these FRUs in or der: v “1010 Battery pack” on page 85 v “1050 DIMM slot cover” on page 91 v “1080 Keyboard” on page 95 v “1 120 Keyboard bezel assembly , FPC cable, and Bluethooth daughter card (BDC-2.1)” on page 107 T able 24. Removal steps of modem daughter card (MDC) 1 1 2 Step [...]

1 150 Speaker assembly For access, remove these FRUs in or der: v “1010 Battery pack” on page 85 v “1050 DIMM slot cover” on page 91 v “1080 Keyboard” on page 95 v “1 120 Keyboard bezel assembly , FPC cable, and Bluethooth daughter card (BDC-2.1)” on page 107 T able 25. Removal steps of speaker assembly 1 1 1 1 Step Screw (quantity)[...]

T able 25. Removal steps of speaker assembly (continued) 3 3 2 Cable routing: Attach the speaker assembly and route the cable as shown in this figure, and make sur e that the speaker connector is attached firmly . 11 6 ThinkPad T410 Hardwar e Maintenance Manual[...]

1 160 LCD unit For access, remove these FRUs in or der: v “1010 Battery pack” on page 85 v “1020 ExpressCar d blank bezel” on page 87 v “1050 DIMM slot cover” on page 91 v “1070 PCI Express Mini Car d for wireless W AN” on page 93 v “1080 Keyboard” on page 95 v “1 1 10 PCI Expr ess Mini Card for wireless LAN” on page 105 v ?[...]

T able 26. Removal steps of LCD unit (continued) 2 3 4 5 Step Screw (quantity) Color T orque 2 M2 × 3 mm, wafer-head, nylon-coated (1) Black 0.181 Nm (1.85 kgfcm) 4 M2 × 3 mm, wafer-head, nylon-coated (1) Black 0.181 Nm (1.85 kgfcm) 11 8 ThinkPad T410 Hardwar e Maintenance Manual[...]

T able 26. Removal steps of LCD unit (continued) 8 8 7 6 Step Screw (quantity) Color T orque 8 M2.5 × 6 mm, wafer-head, nylon-coated (2) Black 0.392 Nm (4.0 kgfcm) Removing and replacing a FRU 11 9[...]

T able 26. Removal steps of LCD unit (continued) 9 10 10 10 10 10 10 10 When installing: v Make sure that you attach the connectors and r oute the cables firmly , and tape up in the proper positions as shown in this figur e. v When you route the cables, make sur e that they are not subjected to any tension. T ension could cause the cables to be dam[...]

T able 26. Removal steps of LCD unit (continued) 11 Removing and replacing a FRU 121[...]

T able 26. Removal steps of LCD unit (continued) 12 12 122 ThinkPad T410 Hardwar e Maintenance Manual[...]

1 170 Fan assembly For access, remove these FRUs in or der: v “1010 Battery pack” on page 85 v “1020 ExpressCar d blank bezel” on page 87 v “1050 DIMM slot cover” on page 91 v “1070 PCI Express Mini Car d for wireless W AN” on page 93 v “1080 Keyboard” on page 95 v “1 1 10 PCI Expr ess Mini Card for wireless LAN” on page 105[...]

T able 27. Removal steps of fan assembly (continued) 4 5 When installing: v Before you attach the fan assembly to the computer , apply thermal grease, at an amount of 0.2 grams, on the parts marked a as in the following figures. Either too much or too less application of grease can cause a thermal pr oblem due to imperfect contact with a comp[...]

T able 27. Removal steps of fan assembly (continued) For Integrated graphics models: a v When attaching the fan assembly to the frame, take care not to damage the heat sink ( a ) of the fan assembly . a a v Make sure that the fan connector is attached firmly . Removing and replacing a FRU 125[...]

1 180 CPU For access, remove these FRUs in or der: v “1010 Battery pack” on page 85 v “1020 ExpressCar d blank bezel” on page 87 v “1050 DIMM slot cover” on page 91 v “1070 PCI Express Mini Car d for wireless W AN” on page 93 v “1080 Keyboard” on page 95 v “1 1 10 PCI Expr ess Mini Card for wireless LAN” on page 105 v “1 1[...]

1 190 Base cover assembly , I/O sub card, and I/O sub card cable For access, remove these FRUs in or der: v “1010 Battery pack” on page 85 v “1020 ExpressCar d blank bezel” on page 87 v “1030 Serial Ultrabay Slim device or travel bezel” on page 88 v “1040 Hard disk drive (HDD) slot cover , HDD rubber rails and HDD or storage converter[...]

T able 29. Removal steps of base cover assembly , I/O sub card, and I/O sub card cable (continued) 4 3 3 3 5 5 Step Screw (quantity) Color T orque 3 M2 × 3 mm, wafer-head, nylon-coated (3) Black 0.181 Nm (1.85 kgfcm) When installing: Make sure that the connector is attached firmly . 128 ThinkPad T410 Hardwar e Maintenance Manual[...]

T able 29. Removal steps of base cover assembly , I/O sub card, and I/O sub card cable (continued) 8 7 6 6 a When installing: Make sure that wir eless switch is adjusted as shown in figure a . 9 Removing and replacing a FRU 129[...]

T able 29. Removal steps of base cover assembly , I/O sub card, and I/O sub card cable (continued) 10 11 11 12 Step Screw (quantity) Color T orque 11 M2 × 3.5 mm, flat-head, nylon-coated (2) Silver 0.181 Nm (1.85 kgfcm) 13 130 ThinkPad T410 Hardwar e Maintenance Manual[...]

T able 29. Removal steps of base cover assembly , I/O sub card, and I/O sub card cable (continued) Cable routing: Make sure that connectors ar e firmly attached and route the cables as shown in this figure. Removing and replacing a FRU 131[...]

Note: Applying labels to the base cover The new base cover FRU is shipped with a kit containing labels of several kinds. When you replace the base cover , you need to apply the following labels: 18 Homologation label Following labels need to be peeled off fr om the old base cover , and need to be put on the new base cover . 1 W indows l[...]

1200 Magnesium structure frame For access, remove these FRUs in or der: v “1010 Battery pack” on page 85 v “1020 ExpressCar d blank bezel” on page 87 v “1030 Serial Ultrabay Slim device or travel bezel” on page 88 v “1040 Hard disk drive (HDD) slot cover , HDD rubber rails and HDD or storage converter and solid state drive (SSD)” on[...]

T able 30. Removal steps of magnesium structure frame (continued) 8 7 134 ThinkPad T410 Hardwar e Maintenance Manual[...]

1210 System board, DC-in connector cable, and ExpressCard slot assembly For access, remove these FRUs, in or der: v “1010 Battery pack” on page 85 v “1020 ExpressCar d blank bezel” on page 87 v “1030 Serial Ultrabay Slim device or travel bezel” on page 88 v “1040 Hard disk drive (HDD) slot cover , HDD rubber rails and HDD or storage c[...]

T able 31. Removal steps of system board, DC-in connector cable, and ExpressCard slot assembly Following components soldered on the top side of the system boar d are extremely sensitive. When you service the system boar d, avoid any kind of rough handling. a CPU b Accelerometer chip for the HDD Active Protection System ™ c PCH ([...]

T able 31. Removal steps of system board, DC-in connector cable, and ExpressCard slot assembly (continued) 1 2 1 Step Screw (quantity) Color T orque 1 M2 × 10 mm, wafer-head, nylon-coated (2) Black 0.181 Nm (1.85 kgfcm) 2 M2 × 5 mm, wafer-head, nylon-coated (1) Black 0.181 Nm (1.85 kgfcm) 3 4 When installing: Make sure that the connec[...]

2010 LCD bezel assembly For access, remove the following FRU: v “1010 Battery pack” on page 85 T able 32. Removal steps of LCD bezel assembly 1 1 Step Screw cap Screw (quantity) Color T orque 1 M2.5 × 6 mm, wafer-head, nylon-coated (4) Black 0.392 Nm (4.0 kgfcm) 138 ThinkPad T410 Hardwar e Maintenance Manual[...]

T able 32. Removal steps of LCD bezel assembly (continued) 2 2 2 2 2 3 2 Removing and replacing a FRU 139[...]

2020 LED board For access, remove these FRUs in or der: v “1010 Battery pack” on page 85 v “2010 LCD bezel assembly” on page 138 T able 33. Removal steps of LED board 1 1 3 2 Step Screw (quantity) Color T orque 1 M2 × 3.5 mm, flat-head, nylon-coated (2) Silver 0.181 Nm (1.85 kgfcm) When installing: Make sure that the connector is att[...]

2030 Integrated camera For access, remove these FRUs, in or der: v “1010 Battery pack” on page 85 v “2010 LCD bezel assembly” on page 138 T able 34. Removal steps of integrated camera 1 2 3 Step Screw (quantity) Color T orque 1 M2 × 3.5 mm, flat-head, nylon-coated (1) Silver 0.181 Nm (1.85 kgfcm) When installing: Make sure that the c[...]

2040 LCD panel and LCD cable For access, remove these FRUs in or der: v “1010 Battery pack” on page 85 v “1020 ExpressCar d blank bezel” on page 87 v “1050 DIMM slot cover” on page 91 v “1070 PCI Express Mini Car d for wireless W AN” on page 93 v “1080 Keyboard” on page 95 v “1 1 10 PCI Expr ess Mini Card for wireless LAN” o[...]

T able 35. Removal steps of LCD panel and LCD cable (continued) 6 6 7 7 6 6 Step Screw (quantity) Color T orque 6 M2 × 3 mm, wafer-head, nylon-coated (4) Black 0.181 Nm (1.85 kgfcm) When installing: When attaching the LCD panel to the cover , press the left and right edges covered with metal gently with your fingers. DO NOT pr ess the surfac[...]

2050 Camera cable For access, remove these FRUs in or der: v “1010 Battery pack” on page 85 v “1020 ExpressCar d blank bezel” on page 87 v “1050 DIMM slot cover” on page 91 v “1070 PCI Express Mini Car d for wireless W AN” on page 93 v “1080 Keyboard” on page 95 v “1 1 10 PCI Expr ess Mini Card for wireless LAN” on page 105 [...]

T able 36. Removal steps of camera cable (continued) Cable routing: When you install the cable, route the cable as shown in the figure below . 2 2 2 2 2 Removing and replacing a FRU 145[...]

2060 Wireless LAN antenna assembly or wireless LAN/W AN antenna assembly For access, remove these FRUs in or der: v “1010 Battery pack” on page 85 v “1020 ExpressCar d blank bezel” on page 87 v “1050 DIMM slot cover” on page 91 v “1070 PCI Express Mini Car d for wireless W AN” on page 93 v “1080 Keyboard” on page 95 v “1 1 10 [...]

T able 37. Removal steps of wireless LAN antenna assembly or wireless LAN/WAN antenna assembly (continued) 4 4 4 3 3 4 4 Step Screw (quantity) Color T orque 3 M2 × 3.5 mm, flat-head, nylon-coated (2) Silver 0.181 Nm (1.85 kgfcm) 5 5 Removing and replacing a FRU 147[...]

2070 Hinges and LCD rear cover assembly For access, remove these FRUs in or der: v “1010 Battery pack” on page 85 v “1020 ExpressCar d blank bezel” on page 87 v “1050 DIMM slot cover” on page 91 v “1070 PCI Express Mini Car d for wireless W AN” on page 93 v “1080 Keyboard” on page 95 v “1 1 10 PCI Expr ess Mini Card for wirele[...]

Locations This chapter presents the location of ThinkPad T410 and T410i featur es and hardwar e. Front view 1 Integrated camera (for some models) 2 ThinkLight 3 Built-in microphone 4 Power switch 5 Built-in speakers 6 Security keyhole 7 IEEE 1394 connector 8 Universal serial bus (USB) connector 9?[...]

1 2 3 4 5 6 8 9 7 5 13 11 12 10 15 16 17 14 18 19 20 21 150 ThinkPad T410 Hardwar e Maintenance Manual[...]

Rear view 1 Status indicators Note: For the description of each indicator , see “Status indicators” on page 71. 2 DisplayPort 3 HDD or SSD 4 Universal serial bus (USB) connectors 5 RJ-45 (Ethernet) connector 6 External monitor connector 7 AC power connector 8 RJ-1 1 (modem) connector 1 2 4 5 6 7 8[...]

Bottom view 1 Battery pack 2 Battery pack latch 3 DIMM slot 4 Docking connector 5 LCD cover latch 6 Media Card Reader slot 7 Serial Ultrabay Slim lock latch 8 Serial Ultrabay Slim eject latch 1 7 8 5 6 2 3 4 152 ThinkPad T410 Hardwar e Maintenance Manual[...]

Parts list This chapter contains following lists of the service parts. v “Overall” on page 154 v “LCD FRUs” on page 170 v “Keyboard” on page 178 v “Miscellaneous parts” on page 179 v “AC adapters” on page 181 v “Power cords” on page 182 v “Recovery discs” on page 183 v “Common service tools” on page 191 Notes: v Each[...]

Overall 1 3 2 b a 4 5 6 c d e 10 11 6 7 8 9 13 12 14 16 15 19 17 18 20 23 g f h 22 21 26 27 24 25 154 ThinkPad T410 Hardwar e Maintenance Manual[...]

T able 39. Parts list—Overall No. FRU (Overall) FRU no. CRU ID a-g See “Miscellaneous parts” on page 179. 1 LCD unit (see “LCD FRUs” on page 170.) 2 Keyboard bezel assembly without fingerprint r eader v 2516-CTO, A6x, ADx, AEx v 2518-CTO, CHx, EMx, F3x, FPx, FQx, FSx, FTx, FUx, FVx, FWx, FXx v 2519-CTO, 86x, 8Ax v 2522-CTO, 3Bx, 3Kx, 3Lx,[...]

T able 39. Parts list—Overall (continued) No. FRU (Overall) FRU no. CRU ID 6 1-GB DDR3-1066 SDRAM SO-DIMM (PC3-8500) card v 2516-CTO, AMx, ANx v 2518-CTO, DWx, DYx, DZx, E4x, E7x, ENx, EPx, EQx, ERx, F4x, G5x, G6x, GSx, GTx v 2519-CTO v 2522-CTO, 30x, 3Kx, 3Lx,, 3Rx, 3Sx, 49x, 54x, 56x, 64x v 2537-CTO, 9Cx v 2538-CTO v 2539-CTO 55Y3712 ** 6 2-GB [...]

T able 39. Parts list—Overall (continued) No. FRU (Overall) FRU no. CRU ID 10 Battery pack, Li-ion (4 cell) 25 v 2516-CTO v 2518-CTO, CPx, CQx, CRx, CSx, CUx, CVx, CWx, CXx, CYx, CZx, D2x, D3x, D4x, D5x, D6x, D7x, D8x, D9x, DAx, DBx, DCx, DDx, DEx, DFx, DGx, DHx, DJx, DKx, DLx, DMx, DNx, DPx, DQx, DRx, DSx, DTx, E9x, EAx, EBx, ECx, EDx, EEx, EFx,[...]

T able 39. Parts list—Overall (continued) No. FRU (Overall) FRU no. CRU ID 10 Battery pack, Li-ion (6 cell) 55+ v 2516-CTO, A2x, A3x, A4x, A5x, A6x, A7x, A8x, A9x, AAx, ACx, ADx, AFx, AGx, AHx, AJx, AKx, ALx, AMx, ANx v 2518-CTO, C2x, C3x, C6x, C7x, C8x, C9x, CAx, CBx, CCx, CDx, CEx, CFx, CGx, CHx, CJx, CKx, CLx, CMx, CNx, DUx, DVx, DWx, DXx, DYx[...]

T able 39. Parts list—Overall (continued) No. FRU (Overall) FRU no. CRU ID 10 Battery pack, Li-ion (9 cell) 55++ v 2516-CTO, ABx, AEx v 2518-CTO, C4x, C5x, EWx, F2x, F5x, F6x, FGx, FLx v 2519-CTO v 2522-CTO, 30x, 23x, 24x, 2Bx, 2Wx, 3Ax, 3Jx, 3Lx, 3Sx, 3Tx, 3Ux, 3Wx, 3Xx, 43x, 47x, 4Ax, 56x, 64x v 2537-CTO, 23x, 24x, 9Ex v 2538-CTO v 2539-CTO 42T[...]

T able 39. Parts list—Overall (continued) No. FRU (Overall) FRU no. CRU ID 14 SA T A hard disk drive, 160 GB, 5,400 rpm v 2516-CTO, A6x v 2518-CTO, CPx, CQx, CRx, CSx v 2519-CTO v 2522-CTO v 2537-CTO v 2538-CTO v 2539-CTO 45N7205 ** 14 SA T A hard disk drive, 250 GB, 5,400 rpm v 2516-CTO, A7x, ADx, AFx, AHx, AKx v 2518-CTO, C2x, CHx, CUx, CVx, CW[...]

T able 39. Parts list—Overall (continued) No. FRU (Overall) FRU no. CRU ID 14 SA T A hard disk drive, 500 GB, 5,400 rpm v 2516-CTO v 2518-CTO, G9x, GDx, GGx, GKx, GMx, GPx v 2519-CTO v 2522-CTO v 2537-CTO v 2538-CTO v 2539-CTO 45N7221 ** 14 SA T A hard disk drive, 500 GB, 5,400 rpm v 2516-CTO v 2518-CTO, G9x, GDx, GGx, GKx, GMx, GPx v 2519-CTO v [...]

T able 39. Parts list—Overall (continued) No. FRU (Overall) FRU no. CRU ID 14 SA T A hard disk drive, 500 GB, 7,200 rpm v 2516-CTO v 2518-CTO, E7x, E8x, ERx, ESx, EVx, EZx, F5x, F8x, F9x, FBx, FCx, FFx, FKx, G6x v 2519-CTO, 89x v 2522-CTO, 3Sx, 3Wx, 3Xx, 42x, 46x v 2537-CTO, 9Cx, 9Ex, 9Fx v 2538-CTO v 2539-CTO 45N7257 ** 14 SA T A hard disk drive[...]

T able 39. Parts list—Overall (continued) No. FRU (Overall) FRU no. CRU ID 14 MicroSA T A solid state drive, 256 GB, FDE v 2516-CTO v 2518-CTO v 2519-CTO v 2522-CTO v 2537-CTO v 2538-CTO v 2539-CTO 45N8207 ** 15 Modem daughter card (MDC) 43Y6463 N 16 System board assembly , integrated graphics, iAMT , TPM v 2516-CTO, A2x, A6x, A7x, A8x, ADx, AFx,[...]

T able 39. Parts list—Overall (continued) No. FRU (Overall) FRU no. CRU ID 16 System board assembly , discrete graphics 256 MB, iAMT , TPM v 2516-CTO, A4x, A9x, AAx, ABx, ACx, AEx, AHx, AJx, AKx, ALx, AMx, ANx v 2518-CTO, C4x, C5x, C8x, CEx, CFx, CGx, DUx, DVx, DWx, DXx, DYx, DZx, E4x, E7x, E8x, E9x, EAx, EBx, ECx, EDx, EEx, EFx, EGx, EUx, EVx, E[...]

T able 39. Parts list—Overall (continued) No. FRU (Overall) FRU no. CRU ID 17 CPU assembly , Intel Cor e i3-330M Processor (2.13 GHz) v 2516-CTO, AFx, AGx, AHx, AJx v 2518-CTO, FPx, FQx, FSx, FTx, FYx, FZx, G2x, G7x, G8x, GBx, GCx, GEx, GFx, GHx, GJx, GLx, GMx, GQx, GSx v 2519-CTO v 2522-CTO v 2537-CTO v 2538-CTO v 2539-CTO 63Y2174 N 17 CPU assem[...]

T able 39. Parts list—Overall (continued) No. FRU (Overall) FRU no. CRU ID 18 Intel Centrino Advanced-N 6200 v 2516-CTO, A6x v 2518-CTO, C2x, C5x, CCx, CDx, CEx, CFx, CGx, CHx, CJx, CKx, CLx, CMx, CPx, CQx, CRx, CSx, CUx, CVx, CWx, CXx, D4x, D5x, D6x, D7x, DCx, DDx, DEx, DFx, DLx, DMx, DNx, DPx, DXx, DYx, DZx, E4x, ETx, EXx, F4x, F6x, F7x, F8x, F[...]

T able 39. Parts list—Overall (continued) No. FRU (Overall) FRU no. CRU ID 22 SmartCard Reader v 2516-CTO v 2518-CTO v 2519-CTO v 2522-CTO, 2Ux, 2Vx, 30x, 3Ex, 62x, 63x, 64x v 2537-CTO, 98x, 99x v 2538-CTO v 2539-CTO 60Y5029 N 22 SmartCard Reader v 2516-CTO v 2518-CTO v 2519-CTO v 2522-CTO, 2Ux, 2Vx, 30x, 3Ex, 62x, 63x, 64x v 2537-CTO, 98x, 99x v[...]

T able 39. Parts list—Overall (continued) No. FRU (Overall) FRU no. CRU ID 23 Fan assembly , discr ete v 2516-CTO, A4x, A5x, A9x, AAx, ABx, ACx, AEx, AHx, AJx, AKx, ALx, AMx, ANx v 2518-CTO, C4x, C5x, C8x, C9x, CEx, CFx, CGx, DUx, DVx, DWx, DXx, DYx, DZx, E4x, E7x, E8x, E9x, EAx, EBx, ECx, EDx, EEx, EFx, EGx, EPx, EQx, ERx, ESx, EUx, EVx, EWx, EY[...]

T able 39. Parts list—Overall (continued) No. FRU (Overall) FRU no. CRU ID 25 Bluetooth daughter card (BDC-2.1) v 2516-CTO, A2x, A3x, A4x, A5x, A6x, A7x, A8x, A9x, AAx, ABx, ACx, AEx, AFx, AGx, AHx, AJx, AKx, ALx, AMx, ANx v 2518-CTO, C2x, C3x, C4x, C5x, C6x, C7x, C8x, C9x, CAx, CBx, CCx, CDx, CEx, CFx, CGx, CHx, CJx, CKx, CLx, CMx, CNx, CPx, CQx[...]

LCD FRUs In ThinkPad T410 and T410i, there ar e following types of LCDs. v 14.1-inch WXGA LED-backlight LCD (T able 40 on page 171) v 14.1-inch WXGA+ LED-backlight LCD (T able 41 on page 175) 1 2 3 a b 4 5 6 8 7 9 10 11 170 ThinkPad T410 Hardwar e Maintenance Manual[...]

T able 40. Parts list—14.1-inch WXGA LED-backlight LCD No. FRU (14.1-inch WXGA LED-backlight LCD) FRU no. CRU ID a, b See “Miscellaneous parts” on page 179. 1 LCD bezel assembly v 2516-CTO, A2x, A3x, A4x, A5x, A6x, A7x, A8x, A9x, AAx, ACx, ADx, AEx, AFx, AGx, AHx, AJx, AKx, ALx, AMx, ANx v 2518-CTO, C2x, C3x, C6x, C7x, C8x, C9x, CAx, CBx, CCx[...]

T able 40. Parts list—14.1-inch WXGA LED-backlight LCD (continued) No. FRU (14.1-inch WXGA LED-backlight LCD) FRU no. CRU ID 2 LCD module, 14.1-inch WXGA LED-backlight v 2516-CTO, A2x, A3x, A4x, A5x, A6x, A7x, A8x, A9x, AAx, ACx, ADx, AEx, AFx, AGx, AHx, AJx, AKx, ALx, AMx, ANx v 2518-CTO, C2x, C3x, C6x, C7x, C8x, C9x, CAx, CBx, CCx, CDx, CHx, CJ[...]

T able 40. Parts list—14.1-inch WXGA LED-backlight LCD (continued) No. FRU (14.1-inch WXGA LED-backlight LCD) FRU no. CRU ID 4 Hinges v 2516-CTO, A2x, A3x, A4x, A5x, A6x, A7x, A8x, A9x, AAx, ACx, ADx, AEx, AFx, AGx, AHx, AJx, AKx, ALx, AMx, ANx v 2518-CTO, C2x, C3x, C6x, C7x, C8x, C9x, CAx, CBx, CCx, CDx, CHx, CJx, CKx, CLx, CMx, CNx, CPx, CQx, C[...]

T able 40. Parts list—14.1-inch WXGA LED-backlight LCD (continued) No. FRU (14.1-inch WXGA LED-backlight LCD) FRU no. CRU ID 9 LCD cable v 2516-CTO, A2x, A3x, A4x, A5x, A6x, A7x, A8x, A9x, AAx, ACx, ADx, AEx, AFx, AGx, AHx, AJx, AKx, ALx, AMx, ANx v 2518-CTO, C2x, C3x, C6x, C7x, C8x, C9x, CAx, CBx, CCx, CDx, CHx, CJx, CKx, CLx, CMx, CNx, CPx, CQx[...]

T able 41. Parts list—14.1-inch WXGA+ LED-backlight LCD No. FRU (14.1-inch WXGA+ LED-backlight LCD) FRU no. CRU ID a, b See “Miscellaneous parts” on page 179. 1 LCD bezel assembly v 2516-CTO, ABx v 2518-CTO, C4x, C5x, CEx, CFx, CGx, CUx, CVx, CWx, CXx, CYx, CZx, D2x, D3x, D4x, D5x, D6x, D7x, D8x, D9x, DAx, DBx, DCx, DDx, DEx, DFx, DGx, DHx, D[...]

T able 41. Parts list—14.1-inch WXGA+ LED-backlight LCD (continued) No. FRU (14.1-inch WXGA+ LED-backlight LCD) FRU no. CRU ID 3 LCD module, 14.1-inch WXGA+ LED-backlight v 2516-CTO, ABx v 2518-CTO, C4x, C5x, CEx, CFx, CGx, CUx, CVx, CWx, CXx, CYx, CZx, D2x, D3x, D4x, D5x, D6x, D7x, D8x, D9x, DAx, DBx, DCx, DDx, DEx, DFx, DGx, DHx, DJx, DKx, DLx,[...]

T able 41. Parts list—14.1-inch WXGA+ LED-backlight LCD (continued) No. FRU (14.1-inch WXGA+ LED-backlight LCD) FRU no. CRU ID 6 LCD rear cover assembly v 2516-CTO, ABx v 2518-CTO, C4x, C5x, CEx, CFx, CGx, CUx, CVx, CWx, CXx, CYx, CZx, D2x, D3x, D4x, D5x, D6x, D7x, D8x, D9x, DAx, DBx, DCx, DDx, DEx, DFx, DGx, DHx, DJx, DKx, DLx, DMx, DNx, DPx, DQ[...]

Keyboard T able 42. Parts list—Keyboard Language FRU no. CRU ID Arabic 45N2076 45N2146 45N2216 * Belgian 45N2077 45N2147 45N2217 Brazilian Portuguese 45N2075 45N2145 45N2215 Bulgarian 45N2078 45N2148 45N2218 Canadian French (058) 45N2073 45N2143 45N2213 Canadian French (Acnor) 45N2072 45N2142 45N2212 Czech 45N2079 45N2149 45N2219 Danish 45N2080 4[...]

Miscellaneous parts T able 43. Parts list—Miscellaneous parts FRU FRU no. CRU ID Screw kit: v M2 × 3 mm (silver), small head (50) v M2 × 3.5 mm (black), wafer head (15) v M2 × 5 mm (black), wafer head (15) v M2 × 10 mm (black), wafer head (15) v M2 × 14 mm (black), wafer head (10) v M2.5 × 6 mm (black), flat head (20) v M3 × 2.8 mm (black)[...]

T able 43. Parts list—Miscellaneous parts (continued) FRU FRU no. CRU ID System miscellaneous parts: v (a) Express dummy car d v (b) EMI bracket v (c) RJ-1 1 cable assembly , integrated v (c) RJ-1 1 cable assembly , discrete v (d) DIMM slot door v (e) Hard disk drive cover for SmartCar d model v (e) Hard disk drive cover for non-SmartCar d model [...]

AC adapters T able 44. Parts list—2-pin AC adapters FRU FRU no. CRU ID 2-pin (65 W , 20 V) adapter (models CTO, xxE, xxF , xxJ, xxL, xxP , xxS, xxU, xxY) 42T5282 * 2-pin (65 W , 20 V) adapter (models CTO, xxE, xxF , xxJ, xxL, xxP , xxS, xxU, xxY) 42T4423 2-pin (65 W , 20 V) adapter (models CTO, xxE, xxF , xxJ, xxL, xxP , xxS, xxU, xxY) 42T4419 2-[...]

Power cords A ThinkPad power cord for a specific country or region is usually available only in that country or region: T able 47. Parts list—2-pin power cords Country or region FRU no. CRU ID Argentina v models -CTO, xxY 42T5020 42T5105 * Brazil v models -CTO, xxP 42T5180 42T5183 Canada, U.S. v models -CTO, xxF , xxL, xxS, xxU 42T5008 42T5093 Ja[...]

Recovery discs Windows XP Professional (32 bit) DVDs W indows XP Pr ofessional (32 bit) is preinstalled as the operating system in the following models: v 2516-CTO v 2518-CTO, C3x, C5x, CAx, CCx, CEx, CRx, CSx, CWx, CXx, D2x, D3x, D6x, D7x, DAx, DBx, DEx, DFx, DJx, DKx, DNx, DPx, DSx, DTx, F4x v 2519-CTO v 2522-CTO, 36x, 38x, 62x, 63x v 2537-CTO, 9[...]

Windows V ista Business (32 bit) DVDs W indows V ista Business (32 bit) is pr einstalled as the operating system in the following models: v 2516-CTO v 2518-CTO v 2519-CTO v 2522-CTO v 2537-CTO v 2538-CTO v 2539-CTO T able 50. Parts list—Windows Vista Business (32 bit) recovery DVDs Language P/N CRU ID English 58Y4301 * English (for India) 58Y4853[...]

Windows 7 Home Basic (32 bit) DVDs W indows 7 Home Basic (32 bit) is preinstalled as the operating system in the following models: v 2516-CTO, A2x, A3x, A4x, A5x, A7x, A9x, ACx, AFx, AHx, AJx, AKx, ALx, AMx v 2518-CTO, DUx, FYx, G3x v 2519-CTO, 87x v 2522-CTO v 2537-CTO v 2538-CTO v 2539-CTO T able 51. Parts list—Windows 7 Home Basic (32 bit) rec[...]

Windows 7 Home Premium (32 bit) DVDs W indows 7 Home Premium (32 bit) is pr einstalled as the operating system in the following models: v 2516-CTO v 2518-CTO, E9x, EDx, FSx, FUx, FWx, GLx v 2519-CTO, 82x, 83x, 84x, 85x, 89x v 2522-CTO v 2537-CTO v 2538-CTO v 2539-CTO T able 52. Parts list—Windows 7 Home Premium (32 bit) recovery DVDs Language P/N[...]

Windows 7 Home Premium (64 bit) DVDs W indows 7 Home Premium (64 bit) is pr einstalled as the operating system in the following models: v 2516-CTO v 2518-CTO v 2519-CTO v 2522-CTO v 2537-CTO v 2538-CTO v 2539-CTO T able 53. Parts list—Windows 7 Home Premium (64 bit) recovery DVDs Language P/N CRU ID Czech 58Y4506 * English 58Y4521 English (for In[...]

Windows 7 Professional (32 bit) DVDs W indows 7 Professional (32 bit) is pr einstalled as the operating system in the following models: v 2516-CTO, A6x, A8x, AAx, ADx, AEx, AGx, ANx v 2518-CTO, C2x, C4x, C6x, C7x, C8x, C9x, CBx, CDx, CFx, CGx, CHx, CJx, CKx, CLx, CMx, CNx, CPx, CQx, CUx, CVx, CYx, CZx, D4x, D5x, D8x, D9x, DCx, DDx, DGx, DHx, DLx, D[...]

T able 54. Parts list—Windows 7 Professional (32 bit) recovery DVDs Language P/N CRU ID Brazilian Portuguese 58Y4304 * Czech 58Y4307 Danish 58Y4308 English 58Y4330 English (for India) 58Y4856 English (modem-disabled) 58Y4329 English, Finnish, and Swedish (in Sweden) 58Y4332 English, French, German, and Dutch (in Belgium and Luxembur g) 58Y4331 En[...]

Windows 7 Professional (64 bit) DVDs W indows 7 Professional (64 bit) is pr einstalled as the operating system in the following models: v 2516-CTO, ABx v 2518-CTO, E8x, EAx, EBx, ECx, EEx, EFx, EGx, ETx, EUx, EVx, EWx, FDx, FEx, FFx, FGx, FQx, FTx, FVx, FXx, G7x, G8x, G9x, GEx, GFx, GGx v 2519-CTO v 2522-CTO, 3Fx, 3Gx, 3Tx, 3Ux, 3Yx, 3Zx, 42x, 43x [...]

Common service tools T able 56. Parts list—Common service tools T ool P/N Screwdriver kit 95F3598 1/4 ″ drive spinner handle 1650840 1/4 ″ Sq. to 1/4 ″ hex torx adapter 93F2838 TR7-TR-10 tamper resistant torx bits 00P6967 Removal tool antenna RF connector 08K7159 USB 2.0 CD-R W/DVD-ROM combo drive II 40Y8687 USB cable 40Y8704 USB floppy dis[...]

192 ThinkPad T410 Hardwar e Maintenance Manual[...]

Notices Lenovo may not offer the pr oducts, services, or features discussed in this document in all countries. Consult your local Lenovo repr esentative for information on the products and services curr ently available in your area. Any refer ence to a Lenovo product, program, or service is not intended to state or imply that only that Lenovo produ[...]

vary significantly . Some measurements may have been made on development-level systems and there is no guarantee that these measur ements will be the same on generally available systems. Furthermore, some measur ements may have been estimated through extrapolation. Actual results may vary . Users of this document should verify the applicable data f[...]

[...]

Part Number: 63Y0535 (1P) P/N: 63Y0535[...]