Lenovo THINKPAD Z60M инструкция обслуживания

T hinkP a d ® Z6 0m Hard w ar e M a in t e n an c e Ma nu a l October 2007 This manual supports: ThinkPad Z60m (MT 2529, 2530, 2531, and 2532)[...]

[...]

T hinkP a d ® Z6 0m Hard w ar e M a in t e n an c e Ma nu a l[...]

Note Before using this information and the pr oduct it supports, be sure to read the general information under “Notices” on page 156. Second Edition (October 2007) © Copyright Lenovo 2006, 2007. All rights reserved. LENOVO products, data, computer softwar e, and services have been developed exclusively at private expense and are sold to govern[...]

Contents About this manual . . . . . . . . . .1 Introduction . . . . . . . . . . . . .3 Important service information . . . . . . . .3 Strategy for replacing FRUs . . . . . . . . .3 Strategy for replacing a har d disk drive . . . .4 Important notice for replacing a system boar d . .4 How to use error messages . . . . . . . .4 Strategy for replacing[...]

iv MT 2529, 2530, 2531, and 2532[...]

About this manual This manual contains service and refer ence information for ThinkPad ® Z60m (MT 2529, 2530, 2531, and 2532) products. Use this manual along with the advanced diagnostic tests to troubleshoot pr oblems. The manual is divided into sections as follows: v The common sections provide general information, guidelines, and safety informa[...]

2 MT 2529, 2530, 2531, and 2532[...]

Introduction Important service information Important BIOS and device driver fixes are customer -installable. The BIOS and device drivers are posted on the customer support site http://www.lenovo.com/ support Advise customers to contact the Customer Support Center at 800-426-7378 if they need assistance in obtaining or installing any software fixes,[...]

Attention: The setup configuration on the computer you are servicing may have been customized. Running Automatic Configuration may alter the settings. Note the current configuration settings (using the V iew Configuration option); then, when service has been completed, verify that those settings remain in ef fect. Strategy for replacing a hard disk[...]

v The PEW recor d is the 4-digit MT and 3-digit model, where model = “CT O” (Example: 1829-CTO). v eSupport will show both the CTO and CMV machine type models (Example: 1829-CTO and 1829-W15 will be found on the eSupport site.) v The HMM will have the 4-digit MT and 3-digit CTO model only (Example: 1829-CTO). Again, CMVs ar e custom models and [...]

For the Remaining FRUs (the complete list of FRUs at the MT Model level) v eSupport can be used to view the complete list of FRUs for a machine type and model. v To view the complete list of FRUs, type in the machine type and model (Example: 1829-CTO) under QUICK P A TH. Under “V iew by Document T ype” select PA R T S INFORMA TION. Under “Fil[...]

Diskette compatibility matrix The compatibility of each of the drives with the diskettes for it is as follows: Diskette drive Diskette capacity Compatibility 3.5-inch 1.0 MB Read and write 2.0 MB Read and write 4.0 MB Not compatible Safety notices: multilingual translations In this manual, safety notices appear in English with a page number refer e[...]

Safety notice 2 D ANGER Some standby batteries contain a small amount of nickel and cadmium. Do not disassemble a standby battery , recharge it, throw it into fire or water , or short-circuit it. Dispose of the battery as required by local ordinances or regulations. Use only the battery in the appropriate parts listing. Use of an incorrect battery [...]

Safety notice 3 D ANGER The battery pack contains small amounts of nickel. Do not disassemble it, throw it into fire or water , or short-circuit it. Dispose of the battery pack as required by local ordinances or regulations. Use only the battery in the appropriate parts listing when replacing the battery pack. Use of an incorrect battery can result[...]

Safety notice 4 D ANGER The lithium battery can cause a fire, an explosion, or a severe burn. Do not recharge it, remove its polarized connector , disassemble it, heat it above 100°C (212°F), incinerate it, or expose its cell contents to water . Dispose of the battery as required by local ordinances or regulations. Use only the battery in the app[...]

Safety notice 5 Safety notice 6 D ANGER If the LCD breaks and the fluid fr om inside the LCD gets into your eyes or on your hands, immediately wash the affected ar eas with water for at least 15 minutes. Seek medical care if any symptoms fr om the fluid are present after washing. Si le panneau d’affichage à cristaux liquides se brise et que vous[...]

Safety notice 7 D ANGER Safety notice 8 D ANGER Though the main batteries have low voltage, a shorted or grounded battery can produce enough current to burn personnel or combustible materials. Bien que le voltage des batteries principales soit peu élevé, le court-circuit ou la mise à la masse d’une batterie peut produire suffisamment de couran[...]

Safety information The following section presents safety information with which you need to be familiar before you service a ThinkPad computer . General safety Follow these rules to ensur e general safety: v Observe good housekeeping in the area of the machines during and after maintenance. v When lifting any heavy object: 1. Make sure that you can[...]

Important Use only approved tools and test equipment. Some hand tools have handles covered with a soft material that does not insulate you when working with live electrical currents. Many customers have, near their equipment, rubber floor mats that contain small conductive fibers to decrease electr ostatic discharges. Do not use this type of mat to[...]

v Do not service the following parts with the power on when they are r emoved from their normal operating places in a machine: – Power supply units – Pumps – Blowers and fans – Motor generators and similar units. (This practice ensures corr ect grounding of the units.) v If an electrical accident occurs: – Use caution; do not become a vic[...]

9. Check that the power-supply cover fasteners (scr ews or rivets) have not been removed or tamper ed with. Handling devices that are sensitive to electrostatic discharge Any computer part containing transistors or integrated circuits (ICs) should be considered sensitive to electr ostatic discharge (ESD.) ESD damage can occur when there is a dif fe[...]

Laser compliance statement Some models of ThinkPad computer are equipped fr om the factory with an optical storage device such as a CD-ROM drive or a DVD-ROM drive. Such devices are also sold separately as options. If one of these drives is installed, it is certified in the U.S. to conform to the requir ements of the Department of Health and Human [...]

A CD-ROM drive, a DVD-ROM drive, or any other storage device installed may contain an embedded Class 3A or Class 3B laser diode. Note the following: D ANGER Emits visible and invisible laser radiation when open. Do not stare into the beam, do not view directly with optical instruments, and avoid direct exposure to the beam. Radiação por raio lase[...]

General descriptions The descriptions in this chapter apply to any ThinkPad model that has the PC-Doctor ® for DOS diagnostics program. Some descriptions might not apply to your particular computer . Read this first Before you go to the checkout guide, be sur e to read this section. Important notes v Only certified trained personnel should service[...]

Following is a list of some common items that are not cover ed under warranty and some symptoms that might indicate that the system was subjected to stress beyond normal use. Before checking pr oblems with the computer , determine whether the damage is covered under the warranty by r eferring to the following list: The following are not covered und[...]

Related service information This section provides information about the following: v “Service We b site” v “Restoring the pre-installed system” v “Passwords” v “Power management” on page 24 Service We b site When the latest maintenance diskette and the system program service diskette become available, they will be posted on http://w[...]

If any of these passwords has been set, a pr ompt for it appears on the screen whenever the computer is turned on. The computer does not start until the password is enter ed. Exception: If only an SVP is installed, the password pr ompt does not appear when the operating system is booted. Power-on password: A power-on passwor d (POP) protects the sy[...]

1. T urn on the computer; then, while the “T o interrupt normal startup, pr ess the blue ThinkV antage button” message is displayed at the lower-left of the scr een, press the ThinkV antage button. Rescue and Recovery screen opens. Note: To check whether the ThinkPad computer supports the Passphrase function, enter BIOS Setup Utility and go to [...]

Power management To reduce power consumption, the computer has thr ee power management modes: screen blank, standby , and hibernation. Screen blank mode Screen blank mode has thr ee variants, as follows: 1. If you press Fn+F3, or if the time set on the “LCD of f timer” in the BIOS Setup Utility expires, v The LCD backlight turns off. v The hard[...]

Note: The computer does not accept any input immediately after it enters standby mode. W ait a few seconds before taking any action to r eenter operation mode. Hibernation mode In hibernation mode, the following occurs: v The system status, RAM, VRAM, and setup data are stor ed on the hard disk. v The system is powered of f. Note: If the computer e[...]

Checkout guide Use the following procedur es as a guide in identifying and correcting problems with the ThinkPad computer . Note: The diagnostic tests are intended to test only ThinkPad pr oducts. The use of non-ThinkPad products, pr ototype cards, or modified options can lead to false indications of errors and invalid system r esponses. 1. Identif[...]

Note: In the following procedur e, you can select an item not only with the arrow keys, but also with the T rackPoint pointer . Instead of pressing Enter , click the left button. 1. Insert the PC-Doctor disk into the diskette drive; then power on the computer . If the computer cannot be powered on, go to “Power system checkout” on page 30, and [...]

The options on the test menu are as follows: Diagnostics Interactive T ests v Run Normal T est v Run Quick T est v CPU/Coprocessor v Systemboard v V ideo Adapter v Serial Ports v Parallel Ports v Fixed Disks v Diskette Drives v Other Devices v ThinkPad Devices v Communication v W ir eless LAN v Memory T est – Full v Memory T est – Quick v Keybo[...]

v Logical Disk Drives v VGA Information v IDE Drive Info v PCI Information v PNPISA Info v SMBIOS Info v VESA LCD Info v Hardwar e Events Log Utility v Run External T ests v Surface Scan Hard Disk v Benchmark System v DOS Shell v T ech Support Form v Battery Rundown v V iew T est Log v Print Log v Save Log v Full Erase Hard Drive v Quick Erase Hard[...]

Power system checkout To verify a symptom, do the following: 1. T urn off the computer . 2. Remove the battery pack. 3. Connect the ac adapter . 4. Check that power is supplied when you turn on the computer . 5. T urn off the computer . 6. Disconnect the ac adapter and install the charged battery pack. 7. Check that the battery pack supplies power [...]

Perform operational charging. If the battery status indicator or icon does not turn on, remove the battery pack and let it r eturn to room temperature. Reinstall the battery pack. If the charge indicator or icon still does not turn on, r eplace the battery pack. If the charge indicator still does not turn on, r eplace the system board. Then reinsta[...]

Red (+) Black (-) W ire V oltage (V dc) Red +2.5 to +3.2 Black Ground v If the voltage is correct, r eplace the system board. v If the voltage is not correct, r eplace the backup battery . v If the backup battery discharges quickly after r eplacement, replace the system board. Checkout guide 32 MT 2529, 2530, 2531, and 2532[...]

ThinkPad Z60m Product overview . . . . . . . . . . . .3 4 Specifications . . . . . . . . . . . . .3 4 Status indicators . . . . . . . . . . . .3 7 FRU tests . . . . . . . . . . . . . .4 0 Fn key combinations . . . . . . . . . .4 2 Symptom-to-FRU index . . . . . . . . . .4 5 Numeric error codes . . . . . . . . . .4 5 Error messages . . . . . . . . .[...]

Product overview This section presents the following pr oduct-unique information: v “Specifications” v “Status indicators” on page 37 v “FRU tests” on page 40 v “Fn key combinations” on page 42 Specifications The following table lists the specifications of the ThinkPad Z60m: Feature Description Processor v Intel Celeron 360 (1.4 GHz[...]

Feature Description Standard memory v 256-MB DDR2-533 SDRAM SO-DIMM (PC2-4200) card × 1 v 512-MB DDR2-533 SDRAM SO-DIMM (PC2-4200) card × 1 v 512-MB DDR2-533 SDRAM SO-DIMM (PC2-4200) card × 1 and 256-MB DDR2-533 SDRAM SO-DIMM (PC2-4200) card × 1 v 512-MB DDR2-533 SDRAM SO-DIMM (PC2-4200) card × 2 v 1-GB DDR2-533 SDRAM SO-DIMM (PC2-4200) card ?[...]

Feature Description Infrared transfer v IrDA 1.1 Ethernet (on the system board) v Gigabit Ethernet Mini PCI adapter v Intel PRO W ireless 2200BG Mini-PCI Adapter v Intel PRO W ireless 2915ABG Mini-PCI Adapter v ThinkPad 1 1a/b/g W ireless LAN Mini PCI Adapter II PCI Express Mini car d v Sierra W ireless EV -DO Wir eless WA N Mini PCI Express Adapte[...]

Status indicators The system status indicators show the status of the computer , as follows: 123456789 1 0 11 8 9 10 Product overview ThinkPad Z60m 37[...]

Indicator Meaning 1 W ireless status Green: The wireless featur e (the IEEE 802.1 1 standard) is on, and the radio link is ready for use. Blinking green: Data is being transmitted. 2 Bluetooth status R Green: Bluetooth wireless is operational. This indicator is on when Bluetooth wireless is on and not in suspend mode. 3 W ireless [...]

Indicator Meaning 8 Battery status Green: The battery is charged between 80% to 100% of the capacity , and being discharged between 20% to 80% of the capacity . Blinking green: The battery is charged between 20% to 80% of the capacity , and being charged. Orange: The battery is charged between 5% and 20% of the capacity , and being discharged[...]

FRU tests The following table shows the test for each FRU. FRU Applicable test System board 1. Diagnostics --> CPU/Coprocessor 2. Diagnostics --> Systemboard 3. If the docking station or the port replicator is attached to the ThinkPad computer , undock it. Place the computer on a horizontal surface, and run Diagnostics --> ThinkPad Devices[...]

FRU Applicable test Memory 1. If two DIMMs are installed, r emove one of them and run Diagnostics --> Memory T est—Quick . 2. If the problem does not r ecur , return the DIMM to its place, remove the other one, and run the test again. 3. If the test does not detect the error , run Diagnostics --> Memory T est—Full . Fan 1. T urn on the co[...]

Fn key combinations The following table shows the function of each combination of Fn with a function key . Key combination Description Fn+F1 Reserved. Fn+F2 Reserved. Fn+F3 Select a power scheme that has been created by Power Manager . Fn+F4 Put the computer in standby mode. To return to normal operation, press the Fn key only , without pressing a [...]

Key combination Description Fn+F8 Change the settings of the T rackPoint and the touch pad. Fn+F9 Open the ThinkPad EasyEject Utility screen. Buttons for the following choices are displayed: v Eject ThinkPad PC from Dock : This button is displayed only if the ThinkPad computer has been attached to a ThinkPad Dock II or a ThinkPad Mini Dock. The com[...]

Key combination Description Fn+PgUp T urn the ThinkLight on or off. Note: This function is supported only on the ThinkPad computers that have the ThinkLight. The on or off status of the ThinkLight is shown on the screen for a few seconds when you pr ess Fn+PgUp. Fn+Home The computer display becomes brighter . Fn+End The computer display becomes dim[...]

Symptom-to-FRU index The symptom-to-FRU index in this section lists symptoms and errors and their possible causes. The most likely cause is listed first, in boldface type. Note: Do the FRU replacement or other actions in the sequence shown in the column headed “FRU or action, in sequence.” If replacing a FRU does not solve the problem, put the [...]

Symptom or error FRU or action, in sequence 0190 Critical low-battery error 1. Charge the battery pack. 2. Battery pack. 0191 System Security—Invalid Remote Change requested. 1. Run BIOS Setup Utility , and then save current setting by pressing F10. 2. System board. 0192 System Security— Embedded Security hardwar e tamper detected. System board[...]

Symptom or error FRU or action, in sequence 0252 Password checksum bad—The passwor d is cleared. Reset the password by running BIOS Setup Utility . 0260 System timer error . 1. Charge the backup battery for more than 8 hours by connecting the ac adapter . 2. Replace the backup battery and run BIOS Setup Utility to reset the time and date. 3. Syst[...]

Symptom or error FRU or action, in sequence 2010 W arning: Y our internal hard disk drive (HDD) may not function correctly on this system. Ensure that your HDD is supported on this system and that the latest HDD firmware is installed. Inform the following information to the customer: If in the primary bay the customer is using a non-IBM or non-Leno[...]

Error messages Symptom or error FRU or action, in sequence Device address conflict. 1. Load “Setup Defaults” in the BIOS Setup Utility . 2. Backup battery . 3. System board. Allocation error for device. 1. Load “Setup Defaults” in the BIOS Setup Utility . 2. Backup battery . 3. System board. Failing bits: nnnn. 1. DIMM . 2. System board. In[...]

Beep symptoms Symptom or error FRU or action, in sequence One beep and a blank, unreadable, or flashing LCD. 1. Reseat the LCD connector . 2. LCD assembly . 3. External CR T . 4. System board. One long and two short beeps, and a blank or unreadable LCD. 1. System board . 2. LCD assembly . 3. DIMM. Tw o short beeps with error codes. POST error . See[...]

LCD-related symptoms Important: The TFT LCD for the notebook computer contains many thin-film transistors (TFT s). The presence of a small number of dots that ar e missing, discolored, or always lighted is characteristic of TFT LCD technology , but excessive pixel problems can cause viewing concerns. The LCD should be replaced if the number of miss[...]

Intermittent problems Intermittent system hang problems can be due to a variety of causes that have nothing to do with a hardwar e defect, such as cosmic radiation, electrostatic discharge, or softwar e errors. FRU replacement should be consider ed only when a problem r ecurs. When analyzing an intermittent problem, do the following: 1. Run the dia[...]

FRU replacement notices This section contains notices related to r emoving and replacing parts. Read this section carefully befor e replacing any FRU. Screw notices Loose screws can cause a r eliability problem. In the ThinkPad computer , this problem is addr essed with special nylon-coated screws that have the following characteristics: v They mai[...]

v “Retaining the UUID” v “Reading or writing the ECA information” Restoring the serial number of the system unit When the computer was manufactured, the EEPROM on the system boar d was loaded with the serial numbers of the system and all major components. These numbers need to remain the same thr oughout the life of the computer . If you re[...]

To check what ECAs have been previously applied to the machine, use the ECA Information Read/W rite function on the ThinkPad Hardware Maintenance Diskette V ersion 1.73 or later . 1. Insert the ThinkPad Hardwar e Maintenance Diskette V ersion 1.73 or later , and restart the computer . 2. From the main menu, select 6. Set ECA Information . 3. To rea[...]

Removing and replacing a FRU This section presents dir ections and drawings for use in removing and replacing a FRU. Be sure to observe the following general r ules: 1. Do not try to service any computer unless you have been trained and certified. An untrained person runs the risk of damaging parts. 2. Before r eplacing any FRU, review “FRU r epl[...]

1010 Battery pack D ANGER Unlock the battery release lever 1 . Holding the battery r elease lever in the unlocked position 2 , remove the battery pack in the dir ection shown by arrow 3 . 1 2 3 Use only the battery specified in the parts list for your computer . Any other battery could ignite or explode. Removing and replacing a F[...]

When installing: Install the battery pack along the slide rails of the slot. Then make sure that the battery r elease lever is locked, as in this figure. 2 1 Removing and replacing a FRU 58 MT 2529, 2530, 2531, and 2532[...]

1020 Ultrabay Enhanced device Note Ultrabay Enhanced does not accept any of the following devices: v Ultrabay Plus devices v Ultrabay 2000 devices Note: When you release the switch in step 1 , the lever pops out. In step 2 , pull the lever a little to release the device fr om the bay . 1 2 3 Removing and replacing a FRU ThinkPad Z60m 59[...]

1030 Hard disk drive cover , hard disk drive, and hard disk drive rubber rails For access, remove this FRU: v “1010 Battery pack” on page 57 Attention v Do not drop the hard disk drive or apply any physical shock to it. The hard disk drive is sensitive to physical shock. Impr oper handling can cause damage and permanent loss of data. v Before r[...]

2 3 4 When installing: Make sure that the har d disk drive connector is attached firmly . (continued) Removing and replacing a FRU ThinkPad Z60m 61[...]

5 6 6 When installing: Rubber rails of the hard disk drive must be attached to the replacement drive. Otherwise the har d disk drive cannot be properly installed to the computer . Removing and replacing a FRU 62 MT 2529, 2530, 2531, and 2532[...]

1040 Palm rest or palm rest with fingerprint reader For access, remove this FRU in or der: v “1010 Battery pack” on page 57 Notes In models with the fingerprint reader , the sensor has been attached to the palm rest FRU as the child part. If the fingerprint r eader has any defects and needs to be replaced, you need to r eplace the palm rest by [...]

In step 2 , press the left and right sides of the palm r est toward the center to release the side latches, as in this figur e. Then release the latches indicated by arrow 3 . 3 2 2 Pull the palm rest a little in the dir ection shown by arrow 4 , and then detach the touch pad connector by pulling the tab with your fingers in the d[...]

1050 DIMM For access, remove these FRUs in or der: v “1010 Battery pack” on page 57 v “1040 Palm rest or palm r est with fingerprint reader” on page 63 2 1 1 When installing: Insert the notched end of the DIMM into the socket. Press the DIMM firmly , and pivot it until it snaps into the place. Make sure that it is firmly fixed in the slot a[...]

1060 Keyboard For access, remove these FRUs in or der: v “1010 Battery pack” on page 57 v “1040 Palm rest or palm r est with fingerprint reader” on page 63 1 Step Icon Screw (quantity) Color T orque 1 M2 × 17 mm, flat-head, nylon-coated (1) Black 0.196 Nm (2.0 kgfcm) Lift the keyboard a little in the dir ection shown by arrow 2[...]

When installing: Make sure that the keyboar d edges a are under the frame as shown in this figure. a a Removing and replacing a FRU ThinkPad Z60m 67[...]

1070 Mini PCI adapter for wireless LAN For access, remove these FRUs in or der: v “1010 Battery pack” on page 57 v “1040 Palm rest or palm r est with fingerprint reader” on page 63 v “1060 Keyboard” on page 66 In steps 2a and 2b , unplug the jacks by using the removal tool antenna RF connector (P/N: 08K7159), or pick the con[...]

1080 Modem daughter card (MDC-1.5) For access, remove these FRUs in or der: v “1010 Battery pack” on page 57 v “1040 Palm rest or palm r est with fingerprint reader” on page 63 v “1060 Keyboard” on page 66 1 1 2 Step Screw (quantity) Color T orque 1 M2 × 3 mm, flat-head, nylon-coated (2) Black 0.196 Nm (2.0 kgfcm) In step 2[...]

T urn the card over 3 , and detach the modem connector 4 . 3 4 When installing: Make sure that the modem connector and the connector on the underside of the card ar e attached firmly . Removing and replacing a FRU 70 MT 2529, 2530, 2531, and 2532[...]

1090 PCI Express Mini card for wireless WA N For access, remove these FRUs in or der: v “1010 Battery pack” on page 57 v “1040 Palm rest or palm r est with fingerprint reader” on page 63 v “1060 Keyboard” on page 66 In step 1a or 1b , unplug the jacks by using the removal tool antenna RF connector (P/N: 08K7159) or pick the [...]

3 When installing: Plug the red cable into the jack labeled MAIN on the card, and the blue cable into the jack labeled DIV . Removing and replacing a FRU 72 MT 2529, 2530, 2531, and 2532[...]

1 100 Backup battery D ANGER For access, remove these FRUs in or der: v “1010 Battery pack” on page 57 v “1040 Palm rest or palm r est with fingerprint reader” on page 63 v “1060 Keyboard” on page 66 2 1 When installing: Make sure that the battery connector is attached firmly . Use only the battery specified in the parts list for your c[...]

111 0 Wireless WA N antenna cable (DIV) For access, remove these FRUs in or der: v “1010 Battery pack” on page 57 v “1040 Palm rest or palm r est with fingerprint reader” on page 63 v “1060 Keyboard” on page 66 v “1090 PCI Express Mini car d for wireless W AN” on page 71 In step 1 , strip off the tapes securing the antenna cab[...]

When installing: Make sure that the cable is r outed along the cable guides a , and that secured with tapes b . a a a a a b b Removing and replacing a FRU ThinkPad Z60m 75[...]

1 120 Keyboard bezel and speaker assembly For access, remove these FRUs in or der: v “1010 Battery pack” on page 57 v “1040 Palm rest or palm r est with fingerprint reader” on page 63 v “1060 Keyboard” on page 66 1 1 Step Screw (quantity) Color T orque 1 M2 × 17 mm, flat-head, nylon-coated (2) Black 0.196 Nm (2.0 kgfcm) (continue[...]

4 2 3 4 Strip the tape that secures the cable 2 , and disconnect the speaker cable 3 . Step Screw (quantity) Color T orque 5 M2 × 3 mm, flat-head, nylon-coated (2) Black 0.196 Nm (2.0 kgfcm) 5 5 (continued) Removing and replacing a FRU ThinkPad Z60m 77[...]

6 6 6 6 9 7 8 8 Step Screw (quantity) Color T orque 6 M2 × 3 mm, flat-head, nylon-coated (4) Black 0.196 Nm (2.0 kgfcm) When installing: Make sure that the speaker cables ar e routed along the cable guides, and that the connector is attached firmly . Removing and replacing a FRU 78 MT 2529, 2530, 2531, and 2532[...]

1 130 Fan assembly For access, remove these FRUs in or der: v “1010 Battery pack” on page 57 v “1040 Palm rest or palm r est with fingerprint reader” on page 63 v “1060 Keyboard” on page 66 v “1 120 Keyboar d bezel and speaker assembly” on page 76 1 1 1 1 1 1 Step Screw (quantity) Color T orque 1 M2 × 3 mm, flat-head, nylon-c[...]

2 3 Removing and replacing a FRU 80 MT 2529, 2530, 2531, and 2532[...]

When installing: v Before you attach the fan assembly to the computer , apply thermal gr ease on the part marked a as in the following figure. a v Make sure that the fan connector is attached firmly . (continued) Removing and replacing a FRU ThinkPad Z60m 81[...]

v When attaching the fan assembly to the frame, take care not to damage the heat sink ( b ) of the fan assembly . b b Removing and replacing a FRU 82 MT 2529, 2530, 2531, and 2532[...]

1 140 CPU For access, remove these FRUs in or der: v “1010 Battery pack” on page 57 v “1040 Palm rest or palm r est with fingerprint reader” on page 63 v “1060 Keyboard” on page 66 v “1 120 Keyboar d bezel and speaker assembly” on page 76 v “1 130 Fan assembly” on page 79 Attention: CPU is extr emely sensitive. When you service [...]

1 150 LCD assembly For access, remove these FRUs in or der: v “1010 Battery pack” on page 57 v “1040 Palm rest or palm r est with fingerprint reader” on page 63 v “1060 Keyboard” on page 66 v “1070 Mini PCI adapter for wireless LAN” on page 68 v “1090 PCI Express Mini car d for wireless W AN” on page 71 v “1 120 Keyboar d beze[...]

5 4 3 3 4 6 Step Screw (quantity) Color T orque 3 M2 × 5 mm, flat-head, nylon-coated (2) Black 0.196 Nm (2.0 kgfcm) 4 M2 × 5 mm, flat-head, nylon-coated (2) Black 0.296 Nm (3.0 kgfcm) In step 6 , release the antenna cables fr om the cable guides. Notes: 1. Route the antenna cables along the cable guides. When you route the cable[...]

7 7 Removing and replacing a FRU 86 MT 2529, 2530, 2531, and 2532[...]

1 160 Base cover For access, remove these FRUs, in or der: v “1010 Battery pack” on page 57 v “1020 Ultrabay Enhanced device” on page 59 v “1030 Hard disk drive cover , har d disk drive, and hard disk drive rubber rails” on page 60 v “1040 Palm rest or palm r est with fingerprint reader” on page 63 v “1060 Keyboard” on page 66 v[...]

Attention: Befor e step 3 , be sur e that the Ultrabay Enhanced device eject lever is not popped out and it is housed in its position properly as shown in the figur e a . 3 a Removing and replacing a FRU 88 MT 2529, 2530, 2531, and 2532[...]

Note: Applying labels to the base cover The new base cover FRU is shipped with a kit containing labels of several kinds. When you replace the base cover , you need to apply the following labels: a W indows license label (COA) b FCC label c Product label d FCC or homologation label For some models, you also need to apply one [...]

1 170 3-1 Digital Media Reader sub card with cable For access, remove these FRUs, in or der: v “1010 Battery pack” on page 57 v “1020 Ultrabay Enhanced device” on page 59 v “1030 Hard disk drive cover , har d disk drive, and hard disk drive rubber rails” on page 60 v “1040 Palm rest or palm r est with fingerprint reader” on page 63 [...]

3 4 Step Screw (quantity) Color T orque 3 M2 × 3 mm, flat-head, nylon-coated (1) Black 0.196 Nm (2.0 kgfcm) Removing and replacing a FRU ThinkPad Z60m 91[...]

1 180 USB sub card with cable For access, remove these FRUs, in or der: v “1010 Battery pack” on page 57 v “1020 Ultrabay Enhanced device” on page 59 v “1030 Hard disk drive cover , har d disk drive, and hard disk drive rubber rails” on page 60 v “1040 Palm rest or palm r est with fingerprint reader” on page 63 v “1060 Keyboard”[...]

3 3 4 2 Step Screw (quantity) Color T orque 3 M2 × 5 mm, flat-head, nylon-coated (2) Black 0.196 Nm (2.0 kgfcm) Removing and replacing a FRU ThinkPad Z60m 93[...]

1 190 MG (magnesium) frame For access, remove these FRUs, in or der: v “1010 Battery pack” on page 57 v “1020 Ultrabay Enhanced device” on page 59 v “1030 Hard disk drive cover , har d disk drive, and hard disk drive rubber rails” on page 60 v “1040 Palm rest or palm r est with fingerprint reader” on page 63 v “1060 Keyboard” on[...]

Remove the ac power jack cable a and the modem cable b . 3 4 5 1 2 When installing: Make sure the connectors ar e attached firmly , and that the cables are r outed as in the figure above. (continued) Removing and replacing a FRU ThinkPad Z60m 95[...]

Remove the CPU support plate ( c ). 6 6 c Step Screw (quantity) Color T orque 6 M2 × 5 mm, flat-head, nylon-coated (4) Black 0.196 Nm (2.0 kgfcm) (continued) Removing and replacing a FRU 96 MT 2529, 2530, 2531, and 2532[...]

7 7 7 7 7 7 8 8 8 9 Step Screw (quantity) Color T orque 7 M2 × 5 mm, flat-head, nylon-coated (6) Black 0.196 Nm (2.0 kgfcm) 8 M2 × 9 mm, flat-head, nylon-coated (3) Black 0.196 Nm (2.0 kgfcm) In step 9 , loosen the hex screws. (continued) Removing and replacing a FRU ThinkPad Z60m 97[...]

Remove the system board and the PC Car d/ExpressCard slots assembly fr om the MG frame together , in the direction shown by arrow 10 . 10 Removing and replacing a FRU 98 MT 2529, 2530, 2531, and 2532[...]

1200 System board and PC Card/ExpressCard slots assembly For access, remove these FRUs, in or der: v “1010 Battery pack” on page 57 v “1020 Ultrabay Enhanced device” on page 59 v “1030 Hard disk drive cover , har d disk drive, and hard disk drive rubber rails” on page 60 v “1040 Palm rest or palm r est with fingerprint reader” on pa[...]

Important notice for handling the system board When handling the system board, bear the following in mind. v The system board has an acceler ometer , which can be broken by applying several thousands of G-forces. Note: Dropping a system boar d from a height of as little as 6 inches so that it falls flat on a hard bench can subject the acceler omete[...]

Following components soldered on the top side of the system boar d are extremely sensitive. When you service the system board, avoid any kind of r ough handling. a CPU b V ideo chip c ICH (I/O Controller Hub) d MCH (Memory ControllerHub) e Security chip f Accelerometer chip for the HDD Active Pr otection System f[...]

1 1 Step Screw (quantity) Color T orque 1 M2 × 3 mm, flat-head, nylon-coated (2) Silver 0.196 Nm (2.0 kgfcm) T urn over the system board, and then disconnect the PC Car d/ExpressCard slots assembly from the system boar d. 2 When installing: Make sure that the connector of PC Car d/ExpressCar d slots assembly is attached to the system board f[...]

2010 LCD front bezel For access, remove this FRU: v “1010 Battery pack” on page 57 v “1040 Palm rest or palm r est with fingerprint reader” on page 63 v “1060 Keyboard” on page 66 v “1070 Mini PCI adapter for wireless LAN” on page 68 v “1090 PCI Express Mini car d for wireless W AN” on page 71 v “1 120 Keyboar d bezel and spea[...]

In step 3 , while sliding the LCD latch lever in the direction shown by the arr ow , remove the bezel in the dir ection shown by arrow 4 . 2 2 5 2 2 3 4 2 2 2 2 Removing and replacing a FRU 104 MT 2529, 2530, 2531, and 2532[...]

2020 Inverter card For access, remove these FRUs in or der: v “1010 Battery pack” on page 57 v “1040 Palm rest or palm r est with fingerprint reader” on page 63 v “1060 Keyboard” on page 66 v “1070 Mini PCI adapter for wireless LAN” on page 68 v “1090 PCI Express Mini car d for wireless W AN” on page 71 v “1 120 Keyboar d beze[...]

2030 Bluetooth daughter card (BDC-2) For access, remove these FRUs in or der: v “1010 Battery pack” on page 57 v “1040 Palm rest or palm r est with fingerprint reader” on page 63 v “1060 Keyboard” on page 66 v “1070 Mini PCI adapter for wireless LAN” on page 68 v “1090 PCI Express Mini car d for wireless W AN” on page 71 v “1 [...]

When installing: Make sure that connector is attached firmly , and that the card is attached to the guide as in this figure. Removing and replacing a FRU ThinkPad Z60m 107[...]

2040 Wireless WA N antenna cable (MAIN) For access, remove these FRUs in or der: v “1010 Battery pack” on page 57 v “1040 Palm rest or palm r est with fingerprint reader” on page 63 v “1060 Keyboard” on page 66 v “1070 Mini PCI adapter for wireless LAN” on page 68 v “1090 PCI Express Mini car d for wireless W AN” on page 71 v ?[...]

When installing: In step 2 , press the part indicated by the arr ow until it snaps into place. 1 3 4 1 2 Note: In step 4 , do not tense the cable. To do so, the cable may get damaged by the hinge, and may cause a broken wir e. (continued) Removing and replacing a FRU ThinkPad Z60m 109[...]

Cable routing: Route the antenna cable as shown in this figure. Removing and replacing a FRU 11 0 MT 2529, 2530, 2531, and 2532[...]

2050 LCD panel, LCD cable, and hinges For access, remove these FRUs in or der: v “1010 Battery pack” on page 57 v “1040 Palm rest or palm r est with fingerprint reader” on page 63 v “1060 Keyboard” on page 66 v “1070 Mini PCI adapter for wireless LAN” on page 68 v “1090 PCI Express Mini car d for wireless W AN” on page 71 v “1[...]

3a 3b 6 5 4 (continued) Removing and replacing a FRU 11 2 MT 2529, 2530, 2531, and 2532[...]

Remove the hinges ( a ) from the LCD panel. 7 7 7 7 8 8 a a Step Screw (quantity) Color T orque 7 M2 × 3 mm, small-head, nylon-coated (4) Silver 0.196 Nm (2.0 kgfcm) Remove the LCD cable assembly ( b ) from the LCD panel. 9 10 b When installing: When replacing any LCD FRUs, be sur e not to pinch the antenna cables. Make sure that[...]

2060 LCD rear cover and wireless LAN antenna cables For access, remove these FRUs in or der: v “1010 Battery pack” on page 57 v “1040 Palm rest or palm r est with fingerprint reader” on page 63 v “1060 Keyboard” on page 66 v “1070 Mini PCI adapter for wireless LAN” on page 68 v “1090 PCI Express Mini car d for wireless W AN” on [...]

3 When installing: Attache the latches as shown in this figure. 1 2 3 4 (continued) Removing and replacing a FRU ThinkPad Z60m 11 5[...]

5 4 4 4 4 5 Removing and replacing a FRU 11 6 MT 2529, 2530, 2531, and 2532[...]

Cable routing: Route the antenna cables as shown in the following figures. W ireless LAN antenna cable (MAIN: gray) a (continued) Removing and replacing a FRU ThinkPad Z60m 11 7[...]

W ireless LAN antenna cable (AUX: black) a Removing and replacing a FRU 11 8 MT 2529, 2530, 2531, and 2532[...]

Locations Front view 1 ThinkLight 2 Status indicators Note: For the description of each indicator , see “Status indicators” on page 37. 3 W ireless WA N antenna 4 Security key hole 5 Universal serial bus (USB) connectors 6 Ultrabay Enhanced status indicator 7 Ultrabay Enhanced latch 8 Ultrabay Enh[...]

Rear view 1 Status indicators Note: For the description of each indicator , see “Status indicators” on page 37. 2 PC Card/Expr essCard slots 3 PC Card slot eject button 4 Security key hole 5 Microphone jack 6 Stereo headphone jack 7 RJ-45 (Ethernet) connector 8 RJ-1 1 (modem) connector 9 Ext[...]

Bottom view 1 Battery pack 2 Battery pack latch 3 Docking connector 4 Infrared port 5 W ireless raido switch 6 LCD cover latch 7 3-1 Digital Media Reader status indicator 8 3-1 Digital Media Reader 9 Hard disk drive 9 8 1 2 3 4 5 6 7 Locations ThinkPad Z60m 121[...]

Parts list v Each FRU is available for all types or models, unless specific types or models are specified. v A CRU (customer replaceable unit) is identified by a single asterisk (*) or two asterisks (**) in the CRU ID column. An N in the CRU ID column means the part is not a CRU. A single asterisk (*) means the part is a T ier 1 CRU; two asterisks [...]

Overall 1 2 a 4 5 3 7 8 10 12 13 14 15 16 b 17 18 19 20 21 22 c 23 24 25 9 6 11 Parts list ThinkPad Z60m 123[...]

No. FRU P/N CRU ID a-c See “Miscellaneous parts” on page 153. 1 LCD unit (see “LCD FRUs” on page 143.) 2 Keyboard bezel assembly 26R9588 N 3 Speaker assembly 39T7221 N 4 Modem daughter card (MDC-1.5) 39T0495 ** 5 W ireless WA N antenna cable (MAIN and AUX) v 2529-CTO v 2529-HUx, HWx v 2530-CTO, 36x, 37x v 2531-CTO v 2532-CTO 91P6959 N 6 Int[...]

No. FRU P/N CRU ID 6 Intel PRO W ireless 2915ABG Mini-PCI Adapter US v 2529-CTO, xxU of E1x, E2x, E3x, E6x, E9x, EAx, EBx, F1x, F3x, F4x, F5x, F6x, F7x, F8x, F9x, F Ax, FBx, FCx, FEx, FGx, FHx, FJx, FKx, FLx, FMx, FPx, FQx, FRx v 2529-xxU of H4x, H5x, H6x, H7x, H8x, H9x, HAx, HCx, HDx, HFx, HGx, HHx, HJx, HKx, HSx, HTx, R3x, R7x, 8x, R9x, RAx, RBx,[...]

No. FRU P/N CRU ID 6 Intel PRO W ireless 2915ABG Mini-PCI Adapter EU v 2529-CTO, xxG of E1x, E2x, E3x, E6x, E9x, EAx, EBx, F1x, F3x, F4x, F5x, F6x, F7x, F8x, F9x, F Ax, FBx, FCx, FEx, FGx, FHx, FJx, FKx, FLx, FMx, FPx, FQx, FRx v 2529-xxG of H4x, H5x, H6x, H7x, H8x, H9x, HAx, HCx, HDx, HFx, HGx, HHx, HJx, HKx, HSx, HTx, R3x, R7x, 8x, R9x, RAx, RBx,[...]

No. FRU P/N CRU ID 6 Intel PRO W ireless 2915ABG Mini-PCI Adapter Japan v 2529-CTO, xxJ xxE of E1x, E2x, E3x, E6x, E9x, EAx, EBx, F1x, F3x, F4x, F5x, F6x, F7x, F8x, F9x, F Ax, FBx, FCx, FEx, FGx, FHx, FJx, FKx, FLx, FMx, FPx, FQx, FRx v 2529-xxJ xxE of H4x, H5x, H6x, H7x, H8x, H9x, HAx, HCx, HDx, HFx, HGx, HHx, HJx, HKx, HSx, HTx, R3x, R7x, 8x, R9x[...]

No. FRU P/N CRU ID 6 Intel PRO W ireless 2915ABG Mini-PCI Adapter Hebrew v 2529-CTO, xxC, xxK, xxL, xxP , xxS, xxV , xxY of E1x, E2x, E3x, E6x, E9x, EAx, EBx, F1x, F3x, F4x, F5x, F6x, F7x, F8x, F9x, F Ax, FBx, FCx, FEx, FGx, FHx, FJx, FKx, FLx, FMx, FPx, FQx, FRx v 2529-xxC, xxK, xxL, xxP , xxS, xxV , xxY of H4x, H5x, H6x, H7x, H8x, H9x, HAx, HCx, [...]

No. FRU P/N CRU ID 6 ThinkPad 1 1a/b/g W ireless LAN Mini PCI Adapter II US v 2529-CTO v 2529-xxU, xxF , xxL, xxS, xxM, xxB, xxH of H3x, HMx, HNx, HPx, HQx, HRx, HUx, HWx v 2530-CTO, xxU, xxF , xxL, xxS, xxM, xxB, xxH of 37x, 38x, 3Bx, 4Cx v 2530-xxU, xxF , xxL, xxS, xxM, xxB, xxH of K3x, K4x, K6x v 2531-CTO, xxU, xxF , xxL, xxS, xxM, xxB, xxH of 3[...]

No. FRU P/N CRU ID 6 ThinkPad 1 1a/b/g W ireless LAN Mini PCI Adapter II T aiwan v 2529-CTO v 2529-xxV of H3x, HMx, HNx, HPx, HQx, HRx, HUx, HWx v 2530-CTO, xxV of 37x, 38x, 3Bx, 4Cx v 2530-xxV of K3x, K4x, K6x v 2531-CTO, xxV of 38x v 2531-xxV of M8x, MDx, MSx, MUx v 2532-CTO, xxV of 38x v 2532-xxV of MDx, MSx, MUx 27K9999 ** 7 Magnesium frame 41V[...]

No. FRU P/N CRU ID 12 Hard disk drive, 80 GB, 9.5 mm, 5,400 rpm v 2529-CTO, 1Hx, E8x, E9x, EBx, F6x, F8x, F9x, F Ax, FBx, FCx, FEx, FGx, FHx, FMx, FQx, FRx, FSx v 2529-H5x, H7x, H8x, HAx, HBx, HCx, HDx, HEx, HFx, HNx, HPx, HSx, HTx, R3x, R8x v 2530-CTO, 1Hx, 35x, 36x, 37x, 3Jx, 3Mx, 3Nx, 3Px, 3Qx, 43x, 47x, 49x, 4Ax, 4Dx, 4Gx, 4Lx, 4Mx, E9x, EBx v [...]

No. FRU P/N CRU ID 13 Battery pack, Li-ion (6 cell) v 2529-CTO, 1Hx, E1x, E2x, E3x, E4x, E5x, E6x, E7x, E8x, EBx, Fxx v 2529-H1x, H2x, H3x, H6x, H7x, H8x, HAx, HBx, HCx, HDx, HEx, HFx, HGx, HHx, HJx, HKx, HLx, HMx, HRx, HWx, HSx, HTx, R2x, R3x, R5x, R6x, R7x, R8x, R9x, RAx, RBx v 2530-CTO, 1xx, 2xx, 31x, 32x, 33x, 39x, 3Bx, 3Cx, 3Dx, 3Ex, 3Fx, 3Gx,[...]

No. FRU P/N CRU ID 14 CD-ROM drive, 12.7 mm, TEAC (CD-244EN) v 2529-CTO v 2530-CTO v 2530-JQx v 2531-CTO v 2532-CTO 39T2661 * DVD drive, 12.7 mm v 2529-CTO, E4x, E5x v 2530-CTO, 1Yx, 1Zx, E4x v 2530-JPx v 2531-CTO v 2532-CTO MKE (SR-8178) 39T2663 * HLDS (GDR-8084N) 39T2665 * DVD/CD-R W combo drive, 12.7 mm v 2529-CTO, E1x, E3x, E7x, F1x, F2x, F3x, [...]

No. FRU P/N CRU ID 14 DVD-RAM/R W drive, 12.7 mm v 2529-H1x, H3x, H4x, H5x, H7x. H8x, H9x, HAx, HBx, HCx, HDx, HEx, HFx, HGx, HHx, HJx, HKx, HLx, HNx, HPx, HQx, HRx, HUx, HWx, HSx, HTx, R3x, R5x, R8x, RCx v 2530-J1x, J2x, J3x, J4x, J5x, J6x, J7x, J8x, JBx, JDx, JE,x JFx, JGx, JHx, JKx, JLx. JRx, JSx, JTx, JVx, K7x, K8x, K9x, KAx, KBx, R8x v 2531-M4[...]

No. FRU P/N CRU ID 17 256-MB DDR2-533 SDRAM SO-DIMM (PC2-4200) card R v 2529-CTO, E1x, E4x, F1x, F2x, F3x, F4x, F5x v 2529-H2x, R2x, R6x, v 2530-CTO 13x, 14x, 1Dx, 1Gx, 1Kx, 1Mx, 1Yx, 1Zx, 22x, 23x, 24x, 2Gx, 2Hx, 32x, 33x, 3Cx, 3Dx, 3Ex, 3Fx, 3Gx, 3Hx, 46x, E4x, F2x v 2530-JBx, JDx, JEx, JFx, JGx, JHx, JKx, JLx, JMx, JNx, JPx, JQx, v 2531-CT[...]

No. FRU P/N CRU ID 17 1-GB DDR2-533 SDRAM SO-DIMM (PC2-4200) card R v 2529-CTO, EAx, EBx v 2529-RCx v 2530-CTO 36x, 37x, 38x, 3Kx, 44x, 4Bx, 4Cx, EBx v 2530-JVx v 2531-CTO, 38x, 3Kx v 2531-M6x, M7x, M8x, MTx v 2532-CTO, 38x v 2532-MTx 73P3845 ** 18 System board assembly with 915GM, integrated v 2529-CTO, E1x, E2x, E3x, E4x, E5x, E6x, F1x, F2x[...]

No. FRU P/N CRU ID 18 System board assembly with 915PM, M22-64 v 2529-CTO, 1Hx, E7x, E8x, F8x, F9x, F Ax, FBx, FCx, FEx, FFx, FMx, FPx, FQx, FRx, FSx, G6x, G7x, G8x, G9x v 2529-H1x, H7x, H8x, HDx, HEx, HFx, HTx, L2x, P3x, R9x, RAx v 2530-CTO, 1 1x, 1Gx, 1Hx, 1Jx, 1Kx, 1Mx, 1Nx, 2Bx, 2Cx, 2Ex, 34x, 39x, 3Dx, 3Ex, 3Jx, 3Mx, 42x, 47x, 48x, 4Dx, 4Ex, 4[...]

No. FRU P/N CRU ID 20 CPU assembly , Intel Celer on M processor 370 (1.5 GHz) v 2529-CTO, F3x, F4x, FRx v 2529-H6x, P1x v 2530-CTO, 18x, 1Dx, 1Ex, 2Dx, 3Bx, 52x v 2530-J9x, JAx, JBx, JDx, JEx, JFx, JGx, JHx, JKx, JLx, JMx, JNx, JPx, JQx, K8x, K9x, KAx, KBx, LBx, LCx. LDx v 2531-CTO v 2532-CTO 39T0331 N CPU assembly , Intel Celer on M processor 380 [...]

No. FRU P/N CRU ID 20 CPU assembly , Intel Pentium M pr ocessor 750 (1.86 GHz) v 2529-CTO, 1Hx, E7x, E8x, F7x, F8x, F9x, F Ax, FBx, FCx, FEx, FGx, FHx, FMx, FSx, G3x, G7x, GAx v 2529-H8x, HAx, HBx, HCx, HFx, R3x, R7x, R8x, R9x, RAx, RBx, P3x, P7x v 2530-CTO, 19x, 1Hx, 1Jx, 21x, 2Ax, 2Cx, 2Ex, 34x, 35x, 3Mx, 3Nx, 42x, 48x, 4Ax, 4Bx, 4Fx, 4Gx v 2530-[...]

No. FRU P/N CRU ID 21 Fan and thermal device, without graphic v 2529-CTO, E1x, E2x, E3x, E4x, E5x, E6x, F1x, F2x, F3x, F4x, F5x, F6x, F7x, G1x, G2x, G3x, G4x, G5x v 2529- v 2530-CTO, 13x, 14x, 16x, 18x, 19x, 1Cx, 1Dx, 1Ex, 1Fx, 1Yx, 1Zx, 21x, 22x, 23x, 24x, 25x, 26x, 27x, 28x, 29x, 2Dx, 2Gx, 2Hx, 31x, 32x, 33x, 3Bx, 3Cx, 51x, 52x,57x, E4x, F2x v 25[...]

No. FRU P/N CRU ID 22 Sierra W ireless EV -DO W ireless WA N Mini PCI Express Adapter v 2529-CTO v 2529-HUx, HWx v 2530-CTO, 36x, 37x v 2531-CTO v 2532-CTO 39T5664 N 23 Palm rest assembly without fingerprint r eader v 2529-CTO, E1x, E2x, E3x, E4x, E5x, F1x, F2x, F3x, F4x, F5x, F7x, FQx, G1x v 2529-H2x, H3x, H6x, HMx, HNx, R2x, R5x, R6x, R7x, R8x, R[...]

No. FRU P/N CRU ID 23 Palm rest assembly with fingerprint r eader v 2529-CTO, 1Hx, E6x, E7x, E8x, E9x, EAx, EBx, F6x, F8x, F9x, F Ax, FBx, FCx, FEx, FFx, FGx, FHx, FJx, FKx, FLx, FMx, FPx, FRx, FSx, FTx, G2x, G3x, G4x, G5x, G6x, G7x, G8x, G9x, GAx, GBx, GCx v 2529-H1x, H4x, H5x, H7x, H8x, H9x, HAx, HBx, HCx, HDx, HEx, HFx, HGx, HHx, HJx, HKx, HLx, [...]

LCD FRUs a b c d 1 2 3 7 8 9 10 4 5 6 e Parts list ThinkPad Z60m 143[...]

No. FRU P/N CRU ID a-d See “Miscellaneous parts” on page 153. 1 LCD front bezel 41V9410 N 2 LCD panel, 15.4-in. WXGA v 2529-CTO, E1x, E2x, E3x, E4x, E5x, E6x, E7x, F1x, F2x, F3x, F4x, F5x, F6x, F7x, F8x, F9x, FMx, FPx, FQx, FRx, FSx, G1x, g2x, G3x, G4x, G5x, G6x, G7x, G8x, G9x v 2529-H2x, H3x, H5x, H6x, H7x, H8x, HBx, HMx, HNx, HPx, HQx, HRx, H[...]

No. FRU P/N CRU ID 2 LCD panel, 15.4-in. WSXGA+, LG v 2529-CTO, E8x, E9x, EAx, FFx, FGx, FHx, FJx, FKx, FTx, GAx, GBx, GCx v 2529-HAx, HCx, HGx, HHx, HJx, HKx, HLx v 2530-CTO, 1Ex, 1Fx, 2Ax, 2Cx, 3Cx, 3Hx, 3Px, 3Qx, 3Rx, 3Sx, 43x, 46x, 48x, 49x, 4Ax, 4Bx, 4Cx, 4Lx, 4Mx, 4Nx, 4Px, 51x, 52x, 53x, 55x, 57x, 58x, 5Ax, E9x v 2530-J1x, J2x, J3x, J4x, J5x[...]

No. FRU P/N CRU ID 3 Hinge, silver v 2529-CTO, 1Hx, E9x, EAx, EBx, F Ax, FBx, FCx, FEx, FGx, FHx, FJx, FKx, FLx, FTx, GAx, GBx, GCx v 2529-H1x, H4x, H9x, HDx, HEx, HFx, HGx, HHx, HJx, HKx, HLx, HSx, HTx, L2x, P3x, P6x, P7x, P8x, P9x, R3x, R6x, R7x, R8x, R9x, RCx v 2530-CTO, 1Gx, 1Hx, 1Jx, 1Kx, 1Mx, 1Nx, 2Ax, 2Ex, 38x, 3Ex, 3Gx, 3Jx, 3Kx, 3Mx, 3Nx, [...]

No. FRU P/N CRU ID 5 LCD cover kit (black) v 2529-CTO, E1x, E2x, E3x, E4x, E5x, E6x, E7x, E8x, F1x, F2x, F3x, F4x, F5x, F6x, F7x, F8x, F9x, FFx, FMx, FPx, FQx, FRx, FSx, G1x, G2x, G3x, G4x, G5x, G6x, G7x, G8x, G9x v 2529-H2x, H3x, H5x, H6x, H7x, H8x, HAx, HBx, HCx, HMx, HNx, HPx. HQx, HRx, HUx, HWx, P1x, P2x, R2x, R5x, RAx, RBx v 2530-CTO, 1 1x, 13[...]

No. FRU P/N CRU ID 5 LCD cover kit (silver) v 2529-CTO, 1Hx, E9x, EAx, EBx, F Ax, FBx, FCx, FEx, FGx, FHx, FJx, FKx, FLx, FTx, GAx, GBx, GCx v 2529-H1x, H4x, H9x, HDx, HEx, HFx, HGx, HHx, HJx, HKx, HLx, HSx, HTx, L2x, P3x, P6x, P7x, P8x, P9x, R3x, R6x, R7x, R8x, R9x, RCx v 2530-CTO, 1Gx, 1Hx, 1Jx, 1Kx, 1Mx, 1Nx, 2Ax, 2Ex, 38x, 3Ex, 3Gx, 3Jx, 3Kx, 3[...]

Keyboard Language P/N (NMB) P/N (ALPS) P/N (Chicony) CRU ID Arabic 39T0961 39T7121 39T7181 ** Belgian 39T0962 39T7122 39T7182 Canadian, multilanguage (445) 39T0959 39T71 19 39T7179 Chinese, T raditional 39T0985 39T7145 39T7205 Czech 39T0963 39T7123 39T7183 Danish 39T0964 39T7124 39T7184 Dutch 39T0972 39T7132 39T7192 English, U.K. 39T0982 39T7142 39[...]

Recovery CDs Windows XP Professional W indows XP Professional is pr einstalled as the operating system in the following models: v 2529-CTO, E1x, E2x, E3x, E5x, E6x, E7x, E8x, E9x, EAx, F2x, F4x, F6x, F7x, F8x, F Ax, FCx, FFx, FGx, FKx, FLx, FMx, FPx, Fx v 2529-H1x, H3x, H4x, H5x, H8x, H9x, HCx, HGx, HJx, HPx, HQx, HRx, HUx, HWx, R2x, R3x, R5x, R6x,[...]

Language P/N CRU ID Arabic 42J5258 * Chinese, Simplified 42J5251 Chinese, T raditional 42J5252 Chinese, T raditional (Hong Kong S.A.R.) 42J5253 Czech 42J5257 Danish 42J5247 Dutch 42J5250 English, Russia 42J5240 English, U.K. 42J5239 English, U.S. 42J5238 Finnish 42J5248 French 42J5241 German 42J5242 Greek 42J5262 Hebrew 42J5255 Hungarian 42J5261 It[...]

Windows XP Home Edition W indows XP Home Edition is preinstalled as the operating system in the following models: v 2529-CTO, 1Hx, E4x, EBx, F1x, F3x, F5x, F9x, FBx, FEx, FHx, FJx, FQx, FRx, FTx v 2529-H2x, H6x, H7x, HAx, HBx, HDx, HEx, HFx, HHx, HKx, HLx, HMx, HNx, HSx, HTx v 2530-CTO, 14x, 16x, 1Cx, 1Dx, 1Ex, 1Gx, 1Hx, 1Jx, 1Mx, 1Yx, 1Zx, 22x, 23[...]

Miscellaneous parts FRU P/N CRU ID Screw kit (including nylon-coated scr ews): v M2 × 3 mm-I (BNI, NYLOK) (25) v M2 × 5 mm-I (BNI, NYLOK) (31) v M2 × 5 mm-F (BNI, NYLOK) (2) v M2 × 9 mm-I (BNI, NYLOK) (5) v M2 × 17 mm-I (BNI, NYLOK) (7) v M3 × 4 mm-P (BNI, NYLOK) (1) v M3 × 2.8 mm-I (BNI, D6.2, T2.0) (1) v Hex stud (2) 26R9579 N System misce[...]

AC adapters FRU P/N CRU ID 3-pin (90 W, 20 V) adapter (models CTO, xxA, xxB, xxC, xxG, xxH, xxK, xxM, xxQ, xxV) OP ASTEC 92P1 104 * Lite-On 92P1 108 * Sanken 92P1 1 12 * 2-pin (90W , 20 V) slim adapter for non-PFC model (models CTO, xxE, xxF , xxJ, xxL, xxP , xxS, xxU, xxY) OP ASTEC 92P1 106 * Lite-On 92P1 1 10 * Sanken 92P1 1 14 * Comm[...]

Power cords (system) A ThinkPad power cord for a specific country or r egion is usually available only in that country or region: For 2-pin power cords: Region P/N CRU ID Canada, U.S. R v models -CTO, xxF , xxL, xxS, xxU 39M5016 * Japan R v models -Exx, Jxx 39M5040 Argentina R v models -CTO, xxY 39M5020 Brazil R v models -CT[...]

Notices Lenovo may not offer the pr oducts, services, or features discussed in this document in all countries. Consult your local Lenovo repr esentative for information on the products and services curr ently available in your area. Any refer ence to a Lenovo product, program, or service is not intended to state or imply that only that Lenovo produ[...]

estimated through extrapolation. Actual r esults may vary . Users of this document should verify the applicable data for their specific environment. T rademarks The following terms are trademarks of Lenovo in the United States, other countries or both: Lenovo Rescue and Recovery ThinkLight ThinkPad ThinkPad Dock II ThinkPad Mini Dock ThinkPad Port [...]

Part Number: 39T6195_01 (1P) P/N: 39T6195_01[...]