Regency U39-NG1 инструкция обслуживания

W ARNING: If the information in these instructions are not followed exactly , a fi re or explosion may result causing property damage, personal injury or loss of life. FOR YOUR SAFETY Do not store or use gasoline or other fl ammable vapors and liquids in the vicinity of this or any other appliance. Installation and service must be performed by a [...]

2 Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove REGENCY ® UL TIMA TE Direct V ent Freestanding Gas Stove T o the New Owner: Congratulations! Y ou are the owner of a state-of-the-art UL TIMA TE Direct V ent Gas Stove by FPI Fireplace Products International Ltd. The Regency ® Gas Series of hand crafted appliances has been designed t[...]

Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 3 T ABLE OF CONTENTS SAFETY LABEL Copy of Safety Label ..................................................... 4 REQUIREMENTS MA Code - CO Detector ................................................ 5 INST ALLA TION Important Message ........................................................ 6[...]

4 Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove This is a copy of the label that accompanies each UL TIMA TE Direct V ent Freestanding Gas Stove. We have printed a copy of the contents here for your review . The safety SAFETY LABEL label is located on the inside of the drop down pedestal door . Copy of Safety Label for U39 Gas Stove[...]

Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 5 REQUIREMENTS 5.08: Modifica tions to NFPA-54, Chapter 10 (2) Revise 10.8. 3 by adding the follow ing additiona l requirements: (a) For all side wall hor izontally vented ga s fueled equipment in stalled in every dwelling, bui lding or structure used in whole or in part for residential [...]

6 Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove IMPORT ANT MESSAGE SA VE THESE INSTRUCTIONS The UL TIMA TE Direct V ent Freestanding Gas Stove must be installed in accordance with these instructions. Carefully read all the instructions in this manual fi rst. Consult the building authority having jurisdiction to determine the need f[...]

Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 7 INST ALLA TION 8) Any safety glass removed for servicing must be replaced prior to operating the appliance. 9) T o prevent injury , do not allow anyone who is unfamiliar with the operation to use the fi replace. INST ALLA TION CHECKLIST 1) Loate your appliance. Refer to the following [...]

8 Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove For V ent T ermination requirements, see "Exterior V ent termination Locations" section. LOUVER INST ALLA TION 1) Attach the top & bottom louvers to the side stove panel using 2 screws per side. INST ALLA TION MANUF ACTURED MOBILE HOME ADDITIONAL REQUIREMENTS 1) Ensure th[...]

Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 9 EXTERIOR VENT TERMINAL LOCA TIONS A = Clearance above grade, veranda, porch, deck, or balcony *(min. 12"/30cm) B= Clearance to window or door that may be opened *(12"/30cm) C= Clearance to permanently closed window *(min. 12"/30cm) D= V ertical clearance to ventilated so[...]

10 Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 4” X 6-5/8” RIGID PIPE CROSS REFERENCE CHART Components from different Manufacturers may not be mixed. Not All Rigid Pipe components are available directly from FPI. Description Simpson Direct V ent Pro ® Simpson Direct V ent GS ® Discontinued Selkirk Direct-T emp™ American Me[...]

Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 11 Description Simpson Direct V ent Pro ® Simpson Direct V ent GS ® Discontinued Selkirk Direct-T emp™ American Metal Products ® Amerivent Direct Metal-Fab ® Sure Seal Security Secure V ent ® Attic Insulation Shield 12” 46DV A-IS - N/A from FPI N/A N/A 4DAIS12 N/A SV4RSA Attic I[...]

12 Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove RIGID PIPE VENTING SYSTEMS Horizontal or V ertical Terminations Alternate Horizontal T er- mination Caps INST ALLA TION This product has been evaluated by Intertek for using a Rigid Pipe Adaptor in conjunction with Duravent Direct-V ent GS, Selkirk Direct-T emp, Ameri V ent Direct ven[...]

Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 13 INST ALLA TION PRECAUTIONS These venting systems are engineered products that have been designed and tested for use with the U39-NG1, and U39-LP1. The warranty will be voided and serious fi re, health or other safety hazards may result from any of the following actions: 1) Installati[...]

14 Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove Horizontal V enting with T wo (2) 90 o Elbows Option V H + H1 A) 3' Min. 2' Max. B) 5' Min. 3' Max. C) 8' Min. 4' Max. With these options, maximum total pipe length is 30 feet with minimum of 8 feet total vertical and maximum 4 feet total horizontal. Plea[...]

Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 15 INST ALLA TION DV ST OVE HORIZONT AL VENT KIT INST ALLA TION Minimum Installation Height: U39: 59-3/4" ( 1518mm) DV ST OVE HORIZONT AL VENT KIT (# 946-1 16 & #946-216) DV Stove Horizontal V ent Kit (2 ft. Part # 946-1 16 or 4 ft. Part # 946-216) includes all the parts needed [...]

16 Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove INST ALLA TION Note: if the centerline cannot be met, the adjustable sections will have to be cut. e) Cut the 2 ft. or 4 ft. section of rigid pipe to length. Ensure that the pipe length when cut will seat onto both the starter collar and the 90 o elbow . Crimped section of rigid pipe [...]

Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 17 Alternate Horizontal T ermination Caps Dura-V ent Basic Horizontal Kit # 970 1 90 o Elbow 1 W all Thimble Cover 1 Horiz. Sq. T erm. Cap DURA-VENT TERMINA TION KIT Planning Y our Dura-V ent Installation There are two basic types of Dura-V ent Direct V ent System installations: horizont[...]

18 Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove NOTE: For Snorkel terminations in ABOVE grade installations, follow national or local code requirements. Diagram 3a Note: Riser V ent is only for use in above grade terminations. U39: 59-3/4" (1518mm) Diagram 2 Note: a) The horizontal run of vent should have a 1/4 inch rise for e[...]

Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 19 Diagram 10 Diagram 9 Diagram 8 Diagram 7 Diagram 6 7) Install the Wall Thimble in the center of the 10" square and attach with wood screws. 8) Slide the decorative wall thimble up to the wall surface being careful not to scratch the paint and attach with screws provided. Apply de[...]

20 Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove INST ALLA TION Diagram 1 1: The upper half of the fl ashing is installed under the roofi ng material and not nailed down until the chimney is installed. This allows for small adjustments. 4) Assemble the desired lengths of black pipe and elbows necessary to reach from the appliance [...]

Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 21 INST ALLA TION Using a level, make sure the support is vertical. If the support extends above the roof, cut it fl ush with the top of the roof. Nail the support to the frame opening using (8) 3" spiral nails or #8 x 1-1/2" screws. Note: If you are using a 6" square sup[...]

22 Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove Converting a Masonry Chimney Important: The existing masonry flue opening needs to have an area of at least a 36 sq. in. to insure proper intake/exhaust fl ow. 1) Before cutting any holes, assemble the desired sections of black direct vent pipe to determine the center of the masonry [...]

Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 23 U39-NG1: For 0 to 2000 feet altitude U39-LP1: For 0 to 4500 feet altitude Burner Inlet Orifi ce Sizes: Natural Gas Propane Burner #32 #50 Max. Input - Natural Gas/Propane 38,000 Btu/h Min. Input - Natural Gas/Propane 20,000 Btu/h Supply Pressure Natural Gas min. 5" w .c. Propane[...]

24 Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove CONVERSION KIT# 731-969 FROM NG T O LP THIS CONVERSION MUST BE DONE BY A QUALIFIED GAS FITTER IF IN DOUBT DO NOT DO THIS CONVERSION !! 1) Shut off the gas supply . 2) Open the front door and carefully remove the logs and lava rock. Pilot assembly is now accessible for steps 4) to 10).[...]

Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 25 16) Pull off the pilot cap to expose the pilot orifi ce. 17) Unscrew the pilot orifi ce with the allen key and replace with the LPG pilot orifi ce in the kit. 19) Reinstall new burner orifi ce LPG stamped #50 and tighten. 20) Reverse steps 3) to 2). 21) Attach the label "This[...]

26 Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 7) Reversing step 2 and secure the control panel back onto the stove pedestal with the screws. 9) The Ground Wire, DC Sparker Ignition Wire and Piezo Spark Wire all go through the hole located on the pedestal back cover . 10) Put on the plastic split bushing. 11 ) Attach the Piezo Ign[...]

Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 27 GAS PIPE PRESSURE TESTING The appliance must be isolated from the gas supply piping system by closing its individual manual shut-off valve during any pressure testing of the gas supply piping system at test pressures equal to or less than 1/2 psig. (3.45 kPa). Disconnect piping from v[...]

28 Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove AERA TION ADJUSTMENT The burner aeration is factory set but may need adjusting due to either the local gas supply or altitude. U39 with 38,000 Btu/h U39-NG1 Natural Gas: 1/4" open U39-LP1 Propane: 1/2" open U39 with 30,000 Btu/h U39-NG1 Natural Gas 3/16" open U39-LP1 Pr[...]

Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 29 LOG SET INST ALLA TION INST ALLA TION Embers Embers The "02" refer numbers (i.e. 02-65) are molded into the rear of each log. Note: Install Optional Brick Panels prior to installing logs. 1) Carefully remove the logs from the box and unwrap them. The logs are fragile, handle[...]

30 Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove Cutout Pin D)02-46 B)02-56 A)02-65 7) Place the Left T op Log D)02-46 on the pin on Log B)02-56 and on top of the cutout on Log A)02-65. E)02-45 C)02-44 8) Place Front Right Log E)02-45 on the two pins as shown. 9) Place the lava rock in the area between the left and right logs, leavi[...]

Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 31 Cutout Notch F)02-47 E)02-45 A)02-65 11 ) Place the notch in Center Log F)02-47 over Log E)02-45 and across the cutout on Log A)02- 65. Notch E)02-45 Bracket A)02-65 The bottom right edge of Log G)02-48 must sit snugly against the bracket Side V iew G)02-48 E)02-45 F)02-47 12) Positio[...]

32 Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove WIRING DIAGRAM CAUTION: Label all wires prior to disconnection when servicing controls. Wiring errors can cause improper and dangerous W ARNING: Electrical Grounding Instructions This appliance is equipped with a three pronged (grounding) plug for your protection against shock hazard [...]

Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 33 14 GA. 16 GA. 18 GA. 20 GA. 22 GA. 50 Ft. 32 Ft. 20 Ft. 12 Ft. 9 Ft. Recommended Maximum Lead Length (T wo-Wire) When Using W all Thermostat (CP-2 System) Wire Size Max. Length Thermostat Wire T able OPTIONAL W ALL THERMOST A T A wall thermostat may be installed if desired. Connect th[...]

34 Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove OPERA TING INSTRUCTIONS SHUTDOWN INSTRUCTIONS 1) Use the Burner ON/OFF switch, thermostat or remote control to turn off the burner . 2) Push in the PILOT knob slightly and turn clockwise to off. Do not force. 3) Turn of f all electric power to the appliance if service is to be perform[...]

Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 35 1) Push in gas control knob slightly and turn to “PILOT” position. 2) Push in control knob all the way and hold in until the pilot lights up. Continue to hold the control knob in for about 20 seconds after the pilot is lit. Release knob. 3) Push in gas control knob slightly and tu[...]

36 Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove MAINTENANCE MAINTENANCE INSTRUCTIONS 1) Always turn off the valve before cleaning. For relighting, refer to lighting instructions. Keep the burner and control compartment clean by brushing and vacuuming at least once a year . When cleaning the logs, use a soft clean paint brush as the[...]

Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 37 Mitred Glass Replacement Removing Glass 1) Remove the door from the unit and place on a soft surface to prevent scratching. 2) Pull out the door gasket. 3) Remove the 24 nuts holding the glass retainers in place. Do not remove the nuts underneath the retainers. 4) Remove the door catc[...]

38 Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove MAINTENANCE F AN MAINTENANCE If your fan requires maintenance or replacement, access to the fan is through the plate on the rear wall of the fi rebox. NOTE: the unit MUST NOT be operated without the fan access panel securely in place and correctly sealed. IMPORT ANT : These fans coll[...]

Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 39 REMOVING V AL VE 2) Undo the six screws holding the control panel in place. 3) Disconnect all wires from the back of the panel and then remove panel. Y ou should lay the panel on a soft cloth so it doesn't get marked up. See diagram below . 6) Remove the two outside frame pieces [...]

40 Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove P ARTS LIST 30) 630-021 Fan Access Panel 31) 730-019 Rear Panel 32) 730-565 Firebox Baffl e/Restrictor Assy 33) 630-520 False T op Assembly 36) 936-194 Gasket-Starter Collar/Air Passage 37) * Gasket-Flue Collar/Starter Collar 38) 820-058 Pedestal Base Cover 39) * Gasket - Air Passage[...]

Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 41 BURNER & LOG ASSEMBL Y 51) 910-241 Burner ON/OFF Switch (3-way) 52) 910-190 Piezo Ignitor & Nut 53) 904-586 Knob for Fan Speed Control 54) 910-373 Knob - Pilot V alve Extension 55) 910-372 Flame Adjusting Knob 56) 908-646 Control Panel Decal 57) 650-220 Control Panel Plate 58)[...]

42 Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove P ARTS LIST DOOR ASSEMBLIES Part # Description 730-923 Brush Nickel Mitred Door - Complete 730-924 Gold Mitred Door - Complete 730-926 Black Mitred Door - Complete 730-932 Gold W rap Door - Complete 730-928 Gold Panel Door - Complete 101) 650-920 Door Gasket Kit 105) * Ceramic Paper 1[...]

Regency ® U39 UL TIMA TE Direct V ent Freestanding Gas Stove 43 W ARRANTY Regency Fireplace Products are designed with reliability and simplicity in mind. In addition, our internal Quality Assurance T e am carefully inspects each unit thoroughly before it leaves our facility . FPI Fireplace Products International Ltd. is pleased to extend this lim[...]

Installer: Please complete the following information Dealer Name & Address: ______________________________________________ ___________________________________________________________________ Installer: ___________________________________________________________ Phone #: ___________________________________________________________ Date Installed:[...]