Seagate Pipeline HD Mini Series SATA ST91603110CS инструкция обслуживания

Product Manual Pipeline HD Mini Series SA T A 100560196 Rev . A March 2009 ST925031 1CS ST916031 10CS[...]

Revision history Copyright © 2009 Seagate T echnology LLC. All right s reserved. Printed in U.S.A. Publication number: 100560196 , Rev . A March 2009 Seagate, Seagate T echnology and the W ave logo ar e registere d trademarks of Seagate T echnology LLC in the United S t ates and/or other co untries. Pipeli ne HD, SeaT ools and SeaTDD are either tr[...]

Pipeline HD Mini Series SAT A Prod uct Manual, Re v. A i Contents 1.0 Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 1.1 About the Serial ATA interface . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 2.[...]

ii Pipeline HD Mini Series SAT A Product Manu al, Rev. A[...]

Pipeline HD Mini Series SATA Produc t Manual, Re v. A iii List of Figures Figure 1. Typical +5V only startup and operation curren t profile . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9 Figure 2. Attaching SATA cabling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20 Figu[...]

[...]

Pipeline HD Mini Series SAT A Prod uct Manual, Re v. A 1 1.0 Introduction This manual describes the functiona l, mechanical an d interface specifications for the following Seagate Pipeline HD ® Mini Series SA T A model drives: • ST925031 1CS • ST916031 10 CS These drives provide the following key fea tures: • 5,400-RPM spindle sp eed. • 8-[...]

2 Pipeline HD Mini Series SAT A Product Manua l, Rev. A 1.1 About the Serial A T A interface The Serial A T A interface pr ovides several advant ages over the traditional (p arallel) A T A interface. The primary advantages include : • Easy installatio n and configuration with true p lug-and-pl ay connectivity . It is not normally necessary to set[...]

Pipeline HD Mini Series SAT A Prod uct Manual, Re v. A 3 2.0 Drive specifications Unless otherwise noted, all specific ations are me asured unde r ambient conditions, at 25°C, and nominal power . For convenienc e, the ph rases the drive and this drive are used throughout this manual to in dicate the Pipeline HD Mini Series SATA models. 2.1 Spec if[...]

4 Pipeline HD Mini Series SAT A Product Manua l, Rev. A * On e Gbyte equals one billion bytes when refer ring to hard driv e capacity. Acce ssib le capacity may vary depending on oper ating environment and formatting. **During periods of drive idle, some offline activity may occu r according to the S.M.A. R.T. specification, which may increa se a c[...]

Pipeline HD Mini Series SAT A Prod uct Manual, Re v. A 5 2.2 Formatted cap acity *One Gbyte equals one billion bytes when referring to hard drive capacity. Accessible capacity may vary depending on operating environment and formatting. 2.2.1 LBA mod e When addressing these d rives in LBA mode, all bloc ks (sectors) a re consecutively numbered from [...]

6 Pipeline HD Mini Series SAT A Product Manua l, Rev. A 2.4 Physical organization 2.5 Recording and interface tec hnology 2.6 Physical characteristics Drive model Read/write heads Number of discs ST925031 1CS 2 1 ST916031 10CS 2 1 Interface Serial A T A (SA T A) Recording method Perpendicular Recording density BPI (bits/inch avg) 1,490k T rack dens[...]

Pipeline HD Mini Series SAT A Prod uct Manual, Re v. A 7 2.7 Seek time Seek measurement s are t aken with nominal p ower at 25°C ambient temperatur e. All times are measured using drive diagnostics. The specifications in th e table belo w are defined as follows: • T rack-to-track s eek time is an averag e of all possible sing le-track s eeks in [...]

8 Pipeline HD Mini Series SAT A Product Manua l, Rev. A 2.9 Power specifications The drive receives DC power (+5V) throug h a native SA T A power conne ctor . 2.9.1 Power consumption Power requirement s for the drives are listed in the tabl e on pa ge 8. T ypical power measureme nts ar e based on an average of drives tested, u nder nomina l co ndit[...]

Pipeline HD Mini Series SAT A Prod uct Manual, Re v. A 9 2.9.1.1 T ypical cu rrent profile Figure 1. T ypical +5V only startup and operation current pro file 2.9.2 Conduct ed noise Input noise ripp le is measured at th e host system powe r supply across an equivalent 15-ohm resistive load o n the +5 volt line. Using 5-volt power , the drive is expe[...]

10 Pipeline HD Mini Series SAT A Product Ma nual, Rev. A 2.9.4 Power -managemen t modes The drive provides prog rammable power man agement to provide gr eater energy ef fici ency . In most systems, you can control power manage ment through the system setup program. The drive features the followin g power-management mod es: • Active mode The drive[...]

Pipeline HD Mini Series SATA Produc t Manual, Re v. A 11 2.10 Environment al specifications 2.10.1 Base plate temperat ure Actual drive base pla te temperat ure should not exc eed 70°C (158°F). Above 1,000 feet (305 meter s), the maximum temper a ture is derated linearly by 1°C every 1000 fee t. 2.10.2 T emperature gra dient 2.10.3 Humidity 2.10[...]

12 Pipeline HD Mini Series SAT A Product Ma nual, Rev. A 2.10.5 Shock All shock specifications assu me that the drive is mounted secu rely with the input sh ock applied at the drive mounting screws. Shock may be applied in the X, Y or Z axis. 2.10.5.1 Operating shock These drives comply with t he performance levels specifie d in this document when [...]

Pipeline HD Mini Series SATA Produc t Manual, Re v. A 13 2.1 1 Acoustics Drive emission of sound is m easured co nsistent wi th the ECMA-7 4 and its’ referen ced standards. T esting is conducted at room temper ature (approxima tely 25 ° C). Emission levels a re reported as the tot al A-we ighted sound power levels for steady st ate, id le, and a[...]

14 Pipeline HD Mini Series SAT A Product Ma nual, Rev. A 2.13 Reliability Measurement type Specification Nonrecoverable read errors 1 per 10 14 bits read, max. Annualized Fa ilure Rate (AFR) <0.55% Load/Unload (U/UL) 25°C, 50% relative humidity 32°C, 80% relative humidity 5°C, 80% relative humidity 5°C, 10% relative humidity 55°C, 16% relat[...]

Pipeline HD Mini Series SATA Produc t Manual, Re v. A 15 2.14 Agency certification 2.14.1 Safety certification These product s are certified to me et the requirem ent s of UL60950 -1, CSA60950-1 and EN60950 and so marked as to the certify agency . 2.14.2 Electromagnetic comp atibility Hard drives that display the CE mark comply with the Eu ropean U[...]

16 Pipeline HD Mini Series SAT A Product Ma nual, Rev. A 2.14.3 FCC verification These drives are intended to be contain ed solely within a personal computer or similar enclosure (not attached as an external device). As such, each drive is consider ed to be a subasse mbly even when it is individually mar- keted to the customer . As a subassembly , [...]

Pipeline HD Mini Series SATA Produc t Manual, Re v. A 17 2.15 Environment al protection Seagate des igns its products to meet envi ronmental pr otection requirements worl dwide, including regulatio ns restricting certain chemical substances. 2.15.1 European Union Restriction of Hazardous Su bst ances (RoHS) The European Un ion Restriction of Hazard[...]

18 Pipeline HD Mini Series SAT A Product Ma nual, Rev. A[...]

Pipeline HD Mini Series SATA Produc t Manual, Re v. A 19 3.0 Configuring and mounting the drive This section contains the specif ications an d instructions for configuring and mounting the drive. 3.1 Handling and st atic-dis charge precautions After unp acking, and befo re installation, the drive may be exposed to po tential handling and ele ctrost[...]

20 Pipeline HD Mini Series SAT A Product Ma nual, Rev. A 3.2 Configuring the drive Each drive on th e Serial A T A interface con nects in a point-to-point configuration with the Serial A T A host adapter . There is no maste r/slave relationship because each drive is consider ed a master in a p oint-to-point relationships. If two drives are at tache[...]

Pipeline HD Mini Series SATA Produc t Manual, Re v. A 21 3.4 Drive mounting Y ou can mo unt the drive using four screws in the side-mo untin g holes or four screws in the bottom-mo unting holes. See Figure 3 for drive mounting dimensions. Follow these imp ortant mounting prec autions when mo unt- ing the drive: • Allow a minimum clearance of 0.03[...]

22 Pipeline HD Mini Series SAT A Product Ma nual, Rev. A Measurem ents shown in Figure 3 ar e in inches. Figure 3. Mounting dimens ions—top, sid e and end view[...]

Pipeline HD Mini Series SATA Produc t Manual, Re v. A 23 4.0 Serial A T A (SA T A) interface These drives use the industry-s tandar d Serial A T A interfac e th at support s FIS dat a transfers. It support s A T A programmed inpu t/output (PIO) mod es 0–4; multiword DMA mo des 0–2, and Ultra DM A modes 0–6. The dr ive also support s the use o[...]

24 Pipeline HD Mini Series SAT A Product Ma nual, Rev. A Notes: 1. All pins are in a single row , with a 1.27 mm (0.050”) pitch. 2. The comment s on the mating sequence a pply to the case of backplane blin dmate connector only . In this case, the mating sequences ar e: • the ground p ins P4 and P1 2. • the pre-charge power pins and the other [...]

Pipeline HD Mini Series SATA Produc t Manual, Re v. A 25 4.3 Supported A T A commands The following t able list s Serial A T A standa rd commands that the drive support s. For a deta iled description of the A T A commands, refer to the Serial A T A: High S p eed Serialized A T Att achment specification . See “S.M.A.R.T . commands” on pa ge 33.f[...]

26 Pipeline HD Mini Series SAT A Product Ma nual, Rev. A Set Max Address F9h Note: Individual Set Max commands are identi- fied by the value placed in the Set Max Fea - tures register as defined to the right. Address: Password: Lock: Unlock: Freeze Lock: 00 H 01 H 02 H 03 H 04 H Set Multiple Mode C6h S.M.A.R.T . Disable Operations B0h/D9h S.M.A.R.T[...]

Pipeline HD Mini Series SATA Produc t Manual, Re v. A 27 Sleep E6h S t andby E2h S t andby Immediate E 0h A T A-standard security commands Security Set Password F1h Security Unlock F2h Security Erase Prepare F3h Security Erase Unit F4h Security Freeze Lock F5h Security Disable Password F6h Command name Command code (in hex)[...]

28 Pipeline HD Mini Series SAT A Product Ma nual, Rev. A 4.3.1 Ident ify Device co mmand The Identify Device command (command code EC H ) transfers information about the drive to the ho st following power up. The dat a is organized as a single 51 2-byte bl ock of dat a, whose content s are shown in th e table on page 27. All re served bit s or word[...]

Pipeline HD Mini Series SATA Produc t Manual, Re v. A 29 59 Numbe r of sectors transferred during a Read Multiple or Wr ite Multiple command xxxx H 60–61 T otal number of user-addressable secto rs This field contains a val ue that is one greater th an the total number of user-addressable sectors. The maximum value that shall be pla ced in this fi[...]

30 Pipeline HD Mini Series SAT A Product Ma nual, Rev. A 94 Auto acoustic ma nagement setting xxxx H 95–99 A T A-reserved 0000 H 100–103 T ot al number of user-addressable LBA sectors available (see Section 2.2 for related information) These words are required for drives that support the 48- bit addressing feature. Maximum value: 0000FFFFFFF FF[...]

Pipeline HD Mini Series SATA Produc t Manual, Re v. A 31 Bit Wor d 8 8 0 Ultra DMA mode 0 is supp orted. 1 Ultra DMA mode 1 is supp orted. 2 Ultra DMA mode 2 is supp orted. 3 Ultra DMA mode 3 is supp orted. 4 Ultra DMA mode 4 is supp orted. 5 Ultra DMA mode 5 is supp orted 6 Ultra DMA mode 6 is supp orted 8 Ultra DMA mode 0 is curren tly active. 9 [...]

32 Pipeline HD Mini Series SAT A Product Ma nual, Rev. A 4.3.2 Set Fe atures comm and This command controls the implemen tation of various fe at ures th at the drive suppo rts. When the drive r eceives this command, it sets BSY , checks the contents of the Featur es register , clears BSY and gen erates an inter- rupt. If the value in the register d[...]

Pipeline HD Mini Series SATA Produc t Manual, Re v. A 33 4.3.3 S.M.A.R.T . commands S.M.A.R.T . provides near-term failure prediction for d isc drives. When S.M.A.R.T . is enabled, the drive moni- tors predetermined drive attributes that are suscep tible to degradation ove r time. If self-monitoring dete rmines that a failure is likely , S.M.A.R.T [...]

34 Pipeline HD Mini Series SAT A Product Ma nual, Rev. A[...]

Pipeline HD Mini Series SATA Produc t Manual, Re v. A 35 5.0 Seagate T echnology support services Internet For information regardin g Seagate product s and services, visit www .sea gate.com . Worldwide support is available 24 hours daily by ema il for your questions. Presales Support: Presales@Seagate.com T echnical Support: DiscSupport@Seagate.com[...]

36 Pipeline HD Mini Series SAT A Product Ma nual, Rev. A Customer Service Operations W arranty Servi ce Seagate of fers worldwide customer support for Seagate product s. Seagate distributor s, OEMs and othe r direct customers should contact their Seagate Customer Ser v ice Operat ions (CSO) repr esentative for warr anty- related issues. Resellers o[...]

Pipeline HD Mini Series SATA Produc t Manual, Re v. A 37 Index A ACA 15 acoustics 4 , 13 Active m ode 10 Address 26 AFR 14 Agency certification 15 Altitude 11 Altitude, nonoperating 4 Altitude, operating 4 ambient temperature 7 Annualized Failure Rate 14 Annualized Failure Rate (AFR) 4 Areal density 3 , 6 ATA commands 25 ATA data-transfer mode s su[...]

38 Pipeline HD Mini Series SAT A Product Ma nual, Rev. A Guaranteed sectors 3 , 5 guaranteed sector s 5 H handling 19 Handling precautions 19 heads 5 Height 3 height 6 Humidity 11 humidity 4 I I/O data-transfer rate 3 , 6 Identify 25 Identify Device 25 Identify Device command 28 Idle 8 , 26 Idle and Standby timer s 10 Idle Immediate 26 Idle mode 4 [...]

Pipeline HD Mini Series SATA Produc t Manual, Re v. A 39 Read Stream Extended 25 Read Verify Sectors 25 Read Verify Sectors Extended 25 Read Verify Sect ors without R etries 25 Read/write heads 5 Read/write power 4 read/write power and current 8 Recording density 3 , 6 Recording method 6 Recording technology 6 Relative humidity 4 , 11 Reliability 1[...]

40 Pipeline HD Mini Series SAT A Product Ma nual, Rev. A[...]

[...]

Seagate T echnology LLC 920 Disc Drive, Scotts V a lley , California 95066 -4544, USA Publication Number: 1005601 96, Rev . A, Printed in USA[...]