Stovax 7106HC инструкция обслуживания

PM227 ENG Issue 2 (July 2008) Stockton 3/4/5/6/7/8/11 Free Standing Stove M ODELS: 7118/7101/7102/7119/7160/7127/7130/7161/7100/7162/7117/7120/7163/7103/7104/ 7105/7113/7113LC/7128/7114/7106/7106LC/7106HC/7116/7116LC/7116HC Instructions for Use, Installation and Servicing For use in GB & IE (Great Britain and Republic of Ireland). IMPORTANT Thi[...]

COVERING THE FOLLOWING MODELS: 7118/7101/7102/7119/7160/7127/7130/7161/7100/7162/7117/7120/7163/7103/7104/ 7105/7113/7113LC/7128/7114/7106/7106LC/7106HC/7116/7116LC/7116HC 2 APPLIANCE COMMISSIONING CHECKLIST 3 USER INSTRUCTIONS 4 General Points 4 Using the Appliance for the first time 5 Recommended Fuels 5 Lighting the appliance 6 Running the appli[...]

3 APPLIANCE COMMISSIONING CHECKLIST To assist us in any guarantee claim please complete the following information:- Dealer appliance was purchased from Name: ................................................................................................................................................................. Address: .....................[...]

4 USER INSTRUCTIONS 1. GENERAL POINTS 1.1 Before use of this appliance please read these instructions fully. 1.2 All local regulations, including those referring to national and European Standards need to be complied with when installing the appliance. 1.3 Only use for domestic heating in accordance with these operating instructions. 1.4 You must b[...]

5 USER INSTRUCTIONS AIR CONTROLS Airwash Control OP E N CL O S E Primary Control OP E N CL O S E 1 DOOR PR7213 PR7212 2 DOOR DOOR HANDLE 1.14 Use a protected gloved hand to operate. DO NOT OPEN THE DOOR WITH BARE HANDS To Open and Close Drop tool over knob to fit. Lift and remove 1 DOOR 2 DOOR PR7210 PR7209 WARNING Properly installed, operated and [...]

6 USER INSTRUCTIONS Poor quality timber: — Causes low combustion efficiency — Produces harmful condensation — Reduces effectiveness of the airwash and life of the appliance Do not burn construction timber, painted, impregnated / treated wood, manufactured board products or pallet wood . 3.2 Solid fuel:  •Burn only anthracite [...]

7 USER INSTRUCTIONS 5.2 Burning Solid fuel : To burn solid fuel efficiently in a wood version the multi- fuel kit should be fitted. Multi-fuel kit part numbers: Appliance Part No. Stockton 5 (all) 7108 Stockton 6 (all) 7117 Stockton 7 7109 Stockton 8 7111 Stockton 8 Slimline 7111SL Only for use with recommended fuels, see Installation Section for f[...]

8 USER INSTRUCTIONS 5.5 When in use, burning the appliance at high output for a short period also reduces tars and creosote. 5.6 You must burn only anthracite or smokeless fuels suitable for use in closed appliances . 5.7 Do not burn bituminous coal, ‘petro-coke’ or other petroleum based fuels as this invalidates the product guarantee . Do not [...]

9 Do not re-light the appliance until the problem is solved. 7. ASH REMOVAL 7.1 All Fuels when Multi-fuel kit is fitted:  •Riddle, See Diagram 11 PR7208 Push/Pull to operate  •Open Doors, See Diagram 12 PR7211 Open  •Remove Ashpan carefully Heat can remain long after use.  •Use gloves,?[...]

10 13.3 Ensure adequate access to cleaning doors where it is not possible to sweep through the chimney. 13.4 If the appliance is believe to have previously served an open fire the chimney must be swept a second time within a month of regular use after installation. 14. CARE OF STOVE Stovax has a range of cleaning and maintenance products and access[...]

11  •Glass blackening  •Thick, brown and sticky tar oozes from the pipe joints This is caused by burning damp wood and burning your appliance at too low a temperature;  •Use well seasoned wood and operate the appliance in the ideal temperature range Tar is a major c[...]

12 TECHNICAL SPECIFICATION STOCKTON Model Stockton 3 - 7118 Stockton 4 - 7101/7102 Stockton 5 - 7119/7160/7108/7127/Stockton 5ML - 7130 Stockton 6 - 7100/7162/Stockton 6HL - 7117 Stockton 7 - 7120/7163 Stockton 8 - 7103/7104/7105/7113/7113LC/7113HC/7114/7128 Stockton 11 - 7106/7106LC/7106HC/7116/7116LC/7116HC Stockton 4 Stockton 3 Stockton 5 Stockt[...]

13 TECHNICAL SPECIFICATION 1. STANDARD FEATURES • Primaryair (under grate air for full multi-fuel use) • Airwash(for wood burning / clean glass) • Presetsecondary air control (to ensure complete burning of flue gases) • Riddlinggrate system for clea[...]

14 TECHNICAL SPECIFICATION STOCKTON DIMENSIONS Description Model A B C D E F G H (dia) Stockton 3 7118 510 389 291 90 405 338 96 125 Stockton 4 7101 572 389 291 90 465 338 112 125 7102 Stockton 5 7119 544 481 294 90 436 335 120 125 7127 Stockton 5 LC 7160 684 503 294 90 436 335 120 125 7161 Stockton 5ML 7130 600 481 294 90 493 294 175 125 Stockton [...]

15 1. FLUE OR CHIMNEY 1.1 The flue or chimney system must be in good condition. It must be inspected by a competent person and passed for use with the appliance before installation Products of combustion entering the room can cause serious health risks. 1.2 You must check the following: — The construction of the masonry chimneys, flue block chimn[...]

16 2.1 Except Stockton 5 Midline and Stockton 6 Highline the appliance must stand on a constructional hearth which is at least 125mm thick with the minimum dimensions as shown. SITE REQUIREMENTS 150mm minimum Constructional Hearth 840mm minimum Constructional Hearth 840mm minimum 150mm minimum 150mm minimum 225mm minimum PR7205 1. HEARTH DIMENSIONS[...]

17 SITE REQUIREMENTS WALLS NEXT TO A HEARTH Solid, non-combustible material e.g. masonry or concrete Thickness W C 150mm minimum 150mm minimum C H PR7204 Position of Appliance & Hearth in relation to walls Requirement for the walls Distance of hearth from wall 'C' Distance of Appliance to wall Min thickness of Wall 'W' Min h[...]

18 PRE-INSTALLATION CHECKS * When measured from the top of the flue, with no horizontal sections and a maximum of 4 bends with angles of less than 45° ‡ May be 125mm (5”) if burning low volatiles (smokeless) fuels approved for use in Smoke Control Areas. See web site http://uksmokecontrolareas.co.uk for more information about approved fuels. 1[...]

19 PRE-INSTALLATION CHECKS 3.1 This appliance requires ventilation to supply combustion air. Any room containing the appliance must have a permanent air vent opening with a total free area of at least 550mm 2 per kW of appliance rated output above 5kW. 3.2 Increase air supply provisions where a room contains multiple appliances. 3.3 If vents open i[...]

20 LEGAL REQUIREMENTS Before installation of this product please read these instructions fully. It is very important to understand the requirements of the national Building Regulations* and standards**, along with any local regulations and working practices that may apply. Should any conflict occur between these instructions and these regulations t[...]

21 INSTALLATION INSTRUCTIONS PR7218 Seal Collar with Fire Cement Self Tapping Screw Tee Size Stovax Part No. 5" 4516* 6" 4616 Cap PR7195 600mm min 1000mm max unsupported Elbow with access cover Size Stovax Part No. 5" 4512 6" 4612 7" 4712 Flue Pipe 915mm (3ft) Size Stovax Part No. 5" 4502* 6" 4602 7" 4702 To [...]

22 INSTALLATION INSTRUCTIONS PR7211a  •Replace in reverse order 4. FITTING AND REMOVAL OF THE BAFFLES 4.1 The appliance is fitted with a baffle in the top of the firebox to maintain efficient combustion 4.2 Allow the stove to cool fully before removing the baffle system. 4.3 To remove the baffle: •R emove the log guard from th[...]

23 INSTALLATION INSTRUCTIONS •Place the main grate into place on the steel runners The grate must sit flat and locate in the fixing slots in the supports. •Refit the firebricks above the grate •Remove the operating knob and nut from the end of the rod •Fi[...]

24 COMMISSIONING 1.1 To commission: • Replace the firebricks, baffle, and log retainer  • Check the door alignment and catch operation, adjust if required, see Installation Section 6. Adjusting Door hinges  • Check the soundness of door seals, castings and joints  •C heck the operation of the air controls 1.2 Now carry [...]

25 MAINTENANCE and SERVICING For a complete list of spare parts and accessories contact your Stovax or call 01392 474011 1. ANNUAL SERVICE 1.1 At the end of the heating season strip, inspect and clean the appliance as detailed:  •Allow appliance to cool  •Remove all of the following internal parts; baff[...]

26 1.4 Using the appliance for the first time:  • Burn at a low output for the first day of use This allows the seals, fixing glues and paint to fully cure. 1.5 During this time the appliance may give off some unpleasant odours:  •Keep the room well ventilated to avoid a build-up of fumes 1.6 Your Stova[...]

27 •Refit the door •Close to apply pressure on the new rope •Leave the appliance closed for at least 12 hours before lighting the stove •Use at a low output for approximately one day 7.3 Using the stove with a damaged door seal could allow dangerous[...]

28 BASIC SPARE PARTS LIST 1 2 6 8 7 9 10 12 11 3 4 5 Number and type of fire bricks vary between models Stockton 6 Highline Multi-fuel Warming Shelf Diagram No. Description Part No. 1 Door Glass GL0233 2 Log Guard SMN25 3 Clean Burn Chamber S3.27 4 Bafe SMN26 5 Side Fire brick SMN31 6 Ashpan Tool SM55 7 Ashpan SMN28 8 Main Grate SMN36 9 Centre G[...]

SERVICE RECORDS 29 1ST SERVICE Date of Service:........................................................................... Next Service Due:....................................................................... Signed:........................................................................................ Dealer's Stamp/HETAS Registration Num[...]

30[...]

31[...]

Stovax Ltd, Falcon Road, Sowton Industrial Estate, Exeter, Devon, England EX2 7LF Tel: (01392) 474011 Fax: (01392) 219932 E-mail: info@stovax.com www.stovax.com[...]