Toshiba M60 инструкция обслуживания

Toshiba Personal Computer Satellite M60 Maintenance Manual TOSHIBA CORPORATION [CONFIDENTIAL][...]

ii [CONFIDENTIAL] Satellite M60 Maintenance Manual Copyright © 2004 by Toshiba Corporation. All rights reserved. Under the copyright laws, this manual cannot be reproduced in any form without the prior written permission of Toshiba. No patent liability is assumed with respect to the use of the inform ation contained herein. Toshiba Personal Comput[...]

Satellite M60 Maintenance Manual [CONFIDENTIAL] iii Preface This maintenance manual describes how to perform hardware service maintenance for the Toshiba Personal Computer Satellite SATELLITE M60, referred to as the M60 Series in this manual. The procedures described in this manual are intended to help service technicians isolate faulty Field Repla[...]

iv [CONFIDENTIAL] Satellite M60 Maintenance Manual The manual is divided into the following parts: Chapter 1 Hardware Overview describes the M60 Series system unit and each FRU. Chapter 2 Troubleshooting Procedures explains how to diagnose and resolve FRU problems. Chapter 3 Test and Diagnostics describes how to perform test and diagnostic operatio[...]

Satellite M60 Maintenance Manual [CONFIDENTIAL] v Conventions This manual uses the following formats to describe, identify, and highlight term s and operating procedures. Acronyms On the first appearance and whenever necessary for clarification acronyms are enclosed in parentheses following their definition. For example: Read Only Memory (ROM) Keys[...]

vi [CONFIDENTIAL] Satellite M60 Maintenance Manual[...]

Satellite M60 Maintenance Manual [CONFIDENTIAL] vii Table of Contents Chapter 1 Hardware Overview 1.1 Features .............................................................................. Error! Bookmark not defined. 1.2 System Unit ........................................................................ Error! Bookmark not defined. 1.3 2.5-inch [...]

viii [CONFIDENTIAL] Satellite M60 Maintenance Manual 2.15 Express card troubleshooting .................................................................................... 2-38 2.16 Bluetooth Troubleshooting………………………………………………….………2-40[...]

Satellite M60 Maintenance Manual [CONFIDENTIAL] ix Chapter 3 Test and Diagnostic Operation Handbook 3.1 The Diagnostic Test ........................................................................................................ .3 - 1 3.2 Executing the Diagnostic Test ................................................................................[...]

x [CONFIDENTIAL] Satellite M60 Maintenance Manual Chapter 4 Replacement Procedures 4.1 General .............................................................................. Error! Bookmark not defined. 4.2 Battery ............................................................................... Error! Bookmark not defined. 4.3 PC Card ..............[...]

Satellite M60 Maintenance Manual [CONFIDENTIAL] xi Appendices Appendix A Handling the LCD Module ................................................................................. A-1 Appendix B Board Layout ...................................................................................................... B-1 Appendix C Pin Assignments..........[...]

Chapter 1 Hardware Overview 1 [CONFIDENTIAL][...]

1 Hardware Overview 1-ii [CONFIDENTIAL] Satellite M60 Ma intenance Manual[...]

1 Hardware Overview Satellite M60 Series Maintenance Manua l [CONFIDENTIAL] 1-iii Chapter 1 Contents 1.1 Features ...................................................................................................................... 1-5 1.2 System Unit .................................................................................................[...]

1 Hardware Overview 1-iv [CONFIDENTIAL] Satellite M60 Ma intenance Manual Figures Figure 1-1 2.5-inch HDD .............................................................................................. 1-12 Table Table 1-1 2.5-inch HDD specifications ....................................................................... 1-12 Table 1-2 DVD-ROM &[...]

1.1 Features 1 Hardware Overview Satellite M60 Series Maintenance Manua l [CONFIDENTIAL] 1-5 1.1 Features The Satellite M60 Series Persona l Computer uses exte nsive Large Scale Integration (LSI), and Complementary Metal-Oxide Semiconductor (C MOS) technology extensively to provide compact size, minimum weight and high reliability. This computer in[...]

1 Hardware Overview 1.1 Features 1-6 [CONFIDENTIAL] Satellite M60 Ma intenance Manual  Memory • DDRII-400/533MHz specification compliant • Dual channel support • No On board memory • Two DDRII SODIMM with 256MB/512MB/1GB , • Max. upgrade to 2GB with 2 DDRII SODIMM Socket  BIOS • MB Flash ROM for system BIOS. • Suspend to RAM/Dis[...]

1.1 Features 1 Hardware Overview Satellite M60 Series Maintenance Manua l [CONFIDENTIAL] 1-7  Optional Devices • 256/512/1024MB SO-DIMM DDRII modules • Li-ION Battery Pack • AC adapter • USB FDD Kit  Keyboard The computer's keyboard layout is that of a 101/102-key enhanced keyboard. There are four types of keys: typewriter keys ,[...]

1 Hardware Overview 1.1 Features 1-8 [CONFIDENTIAL] Satellite M60 Ma intenance Manual  PC Card Slot • One type II card socket • 1.8" 10.5mm removable ATA Device • Card bus card or PC Care with hot insertion and removal • ACPI 1.1 Compliant. • Support 5V/3.3V PC Cards and 3.3V Cardbus cards. • Supports PCMCIA-ATA Specification. ?[...]

1.1 Features 1 Hardware Overview Satellite M60 Series Maintenance Manua l [CONFIDENTIAL] 1-9  Universal Serial Bus (USB) The computer has three Universal Serial Bu s (USB) ports that comply with the USB 2.0 standard, which enable data transfer speed s more than 40 times faster than USB 1.1 (which this computer also supports.) The USB dr ives may[...]

1 Hardware Overview 1.2 System Unit 1-10 [CONFIDENTIAL] Satellite M60 Ma intenance Manual 1.2 System Unit The system unit is composed of the following m ajor components:  Processor • Intel® Celeron® M CPU up to 1.5GHZ 0.09u, 1M L2, FSB 400MHz • Intel® Pentium® M CPU up to 2.13GHZ 0.09u, 2M L2, FSB 533MHz • Micro FC-PGA package CPU  [...]

1.2 System Unit 1 Hardware Overview Satellite M60 Series Maintenance Manua l [CONFIDENTIAL] 1-11  Audio subsystem • Realtek ALC250 for CODEC • 20-bit Stereo Digital-to-Analog Converters. • 18-bit Stereo Analog-to- Digital Converters. • Built-in 7 Bands of Digital Hardware Equalizer for Optimizing Speaker Response. • Supports double sam[...]

1 Hardware Overview 1.3 2.5-inch Hard Disk Drive 1.3 2.5-inch Hard Disk Drive The internal HDD is a random access non-volatile storage device. It has a non-removable 2.5- inch magnetic disk and mini-W inchester type magnetic heads. The computer supports HDDs up to 120 GB. The HDD is shown in Figure 1-1. Speci fications are listed in Table 1-1 Figur[...]

1.4 Optical device Drives 1 Hardware Overview Satellite M60 Series Maintenance Manua l [CONFIDENTIAL] 1-13 1.4 Optical device Drives • DVD-ROM & CD-RW drive • DVD Super Multi drive 1.4.1 CD-RW & DVD-ROM The combo drive accepts 12-cm (4.72-inch) and 8- cm (3.15-inch) discs. At maximum, the drive can play back a DVD at 8x speed, read CD-R[...]

1 Hardware Overview 1.4 Optical device Drives 1-14 [CONFIDENTIAL] Satellite M60 Ma intenance Manual 1.4.2 DVD Super Multi Double Layer The DVD Super Multi drive accepts 12-cm (4.72-inc h) and 8-cm (3.15-inch) discs. At maximum, the drive can play back a DVD at 8x speed, read CD-ROM at 24x speed, and write CD-R at 24x speed and CD-RW at 4x speed or [...]

1.5 Power Supply 1 Hardware Overview Satellite M60 Series Maintenance Manua l [CONFIDENTIAL] 1-15 1.5 Power Supply This specification defines the performance and ch aracteristic of 65W and 75W AC adapter power supply. It supplies a constant voltage 19V output source for M60 series notebook computer.  A/D conversion • The EC uses 10-bit samplin[...]

1 Hardware Overview 1.5 Power Supply 1-16 [CONFIDENTIAL] Satellite M60 Ma intenance Manual  Battery charging control • The EC controls the following. – The quick charging ON/OFF – The detection of full charge  Detection of the low battery • The EC detects the low battery point by the gas gauge. – LB10M = The system will be driven by[...]

1.6 Batteries 1 Hardware Overview Satellite M60 Series Maintenance Manua l [CONFIDENTIAL] 1-17 1.6 Batteries The computer has two types of battery:  Main battery pack (18650 size)  RTC battery The removable main battery pack is the compute r’s main power source when the AC adaptor is not attached. The battery specifications are listed in th[...]

1 Hardware Overview 1.6 Batteries 1-18 [CONFIDENTIAL] Satellite M60 Ma intenance Manual 1.6.1 Main Battery Battery charging is controlled by a power supply microprocessor that is mounted on the system board. The power supply microprocessor controls wh ether the charge is on or off and detects a full charge when the AC adaptor and battery are attach[...]

1.6 Batteries 1 Hardware Overview Satellite M60 Series Maintenance Manua l [CONFIDENTIAL] 1-19 1.6.2 RTC battery The RTC battery provides power to keep the curr ent date, time and other setup information in memory while the computer is turned off. The table below lists the charging time and data preservation period of the RTC battery. The RTC batte[...]

[CONFIDENTIAL] Chapter 2 Troubleshooting Procedures 2[...]

2 Troubleshooting Procedures 2-ii [CONFIDENTIAL] Satellite M60/M65 Series Maintenance Manual Chapter 2 Contents 2.1 Troubleshooting Introduction ..................................................................................... 2-1 2.2 Troubleshooting Flowchart .....................................................................................[...]

2 Troubleshooting Procedures Satellite M60/M65 Series Maintenance Manual [CONFIDENTIAL] 2-iii Figures Figure 2-1 Troubleshooting flowchart (1/2) .................................................................... 2-3 Figure 2-1 Troubleshooting flowchart (2/2) .................................................................... 2-4 Figure 2-2 Power[...]

[...]

2.1 Troubleshooting Introduction 2 Troubleshooting Procedures Satellite M60/M65 Series Mainten ance Manual [CONFIDENTIAL] 2-1 2.1 Troubleshooting Introduction Chapter 2 describes how to determine if a Fi eld Replaceable Unit (FRU) in the com puter is causing the computer to malfunction. The FRUs covered are: 1. Display 6. TouchPad 11. IEEE 1394 por[...]

2 Troubleshooting Procedures 2.2 Troubleshooting Flowchart 2-2 [CONFIDENTIAL] Satellite M60/M65 Series Mainten ance Manual 2.2 Troubleshooting Flowchart If you know the location of the ma lfunction, turn directly to the appropriate section of this chapter. If the problem is unspecified, use the fl owchart in Figure 2-1 as a guide for determ ining w[...]

2.3 Power Supply Troubleshooting 2 Troubleshooting Procedures Satellite M60/M65 Series Mainten ance Manual [CONFIDENTIAL] 2-3 STA R T C onnect t he A C ad apte r t o the D C - IN socket Is the D C -IN L E D o n ? Is th e B a tte ry L E D o n ? T u rn th e P o w e r sw itch o n I s t h e Po we r On LE D o n ? I s t he " T os hi ba" log o m[...]

2 Troubleshooting Procedures 2.2 Troubleshooting Flowchart 2-4 [CONFIDENTIAL] Satellite M60/M65 Series Mainten ance Manual A Does ty ped characters appear corre ctly? Insert the diagnostics disk into the FDD. Then run the diagno stics test program. Is the diagnostics test loaded? Allow each test to perform automatically Is an error detected by any [...]

2.3 Power Supply Troubleshooting 2 Troubleshooting Procedures Satellite M60/M65 Series Mainten ance Manual [CONFIDENTIAL] 2-5 If the diagnostics program cannot detect an erro r, the problem may be intermittent. The test program should be executed several times to isol ate the problem. W hen a problem has been located, perform the appropriate trou b[...]

2 Troubleshooting Procedures 2.2 Troubleshooting Flowchart 2-6 [CONFIDENTIAL] Satellite M60/M65 Series Mainten ance Manual Other problems that are not covered by the diag nostics program may be discovered by a user. 1. If an error is detected when using an ex ternal USB device, perform the External USB Devices Troubleshooting pr ocedures in Section[...]

2.3 Power Supply Troubleshooting 2 Troubleshooting Procedures Satellite M60/M65 Series Mainten ance Manual [CONFIDENTIAL] 2-7 2.3 Power Supply Troubleshooting ST AR T Are the D C - IN and B att er y L E D s lit? Can you tur n the com puter o n? A r e th e inte rn a l p o w er connecti ons secure? END Check P ower Supp l y Sta tus (Procedure 1) No Y[...]

2 Troubleshooting Procedures 2.2 Troubleshooting Flowchart 2-8 [CONFIDENTIAL] Satellite M60/M65 Series Mainten ance Manual The power supply controls many functions and com ponents. To determ ine if the power supply is functioning properly, start with Proc edure 1 and continue with the ot her Procedures as instructed. The flowchart in Figure 2-2 giv[...]

2.3 Power Supply Troubleshooting 2 Troubleshooting Procedures Satellite M60/M65 Series Mainten ance Manual [CONFIDENTIAL] 2-9 Table 2-2 DC-IN LED AC-IN LED Power supply status Solid on AC power exists (LED is solid green). Off No AC power exists. To check the power supply status, install a batter y pack and connect an AC adaptor to the DC-IN port o[...]

2 Troubleshooting Procedures 2.2 Troubleshooting Flowchart 2-10 [CONFIDENTIAL] Satellite M60/M65 Series Mainten ance Manual Procedure 3 Power supply connection check The power supply wiring diagram is shown below: AC adaptor Sys t e m boar d B a tte ry A C adaptor cord AC p o we r c o r d Any of the connectors may be disconnected. Perform Check 1. [...]

2.3 Power Supply Troubleshooting 2 Troubleshooting Procedures Satellite M60/M65 Series Mainten ance Manual [CONFIDENTIAL] 2-11 Procedure 4 Diagnostic check The power supply may not charge the battery pack. Perform the following procedures: 1. Reinstall the battery pack. 2. Attach the AC adaptor and turn on the power . If you cannot turn on the powe[...]

2 Troubleshooting Procedures 2.4 Display Troubleshooting 2-12 [CONFIDENTIAL] Satellite M60/M65 Series Mainten ance Manual 2.4 Display Troubleshooting P e rf orm ext ernal d i spl ay check (P ro ce du re 1 ) ST AR T D oes t he ext ernal d isp la y fun c tio n o k? Per f or m di agn ost i c c he ck (P ro ce du re 2 ) No Wa s a d i s p l a y pr obl em[...]

2.4 Display Troubleshooting 2 Troubleshooting Procedures Satellite M60/M65 Series Mainten ance Manual [CONFIDENTIAL] 2-13 This section describes how to determ ine if the computer’s display is functioning properly. The process is outlined in Figure 2-3. Start with Procedure 1 and continue with the other procedures as instructed. Procedure 1: Exter[...]

2 Troubleshooting Procedures 2.4 Display Troubleshooting 2-14 [CONFIDENTIAL] Satellite M60/M65 Series Mainten ance Manual Procedure 3 Connector and replacement check The FL inverter board, LCD module, and system board are connected to the display circuits. Any of these components may be dam aged. Refer to Chapter 4, Replacement Procedures, for inst[...]

2.5 Keyboard Troubleshooting 2 Troubleshooting Procedures Satellite M60/M65 Series Mainten ance Manual [CONFIDENTIAL] 2-15 2.5 Keyboard Troubleshooting P e rf orm ext ernal keybo ar d check (P ro ce du re 1 ) ST AR T D oes t he ext ernal keyboard f unct i o n ok? Per f or m di agn ost i c c he ck (P ro ce du re 2 ) W as a k ey boar d pr obl em de t[...]

2 Troubleshooting Procedures 2.5 Keyboard Troubleshooting 2-16 [CONFIDENTIAL] Satellite M60/M65 Series Mainten ance Manual To determine if the computer’s keyboard is functioning properly, perform the following procedures. Figure 2-5 outlines the p rocess. Start with Procedure 1 and co ntinue with the other procedures as instructed. Procedure 1: E[...]

2.6 External USB Devices Troubleshooting 2 Troubleshooting Procedures Satellite M60/M65 Series Mainten ance Manual [CONFIDENTIAL] 2-17 2.6 External USB Devices Troubleshooting R epl ace sys tem board (P ro ced ure 2) END O rig in a l U S B d e v i c e is fa ulty P erfo rm ex t e rna l d ev ice a nd connect i on check (P ro ced ure 1) ST AR T D o e [...]

2.6 External USB Devices Troubleshooting 2 Troubleshooting Procedures 2-18 [CONFIDENTIAL] Satellite M60/M65 Series Mainten ance Manual To determine if the computer’s external US B devices are functioning properly, perform the following procedures. Figure 2-6 outlines the proce ss. Start with Procedure 1 and continue as instructed. Procedure 1: Ex[...]

2.7 TV-Out Failure Troubleshootin g 2 Troubleshooting Procedures Satellite M60/M65 Series Mainten ance Manual [CONFIDENTIAL] 2-19 2.7 TV-Out Failure Troubleshooting P e rf orm T V connect i on check (P ro ced ure 1) ST AR T D oes r ep l acem ent T V cabl e f uncti on properl y? Per f or m TV s et ch e ck (P ro ced ure 2) R epl ace sys tem board END[...]

2 Troubleshooting Procedures 2.7 TV-Out Failure Troubleshooting 2-20 [CONFIDENTIAL] Satellite M60/M65 Series Mainten ance Manual To determine if the computer’s TV-out por t is functioning properly, perform the following procedures. Figure 2-7 outlines the p rocess. Start with Procedure 1 and co ntinue as instructed. Procedure 1: TV connection che[...]

2.8 Touch Pad Troubleshooting 2 Troubleshooting Procedures Satellite M60/M65 Series Mainten ance Manual [CONFIDENTIAL] 2-21 2.8 TouchPad Troubleshooting START END To uchP a d co nnect i o n check (Procedure 1) TouchPad replacemen t check (Procedure 2) Replace sy stem board Figure 2-7 TouchPad troubleshooting process[...]

2 Troubleshooting Procedures 2.8 TouchPad Troubleshooting 2-22 [CONFIDENTIAL] Satellite M60/M65 Series Mainten ance Manual To determine if the computer’s built-in TouchP ad is functioning properly, perform the following procedures. Figure 2-9 outlines the p rocess. Start with Procedure 1 and co ntinue as instructed. Procedure 1: TouchPad connecti[...]

2.9 Speaker Troubleshooting 2 Tr oubleshooting Procedures Satellite M60/M65 Series Mainten ance Manual [CONFIDENTIAL] 2-23 2.9 Speaker Troubleshooting START Do al l sour ces ha ve sam e problem? END Per form ea rpho ne te st (Procedure 2 ) Do earphones function correctly ? Perform connection ch eck (Procedure 3 ) Perform replacement check (Procedur[...]

2 Troubleshooting Procedures 2.9 Speaker Troubleshooting 2-24 [CONFIDENTIAL] Satellite M60/M65 Series Mainten ance Manual To determine if the computer’s built-in speaker s are functioning properly, perform the following procedures. Figure 2-10 outlines the process. Firs t adjust the s peaker volume to an appropriate level. Start with Procedure 1 [...]

2.10 Optical Drive Troubleshooting 2 Troubleshooting Procedures 2.10 Optical Drive Troubleshooting START Audio CD fu nctions ok? END Perform softw are check (Procedure 3) Perform diagnostic test (Procedure 4) Perfo rm connection and replacem e nt check (Procedure 5) Perfor m a udio C D che ck (Procedure 1) Perf orm drive- cleaning chec k (Procedu r[...]

2 Troubleshooting Procedures 2.10 Optical Drive Troubleshooting 2-28 [CONFIDENTIAL] Satellite M60/M65 Series Ma in tenance Manual This section describes how to determ ine if the computer’s internal optic al drive is functioning properly. The Satellite P10 module bays can accommodate the following optical driv es: • DVD-R/RW device • DVD-ROM d[...]

2.10 Optical Drive Troubleshooting 2 Troubleshooting Procedures Satellite M60/M65 Series Ma in tenance Manual [CONFIDENTIAL] 2-29 Procedure 5 Connection check and replacement check The optical drive connects to the system board. Th e drive may be disconnected, or the drive or system board may be dam aged. Disassemble th e computer following the ste[...]

2 Troubleshooting Procedures 2.11 Modem Troubleshooting 2.11 Modem Troubleshooting ST ART Com p uter un able to detect t eleph one si gnal ? END Perform connection check (Procedure 2) Perform replacemen t check (Procedure 3) Perform telephone line connection check (Procedure 1) Check / replac e teleph one line and connect ions Yes Replace sy stem b[...]

2.11 Modem Troubleshooting 2 Troubleshooting Procedures Satellite M60/M65 Series Ma in tenance Manual [CONFIDENTIAL] 2-31 This section describes how to determ ine if th e computer's modem is functioning properly. Figure 2-12 outlines the process. Perform the steps belo w starting with Procedure 1 and continuing with the other procedures as req[...]

2 Troubleshooting Procedures 2.12 PCMCIA Troubleshooting 2.12 PCMCIA Troubleshooting ST ART Do errors occu r during SYCARD t est? Perform PCMCIA sock et replacem ent che ck (Procedure 2) Replace sys tem board END PCMCIA un it is not faulty. Perform SYCARD test (Procedure 1) No Yes Figure 2-11 PCMCIA troubleshooting process 2-32 [CONFIDENTIAL] Satel[...]

2.12 PCMCIA Troubleshooting 2 Troubleshooting Procedures Satellite M60/M65 Series Ma in tenance Manual [CONFIDENTIAL] 2-33 This section describes how to determ ine if the PCMCIA card player is functioning properly. The process is summarized in Figure 2-13. Perform the steps below starting with Procedure 1 and continuing with the other procedures as[...]

2 Troubleshooting Procedures 2.13 IEEE 1394 Troubleshooting 2.13 IEEE 1394 Troubleshooting START Perf orm IEEE 1394 de vic e che ck (Pro ce d ure 1) I s I EEE 1394 t ra nsmiss ion ok ? Perform diagno stic check (Pro ce d ure 2) W as an I EEE 1394 pr oble m dete cte d? Perform connection and replacem ent check (Pro ce d ure 3) Replace system board E[...]

2.13 IEEE 1394 Troubleshooting 2 Troubleshooting Procedures Satellite M60/M65 Series Ma in tenance Manual [CONFIDENTIAL] 2-35 To determine if the computer’s IEEE 1394 syst em is functioning properly, perform the following procedures. Figure 2-14 outlines the process. Start with Procedure 1 and c ontinue with the other procedures as instructed. Pr[...]

2 Troubleshooting Procedures 2.14 Wireless LAN Troubleshooting 2.14 Wireless LAN Troubleshooting START Perform diagnostic test (Procedure 1) Was a w ireless L AN prob lem delec ted? Perform connector and replacement check (Procedure 2) Repl ace wirel ess LAN anten na/uni t Replace sy stem board END Yes Wirele ss L AN sy stem is not faulty . Continu[...]

2.14 Wireless LAN Troubleshooting 2 Troubleshooting Procedures Satellite M60/M65 Series Ma in tenance Manual [CONFIDENTIAL] 2-13 Figure 2-13 Wireless LAN troubleshooting process[...]

2 Troubleshooting Procedures 2.14 Wireless LAN Troubleshooting 2-14 [CONFIDENTIAL] Satellite M60/M65 Series Ma in tenance Manual The wireless LAN antenna wire, wireless LAN unit or system board m ay each be the source of a wireless LAN fault. Any of these components ma y be damaged. To determine if the com puter’s wireless LAN system is func tion[...]

2.14 Wireless LAN Troubleshooting 2 Troubleshooting Procedures 2.15 Express Card Troubleshooting START Do errors occur during Express CARD test? Perform Express card soc ket repl acement check (Procedure 2) Replac e system board END Express unit is not faulty. Perform Express CARD te st (Procedure 1) No Yes Figure 2-14 Express card troubleshooting [...]

2 Troubleshooting Procedures 2.14 Wireless LAN Troubleshooting 2-16 [CONFIDENTIAL] Satellite M60/M65 Series Ma in tenance Manual This section describes how to determ ine if the Express card player is functioning properly. The process is summarized in Figure 2-14. Perform the steps below starting with Procedure 1 and continuing with the other proced[...]

2.14 Wireless LAN Troubleshooting 2 Troubleshooting Procedures 2.12 Bluetooth Troubleshooting ST A R T P r e f or m di agn os t i c t e s t (P ro c e d u re 1 ) W as a Bl uet oot h pr obl em de t ect ? Bl uet oot h i s not f a ul t y . C ont i nue t r oubl e s hoot i ng- r e f e r t o Fi gur e 2. 1 R epl a c e s y s t e m boa r d P e r f or m c onn[...]

2 Troubleshooting Procedures 2.14 Wireless LAN Troubleshooting 2-18 [CONFIDENTIAL] Satellite M60/M65 Series Ma in tenance Manual The Bluetooth antenna wire, Bluetooth module or system board may be the reason of a Bluetooth fault. Any of these components may be damaged. To determine if the computer’s Bluetooth is functioning properly, perform the [...]

Chapter 3 Test and Diagnostic Operation Handbook Version 1.0 Write by: Handsome May. 20 2005 released [CONFIDENTIAL][...]

Test and Diagnostic Operation ii [CONFIDENTIAL] Satellite M60/M65 Series T&D Operation Handbook Contents 1. The Diagnostic Test .......................................................................................................1 2. Executing the Diagnostic Test ................................................................................[...]

Test and Diagnostic Operation Satellite M60/M65 Series T&D Operation Handbook [CONFIDENTIAL] 1 1. The Diagnostic Test This chapter explains how to use the Test & Diagnostic program ( based on Charlotte10 T&D Version: 1.0 ) to test the functions of the computer’s hardware modules. The Test & Diagnostic Program is stored on the T&am[...]

Tests and Diagnostics Operation 2 [CONFIDENTIAL] Satellite M60/M65 Series T&D Operation Handbook 2. Executing the Diagnostic Test Toshiba MS-DOS is required to run the DIAGNOSTICS PROGRAM. To start the DIAGNOSTIC PROGRAM, follow these steps: 1. Insert the diagnostics diskette #1 in the floppy disk drive and turn on the computer. (The diagnostic[...]

Test and Diagnostic Operation If the test result passes, the following display will show up: Satellite M60/M65 Series T&D Operation Handbook [CONFIDENTIAL] 3[...]

Tests and Diagnostics Operation If an error is detected and a test fails, the following message displays: Then press any key for next actions – the below display presented if copying test log file onto diskette is necessary. This action will be executed when “ Y ” key pressed. 4 [CONFIDENTIAL] Satellite M60/M65 Series T&D Operation Handbo[...]

Test and Diagnostic Operation It will skip this process if “ N ” key pressed. And then it will check if it’s necessary to leave this program. Program will quit when “ Y ” key pressed and it will go back main menu f or next test if “ N ” key pressed. NOTE : Press Pause to pause a test and Enter to resume. Satellite M60/M65 Series T&[...]

Test and Diagnostic Operation 6 [CONFIDENTIAL] Satellite M60/M65 Series T&D Operation Handbook 2.1. Config Check Test The config check test checks unit configuration. It includes:  CPU type (P4/CEL; Dothan; Cache ; CPU speed ;CPU FSB)  System mem ory size (*** MB)  ODD type (DVD-SuperMulti; COMBO; …)  LCD Type (AU&LG/17.0WXGA&[...]

3.3 Parallel Port Test 3 Tests and Diagnostics Satellite M60/M65 Series T&D Operation Handbook [CONFIDENTIAL] 7[...]

3 Tests and Diagnostics 3.12 Touch Pad test 2.2. DMI Check Test This test will check if the computer’s Desktop Management Interface (DMI) is correct. DMI includes:  Manufacturer  Production Name  Version  Serial Number  UUID  OEM String It needs to input unit Part Number by manual, then show this unit DMI inform ation and makes [...]

Test and Diagnostic Operation 2.3. Speaker Audio Test The speaker audio test allows the user to aurally confirm the speaker functions. And check both speakers if they are OK within 3 times “Beep” sound generated. NOTE : Remember to tune up the volume as “ Maximum ” before this test starts. The screen should display as below, indicating whet[...]

Test and Diagnostic Operation 2.4. Fan ON/OFF Test The fan test allows the user to test aurally whether the fan is working. And follow the below procedures for this test:  The computer will let the fan be “ON” after any key pressed. Listen to check whether the fan is working. NOTE : Remember to approach fan outlet that is near right side of [...]

Test and Diagnostic Operation 2.5. Main Battery Charge Test NOTE : The AC adaptor ( 75W, 19V ) should be connected to successfully run this test. This test shows and measures the main battery:  Battery type ( Lion)  Manufacturer (Sanyo)  Remain charge capacity (0 ~ 100%)  Charge function (PASS/FAIL) - “Battery Is Full” showed when ?[...]

3 Tests and Diagnostics 3.5 Floppy Disk Test 12 [CONFIDENTIAL] Satellite M60/M65 Series T&D Operation Handbook 2.6. FDD Test NOTE : Before running the FDD test, prepare a formatted work diskette (1.44 MB). Remove the diagnostics diskette and insert the work diskette into the FDD. The contents of the floppy diskette maybe erased. The Floppy Disk[...]

Test and Diagnostic Operation Satellite M60/M65 Series T&D Operation Handbook [CONFIDENTIAL] 13[...]

Test and Diagnostic Operation 2. 7. CD-ROM Test The CD-ROM test allows a user to aurally confirm the CD-ROM functions. NOTE : A CD disc (including data file) must be inserted into the CD-ROM drive before this test starts. The CD-ROM test includes two subtests of the: 1. Random read/partial sequential read function 2. Sequential read function (for a[...]

Test and Diagnostic Operation 2. 8. Keyboard Test The keyboard test checks the all keys function. NOTE: The Num Lock and the Overlay mode must be off to execute the keyboard test. When you execute this test, the keyboard layout is drawn on the display. W hen any key is pressed, the corresponding key on the screen changes to black as shown below. It[...]

Test and Diagnostic Operation Pressing a key also reveals that key’s scan codes in the upper right hand corner of the screen. When the key is depressed, its make code is displayed. When the key is released, the break code is shown. 16 [CONFIDENTIAL] Satellite M60/M65 Series T&D Operation Handbook[...]

Test and Diagnostic Operation 2. 9. Mouse (Pad) Test The Mouse test allows the user to select and assign values to the following, using the Touch Pad or “ Tab ” key to move between selections: 1. Mouse Speed (on a scale from slow to fast) 2. Acceleration (Off, Low, Medium, High) 3. Button Assignments (Left + Right / Right button, either Unassig[...]

Test and Diagnostic Operation 18 [CONFIDENTIAL] Satellite M60/M65 Series T&D Operation Handbook It will indicate whether the subtests pass or fail after three questions. NOTE: The above figure has three compartments although the Touch Pad installed may only have two buttons. In this case, the central compartment in the figure does not correspon[...]

Test and Diagnostic Operation 2. 10. LCD Pixels Mode Test This LCD pixels mode test checks whether video display is fine. This test includes two modes of the test: 1. Text Mode - including 40*25 (16 colors) and 80*25 (2/16colors). 2. VGA Mode - including 320*200 (4/16/256 colors), 640*200 (2/16 colors), 640*350 (2/16 colors), 640*480 (2/16/256 colo[...]

Test and Diagnostic Operation 2. 11. Lid Switch Test The lid switch test checks the lid function of the unit. When LCD cover closed, the lid should enable to turn off the display. NOTE : Remember to tune up the volume as “ Maximum ” before this test starts. Follow below steps to run this test: 1. Close the LCD cover. 2. Heard 3 “Beep” sound[...]

Test and Diagnostic Operation 2. 12. HDD R/W Test The HDD R/W test allows the user to test aurally HDD read/write function. For data security concern, it is necessary to input password - “ hard disk ” before HDD write test starts. The HDD test includes three subtests of the: 1. Sequential read (all surface) 2. Sequential write (all surface) 3. [...]

Test and Diagnostic Operation 22 [CONFIDENTIAL] Satellite M60/M65 Series T&D Operation Handbook NOTE : Press “ Ctrl + Break ” keys can terminate the current subtest. The screen should display as previous picture, indicating whether the subtest is passed or failed when finished. NOTE : The AC adaptor should be connected to successfully run t[...]

Test and Diagnostic Operation Satellite M60/M65 Series T&D Operation Handbook [CONFIDENTIAL] 23 2. 13. LAN Test The LAN test checks the LAN full-duplex environment. NOTE: LAN loopback needs to plug in before test begins. And LAN information will show on the test screen:  IO Base – Port: 3000H  IRQ – AH, it’s “IRQ 10”.  Node ?[...]

Test and Diagnostic Operation The screen should display as below, indicating whether the subtests pass or fail when finished. 24 [CONFIDENTIAL] Satellite M60/M65 Series T&D Operation Handbook[...]

Test and Diagnostic Operation 2. 14. RTC Test Checks the computer’s RTC (Real Time Clock) and calendar functions by com paring the DOS and CMOS values. The test runs automatically. The screen should display as below, indicating whether the test is passed or failed when finished. Satellite M60/M65 Series T&D Operation Handbook [CONFIDENTIAL] 2[...]

3 Tests and Diagnostics 3.13 System Running Test .2. 15. CD Control Button Test The CD control button test allows the user to manually test each of the five CD control buttons and one Internet button. Key ”WWW” nee d to pr ess fi rst . On e w ill hear one “bi” sound when press ”WWW” or “Audio” sound, and continuously “bi” sound [...]

Test and Diagnostic Operation 2. 16. Speaker EQ Type Check&Re-Write This test will check if the computer’s EEPROM EQ type is correct. The EQ Type test includes two subtests of the: 1. Read EQ Type from EEPROM 2. Re-Write EQ Type to EEPROM NOTE : To execute this test, you must select speaker type (Harman or No brand). The Item1 figure below wi[...]

3 Tests and Diagnostics 3.13 System Running Test The Item2 figure below will be displayed NOTE : Write speaker EQ must reboot to enable EQ. 28 [CONFIDENTIAL] Satellite M60/M65 Series T&D Operation Handbook[...]

Test and Diagnostic Operation 2. 17. Read 1394 GUID This test will check if the computer’s EEPROM 1394GUID code is correct. NOTE: Must open the RAM Door to see RAM connector GUID bar code before test item begins. The figure below will be displayed Satellite M60/M65 Series T&D Operation Handbook [CONFIDENTIAL] 29[...]

3 Tests and Diagnostics 3.13 System Running Test 30 [CONFIDENTIAL] Satellite M60/M65 Series T&D Operation Handbook[...]

[CONFIDENTIAL] 4 Chapter 4 Replacement Procedures[...]

4 Replacement Procedures 4-ii [CONFIDENTIAL] Satellite M60 Series Maintenance Manual[...]

4 Replacement Procedures Satellite M60 Series Maintenance Manual [CONFIDENTIAL] 4-iii Chapter 4 Contents 4.1 General ....................................................................................................................... 4-5 4.2 Battery .................................................................................................[...]

4 Replacement Procedures 4-iv [CONFIDENTIAL] Satellite M60 Series Maintenance Manual Figures Figure 4-1 Removing the battery pack ................................................................................. 4-11 Figure 4-2 Pressing the eject button ..................................................................................... 4-13 Figur[...]

4 Replacement Procedures Satellite M60 Series Maintenance Manual [CONFIDENTIAL] 4-5 4.1 General This chapter explains how to disassemble the computer and replace Field Replaceable Units (FRUs). It may not be necessary to remove all the FRUs in order to replace one. The chart below is a guide to which FRUs need to be removed in order to remove other[...]

4 Replacement Procedures 4-6 [CONFIDENTIAL] Satellite M60 Series Maintenance Manual The example below shows FRUs to be removed before the Direct Play button board can be removed and repaired or replaced. The Direct Play button board is overlapped by the top cover which must be removed before the Direct Play button board can be reached. The rem ovab[...]

4 Replacement Procedures Satellite M60 Series Maintenance Manual [CONFIDENTIAL] 4-7 Safety Precautions Before you begin disassembly, read the following safety precautions and observe them carefully as you work. DANGER: 1 . Always use the lithium ion battery pack or backup battery that is authorized by Toshiba or compatible with the unit. Since othe[...]

4 Replacement Procedures 4-8 [CONFIDENTIAL] Satellite M60 Series Maintenance Manual Before You Begin Look over the procedures in this section before you begin disassembling the computer. Familiarize yourself with the disassembly and reassem bly steps. Begin each procedure by removing the AC adaptor and the battery pack as instructed in section 4.2.[...]

4 Replacement Procedures Satellite M60 Series Maintenance Manual [CONFIDENTIAL] 4-9 Disassembly Procedures The computer has two basic types of cable connectors:  Pressure Plate Connectors  Standard Pin Connectors To disconnect a Pressure Plate connector, lift up the tabs on either side of the connector’s plastic pressure plate and slide the[...]

4 Replacement Procedures 4-10 [CONFIDENTIAL] Satellite M60 Series Maintenance Manual Tools and Equipment The use of Electrostatic Discharge (ESD) equipment is very important for your safety and the safety of those around you. Proper use of these devices will increase the success rate of your repairs and lower the cost for damaged or destroyed parts[...]

4 Replacement Procedures 4.2 Battery Removing the Battery Pack To remove the battery pack from the battery bay, follow the steps below. 1. Turn the computer upside down. 2. Unlock the battery double lock and slide the battery bay latch to release the battery pack. Then you can remove it from the bay. Figure 4-1 Removing the battery pack NOTE: For e[...]

4 Replacement Procedures 4-12 [CONFIDENTIAL] Satellite M60 Series Maintenance Manual Installing the Battery Pack To install the battery pack in the battery bay, follow the steps below and refer to the figure in the preceding section. WARNING: The battery is a lithium ion battery and can explode if not properly replaced, used, handled or disposed of[...]

4 Replacement Procedures 4.3 PC Card Removing a PC Card To remove a PC Card, follow the steps below. 1. Click the Safely Remove Hardware icon on the Task Bar. 2. Click the PC Card you want to remove. 3. Press the eject button of the PC Card to extend it. 4. Press the extended eject button to pop the card out slightly. 5. Grasp the PC Card and remov[...]

4 Replacement Procedures Installing the PC Card To install the PC Card, follow the steps below and refer to the figures in the preceding section. 1. Insert the PC Card. 2. Press gently to ensure a firm connection. Figure 4-3 Installing the PC card 4-14 [CONFIDENTIAL] Satellite M60 Series Maintenance Manual[...]

4 Replacement Procedures 4.4 HDD CAUTION : When handling the HDD, do not press the top surface as shown by the arrow. Hold it by the sides. Figure 4-4 HDD Removing the HDD Module Follow the steps below to remove HDD module: 1. Turn the computer upside down 2. Remove two black M2.5x4 security screws to release the HDD door. 3. Pull on the tab to rem[...]

4 Replacement Procedures Figure 4-5 Removing the HDD door 4. Remove four M3x3 silver screws that secure the HDD case and bracket to the HDD. 5. Remove the HDD from the HDD case. 4-16 [CONFIDENTIAL] Satellite M60 Series Maintenance Manual[...]

4 Replacement Procedures Satellite M60 Series Maintenance Manual [CONFIDENTIAL] 4-17 Installing the HDD To install the HDD, follow the steps below and refer to the figures in the preceding section. 1. Seat the HDD in the HDD case and bracket, and secure it with two M3 × 3 black screws. 2. Insert the HDD unit into the HDD slot. 3. Secure the HDD do[...]

4 Replacement Procedures 4.5 Optical Drive Module Removing the Optical Drive Module To remove the optical drive module, you need to rem ove the keyboard first. Follow the steps below: 1. Turn the computer upside down. 2. Remove the screw M2.5x4 securing the optical drive module. 3. Use your hand to pull the module and then you can slide the module [...]

4 Replacement Procedures Satellite M60 Series Maintenance Manual [CONFIDENTIAL] 4-19 Installing the Optical Drive Module To install a device in the optical drive module bay, follow the steps below and refer to the figure in the preceding section. 1. Slide the device into the optical drive module bay. 2. Use the screw M2.5x4 to secure the optical dr[...]

4 Replacement Procedures 4.6 Optical Drive This computer may be fitted with a: CD-RW/DVD-ROM device DVD dual device DVD Super Multi device Disassembling the Optical Drive To disassemble the optical drive, first remove the drive from its module bay, then follow the steps below. 1. Remove two M2x3 screws from the bracket plate. Rem ove the bracket pl[...]

4 Replacement Procedures Satellite M60 Series Maintenance Manual [CONFIDENTIAL] 4-21 Reassembling the Optical Drive To reassemble an optical drive, follow the steps below and refer to the figure in the preceding section. 1. Position the optical drive bracket plate to the rear panel of optical drive. 2. Secure the optical drive bracket plate with tw[...]

4 Replacement Procedures 4.7 Keyboard Removing the Keyboard Follow the steps below to remove the keyboard: 1. Open the display panel. 2. Insert a thin tool into the gap between the strip cover and keyboard to lever the strip cover up and then release the strip cover. Figure 4-8 Removing the strip cover 4-22 [CONFIDENTIAL] Satellite M60 Series Maint[...]

4 Replacement Procedures 3. Remove four M2.5 x 3 black screws securing the keyboard. Push the center of the strip cover and lift the keyboard out and place over the display hinges, revealing the keyboard cable. (Note: There are 6 screw holes, but only 4 are used.) Figure 4-9 Removing the keyboard Satellite M60 Series Maintenance Manual [CONFIDENTIA[...]

4 Replacement Procedures 4. Disconnect the keyboard cable and remove the keyboard. Figure 4-10 Disconnecting the keyboard cable Installing the Keyboard To install the keyboard, follow the steps below and refer to the figures in the preceding section. 1. Connect the keyboard cable to the system board. 2. Set the keyboard in place and secure it with [...]

4 Replacement Procedures 4.8 Wireless LAN Unit Removing the Wireless LAN Unit To remove wireless LAN unit, you must rem ove strip cover and keyboard first, then follow the steps below to remove wireless LAN unit. 1. Remove the embedded M2.5x4 screw securing the wireless LAN door, and then rem ove it. 2. Remove one M2x3 screw securing the Mini-PCI S[...]

4 Replacement Procedures Figure 4-12 Removing the wireless LAN unit CAUTION : Do not touch the connectors on the wireless LAN unit or on the computer. Debris on the connectors may cause malfunction. Installing the Wireless LAN Unit To install the wireless LAN unit, follow the steps below and refer to the figures in the preceding section. 1. Remove [...]

4 Replacement Procedures 4.9 Expansion Memory Removing the Expansion Memory To remove the mem ory module, make sure the com puter is in boot mode then remove the wireless LAN compartment cover: 1. Push the latches securing the memory m odule to the outside to release it. A spring will force one end of the module up. 2. Grasp the module and pull it [...]

4 Replacement Procedures Installing the Expansion Memory CAUTION : Do not touch the connectors on the expansion memory or on the computer. Debris on the connectors may cause memory access problems. To install a memory m odule, follow the steps below and refer to the figures in the preceding section: 1. Fit the module's connectors into the com [...]

4 Replacement Procedures 4.10 Modem Removing the Modem To remove the installed modem , first remove the wireless LAN com partment cover, then follow the steps below: 1. Remove two M2x3 screws securing the modem module. 2. Carefully lift the unit off its connector 3. Disconnect the modem cable from the modem m odule. Figure 4-15 Removing the modem m[...]

4 Replacement Procedures 4-30 [CONFIDENTIAL] Satellite M60 Series Maintenance Manual Installing the Modem To install a modem, follow the steps below and refer to the figures in the preceding section. 1. Connect the modem cable to the m odem module. 2. Fit the modem onto its connector and secure it with two black M2x3 screws.[...]

4 Replacement Procedures 4.11 Display Assembly Removing the Display Assembly To remove the display assembly, first rem ove the keyboard and wireless LAN, then follow the steps below: 1. Disconnect the LCD power cable from the top chassis. Figure 4-16 Disconnecting the LCD cable 2. From the backside, remove two M2.5x6 screws securing the LCD. 3. Rem[...]

4 Replacement Procedures Figure 4-17 Removing the display assembly 4-32 [CONFIDENTIAL] Satellite M60 Series Maintenance Manual[...]

4 Replacement Procedures Satellite M60 Series Maintenance Manual [CONFIDENTIAL] 4-33 Installing the Display Assembly To install the display assembly, follow the steps below and refer to the figures in the preceding section. 1. Seat the display assembly taking care not to crush to the LCD display cable, the LCD power cable, or wireless LAN antenna. [...]

4 Replacement Procedures 4.12 Top Cover Removing the Cover To remove the top cover, first remove the battery pack, keyboard, display assem bly, optical drive module, HDD, and mem ory module and wireless LAN as described in the preceding sections, then follow the steps below: 1. Remove three M2.5x15 screws and one M2.5x6 screw securing top cover. Fi[...]

4 Replacement Procedures Figure 4-19 Removing the top cover-2 4. Turn the computer upright to lift off the top cover. Satellite M60 Series Maintenance Manual [CONFIDENTIAL] 4-35[...]

4 Replacement Procedures 4-36 [CONFIDENTIAL] Satellite M60 Series Maintenance Manual Installing the Top Cover To install the top cover, follow the steps below and refer to the figures in the preceding section. 1. Seat the top cover and secure the upper FFC cable and Touch pad FFC cable to the computer’s top chassis. 2. Secure the top cover with t[...]

4 Replacement Procedures 4.13 TouchPad Removing the TouchPad To remove the TouchPad, first remove the top cover, then follow the steps below: 1. Disconnect the TouchPad FFC cable from the TouchPad. 2. Remove two M2.5x3 black screws securing the control button board. Slide it and lift it out. 3. Remove one M2.5x3 screw securing the TrackPad Bracket.[...]

4 Replacement Procedures 4-38 [CONFIDENTIAL] Satellite M60 Series Maintenance Manual Installing the TouchPad To install the TouchPad, follow the steps below and refer to the figures in the preceding section: 1. With the top cover upside down, place the TouchPad, the Track Pad Bracket, and control button board in position. 2. Secure the Track Pad Br[...]

4 Replacement Procedures 4.14 Speakers Removing the Speakers To remove the speakers, first remove the top cover, then follow the steps below: 1. Remove the four M2.5x4 screws. 2. Disconnect the speaker cable from the system board. Figure 4-21 Removing the speakers 3. Lift out the speakers. Installing the Speakers To install the speakers, follow the[...]

4 Replacement Procedures 4-40 [CONFIDENTIAL] Satellite M60 Series Maintenance Manual 3. Attach the speaker cable to the system board.[...]

4 Replacement Procedures 4.15 System Board Removing the System Board To remove the system board, first rem ove the LCD assembly, top cover and HDD, then follow the steps below: 1. Remove two M2.5x4 screws from the system board. Figure 4-22 Removing the system board 2. Remove two hexagonal screws from the back of the system board. Figure 4-23 Removi[...]

4 Replacement Procedures 4-42 [CONFIDENTIAL] Satellite M60 Series Maintenance Manual Installing the System Board To install the system board, follow the steps below and refer to the figures in the preceding section. 1. Seat the system board in the chassis. 2. Secure two hexagonal screws to the back of the system board. 3. Secure two M2.5x4 screws t[...]

4 Replacement Procedures 4.16 Fan & CPU Removing the Fan & CPU To remove the Fan, Heat Sink, and CPU, you must first rem ove the panel, keyboard, top cover and bottom chassis to reveal the system board, then follow the steps below: 1. Remove two M2.5x4 fan screws and then lift out the fan. Figure 4-24 Removing the hexagonal screws 2. Remove[...]

4 Replacement Procedures 3. Turn the CPU screw cam to loosen it, then lift it out. Figure 4-25 Removing the CPU 4-44 [CONFIDENTIAL] Satellite M60 Series Maintenance Manual[...]

4 Replacement Procedures Satellite M60 Series Maintenance Manual [CONFIDENTIAL] 4-45 Installing the CPU To install the CPU, follow the steps below and refer to the figures in the preceding section. CAUTION: If you remove the heat sink, you should use the CPU grease tool to remove the grease on the CPU and heat sink. Reapply fresh grease before inst[...]

4 Replacement Procedures 4.17 Display Mask Removing the Display Mask To remove the display mask, first rem ove the display assembly as described earlier, then follow the steps below: 1. Remove the mask seals to expose four lower inner corner screws securing the display m ask. 2. Remove four M2.5x4 black screws from the corners that were previously [...]

4 Replacement Procedures Satellite M60 Series Maintenance Manual [CONFIDENTIAL] 4-47 Installing the Display Mask To install the display mask, follow the steps below and refer to the figures in the preceding section. 1. Seat the display mask and secure the snaps on each side. 2. Secure the display mask with four M2.5x4 screws at the bottom inner cor[...]

4 Replacement Procedures 4.18 LCD Module Removing the LCD Module To remove the LCD module, first rem ove the display assembly and display mask, then follow the steps below. 1. Remove two M2x3 black screws securing the LCD cable and FL inverter board. 2. Disconnect the LCD cable from the FL inverter board. 3. Remove two M2.5x6 black screws securing [...]

4 Replacement Procedures Satellite M60 Series Maintenance Manual [CONFIDENTIAL] 4-49 5. Remove six M2x3 screws securing LCD module bracket to LCD m odule. Remove LCD cable. NOTE : If the LCD module malfunctions, remove the LCD cable and LCD bracket. Then replace the whole LCD module unit.[...]

4 Replacement Procedures 4-50 [CONFIDENTIAL] Satellite M60 Series Maintenance Manual Installing the LCD Module To install the LCD module, follow the steps below and refer to the figures in the preceding section. 1. Set the LCD module in the display assembly. 2. Connect the FL cable and the HV cable to the FL inverter board. 3. Seat the LCD module i[...]

4 Replacement Procedures 4.19 FL Inverter Board Removing the FL Inverter Board To remove the FL inverter board, first remove the battery pack, the display assem bly, display mask, and LCD module, then follow the steps below. 1. Remove one M2x3 black screw securing the FL invert board to the LCD display assembly. Figure 4-28 Removing the FL inverter[...]

[CONFIDENTIAL] Appendices[...]

Appendices App-ii [CONFIDENTIAL] Satellite M60 Series Maintenance Manua l[...]

Satellite M60 Series Maintenance Manual [CONFIDENTIAL] App-iii Appendix Contents Appendix A Handling the LCD Module ............................................................................... A-1 System Board (FRDSY*) Bottom View ......................................................................... B-2 PJP2 BATT Connector pin assignments (7[...]

Appendices App-iv [CONFIDENTIAL] Satellite M60 Series Maintenance Manua l Appendix D Keyboard Scan/Character Codes..................................................................... D-1 ppendix E Key Layout ......................................................................................................... E -1 ppendix F Series Screw Torque [...]

Appendix A Appendix A Handling the LCD Module Precautions for handling the LCD module The LCD module can be easily damaged during assem bly or disassembly. Therefore, please observe the following precautions when handling it: 1. When installing the LCD module in the LCD cover, be sure to seat it so that it is properly aligned and maximum visibility[...]

3. If the panel’s surface gets dirty, wipe it with cotton or a soft cloth. If it is still dirty, try breathing on the surface to create a light condensate and wipe it again. If the surface is very dirty, we recommend a CRT cleaning agent. Apply the agent to a cloth and then wipe the panel’s surface. Do not apply cleanser directly to the panel. [...]

5. Glass is used in the panel, so be careful not to drop it or let it strike a hard object, which could cause breakage or cracks. 6. CMOS-LSI circuits are used in the module, so guard against damage from electrostatic discharge. Be sure to wear a wrist or ankle ground when handling the module. Satellite M40X Series Maintenance Manual A-3[...]

7. Do not expose the module to direct sunlight or strong ultraviolet rays for long periods. 8. Do not store the module at temperatures be low specifications. Cold can cause the liquid crystals to freeze, lose their elasticity or otherwise suffer damage. 9. Do not disassemble the LCD module. Disassem bly can cause malfunctions. A-4 [CONFIDENTIAL] Sa[...]

10. If you transport the module, do not use packing material that contains epoxy resin (am ine) or silicon glue (alcohol or oxime). These materials can release gas that can dam age the panel’s polarization. Satellite M40X Series Maintenance Manual A-5[...]

A-6 [CONFIDENTIAL] Satellite M40X Series Maintenance Manual[...]

Appendix B Appendix B Board Layout B.1 System Board (FRDSY*) T OP V iew JP1 A B JP5 JP2 JP4 PJP2 JP3 C JP8 JP9 I Satellite M40X Series Maintenance Manual [CONFIDENTIAL] B-1[...]

B.2 System Board (FRDSY*) BUTT O M View JP16 JP13 JP14 PJP1 JP15 JP18 JP19 D JP20 E JP22 JP24 JP27 JP26 JP23 G F JP31 JP30 H JP32 B-2 [CONFIDENTIAL] Satellite M40X Series Maintenance Manual[...]

Table B-1 System board ICs (top and bottom) Mark Number Name A U4 1394 TSB43AB21 B U7 Marrell 8036 C U18 Intel ICH6 D U34 Intel 915PM E U32 LAN CHIP F U38 ICS95226 G U40 Kb 910 H U43 AC97 CODEC ALC250-VD I U21 ENE 714 Satellite M40X Series Maintenance Manual [CONFIDENTIAL] B-3[...]

Table B-2 System board connectors (top and bottom) Number Name JP1 LVDS Connector JP2 POWER/B Connector JP3 FAN Connector JP4 T/P Connector JP5 KB Connector JP8 NEWCARD Connector JP9 AUDIO Connector JP10 HDD Connector JP13 CRT Connector JP14 Tv-out Connector JP15 LAN Connector JP16 USB Connector JP18 USB Connector JP19 VGA Connector JP22 1394 Conne[...]

C. Appendix C Pin Assignments System Board C.1 JP23, JP26 Table C-1 SODIMM I/F pin assignments (200-PIN) (1/4) Pin No. Signal name I/O Pin No. Signal Name I/O 1 VREF O 2 GND O 3 GND O 4 DDRA_SDQ4 I/O 5 DDRA_SDQ0 I/O 6 DDRA_SDQ2 I/O 7 DDRA_SDQ1 I/O 8 GND O 9 GND O 10 DDRA_SDM0 I/O 11 DDRA_SDQS0# I/O 12 GND O 13 DDRA_SDQS0 I/O 14 DDRA_SDQ6 I/O 15 GND[...]

Table C-1 SODIMM I/F pin assignments (200-PIN) (2/4) Pin No. Signal name I/O Pin No. Signal Name I/O 51 DDRA_SDQS2 I/O 52 DDRA_SDM2 I/O 53 GND O 54 GND O 55 DDRA_SDQ18 I/O 56 DDRA_SDQ22 I/O 57 DDRA_SDQ19 I/O 58 DDRA_SDQ23 I/O 59 GND O 60 GND O 61 DDRA_SDQ24 I/O 62 DDRA_SDQ28 I/O 63 DDRA_SDQ25 I/O 64 DDRA_SDQ29 I/O 65 GND O 66 GND O 67 DDRA_SDM3 I/O[...]

Table C-1 SODIMM I/F pin assignments (200-PIN) (3/4) Pin No. Signal name I/O Pin No. Signal Name I/O 115 DDRA_SCS#1 I/O 116 DDRA_SMA13 I/O 117 +1.8V O 118 +1.8V O 119 DDRA_ODT1 I/O 120 NC - 121 GND O 122 GND O 123 DDRA_SDQ32 I/O 124 DDRA_SDQ36 I/O 125 DDRA_SDQ33 I/O 126 DDRA_SDQ37 I/O 127 GND O 128 GND O 129 DDRA_SDQS4# I/O 130 DDRA_SDM4 I/O 131 DD[...]

Table C-1 SODIMM I/F pin assignments (200-PIN) (4/4) Pin No. Signal name I/O Pin No. Signal Name I/O 181 DDRA_SDQ57 I/O 182 DDRA_SDQ61 I/O 183 GND O 184 GND O 185 DDRA_SDM7 I/O 186 DDRA_SDQS7 # I/O 187 GND O 188 DDRA_SDQS7 I/O 189 DDRA_SDQ58 I/O 190 GND O 191 DDRA_SDQ59 I/O 192 DDRA_SDQ62 I/O 193 GND O 194 DDRA_SDQ63 I/O 195 D_CK_SDATA I/O 196 GND [...]

C.2 JP13 Table C-3 RGB I/F pin assignments (15-pin) Pin No. Signal name I/O Pin No. Signal Name I/O 1 CRT_R_L O 2 CRT_G_L O 3 CRT_B_L O 4 GND - 5 GND - 6 GND - 7 GND - 8 GND - 9 +CRT_VCC - 10 GND - 11 NC - 12 DSUB_12 I/O 13 HSYNC_L O 14 VSYNC_L O 15 DSUB_15 I/O Satellite M30X Series Maintenance Manual [CONFIDENTIAL] C-5[...]

C.3 JP24 Table C-4 HDD I/F pin assignments (44-pin) Pin No. Signal name I/O Pin No. Signal Name I/O 1 PIDE_HRESET# O 2 GND - 3 PIDE_HDD7 I/O 4 PIDE_HDD8 I/O 5 PIDE_HDD6 I/O 6 PIDE_HDD9 I/O 7 PIDE_HDD5 I/O 8 PIDE_HDD10 I/O 9 PIDE_HDD4 I/O 10 PIDE_HDD11 I/O 11 PIDE_HDD3 I/O 12 PIDE_HDD12 I/O 13 PIDE_HDD2 I/O 14 PIDE_HDD13 I/O 15 PIDE_HDD1 I/O 16 PIDE[...]

C.4 JP27 Table C-5 ODD I/F pin assignments (52-pin) Pin No. Signal name I/O Pin No. Signal Name I/O 1 INT_CD_L I 2 INT_CD_R I 3 CD_AGND - 4 GND - 5 SIDE_RST# O 6 SD_D8 I/O 7 SD_D7 I/O 8 SD_D9 I/O 9 SD_D6 I/O 10 SD_D10 I/O 11 SD_D5 I/O 12 SD_D11 I/O 13 SD_D4 I/O 14 SD_D12 I/O 15 SD_D3 I/O 16 SD_D13 I/O 17 SD_D2 I/O 18 SD_D14 I/O 19 SD_D1 I/O 20 SD_D[...]

C.5 JP12 Table C-7 PC Card I/F pin assignments (84-pin) (1/2) Pin No. Signal name I/O Pin No. Signal Name I/O 1 GND - 2 S1_D3 - 3 S1_D4 I/O 4 S1_D5 O 5 S1_D6 I/O 6 S1_D7 I/O 7 S1_CE1# I/O 8 S1_A10 I/O 9 S1_OE# I/O 10 S1_A11 I/O 11 S1_A9 I/O 12 S1_A8 I/O 13 S1_A13 I/O 14 S1_A14 I/O 15 S1_WE# I 16 S1_RDY# I/O 17 +S1_VCC I/O 18 +S1_VPP I 19 S1_A16 I 2[...]

Table C-7 PC Card I/F pin assignments (84-pin) (2/2) Pin No. Signal name I/O Pin No. Signal Name I/O 61 S1_REG# I/O 62 S1_BVD2 I/O 63 S1_BVD1 I/O 64 S1_D8 I/O 65 S1_D9 I/O 66 S1_D10 I 67 S1_CD2# - 68 GND - Satellite M30X Series Maintenance Manual [CONFIDENTIAL] C-9[...]

C.6 JP30 Table C-8 Mini PCI I/F pin assignments (124-pin) (1/2) Pin No. Signal name I/O Pin No. Signal Name I/O 1 NC - 2 NC - 3 NC - 4 NC - 5 NC - 6 NC - 7 NC - 8 NC - 9 NC - 10 NC - 11 NC - 12 NC - 13 SWITCH O 14 NC - 15 NC - 16 NC - 17 PCI_PIRQH# I 18 +5VS - 19 +3VS O 20 PCI_PIRQG# I 21 NC - 22 NC - 23 GND - 24 +3V O 25 CLK_PCI_MINI O 26 PCI_RST#[...]

Table C-8 Mini PCI I/F pin assignments (124-pin)(2/2) Pin No. Signal name I/O Pin No. Signal Name I/O 61 IRDY# I/O 62 GND - 63 +3.3V O 64 FRAME# I/O 65 PM_CLKRUN# I/O 66 TRDY# I/O 67 PCI_SERR# I/O 68 STOP# I/O 69 GND - 70 +3.3V O 71 PCI_PERR# O 72 DEVSEL# I/O 73 C/BE1# I/O 74 GND - 75 AD14 I/O 76 AD15 I/O 77 GND - 78 AD13 I/O 79 AD12 I/O 80 AD11 I/[...]

C.7 JP1 Table C-9 LVDS I/F pin assignments (30-pin) Pin No. Signal name I/O Pin No. Signal Name I/O 1 B+ - 2 B+ - 3 NC - 4 +3VS - 5 LCD_CLK - 6 LCD_DATA - 7 GND - 8 TZOUT0- -2 9 TZOYT0+ - 10 GND - 11 TZOUT1+ - 12 TZOUT1- - 13 GND O 14 TZOUT2+ - 15 TZOUT2- - 16 GND - 17 TZCLK- I 18 TZCLK+ - 19 GND O 20 LCD_ID# I 21 DAC_BRIG - 22 INVT_PWM - 23 DISPOF[...]

C.8 JP32 4IN1 CONN Pin No. Signal name I/O Pin No. Signal Name I/O 1 GND 2 MSBS_XDD1 3 MSD1_XDD6 4 MSD0_XDD2 5 MSD2_XDD5 6 MSINS# 7 MSD3_XDD3 8 MSCLK_XDRE # 9 VCC 10 GND 11 SDDA2_XDCL 12 SDDA3_XDD4 13 SDCM_XDALE 14 GND 15 VCC 16 SDCK_XDWE # 17 GND 18 NC 19 SDDA0_XDD7 20 SDDA1_XDD0 21 SDCD# 22 GND 23 XDCD# 24 GND 25 XDBSY# 26 MSCLK_XDRE # 27 XDCE# 2[...]

C.9 JP21 Table C-9-1 JP21 Fan I/F pin assignments (3-pin) Pin No. Signal name I/O Pin No. Signal Name I/O 1 FAN1_VOUT I 2 FAN-SPEED1 O 3 GND - C.10 PJP1 Table C-10 AC Adaptor Connector pin assignments (6-pin) Pin No. Signal name I/O Pin No. Signal Name I/O 1 DC_IN_S1 I 2 GND - 3 GND - 4 GND - 5 GND - 6 GND - C.1 1 JP14 Table C-11 S-Video Connector [...]

C.13 JP16 Table C-13 Double USB Connector pin assignments (12-pin) Pin No. Signal name I/O Pin No. Signal Name I/O 1 +USB_VCCA I 2 USB20_N0 I 3 5 7 9 11 USB20_P0 +USB_VCCA USB20_P2 GND GND I - - I - 4 6 8 10 12 GND USB20_N2 GND GND GND - I - - I C.14 JP18 Table C-14 Single USB Connector pin assignments (4-pin) Pin No. Signal name I/O Pin No. Signal[...]

27 29 GND GND - - 28 30 GND AC97_BITCLK - I C.16 JP2 Table C-16 PW/LED Connector pin assignments (14-pin) Pin No. Signal name I/O Pin No. Signal Name I/O 1 NC - NC MODE_LED# O 3 5 7 9 DINBTN# PWR_SUSPLED0# MOBELLED# GND O O I I 4 6 8 10 PWR_LED0# NC ON/OFFBTN# NC O I I I C.17 JP4 Table C-17 T/P Connector pin assignments (12-pin) Pin No. Signal name[...]

17 19 21 23 25 KSO11 KSO9 KSO7 KSO5 KSO4 O O O O O 18 20 22 24 26 KSO10 KSO8 KSO6 KSO2 KSO3 O O O O O C.19 JP22 Table C-19 1394 Connector pin assignments (4-pin) Pin No. Signal name I/O Pin No. Signal Name I/O 1 TPB0- I/O 2 TPB0+ I/O 3 5 TPA0- GND I/O - 4 6 TPA0+ GND I/O - C.20 JP9 Table C-20 SPK Connector pin assignments (4-pin) Pin No. Signal nam[...]

19 CLK_PCIE_CARD 20 GND 21 PCIE_PTX_C_IRX_ N2 22 PCIE_PTX_C_IRX_ P2 23 GND 24 PCIE_ITX_C_PRX_ N2 25 PCIE_ITX_C_PRX_ P2 26 GND 27 GND 28 GND C.22 PJP2 Table C-22 BATT Connector pin assignments (7-pin) Pin No. Signal name I/O Pin No. Signal Name I/O 1 BATT_S1 I 2 ALI/NIMH# I 3 5 7 AB/I EC_SMDA GND I O - 4 6 TS_A EC_SMCA O O C-18 [CONFIDENTIAL] Satell[...]

Appendix D Appendix D Keyboard Scan/Character Codes Table D-1 Scan codes (set 1 and set 2) (1/4) Code set 1 Code set 2 Cap No. Keytop Make Break Make Break Note 01 ‘ ~ 29 A9 0E F0 0E 02 1 ! 02 82 16 F0 16 03 2 @ 03 83 1E F0 1E 04 3 # 04 84 26 F0 26 05 4 $ 05 85 25 F0 25 06 5 % 06 86 2E F0 2E 07 6 ^ 07 87 36 F0 36 08 7 & 08 88 3D F0 3D *2 09 8[...]

Table D-1 Scan codes (set 1 and set 2) (2/4) Code set 1 Code set 2 Cap No. Keytop Make Break Make Break Note 29 | 2B AB 5D F0 5D *5 30 Caps Lock 3A BA 58 F0 58 31 A 1E 9E 1C F0 1C 32 S 1F 9F 1B F0 1B 33 D 20 A0 23 F0 23 34 F 21 A1 2B F0 2B 35 G 22 A2 34 F0 34 36 H 23 A3 33 F0 33 37 J 24 A4 3B F0 3B *2 38 K 25 A5 42 F0 42 *2 39 L 26 A6 4B F0 4B *2[...]

Table D-1 Scan codes (set 1 and set 2) (3/4) Code set 1 Code set 2 Cap No. Keytop Make Break Make Break Note 58 Ctrl(L) 1D 9D 14 F0 14 *3 60 Alt (L) 38 B8 11 F0 11 *3 61 Space 39 B9 29 F0 29 62 ALT (R) E0 38 E0 B8 E0 11 E0 F0 11 64 Ctrl(R) E0 1D E0 9D E0 14 E0 F0 14 75 Ins E0 52 E0 D2 E0 70 E0 F0 70 *1 76 Del E0 53 E0 D3 E0 71 E0 F0 71 *1 79 ← E0[...]

Table D-1 Scan codes (set 1 and set 2) (4/4) Code set 1 Code set 2 Cap No. Keytop Make Break Make Break Note 122 F11 57 D7 78 F0 78 *3 123 F12 58 D8 07 F0 07 *3 124 PrintSc *6 *6 *6 *6 *6 126 Pause *7 *7 *7 *7 *7 X Fn — — — — *4 X Win E0 5B E0 DB E0 1F E0 F0 1F x App E0 5D E0 DD E0 2F E0 F0 2F Notes: 1. * Scan codes differ by mode. 2. * Sca[...]

Table D-2 Scan codes with left Shift key Code set 1 Code set 2 Cap No. Key top Make Break Make Break 55 / E0 AA E0 35 E0 B5 E0 2A E0 F0 12 E0 4A E0 F0 4A E0 12 75 INS E0 AA E0 52 E0 D2 E0 2A E0 F0 12 E0 70 E0 F0 70 E0 12 76 DEL E0 AA E0 53 E0 D3 E0 2A E0 F0 12 E0 71 E0 F0 71 E0 12 79 ← E0 AA E0 4B E0 CB E0 2A E0 F0 12 E0 6B E0 F0 6B E0 12 80 Home[...]

Table D-3 Scan codes in Numlock mode Code set 1 Code set 2 Cap No. Key top Make Break Make Break 75 INS E0 2A E0 52 E0 D2 E0 AA E0 12 E0 70 E0 F0 70 E0 F0 12 76 DEL E0 2A E0 53 E0 D3 E0 AA E0 12 E0 71 E0 F0 71 E0 F0 12 79 ← E0 2A E0 4B E0 CB E0 AA E0 12 E0 6B E0 F0 6B E0 F0 12 80 Home E0 2A E0 47 E0 C7 E0 AA E0 12 E0 6C E0 F0 6C E0 F0 12 81 End E[...]

Table D-5 Scan codes in overlay mode Code set 1 Code set 2 Cap No. Keytop Make Break Make Break 09 8 (8) 48 C8 75 F0 75 10 9 (9) 49 C9 7D F0 7D 11 0 (*) 37 B7 7C F0 7C 23 U (4) 4B CB 6B F0 6B 24 I (5) 4C CC 73 F0 73 25 O (6) 4D CD 74 F0 74 26 P (–) 4A CA 7B F0 7B 37 J (1) 4F CF 69 F0 69 38 K (2) 50 D0 72 F0 72 39 L (3) 51 D1 7A F0 7A 40 ; (+) 4E [...]

Table D-7 No.126 key scan code Code set 1 Code set 2 Key top Shift Make Make Pause Common E1 1D 45 E1 9D C5 E1 14 77 E1 F0 14 F0 77 Ctrl E0 46 E0 C6 E0 7E E0 F0 7E *: This key generates only make codes. D-8 Satellite M60 Series Maintenance Manual[...]

Appendix E Appendix E Key Layout E.1 United Kingdom (UK) Keyboard Figure E-1 UK-English_keyboard E.2 United St ates (US) Keyboard Figure E- US_keyboard Satellite M60 Series Maintenance Manual [CONFIDENTIAL] E-1[...]

E.3 S p anish (SP) Keyboard Figure E-3 SP keyboard E.4 T urkish (TR) Ke yboard Figure E-4 TK keyboard E-2 [CONFIDENTIAL] Satellite M60 S eries Maintenance Manua l[...]

E.5 Korean (KO) Keyboard Figure E-5 KO keyboard E.6 Canada France (CF) Keyboard Figure E-6 CF keyboard Satellite M60 Series Maintenance Manua l [CONFIDENTIAL] E-3[...]

E.7 Portuguese (PO) Keyboard Figure E-7 PO keyboard E.8 US-INTE (INTE) Keyboard Figure E-7 Intrnational English_KB E-4 [CONFIDENTIAL] Satellite M60 S eries Maintenance Manua l[...]

E.9 Germanic (GR) Keyboard Figure E-9 GR keyboard E.10 France (FR) Keyboard Figure E-10 FR keyboard Satellite M60 Series Maintenance Manua l [CONFIDENTIAL] E-5[...]

E.1 1 Chinese (CH) Keyboard Figure E-11 CH keyboard E.12 Swiss-Germanic (SW) Keyboard Figure E-12 Swiss- Germanic keyboa rd E-6 [CONFIDENTIAL] Satellite M60 S eries Maintenance Manua l[...]

E.13 It alian (IT) Keyboard Figure E-13 IT keyboard E.14 Belgiun (BE) Keyboard Figure E-14 BE keyboard Satellite M60 Series Maintenance Manua l [CONFIDENTIAL] E-7[...]

E.15 Arabic (AR-E) Keyboard Figure E-15 AR-E keyboard E.16 Czech (CZ) Keyboard Figure E-16 CZ keyboard E-8 [CONFIDENTIAL] Satellite M60 S eries Maintenance Manua l[...]

E.17 Swedish (SD) Keyboard Figure E-17 SWE keyboard E.18 Greece (GK) Keyboard Figure E-18 GR keyboard Satellite M60 Series Maintenance Manua l [CONFIDENTIAL] E-9[...]

E.19 Hebrew (HB) Keyboard Figure E-19 HB keyboard E.20 Hungary (HG) Keyboard Figure E-20 HG Keyboard E-10 [CONFIDENTIAL] Satellite M60 S eries Maintenance Manua l[...]

E.21 Norwegian (NW) Keyboard Figure E-21 NW keyboard E.22 Danish (DM) Keyboard Figure E-22 DN keyboard Satellite M60 Series Maintenance Manua l [CONFIDENTIAL] E-11[...]

E. 23 Russian (RU) Keyboard Figure E-24 RU keyboard E-12 [CONFIDENTIAL] Satellite M60 S eries Maintenance Manua l[...]

F. Appendix F Series Screw Torque List Table F-1 Series Screw Torque List SCREW P/N SCREW SPEC Q'ty LOCATION SCREW TORQUE MAC925003Z0 M2.5*3(NL) NI ( 銀白 ) 1 TRACK PAD BRKT TO LOGIC UP 2.0~2.5kgfcm MAC925003Z0 M2.5*3(NL) NI ( 銀白 ) 1 BATT LATCH TO BAT KNOB 2.0~2.5kgf cm MAC925003Z0 M2.5*3(NL) NI ( 銀白 ) 4 K/B TO LOGIC UP 2.0~2.5kgfcm [...]

SCREW P/N SCREW SPEC Q'ty LOCATION SCREW TORQUE MMCK25040Z2 M2.5*4(N L)NI 2 VGA BOARD TO M/B 2.5~3.0kgfcm MMCK25040Z2 M2.5*4(N L)NI 2 FAN TO MB 2.5~3.0kgfcm MMCK25040Z2 M2 .5*4(NL)NI 4 CPU THERMAL MODULE TO MB 2.5~3.0kgfcm MMCK25040Z2 M2 .5*4(NL)NI 3 VGA THERMAL MODULE TO VGA BOARD 2.5~3.0kgfcm MAC925006Z0 M2.5*6(NL) 2 LCD brk(R/L) TO LCD COVE[...]

SCREW P/N SCREW SPEC Q'ty LOCATION SCREW TORQUE MAAA0015320 M2*3(NL) 2 COVER CARD BUS TO MLB 2.5~3.0kgfcm MAAA0015320 M2*3(NL) 2 EXPRESS CARD T O MLB 2.5~3.0kgfcm MAAA0015320 M2*3(NL) 2 MDC BOARD TO MDC STANDOFF 2.5~3.0kgfcm MAAA0015320 M2*3(NL) 2 ODD brk to OD D Module 2.5~3.0kgfc m MA000001N00 M2*5(NL) 2 EXPRESS CARD T O MLB 2.5~3.0kgfcm MA0[...]

Appendix G Appendix G Reliability The followin g table shows MT BF (Mean Tim e Between Failures) for each com ponent. Table G-1 MTBF Component Time (hours) LCD 50,000 Keyboard 40,000 HDD 300,000 Removable FDD 30,000 Optical (DVD/CD) drive 60,000 AC adaptor 60,000 Satellite M40X Series Maintenance Manual [CONFIDENTIAL] G-1[...]

G-2 [CONFIDENTIAL] Satellite M40X Series Maintenance Manual[...]