Vermont Castings VCS3505 инструкция обслуживания

50002972 7 /05 Rev . 5 En USER’S MANU AL f o r Gas Barbecue Grill M o d e l s VCS3505, V C S 3 5 0 5 B I , VCS4005, VCS5005/5010, VCS5005BI, VCS6005 CERTIFIED D E S I G N C E R T I F I E D n w o h S l e d o M 5 0 0 5 CS V[...]

Page i FOR YOUR SAFETY If y ou smell gas: • Shut off gas to the appliance; • Extinguish any open flame; • Open lid; • If odor continues, immediately call y our gas supplier or fire department. FOR Y OUR SAFETY Do not stor e or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. An LP cylinde[...]

SIGN AL WORDS: The Signal W ords used in this Manual, and their intended meanings, are as follows : D ANGER : Indicates that a failure to observe the safety instructions could result in death or cata- strophic bodily injury . W ARNING: Indicates that a failure to observe the safety instructions could result in serious bodily injury . CA UTION: Indi[...]

A. SAFE LOCA TIONS FOR USE OF THIS OUTDOOR GRILL D ANGER: • Never use this outdoor Grill inside any building, garage, shed or breezeway , or inside any boat, trailer or recreational vehicle, to prevent a possible fire and to prevent the possibility of carbon monoxide poisoning or asphyxiation. W ARNINGS: • Always confirm that this Grill is no[...]

B. SAFE USE OF LP (PR OP ANE) GAS D ANGER: • Never install a propane cylinder that is more than 80 % full, as the contents may lack adequate room for expansion when exposed to heat. Propane vapor may then be vented through the pres- sure release valve, which could accumulate in a pool and later result in a fire or explosion. Always instruct your[...]

• Always promptly shut off the gas supply and immediately extinguish all flames if you smell gas. Always seek assistance from your gas supplier or local Fire Department if the gas smell persists, because of the danger of fire or explosion. • Always confirm that there are no gas leaks before lighting this Grill. Apply a 50/50 solution of liqu[...]

Safety Important W arnings ..................................................... i - v Clearance Requirements ................................................. ii T able of Contents ............................................................ 1 Fuels ................................................................................. 2 Safety ........[...]

FUELS W ARNING: Never use Natural Gas in a Grill that has been configured to burn Propane Gas, and never use Propane Gas in a Grill that has been configured to use Natural Gas, to avoid possible bodily injury . Always consult the Rating Label on the back of your Grill to confirm which fuel must be used with the Grill. W ARNING: Use only the pres[...]

D ANGER: a) Do not store a spare LP - Gas Cylinder under or near this appliance b) Never fill the cylinder beyond 80% full; and c) If the information in a) and b) is not followed exactly , a fire causing death or serious injury may oc - cur . W ARNING: Always confirm that the openings in the cylinder compartment of the Grill are free of any obst[...]

Hooking Up to the LP (Pr opane) Gas Supply FOR Y OUR SAFETY 1. W ARNING: Never store or use gasoline or any other volatile substance in the vicinity of this Grill. 2. W ARN IN G: Nev er sto re a sp ar e pr opa ne cyl in der in the vic inity of this Grill , or in the vic inity of any other potential heat source. LP (PR OP ANE) GAS SUPPL Y CONNECTION[...]

Natural Gas Supply Connection TO CONNECT : 1. Push back the Sleeve on the Socket as shown below (see Fig. 6a). 2. Insert Plug and release the Sleeve (see Fig. 6b). 3. Push the Plug until Sleeve snaps forward to lock the Plug in the Socket. • W ARNING: Alway s conduct the followi ng safety tests before lighting the Grill, to prevent a possible fi[...]

Control Fu nctions PR OP ANE T ANK V AL VE W ARNING: Never open the T ank V alve unless the Grill is being prepared for use, to prevent the pooling of propane vapor . Always open the V alve immediately before lighting the Grill, and always close it immediately after cooking has been completed. BURNER CONTR OL V AL VES (see Fig. 7) On Model VCS3505,[...]

Lighting the Main Burners 1. Always open the Hood completely and always inspect the Grill and burners to confirm that all components are properly positioned before lighting the main burn- ers. W ARNING: Never stand with your head directly over the Grill when preparing to light the main burners, to prevent possible bodily injury . 2. Always confir[...]

T urning the Burners Off 1. Always turn the burner control knob(s) to the OFF position when cooking has been completed. 2. Promptly turn OFF the gas supply valve at the propane cylinder or at the main natural gas supply line. 3. Close the Hood of the Grill. FLARE-UPS “Flare-ups” sometimes occur when food drippings fall onto the hot sear plates [...]

Lighting the Rotisserie Burner (if applicable) The Rotisserie burner provides the stead y , even heat required to cook poultry and roasts to self-basted per - fection. Please read Assembly Procedures for instructions as well. TO ST AR T THE R O TISSERIE BURNER: 1. Always open the Hood completely before attempting to light the Grill. • W ARNING: N[...]

R otis serie Setup ( i f applicab le ) The Rotisser ie bur ner is i ntended to be use d f or rotisser ie cook i ng only . W A R N I NG : Nev er use t he mai n bur ners while using the Rotisserie bur ner , a s t hat could result i n igniti ng the d r ippings, or o verh eat ing y our G r i ll. T h e Rot i s se r ie a ss e mbly i n clud es a cou nt er[...]

Operation Page 1 1 Fig. 13 Control knob Igniter Lighting the Side Burner (if applicable) W ARNING: Never stand with your head directly over the Grill when preparing to light the side burner , to prevent possible bodily injury . 1. Turn the side burner control knob to HIGH (see Fig. 13). 2a. PIEZO IGNITION SYSTEM - T urn the Igniter Knob clockwise u[...]

Methods of Cooking W ith its combination of burners and accessories your gas grill can provide for virtually every conceivable style of cooking. • The powerful Main bur ners deliver the middle and high range of tempera- tures desired for traditional barbecuing. This includes searing and finish- ing steaks, hamburgers, pork chops and the like, or[...]

One of the keys to extending your range of grilling capabilities is a fundamental understanding of the two common methods of cooking, Direct and Indir ect cooking. In the Direct cooking method , food is placed directly above the heat source. This method is used in searing for example where you require high and immediate heat to quickly brown the ou[...]

Grilling T ips: A few helpful hints will ensure that your grilling results are perfect every time. • Apply a light coating of cooking oil to your cooking grids before grilling, to prevent foods from sticking. • Cook similar portion sizes together , so that they all cook evenly . • Use tongs to turn foods on the Grill. • Never pierce foods w[...]

T ype of Food Beef Burgers Roasts Blade, Sirloin T ip Steaks Porterhouse, Rib, Ribeye, Sirloin, T -Bone Filet Mignon Poultry Chicken, Parts Chicken, Whole Chicken Breasts, Boneless Cornish Hens Duck T urkey W eight/ Thickness 1 inch 1 inch 2 inches 3–4 lb. 1–2 lb. 1–1 1 / 2 lb. 4–5 lb. 13–25 lb. Cooking T ime Rare: 4–7 min. Medium: 7–[...]

Cooking T emperature 400–450 ° F . 400–450 ° F . 325–350 ° F . 325–350 ° F . 325–350 ° F . 325–350 ° F . 375–400 ° F . 325–350 ° F . 400–450 ° F . 325–350 ° F . 325–350 ° F . T ype of Food P ork Chops Ham Steak Whole ham Ribs Back, Side Roasts Butt, Loin, Shoul- der T enderloin Sausage Lamb Chops Loin, Rib, Shoul- d[...]

Cooking T emperature 325–350 ° F . 325–350 ° F . 325–350 ° F . 325–350 ° F . 325–350 ° F . 325–350 ° F . 325–350 ° F . 400–450 ° F . 325–350 ° F . 325–350 ° F . 325–350 ° F . 325–350 ° F . T ype of Food V egetables Asparagus Beans Carrots Corn on the Cob Eggplant Mushrooms Onions Peppers Potatoes Roasted Garlic T[...]

Car e & Cleaning W ARNING: Always observe the following safety precautions, to prevent bodily injury and to assure that your Grill will operate properly : CA UTION : Always allow sufficient time for the Grill to cool fully before handling or cleaning any of its parts. BURNERS: NO TE: All of the burn ers shou ld be inspe cted frequently and cle[...]

• Cooking Grids The cooking grids have been porcelain enam- eled for durability and ease of cleaning. These Grills may be cleaned with any nonabrasive cleaning agent formulated for kitchen use, or a brass wire brush. NOTE: Always handle the grids with care, as porcelain enamel is susceptible to chipping. • Rotisserie Burner (if applicable) Insp[...]

DRIP TRA Y Th e d ri p t ra y a nd gr ea se cu p, lo ca t ed un de r the burner pan in the bottom of the Grill body are provided to catch excess cooking fats and juices. The drip tray is accessible from the rear of the Grill. It is necessary to lift up the pan slightly while pulling it out (see Fig. 19). Check it for accumulations in the grease cup[...]

Maintenance BURNER ADJUSTMENT NO TE: It may be necessary to adjust the burners periodically , to compensate for variables in gas char - acteristics. If you notice that the burner flame pattern is irregular (see Figs. 9a, 9b & 9c), it may be necessary to adjust the air shutter opening at the front of the venturi tubes. • The shutters are acce[...]

Unit won’t stay lit W ind Running out of fuel PROBLEM POTENTIAL CAUSE ACTION REQUIRED Burner will not light Gas supply turned off Out of propane Blockage in the gas system Misalignment of the gas valve to the venturi tubes of the burner . Improper attachment of the propane hose and regulator Control knob left open at startup, or turning gas on to[...]

Blockage in the burner or gas system Corroded burner Improper air shutter opening Excessively fatty foods Grease buildup Uneven burn pattern or Flashback fire Excessive yellow flame Flare-up Electrode fouled Electrode improperly gapped Electrode cracked Lead wire is discon- nected Lead wire is cracked Battery dead or installed wrong Igniter does [...]

Lifetime W arranty • On all exterior Stainless Steel Components, such as the cart paneling & doors, shelving, condiment bins and handles, if so equipped. • On all castings (1 year on paint). 10 Y ear W arranty • On all porcelain on steel surfaces such as the hood and burn chamber . • On all burners except side burner . 5 Y ear W arranty[...]

CFM Corporation 2695 Meado wvale Boulev ard Mississaug a, Ontario L5N 8A3 Canada (800) 668-5323 www .cfmcor p .com Service Note: If you are experiencing difficultie s or are dissatisfied with your purchase, please contact CFM at the telephone number listed above prior to returning your grill to the store.[...]