Volvo 850 инструкция обслуживания

1994 Volvo 850 VOLVO 850 1 9 9 4 This manual deals with the operation and care of your Volvo. Welcome to the world-wide family of Volvo owners. We trust that you will enjoy many years of safe driving in your Volvo, an automobile designed with your safety and comfort in mind. To help ensure your satisfaction with this vehicle, we encourage you to fa[...]

1994 Volvo 850 Service and routine maintenance ... 8 Specifications ... 9 Important Before you operate your car for the first time, please familiarize yourself with the BREAK-IN information on page 4:2. You should also be familiar with the information in the first three chapters of this manual. Information contained in the balance of the manual is [...]

1994 Volvo 850 Instruments, switches and controls Instruments, switches and controls pg. 1:1 Instruments, switches and controls IMPORTANT! (Automatic transmission only) Your car is equipped with a Shiftlock-Keylock system. SHIFTLOCK: When your car is parked, the gear selector is locked in the (P)ark position. To release the selector from this posit[...]

1994 Volvo 850 1:19 1 Air vent 1:6 2 Turn signals, high/low beams, 1:15 cruise control 1:8 3 Rear fog light, instrument lighting 1:6 4 Headlights, parking lights 1:2-1:5 5 Instruments 1:7 6 Windshield wiper/washer 1:9 7 Hazard warning flashers 1:19 8 Air mix 1:19 9 Air vents 1:19-1:23 10 Heating and ventilation controls 3:6 11 Passenger side SRS (a[...]

1994 Volvo 850 1 Fuel gauge The fuel tank holds approximately 19.3 US gals. (73 liters). When the warning light comes on, there is approximately 1.8 US gals. (8 liters) of fuel remaining in the tank. See "Refueling" for further information. 2 Boost pressure gauge (Turbo models only) The boost pressure gauge is divided into sections. Black[...]

1994 Volvo 850 pg. 1:3 Indicator and warning lights 1 Turn signal, left 2 Turn signal , right 3 (Not in use) 4 Low washer fluid level If the lamp glows continuously when the engine is running, there is only about 1/2 - 1 US qt. remaining in the washer fluid reservoir. 5 Low fuel level When the lamp glows, only about 1.8 US gals. (8 liters) of fuel [...]

1994 Volvo 850 bulbs. Should a light not go off after the engine has started, the system indicated should be inspected. However, the parking brake reminder light will not go off until the parking brake is fully released. Generator warning light If the light comes on while the engine is running, check the tension of the generator drive belt as soon [...]

1994 Volvo 850 pg. 1:5 Warning lights (cont.) Anti-lock Brake System (ABS) If the warning lamp lights up there is a malfunction of the ABS system (the standard braking system will however function). The vehicle should be driven to a Volvo retailer for inspection. See page 4:16 for additional information. Canadian models are equipped with this warni[...]

1994 Volvo 850 Contents | Top of Page file:///K|/ownersdocs/1994/1994_850/94850_1_1.html (7 of 7)12/30/2006 9:48:23 AM[...]

1994 Volvo 850 pg. 1:12 Trip computer (certain models) Trip computer The trip computer offers six functions which are presented in a single display. The cursor indicates the selected function. The trip computer's clock is shown permanently in the left-hand field. Refer to the previous page for more detailed information regarding the clock func[...]

1994 Volvo 850 Select one of the trip computer's six functions by using control B. The Reset button (C) is used to reset the following functions: average speed, average fuel consumption and the trip meter. Rotate the control to the required position and press the button for at least two seconds to reset the selected function. NOTE: If pressure[...]

1994 Volvo 850 pg. 1:14 Trip computer (certain models) Ambient temperature Shows the ambient temperature just above the road surface while driving. When the temperature is in the range 23-36° F(-5 - +2° C), the ambient temperature sensor activates a red warning light. At low speeds or when the car is not moving, the temperature readings may be sl[...]

1994 Volvo 850 Cruise control The cruise control switches are located on the turn signal switch lever. To engage and set desired speed: 1. Set switch (B) to ON. 2. Accelerate to desired cruise speed. 3. Press the + or - area of the SET button (A) to set the desired speed. NOTE: The cruise control cannot be engaged at speeds below 22 mph (35 km). Br[...]

1994 Volvo 850 selected speed will be maintained without having to set the switch to RESUME. To disengage the cruise control system : Set switch (B) to OFF, depress the brake pedal or move the gear selector to position N. Switching off the starting (ignition) switch will automatically disengage the cruise control system. On cars equipped with manua[...]

1994 Volvo 850 Heated rear seats The rear seat heating can be switched on by pressing the button once. Press the button again to switch the heating off. If the heating is not switched off manually, a timer will automatically turn the system off after 10 minutes. The rear seat heating should be switched off when the seats are not occupied. NOTE: The[...]

1994 Volvo 850 Cigarette lighter To operate, depress the knob fully. When the knob automatically releases, the cigarette lighter is ready for use. The starting (ignition) switch must be either in position I or II for the cigarette lighter to function. * The cigarette lighter is located to the right of the gear shift lever on turbo models. This is d[...]

1994 Volvo 850 Ash trays To open the front ash tray, press lightly on the panel. To open the rear ash tray, pull it straight out. To empty the front ash tray (see illustration, center column): (1) Grasp the removable gray insert on the sides and push it in. (2) Pull the insert straight up. Only this insert can be removed for cleaning. To empty the [...]

1994 Volvo 850 WARNING! Never adjust the steering wheel while driving. Contents | Top of Page file:///K|/ownersdocs/1994/1994_850/94850_1_12.html (9 of 9)12/30/2006 9:48:24 AM[...]

1994 Volvo 850 pg. 1:19 Heating, ventilation and air conditioning Heating and air conditioning Your Volvo is equipped with a heating system combined with air conditioning. Depending on which function you select, warm or cool/cold air is distributed to the different parts of the passenger compartment. A slight amount of condensation may be emitted f[...]

1994 Volvo 850 Air vents (dash) A Closed B Open C Directing air flow horizontally D Directing air flow vertically Air mix The center panel vents have an air mix function which allows fresh air to enter the passenger compartment when the vents are open (position B). This function is designed to allow you to direct cool air toward you face while dire[...]

1994 Volvo 850 Blower 0 = Blower (and A/C) Off 4 = Highest blower speed Air in the passenger compartment recirculates - will not function in defrost setting. The light is ON when the function is engaged. The A/C system is ON when the light in ON. Function selector Air through panel vents Defrost. Air to windshield and side windows. Air to floor, wi[...]

1994 Volvo 850 Close the center panel vents. When the passenger compartment has become sufficiently warm, set the blower control to position 2, adjust the temperature and open the side air vents. Maximum cooling: Open the vents. The A/C system should be ON. Adjust the temperature with the temperature selectors to raise the temperature if necessary.[...]

1994 Volvo 850 vents. The outer vents can be opened to avoid mist on the side windows. ● The panel vents may emit some condensation when the air conditioning is initially switched on and is quite normal. This may occur if the ambient temperature and humidity are high. ● The air conditioning is momentarily disengaged during full-throttle acceler[...]

1994 Volvo 850 Air to floor, windshield and side windows. Air through floor vents Bi-level. Air through floor and panel vents. pg. 1:23 Heating, ventilation and air conditioning (Electronic Climate Control) - option Automatic setting Set the mode selector to AUT and select the desired temperature. The blower will run at its maximum speed in either [...]

1994 Volvo 850 ● Water under the vehicle in hot weather can be the result of condensation from the air conditioning system and is quite normal. ● The air conditioning is disengaged when the blower is set at 0 and the speed of the vehicle is less than 20 mph (30 km/h). ● The air conditioning system functions only at temperatures above 32°F (0[...]

1994 Volvo 850 Electrically-operated windows The electrically operated windows are controlled by switches in the center console as shown in the illustration above. The starting (ignition) switches must be ON (position II) for the electrically-operated windows to function. The window is lowered if the rear part of the switch is pressed and raised if[...]

1994 Volvo 850 Cut-out switch for electrically-operated rear-door windows If your car is equipped with electrically-operated rear door windows, this function can be disabled by a switch located on the center console. This switch is positioned 90° in relation to the other switches. ON The rear door windows can be raised or lowered with the respecti[...]

1994 Volvo 850 pg. 1:25 Audio system, General description The following pages describe the use of your SC-810 Cassette Radio and CD remote control 1. ● On/off (turn) ● Volume (turn) ● Pause/Mute (push) 2. CD mode selector 3. Bass control 4. Treble control 5. Fader control 6. Waveband selectors (FM) 7. Waveband selectors (AM) 8. Preset buttons[...]

1994 Volvo 850 12. Tape direction selector REV, CD-Random play 13. Cassette eject 14. Display 15. Cassette slot 16. TP -Next song CD -Next track UP 17. TP -Fast forward CD -Music search UP 18. TP -Rewind CD -Music search DOWN 19. TP -Previous song REPEAT CD -Previous track DOWN 20. Tape mode selector TP = Applicable only in tape mode CD = Applicabl[...]

1994 Volvo 850 Anti-theft code The radio features anti-theft circuitry. If the set is removed from the vehicle or if the battery power is disconnected, a special code must be entered to enable operation of the set. Refer to the radio code card supplied with your vehicle or ask your retailer for the correct code . When the car is parked with the ign[...]

1994 Volvo 850 pg. 1:27 Radio A - On/off switch and volume control Turn the button clockwise to switch on and to increase the volume. B - Waveband selector The desired waveband is set by pressing one of the waveband selector buttons. The frequency and waveband is shown on the display. NOTE: There are two FM wavebands and two AM wavebands. This make[...]

1994 Volvo 850 D - Manual tuning Turn the knob counter-clockwise to tune to lower frequencies and clockwise to tune to higher frequencies. The tuned frequency is displayed. pg. 1:28 Radio A - Seek tuning Push the tuning knob to seek for higher frequencies. The radio seeks the next audible station and stops there. If you wish to continue the seek tu[...]

1994 Volvo 850 pg. 1:29 Radio A - Automatic programming (Autostore) This function automatically seeks and stores up to 8 strong AM or FM stations. This is especially useful when traveling in areas where radio stations are unfamiliar. 1. Depress and hold one of the "auto store" buttons for at least 1 second. A number of strong stations (ma[...]

1994 Volvo 850 A - Fader control Adjust front/rear speaker balance by sliding the control up or down. (Up to direct more sound to the front speakers, down to direct more sound to the rear speakers). The "detent" indicates "equalized" front/rear balance position. B - Mute function Press the "power-volume" knob to tempor[...]

1994 Volvo 850 pg. 1:31 Cassette deck A - Cassette slot The cassette is inserted with the open side to the right (side 1 or A of the cassette upwards). When the cassette is inserted, the radio is disengaged and the cassette will start to play automatically. "TAPE 1" or "TAPE 2" is displayed to indicate which side of the tape is [...]

1994 Volvo 850 A - "nxt" (next selector) Press the "nxt" button and the tape will automatically advance to the next song. There must be a pause of approx. 5 seconds between songs for this function to operate. B - "rpt" (repeat) selector Press the "rpt" button to rewind the tape to the beginning of the song. P[...]

1994 Volvo 850 A - Cassette eject If the button is pressed the tape will stop and the cassette will be ejected. The radio will be automatically engaged. The radio or CD will engage automatically (depending on which mode was activated before the tape was played). B - To re-enter Radio mode There are three alternative ways to re-enter Radio mode: ●[...]

1994 Volvo 850 A - CD mode selector Press "cd" to actuate the CD mode. The disc/track last listened to will continue to play. If the CD- changer cartridge * is empty, "---" will be displayed. If a selected disc does not exist, the disc number and "5--" will be displayed and the next disc will be automatically selected.[...]

1994 Volvo 850 A - Track number selector Turn the knob to select the track number desired. B - Changing the selected track number Press "nxt" for forward selection or "rpt" for backward selection. The chosen disc number and track number will be displayed. C - Playing-time display When this button is pressed the playing time for [...]

1994 Volvo 850 A - Random choice Press "rev" to actuate the random mode. From a disc chosen at random, 4 tracks will be played (also chosen at random). A new disc will then be played in the same way. "RND" will be displayed when this function is engaged. B - Pause If you press the "power-volume" knob, the disc is stopp[...]

1994 Volvo 850 CD remote changer The CD changer, which is available separately, is loaded with a cartridge containing 6 discs. Extra cartridges are available at your Volvo dealer. Insert the discs into the cartridge, label (A) up. Insert the cartridge and close the cover. Eject the cartridge by pressing the eject button (B). Remove the discs by dep[...]

1994 Volvo 850 Contents | Top of Page file:///K|/ownersdocs/1994/1994_850/94850_1_31.html (8 of 8)12/30/2006 9:48:29 AM[...]

1994 Volvo 850 pg. 1:38 General information Sending signals The FM waves do not follow the earth's surface nor do they bounce off the atmosphere. For this reason their range is limited. The AM waves follow the earth's surface and reflect against the atmosphere, giving them a wide range. Weak reception (fading) file:///K|/ownersdocs/1994/1[...]

1994 Volvo 850 Because of the limited range of the FM senders and the fact that these waves are very reflective, this problem usually occurs with FM reception. If the sender is blocked by buildings or mountains, static can result. Static The reason why FM but not AM is audible is covered parking areas, under bridges, etc., is that FM signals reflec[...]

1994 Volvo 850 Cross modulation If you listen to a weak station in the vicinity of a stronger one, both stations may be received simultaneously. FM - reasons for distortion FM is affected by the electrical systems of nearby vehicles, especially those without suppression. The distortion increases if the station is weak or poorly set. The FM receptio[...]

1994 Volvo 850 AM - reasons for distortion AM reception is sensitive to electrical disturbances such as power lines, lighting, etc. pg. 1:40 Radio FM stereo reception Stereo reception places very high demands on the signal quality which means the type of distortions previously mentioned become even more obvious. The signal strength needs to be stro[...]

1994 Volvo 850 Spray the antenna with WD40 and wipe it clean and dry with a rag. Spray it again. Lower and raise the antenna. Wipe it clean and dry again. Lower and raise the antenna 4-6 times. Make sure it is dry and free from dirt or lubricating oil. Radio antenna (wagons) The radio antenna is built into the driver side window of the cargo area. [...]

1994 Volvo 850 Frequency range: SC - 810 FM 87.9 - 107.9 MHz AM 530 - 1710 kHz Sensitivity: FM 1.1 V AM 20 V Stereo separation: 35dB Cassette deck 4-track, 2 channel stereo Tape speed: 4.76 cm/sec. Channel separation: 48 dB Frequency range: 30-15000 hz S/N (120 V) 55 dB S/N (70 V) 55 dB Wow and Flutter: 0.13 % Contents | Top of Page file:///K|/owne[...]

1994 Volvo 850 pg. 1:6 Headlights, Parking lights, Turn signals Headlights and parking lights All lights off * Parking lights on * Headlights and parking lights are on if starting (ignition) switch is in position I or II. If the headlight switch is in position all lights will go out when starting switch is switched off. With the headlight switch in[...]

1994 Volvo 850 NOTE: A defective turn signal bulb will cause the turn signal indicator and remaining signal lights to flash more rapidly than normal. pg. 1:7 Windshield wipers/washers, Ignition switch Windshield wiper/washer 1 Intermittent wiper. With switch in this position, the wipers will sweep approximately every seventh second. 2 "Single [...]

1994 Volvo 850 3 Wipers, normal speed. 4 Wipers, high speed 5 Windshield wiper/washer, headlight wiper/washer (certain models) The wiper will make 2-3 complete sweeps across the windshield and headlights after lever is released. 0 Locked position: Remove the key to lock the steering wheel* WARNING! Never turn the key to position 0 while driving or [...]

1994 Volvo 850 A chime will sound if the starting key is left in the ignition lock and the front door on the driver's side is opened. pg. 1:8 Instrument illumination, Fog light A - Instrument illumination To increase the brightness: move the slide switch to the right. To decrease the brightness: move the slide switch to the left. B - Rear fogl[...]

1994 Volvo 850 A - TRAction Control System (TRACS) - option TRACS is a system designed as an aid when starting/driving off if one of the drive wheels has poor traction due to weather conditions or the road surface and is connected to the ABS control module. TRACS is switched on manually with a button on the dashboard. The indicator lamp in the butt[...]

1994 Volvo 850 E - Rear window demister, heated side-view mirrors Press the switch to start heating the rear window and side-view mirrors. The control light in the switch will illuminate. A timer switches off the system after approximately 12 minutes. The control light will go out correspondingly. pg. 1:10 Tailgate wiper/washer (wagons) Tailgate wi[...]

1994 Volvo 850 Ambient temperature sensor This sensor indicates the temperature slightly above the road surface. A red warning lamp (C) lights up when the temperature is in the range of 23 - 36° F (-5 - +2° C). At low speeds or when the car is not moving, the temperature readings may be slightly higher than the actual ambient temperature due to t[...]

1994 Volvo 850 Body and interior pg. 2:1 Body and interior Body and interior The seats, doors, sun roof, mirrors, etc. are described on the following pages. 2:2 Keys 2:3 Doors and Locks 2:4 Remote keyless entry system 2:5 Alarm 2:6 Front seats 2:7 Rear/side view mirrors 2:8 Interior light, Vanity mirror 2:9 Sun roof 2:10 Hood 2:11 Storage compartme[...]

1994 Volvo 850 Master key and wallet key This key operates all locks The key number codes are stamped on a separate tag supplied with the keys. This tag should be separated from the key ring and kept in a safe place. As an added anti-theft measure, new keys have been developed which may take slightly longer to copy or replace if the original keys a[...]

1994 Volvo 850 Number tag pg. 2:3 Doors and locks Doors and locks Your car is equipped with a two door operated central locking system. This means that all of the doors (including the trunk lid/tailgate and fuel tank flap) can be locked or unlocked from either of the front doors or the trunk lid/tailgate. If the driver/passenger door or trunk lid/t[...]

1994 Volvo 850 On vehicles equipped with the optional remote control locking system, refer to the following page. WARNING! The lock button should not be in the down position while driving. In case of an accident, this may hinder rapid access to the occupants of the vehicle. (Also see information on "Child safety locks". To avoid battery d[...]

1994 Volvo 850 Remote keyless entry system As an option, your car can be equipped with a remote control transmitter. This transmitter uses a radio frequency which will allow "keyless" entry into the passenger compartment or the trunk. You will be supplied with two coded key ring transmitters, which will enable you to lock/unlock all doors[...]

1994 Volvo 850 To replace the battery: Remove the battery cover on the back of the transmitter with a coin. Replace the battery (type CR2025). The new battery should be put in with the text side up so that the cover can be closed. Install the battery cover again, making sure it is on tightly to help prevent water from entering the transmitter. pg. [...]

1994 Volvo 850 1 Height adjustment (manual) The front section of either front seat can be adjusted to seven different height settings and the rear section of either seat can be adjusted to nine different height settings. Lever forward = adjustment of front section Lever rearward = adjustment of rear section WARNING! Do not adjust the seat while dri[...]

1994 Volvo 850 Electrically operated seats with memory function (certain models) Power seat control panel A Seat front (raise/lower) B Forward - rearward C Seat rear (raise/lower) D Backrest tilt WARNING! The driver's seat is operable with the ignition OFF. Therefore, children should never be left unattended in the car. Movement of the seat ca[...]

1994 Volvo 850 pg. 2:7 Electrically operated driver's seat, Rear/side-view mirrors Programming the memory Three seat positions can be programmed. To program a seat position: 1. Adjust the seat to the desired position. 2. Depress the MEM button. 3. Press button 1 to program the current position of the seat. Buttons 2 and 3 can be programmed in [...]

1994 Volvo 850 Rear-view mirror A Normal position B Night position, reduces glare from following headlights CAUTION: Never use ice scrapers made of metal as they can easily scratch the mirror surface. Electrically operated side-view mirrors The control switches are located in the central console, beside the parking brake. A Lateral adjustment B Ver[...]

1994 Volvo 850 Front courtesy lights The front courtesy lighting consists of two reading lights for the front seat occupants. Front and rear reading lights always on Front and rear reading lights always off Front and rear reading lights come on when a door is opened Left or right reading light illuminates if the center switch is in position . The c[...]

1994 Volvo 850 There are two reading lights for the rear seat passengers. These are turned on/off by using the adjacent switches. Light is on if the front switch is in position . Light turns on if any door is opened. Vanity mirrors The light illuminates when the cover is opened. Contents | Top of Page file:///K|/ownersdocs/1994/1994_850/94850_2_1.h[...]

1994 Volvo 850 pg. 2:16 Folding rear seat (sedan) Folding rear seat The rear seat is split into two sections so that each section can be folded independently. ● Lift the rear seat belts to the fixed section of the backrest. The center seat belt can also be folded across the fixed part of the backrest so that it does not get in the way if the righ[...]

1994 Volvo 850 The two red levers on the rear side of the backrests can be used to bypass the folding mechanism and prevent the backrests from being folded down from inside the car. Push the levers down to lock the backrests in the upright position. This function can be used to limit access to the trunk. ● When folding the backrests up, make sure[...]

1994 Volvo 850 Seat cushion strap The rear seat is split into two sections so that each section can be folded independently. ● Straighten front backrests if they are tilted too far to the rear. ● Pull the strap to lift the rear seat cushion and swing the cushion up and toward the back of the front seats. ● The outboard head restraints must be[...]

1994 Volvo 850 ● Check that the hooks under the seat cushions engage the holes on the top edge of the backrest. When the backrest is raised, the outboard head restraints return to their normal positions. Hooks fit into holes The backrest must lock into place. The red lock indicator will not be visible if the seat has locked into place correctly. [...]

1994 Volvo 850 Removing seat cushions The seat cushion can be easily removed to provide a slightly larger cargo storage area. ● Fold the seat cushion toward the back of the front seats ● Release the red catches ● Disconnect the connector for the rear seat heating (certain models) ● Fold the cushion back to a nearly horizontal position ● L[...]

1994 Volvo 850 WARNING! Do not place extremely heavy articles against the front seats, as the backrest which is folded down is then placed under severe strain. Be sure to secure cargo. Hard and sharp articles could otherwise damage the frontseat backrest and/or cause injury to passengers in the event of rapid braking or a collision. The lid of the [...]

1994 Volvo 850 Luggage net The luggage net helps prevent cargo and animals from being thrown forward should the vehicle stop suddenly or be involved in an accident. The luggage net unreels from the rear upped edge of the rear seat backrest. The luggage net must be accessed from the cargo storage area. 1 Open the cover on the passenger side seat bac[...]

1994 Volvo 850 Eyelets in trunk (sedans) Securing cargo As a safety precaution, your car is equipped with four eyelets (six on wagons) to which straps can be attached to secure luggage. Eyelets inside car (sedans/wagons) file:///K|/ownersdocs/1994/1994_850/94850_2_16.html (8 of 11)12/30/2006 9:48:35 AM[...]

1994 Volvo 850 WARNING! The eyelets are not to be used as passenger restraints or as anchorages for child restraints. See page 3:9. Station wagons only: Unless the station wagon is equipped with Volvo's auxiliary seat for children (option) passengers should not ride in the rear cargo area. Station wagons only: If the optional auxiliary seat fo[...]

1994 Volvo 850 Folding front seat The passenger seat backrest can be folded down to the horizontal position for carrying long loads. To fold down the backrest: ● Move the seat as far rearward as possible ● Adjust the backrest tilt to the most upright position ● Lift the catches on the lower rear side of the backrest ● Without releasing the [...]

1994 Volvo 850 WARNING! Always turn engine off and apply parking brake when loading/unloading the vehicle. Place transmission selector in P (PARK) position to help prevent inadvertent movement of selector. Contents | Top of Page file:///K|/ownersdocs/1994/1994_850/94850_2_16.html (11 of 11)12/30/2006 9:48:35 AM[...]

1994 Volvo 850 pg. 2:9 Sun roof (option) Electrically-operated sun roof The switch for operating the sun roof is located on the instrument panel. The starting (ignition) key must first be turned to the drive position. ● To slide open the sun roof: press the lower section of the switch. ● To close the sun-roof : press the upper section of the sw[...]

1994 Volvo 850 The sun roof also features a manually-operated sliding sun visor. The sun visor automatically slides back slightly when the sun roof is opened to the ventilation position. CAUTION: Do not close the sun visor when the sun roof is in the ventilation position as this could damage the mechanism. NOTE: The electrically-operated sun roof h[...]

1994 Volvo 850 To open the hood Pull the lever located under the left side of the dash to release both hood catches. This also releases and exposes the safety handle in the front of the grille. Lift the hood slightly to expose the safety handle. Pull the safety handle and open the hood. Do not lift the hood using the safety handle. WARNING! Check t[...]

1994 Volvo 850 The hood normally opens to an angle of approximately 57°. The hood can be opened to the vertical position by rotating the hinge catches (see illustrations). The catches will return to their normal positions when the hood is closed. Ensure adequate clearance in low-roof garages to avoid damaging the hood. pg. 2:11 Storage compartment[...]

1994 Volvo 850 1 Compartment in center console 2 Glove compartment 3 Compartment in armrest 4 Compartment in door 5 Compartment beside front seat (certain models) 6 Compartment between front seats 7 Pocket on rear of front seat 8 Pocket on rear of front seat WARNING! Packages on the rear window shelf can obscure vision and may become dangerous proj[...]

1994 Volvo 850 Child safety locks The controls are located on the rear door jambs. A The door cannot be opened from the inside. Normal operation from the outside. B The door lock functions normally. WARNING! Remember, in the event of an accident, the rear seat passengers cannot open the doors from the inside with the buttons in position A. Trunk li[...]

1994 Volvo 850 The trunk lock is incorporated in the central locking system. This means that you can either lock or unlock the trunk by means of either of the front doors. You can also operate the trunk lock directly with the master (or wallet) key even if the vehicle is centrally locked. Locking or unlocking the trunk lid will also unlock the door[...]

1994 Volvo 850 Opening the tailgate Tailgate The tailgate is opened by pressing the catch in the handle (see illustration above). To unlock - fold down the flap covering the lock (see inset illustration above) insert the key, turn it clockwise and allow it to spring back. To lock - turn the key counter-clockwise and allow it to spring back. NOTE: T[...]

1994 Volvo 850 Opening from the inside To open the tailgate from the inside of the vehicle move the lever to the right and push outwards. WARNING! Do not drive with tailgate open! Poisonous exhaust gases may enter via the open tailgate. Location and setting of child safety lock Child Safety lock The tailgate incorporates a safety catch which is loc[...]

1994 Volvo 850 Trunk light A Light always off. B Light is on when trunk lid is opened. Spare tire The spare tire is located under the carpet in a special well under the floor of the trunk. The jack is placed inside the wheel rim. Make sure that the jack is properly secured in this position after use (Refer to the illustration on page 2:15). NOTE: S[...]

1994 Volvo 850 pg. 2:15 Cargo space lighting, Spare tire, Jack (wagon) Cargo space lighting There is an extra courtesy light at the rear of the cargo space. A The light is always OFF. B Light comes on when the tailgate is opened. file:///K|/ownersdocs/1994/1994_850/94850_2_9.html (11 of 12)12/30/2006 9:48:36 AM[...]

1994 Volvo 850 Spare tire and jack The spare tire and the jack are located beneath the floor mat in the large storage bin. Always secure the spare tire and the jack to prevent them from rattling (see illustration). NOTE: See pages 6:2-6:3 for information on how the jack should be used. Contents | Top of Page file:///K|/ownersdocs/1994/1994_850/9485[...]

1994 Volvo 850 Occupant safety pg. 3:1 Occupant safety Occupant safety 3:2 Seat belts 3:4 Volvo SRS 3:8 Child safety 3:11 Occupant safety 3:11 Reporting Safety Defects Despite our strongest recommendations, and your best intentions, not wearing a seat belt is like believing "It'll never happen to me!". Volvo urges you and all adult o[...]

1994 Volvo 850 Pull the belt out far enough to insert the latch plate into the receptacle (buckle for rear seats) until a distinct snapping sound is heard. The seat belt retractor is normally "unlocked" and you can move freely, provided that the shoulder belt is not pulled out too far. The retractor will lock up as follows: ● if the bel[...]

1994 Volvo 850 WARNING! Any device used to induce slack into the shoulder belt portion of the three-point belt system will have a detrimental effect on the amount of protection available to you in the event of a collision. The seat back should not be tilted too far back. The shoulder belt must be taut in order to function properly. pg. 3:3 Seat bel[...]

1994 Volvo 850 Center head restraint The center head restraint can be adjusted according to the passenger's height. The restraint should be carefully adjusted to support the occupant's head. To raise: Pull straight up To lower: Pull forward and push down pg. 3:4 Volvo SRS As an enhancement to the three-point seat belt system, your Volvo i[...]

1994 Volvo 850 compartment, the knee bolsters beneath the steering column and the glove compartment and decals on both sun visors and on the far right side of the dash. The airbags are folded and located in the center of the steering wheel and above the glove compartment. They are designed to deploy during certain frontal-angular collisions, impact[...]

1994 Volvo 850 WARNING! When installing any optional equipment make sure that the SRS system is not damaged. Do not attempt to service any component of the SRS yourself. Attempting to do so may result in serious personal injury. If a problem arises, take your car to the nearest authorized Volvo Retailer for inspection as soon as possible. pg. 3:5 V[...]

1994 Volvo 850 There is no maintenance to perform on the SRS yourself. The only periodic maintenance recommended on the SRS is that the air bag modules and front seat belts (including tensioners) should be replaced approximately every ten years and that the other components in the system (wiring, connectors, etc.) should also be inspected at this t[...]

1994 Volvo 850 seat-belt properly fastened. The safest place in the car for children is in the rear seat. FAILURE TO FOLLOW THESE INSTRUCTIONS CAN RESULT IN INJURY TO THE VEHICLE OCCUPANTS IN AN ACCIDENT. For further information, see owner's manual. VOLVO SRS texts at far right on instrument panel CAUTION TO AVOID SERIOUS INJURY: FOR MAXIMUM S[...]

1994 Volvo 850 WARNING! Do not use child safety seats or child boosters cushions/backrests in the front passenger's seat. We also recommend that children who have outgrown these devices sit in the rear seat with the seat belt properly fastened. NOTE: Deployment of SRS components occurs only one time during an accident. In a collision where dep[...]

1994 Volvo 850 ● Use only new, Genuine Volvo Parts when replacing SRS components (airbags, seat belts, tensioners, etc.) When are the airbags NOT deployed? Not all frontal collisions activate the SRS system. If the collision involves a non-rigid object (e.g., a snow drift or bush), or a rigid, fixed object at a low speed, the SRS system will not [...]

1994 Volvo 850 Contents | Top of Page file:///K|/ownersdocs/1994/1994_850/94850_3_1.html (11 of 11)12/30/2006 9:48:37 AM[...]

1994 Volvo 850 pg. 3:8 Child safety Child Restraint Anchorages Volvo cars can be fitted with Child Restraint Top Tether Anchorages in the rear seat. Sedans: There are three pre-drilled anchorage points under the rear window shelf which are not visible from the passenger compartment. Wagons: The anchorage points are on the rear seat backrest and are[...]

1994 Volvo 850 Integrated booster cushion: 1-sedan, 2-wagon Integrated booster cushion (certain models) Volvo's own integrated booster cushion has been specially designed to help safeguard a child seated in the center position of the rear seat. When using the integrated booster cushion, the child must be secured with the vehicle's three-p[...]

1994 Volvo 850 Storing the booster cushion To store (fold up): ● Press button A (see illustration in left column) ● Fold down the booster cushion backrest to the seat section (B) ● Snap the backrest strap to the fastener on the seat (C) ● Fold up the booster cushion unit (D) NOTE: The booster cushion must be folded down as one unit. If the [...]

1994 Volvo 850 WARNING! When using the auxiliary seat for children, both sections of the rear seat backrest must be secured in the upright position. pg. 3:11 Occupant safety Seat belt maintenance Check periodically that the anchor bolts are secure and that the belts are in good condition. Use water and a mild detergent for cleaning. Check seat belt[...]

1994 Volvo 850 Contents | Top of Page file:///K|/ownersdocs/1994/1994_850/94850_3_8.html (5 of 5)12/30/2006 9:48:38 AM[...]

1994 Volvo 850 Starting and driving pg. 4:1 Starting and driving Starting and driving This section on starting and driving contains items such as starting the engine, operating gear selector, towing, trailers. 4:2 Break-in period 4:3 Fuel requirements, Octane rating 4:4 Driving economy 4:5 Starting the engine 4:6 Manual transmission 4:7 Automatic T[...]

1994 Volvo 850 Although some oil consumption during normal engine operation, more oil is consumed when the engine is new as the internal parts generate higher friction while wearing-in to each other. From the time the engine is new until the first service is performed, the oil consumption could be higher than normal. For this reason, it is especial[...]

1994 Volvo 850 Each Volvo has a three-way catalytic converter and must use only unleaded gasoline (as specified on the instrument panel and by a label near the filler inlet). U.S. and Canadian regulations require that pumps delivering unleaded gasoline be labelled "UNLEADED". Only these pumps have nozzles which fit your car's filler [...]

1994 Volvo 850 to accommodate possible expansion of the fuel in hot weather. The "usable" tank capacity will be somewhat less than the specified maximum. When the fuel level is low, such factors as ambient temperature, the fuel's "vapor pressure" characteristics, and terrain can affect the fuel pumps' ability to supply[...]

1994 Volvo 850 pg. 4:14 Jump starting CAUTION: Improper hook-up of jumper cables or use of other than 12-volt batteries could result in damage to equipment and/or battery. If the booster battery to be used is in another car, check that the cars are not touching to prevent premature completion of negative circuit. Note the position of the battery te[...]

1994 Volvo 850 WARNING! ● To reduce the possibility of explosion, never expose battery to open flame or electric spark. ● Do not smoke near battery. ● Batteries generate hydrogen gas which is flammable and explosive. ● Battery fluid contains sulfuric acid. Do not allow battery fluid to contact eyes, skin, fabrics or painted surfaces. If con[...]

1994 Volvo 850 and can cause three-way catalytic converter or exhaust system overheating. This includes: - Altering fuel injection settings or components. - Adjusting distributor ignition timing beyond specified limits. - Altering emission system components or location or removing components - Repeated use of leaded fuel. NOTE: Unleaded fuel is req[...]

1994 Volvo 850 The system performs a self-diagnostic test when the vehicle is started and at 20 mph (30 km/h). The brake pedal will pulsate several times and a sound may be audible from the ABS control module. This is normal. To obtain optimal effect from the ABS system, constant pressure should be kept on the brake pedal while the system is modula[...]

1994 Volvo 850 NOTE: Models with automatic transmission are equipped with a transmission oil cooler as standard equipment. This cooler helps prevent overheating of the transmission during times of increased load, as when towing a trailer. ● Maximum trailer weight recommended by Volvo is: Trailers without brakes : 1540 lbs (700kg) Trailers with br[...]

1994 Volvo 850 WARNING! ● Bumper-attached trailer hitches must not be used on Volvos, nor should safety chains be attached to the bumper. ● Trailer hitches attaching to the vehicle rear axle must not be used. ● Never connect a trailer's hydraulic brake system directly to the vehicle brake system, nor a trailer's lighting system dire[...]

1994 Volvo 850 ● Use lock spray or grease in the locks. NOTE: Avoid the use of de-icing spray as they can cause damage to the locks. pg. 4:19 Long distance trips, City driving Before a long distance trip It is always worthwhile to have your car checked at a Volvo retailer before driving long distances. Your retailer will also be able to supply yo[...]

1994 Volvo 850 pg. 4:7 Automatic transmission P (Park) Use this position when starting the engine or parking the car. Never use P while car is in motion. The parking brake should also be used when parking on grades. The gear selector is mechanically locked in the P position (Shift lock). To release the selector, start the engine and depress the bra[...]

1994 Volvo 850 Never engage R while is moving forward. N (Neutral) Neutral = no gear is engaged. Use the parking brake. The engine can be started with the gear selector in this position. D (Drive) D is the normal driving position and should be used as often as possible to help improve fuel economy. When modes E or S are selected, upshift and downsh[...]

1994 Volvo 850 Shift gate positions The gear selector can be moved freely between N and D. Selections of other positions are obtained by depressing the selector knob prior to moving the selector. Slightly depressing the selector knob allows selection of positions R, N, D, 3 and L. Fully depressing the selector knob allows selection of positions P. [...]

1994 Volvo 850 can be selected at any time, including while the car is moving. Economy Mode This mode is used for normal driving. The gearbox changes gears at a lower engine speed to achieve the lowest possible fuel consumption. Sport Mode This mode is adapted to "sporty" driving characteristics. The transmission upshifts at higher engine[...]

1994 Volvo 850 ● For driving down steep hills and when driving for prolonged periods at low speeds, position L should be selected. Avoid, however, repeated changes since this can cause overheating of the transmission oil. For driving on long continuous uphill gradients, select position 3. ● The transmission may shift down automatically (ECONOMY[...]

1994 Volvo 850 CAUTION: Drive slowly and carefully if going through standing water (i.e. flooded roadways, etc.). Damage to engine could result if excess water is ingested through the air intake system. Never drive the vehicle in water deeper than 1 foot (300 mm). See the flood warning on page 3:7. WARNING! Do not drive with trunk lid or tailgate o[...]

1994 Volvo 850 vehicle load. The heavier the load in the trunk (max. 220 lbs, 100 kg), the less the tendency to understeer. Handling, roadholding Vehicle load, tire design, and inflation pressure, all affect vehicle handling. Therefore, check that the tires are inflated to the recommended pressure according to the vehicle load. See "Tire press[...]

1994 Volvo 850 WARNING! An extra mat on the driver's floor can cause the accelerator pedal to catch. Check that the movement of the accelerator pedal is not impeded. Not more than one protective floor covering may be used at one time. pg. 4:12 Emergency towing (pulling of vehicles) Front eyelet Rear eyelet Precautionary steps to observe when c[...]

1994 Volvo 850 CAUTION: The towing eyelets must not be used for pulling another vehicle out of a ditch or any similar purpose involving severe strain. Do not attempt to start the car by pushing or pulling it as damage to the three-way catalytic converter can result. pg. 4:13 Vehicle towing information Only use flat bed equipment. CAUTION: Sling-typ[...]

1994 Volvo 850 Wheels and tires pg. 5:1 Wheels and tires Wheels and tires The handling and riding comfort of the vehicle is dependent on the inflation pressure and the type of tires fitted. Read the following pages carefully. 5:2 General information, Wear indicator, Tire economy, Flat spots 5:3 Snow chains, Winter tires 5:4 Inflation pressure pg. 5[...]

1994 Volvo 850 Wear indicator The tires have a so-called "wear indicator" in the form of a number of narrow strips running across or parallel to the tread. When approx. 1/16" (1.6 mm) is left on the tread, these strips show up and indicate that the tire should be replaced. Tires with less than 1/16" (1.6 mm) tread have a very po[...]

1994 Volvo 850 If accessory, aftermarket or "custom" tires and wheels are installed and are of a size different than the original tires and wheels, chains in some cases CANNOT be used. Sufficient clearances between chains and brakes, suspension and body components must be maintained. ● Some strap-on type chains will interfere with brake[...]

1994 Volvo 850 WARNING! Special wheel rims for air dams Only special wheel rims, tested and approved by Volvo, are suitable for use with the air dam installed on the 850. pg. 5:4 Wheels and tires Checking and correcting tire pressure ● Check the tire pressure when refueling. ● The tire pressure should be corrected only when the tires are cold. [...]

1994 Volvo 850 file:///K|/ownersdocs/1994/1994_850/94850_5_1.html (5 of 5)12/30/2006 9:48:43 AM[...]

1994 Volvo 850 In case of emergency pg. 6:1 In case of an emergency In case of emergency Even if you maintain your car in good running condition, there is always the possibility that something might go wrong and prevent you from driving, such as a punctured tire, blown fuse or bulb, etc. For additional information, see section "ON CALL Road As[...]

1994 Volvo 850 Pull straight out Changing a wheel The spare wheel is located under the carpet on the trunk floor. The jack and crank are secured in the wheel recess. ● Engage the parking brake. ● Put the gear selector in (P)ark (automatic) or in Reverse (manual). ● Remove the wheel cap (where applicable) using the lug wrench in the tool kit. [...]

1994 Volvo 850 There is a jack attachment located in the center on each side of the car. Position the jack on the bar in the jack attachment as shown in illustration A above and crank while simultaneously guiding the base of the jack to the ground. The base of the jack must be flat on a level, firm, non-slippery surface. Before raising the car chec[...]

1994 Volvo 850 WARNING! ● The jack attachment must engage the bar in the jack attachment (A). The car's weight must not rest on the jack's attachment (B). ● Be sure the jack is on a firm, level, non-slippery surface. ● Never allow any part of your body to be extended under a car supported by a jack. ● Use the jack intended for the[...]

1994 Volvo 850 WARNING! Current legislation prohibits the use of the "Temporary Spare" tire other than as a temporary replacement for a punctured tire. In other words, it must be replaced as soon as possible by a standard tire. Roadholding, etc.., may be affected with the "Temporary Spare" in use. Do not, therefore, exceed 50 mp[...]

1994 Volvo 850 pg. 6:13 Replacing Fuses Fuse removal tool Defective fuse Intact fuse Replacing fuses If an electrical component fails to function, it is likely that a fuse has blown due to a temporary circuit overload. The fuse box is located in the engine compartment (see illustration) and can be opened by lifting the cover. A label on the inside [...]

1994 Volvo 850 If you find it difficult to remove a fuse, you will find a special fuse tool clipped in the fuse box. pg. 6:14 Fuses Location * Amperage 1 Fuel injection, distributor ignition system, automatic gearbox 15A 2 Fuel pump, alarm 15A 3 Interior courtesy lights, oil level sensor 10A 4 – 5 ECC blower (speed 4) 30A 6 Central locking system[...]

1994 Volvo 850 32 Audio system, remote controlled central locking 10A 33 Power seat, OBD socket, rear window wiper/washer (wagons) 15A 34 Windshield/headlight wipers/washers, horn 25A 35 Instrument panel lights, power sun roof 10A 36 – 37 Power windows, power sun roof AUT/CB ** 38 – 39 Power seat (driver's side) AUT/CB ** 40 – * Some of [...]

1994 Volvo 850 To obtain maximum lifetime from a set of wiper blades, clean them with a stiff-bristle brush and warm, soapy water as part of a normal car wash. Replacing headlight wiper blades (certain models) Pull the wiper blade in the direction indicated by the arrow in illustration to remove it. Press the new blade into place. Check that the ne[...]

1994 Volvo 850 With the starting (ignition) switch in the "Driving" or "On" position, check to see if the warning lights on the dashboard come on and if they stay on when the starter is engaged. if the lights do not come on or if they go off when the starter is engaged the battery is discharged, or see below. Fault in the electr[...]

1994 Volvo 850 Check the coolant level and add as necessary. See page 8:16 Fault in electric cooling fan Check that the electric cooling fan functions properly. WARNING! The electric cooling fan may start or continue to operate (for up to 6 minutes) after the engine has been switched off. pg. 6:17 Service diagnosis (cont.) Excessive fuel consumptio[...]

1994 Volvo 850 Misfiring at highway driving speed Spark plugs fouled. Drive the vehicle in a lower gear and keep the engine rpm higher for a few miles in order to remove carbon deposits on the spark plugs. If this procedure in not effective, clean or replace the spark plugs. Please be aware that faulty plugs can damage the three-way catalytic conve[...]

1994 Volvo 850 Check fuse no. 35. pg. 6:19 Service diagnosis (cont.) Shiftlock release (automatic transmission only) The gear selector is locked in the (P)ark position. To manually release the shiftlock, turn the starting (ignition) key to position I and press firmly on the "SHIFTLOCK OVERRIDE" button located to the right of the base of t[...]

1994 Volvo 850 pg. 6:5 Replacing bulbs Replacing bulbs Make sure when installing bulbs, that the guide pin on the socket fits into its corresponding recess. When installing Halogen bulbs, do not touch the glass with your fingers because grease, oil or any other impurities can be carbonized onto the bulb and damage the reflector. Use bulbs of correc[...]

1994 Volvo 850 1-Plastic cover 2-Spring-loaded clip 3-Bulb HB2/9003 4-Connector Headlight bulb replacement 1. Turn the plastic cover counter-clockwise and remove it. 2. Turn the bulb and connector (one unit) 1/4 turn counter-clockwise and remove. 3. Disconnect the wiring from the bulb unit. 4. Connect a new bulb unit into the wiring without touchin[...]

1994 Volvo 850 2. Turn the bulb and connector (one unit) 1/4 turn counter-clockwise and remove. 3. Disconnect the wiring from the bulb unit. 4. Connect a new bulb unit to the wiring without touching the bulb itself. 5. Re-insert the bulb unit into the headlight housing and turn 1/4 turn clockwise until the unit seats properly. The bulb has three gu[...]

1994 Volvo 850 Lamp location, right side, A- covers, B- bulb holder Tail light bulbs (sedans) 1. Tail light 2. Direction indicator 3. Brake light 4. Tail light 5. Back-up light 6. Rear fog light (left side only) Location of bulbs in holder All the bulbs in the tail light unit are replaced from inside the trunk as follows: 1. Turn the two plastic sc[...]

1994 Volvo 850 pg. 6:8 Replacing bulbs Removing speaker from upper section 1,2,4 3,5 21W BA 15s 21/4W BAZ 15d file:///K|/ownersdocs/1994/1994_850/94850_6_5.html (5 of 12)12/30/2006 9:48:46 AM[...]

1994 Volvo 850 Tail light bulbs (wagons) 1. Direction indicator 2. Brake light 3. Tail light 4. Back-up light 5. Tail light / Rear fog light (left side only) All the bulbs in the tail light unit are replaced from inside the cargo space as follows: ● Turn the ignition key to position 0 and switch off the lights. ● Remove the upper panel of the t[...]

1994 Volvo 850 Press in the springs (sedans) Remove the cover (wagons) High-mounted brake light Sedans: ● Turn off the ignition. ● Press in the springs on both sides of the holder. ● Pull the cover towards you. ● Depress the catches on both sides of the reflector and withdraw it from the holder. ● Replace the bulb. ● Reinstall the refle[...]

1994 Volvo 850 Brake lights mounted in spoiler (certain models) Switch off the lights. Unscrew the three screws. Insert the screwdriver and turn gently to loosen the glass lens to gain access to the bulb holder. Replace the bulb(s) and reinstall the bulb holder and glass lens. Insert screwdriver and turn Trunk light (sedans)/Rear courtesy light (wa[...]

1994 Volvo 850 Phillips-head screwdriver for glass lens License plate lights (sedans and wagons) Switch off the lights. Unscrew the two screws. Insert the screwdriver and turn gently to loosen the glass lens. Replace the bulb and reinstall the glass lens. pg. 6:11 Replacing bulbs Insert screwdriver, turn and pull downward Front courtesy lights ● [...]

1994 Volvo 850 Insert a screwdriver and turn Rear reading lights ● Switch off the ignition. ● Insert a screwdriver and turn to loosen the lamp unit. ● Replace the bulb and press the lamp unit back into place. Insert a screwdriver and turn Vanity mirror ● Switch off the ignition. ● Insert a screwdriver under the lower edge and turn to loos[...]

1994 Volvo 850 Door warning lights Front ● Slide the lamp unit upward and lift it out. ● Twist off the bulb holder. ● Pull the bulb straight out. ● Replace the bulb. ● Reinstall the holder and lamp unit in reverse order. Rear ● Insert a screwdriver and turn carefully to loosen the glass lens. ● Pull the bulb straight out. ● Replace [...]

1994 Volvo 850 ● Insert a screwdriver and turn carefully to loosen the glass lens. ● Withdraw the lamp unit, bend back the tabs and remove the plate. ● Replace the bulb. ● Reinstall the plate. ● Press the lamp unit back into place. NOTE: Other bulbs may be difficult for the owner to replace. Let your Volvo retailer replace these bulbs if [...]

1994 Volvo 850 Car care pg. 7:1 Car care Car care Car care includes not only maintaining the appearance of the car, but also protecting the car exterior from the effects of air pollution, rain, mud or road salt. The rustproofing compound under the car should be checked regularly and, if necessary, damaged areas should be repaired. The paintwork sho[...]

1994 Volvo 850 stay above the freezing point and where the atmosphere is affected by industrial pollution, or where salt is used for de-icing the roads. Where parts of the car are covered with road dirt containing road salt, corrosion will be accelerated at lower relative humidity than if the surface were clean. ● Increased temperature will cause[...]

1994 Volvo 850 There are three different types of rustproofing compounds available: A) thin (ML), for seams under the car. B) thin (transparent) for visible parts. C) thick, for parts on the underbody and wheel housing which experience most wear. Parts of the car which may need to be touched up (and the recommended rustproofing compound) are: ● v[...]

1994 Volvo 850 NOTE: When ordering touch-up paint from your Volvo retailer, use the paint code indicated on the model plate. The plate is located on the panel above the right-side head lights. Minor stone chips and scratches Material: Primer - can Paint - touch-up bottle Brush Masking tape NOTE: When touching up the car, it should be clean and dry.[...]

1994 Volvo 850 1. Place a strip of masking tape over the damaged surface. Pull the tape off so that any loose flakes of paint adhere to it. 2. Thoroughly mix the primer and apply it with a small brush. When the primer surface is dry, the paint can be applied using a brush. Mix the paint thoroughly; apply several thin paint coats and let dry after e[...]

1994 Volvo 850 Touching up damaged paint on fender edges and sills Material: Primer - spray can Paint - spray can Masking tape Note: When touching up the car, it should be well cleaned and dry and have a temperature exceeding 60° F (+15°C). When large surfaces have to be repainted, suitably mask the surrounding area with masking tape and paper. R[...]

1994 Volvo 850 pg. 7:6 Washing Washing the car ● The car should be washed at regular intervals since dirt, dust, insects and tar spots adhere to the paint and may cause damage. NOTE: It is particularly important to wash the car frequently in the wintertime to prevent corrosion, when salt has been used on the roads. ● When washing the car, do no[...]

1994 Volvo 850 Remove from paintwork as soon as possible. Otherwise the finish may be permanently damaged. WARNING! ● When the car is driven immediately after being washed, apply the brake several times in order to remove any moisture from the brake linings. ● Engine cleaning agents should not be used when the engine is warm. This constitutes a[...]

1994 Volvo 850 Normally, polishing is not required during the first year after delivery, however, waxing may be beneficial. Before applying polish or wax the car must be washed and dried. Tar spots can be removed with kerosene or tar remover. Difficult spots may require a fine rubbing compound. After polishing use liquid or paste wax. Several comme[...]

1994 Volvo 850 should be taken out for drying. Spots on textile mats can be removed with a mild detergent. Bear in mind ● Take extra care when removing stains such as ink or lipstick since the coloring can spread. ● Use solvents sparingly. Too much solvent can damage the seat padding. ● Start from the outside of the stain and work toward the [...]

1994 Volvo 850 Volvo service pg. 8:1 Volvo Service Service - an investment! An investment which will pay dividends in the form of improved reliability, durability, and resale value. 8:2 Label Information 8:3 Maintenance service, Warranty 8:4 Maintenance schedule 8:6 Servicing 8:9 Lubrication 8:10 Engine oil 8:12 Power steering fluid, Brake/clutch s[...]

1994 Volvo 850 5 Federal Motor Vehicle Safety Standards (FMVSS) specifications (USA) and Ministry of Transport (CMVSS) Standards (Canada) Your Volvo is designed to meet all applicable safety standards, as evidenced by the certification label on the facing side of the driver's door. For further information regarding these regulations, please co[...]

1994 Volvo 850 Applicable warranties - U.S. In accordance with U.S. Federal Regulations, the following list of applicable U.S. warranties is provided. For Canadian specification vehicles, see your separate warranty booklet. ● New Car Limited Warranty ● Parts and Accessories Limited Warranty ● Corrosion Protection Limited Warranty ● Seatbelt[...]

1994 Volvo 850 Exhaust pipe attachment to turbo-charger, retorque, B 5234 T A 1) See section "Engine oil" for detailed information. NOTE: The oil should be changed at these intervals or after 750 hours of driving or after 12 months which ever occurs first. See "Service Reminder indicator", page 1:5. 2) For services beyond 60,000[...]

1994 Volvo 850 Power antenna (clean) I I I I I I Trunk/hood, hinges and latches L L L L L L 1) No cost to owner 2) For proper functioning of the vehicle and its emission control systems, Volvo recommends that the fuel line filter be replaced every 60,000 miles (96,000 km) The following items should be checked weekly by the driver (it takes only a f[...]

1994 Volvo 850 pg. 8:12 Power steering fluid, Brake/clutch fluid reservoir Power steering fluid The dipstick has marks for checking hot and cold oil. The oil level when the engine is cold must never be higher than the COLD mark. After the engine has reached normal operating temperature, the level may not be higher than the HOT mark. Top up when the[...]

1994 Volvo 850 pg. 8:13 Automatic transmission fluid Check the oil level as follows: Park the car on a level surface with the engine idling . Slowly move the gear selector lever through all the shift positions and then to position P. Wait 3 minutes before checking the oil level. As the illustration shows, the dipstick has a COLD and a HOT side. The[...]

1994 Volvo 850 WARNING! Oil spilled on a hot exhaust pipe constitutes a fire risk. pg. 8:14 Drive belt, Air pump system A - crankshaft, B - A/C compressor, C - generator, D - power steering pump Belt check Check the belt regularly to make sure it is in good condition and is clean. A worn or dirty belt can cause poor cooling and low generator output[...]

1994 Volvo 850 Air pump system (B 5254 S) During cold starts, an electrical air pump is activated which directs air to the exhaust channels. This initiates a secondary combustion of exhaust gases which helps minimize hydrocarbon and carbon monoxide levels and reduces warm-up time for the catalytic converter. The pump begins to function when the eng[...]

1994 Volvo 850 freeze. pg. 8:16 Coolant Check coolant level The cooling system must be filled with coolant and not leak to operate at maximum efficiency. Check the coolant level regularly. The level should be between the "MAX" and "MIN" marks on the expansion tank. The check should be made with particular thoroughness when the e[...]

1994 Volvo 850 Capacity: Approx. 7.6 US qts. (7.2 liters) Turbo - 7.4 US qts. (7.0 liters) Coolant: Volvo Genuine Coolant/Antifreeze only NOTE: Do not top up with water only. Water by itself reduces the rust-protective and anti-freeze qualities of the coolant and has a lower boiling point. It can also cause damage to the cooling system if it should[...]

1994 Volvo 850 pg. 8:18 Engine compartment (cont.) Engine compartment 850 Turbo (engine B 5234 T) 1 Expansion tank, coolant 2 Engine designation plate 3 Oil filler cap, engine 4 Clutch/brake system fluid reservoir 5 Fuse box 6 Washer fluid reservoir 7 Power steering fluid reservoir 8 Dipstick - engine oil 9 Dipstick - automatic transmission 10 Air [...]

1994 Volvo 850 pg. 8:6 Servicing (cont.) The following precautions must be observed when carrying out repairs to the vehicle WARNING! The distributor ignition system operates at very high voltages. Special safety precautions must be followed to prevent injury. Always turn the ignition off when: ● Connecting engine test and diagnostic equipment to[...]

1994 Volvo 850 If a two-post hoist is used to lift the car, the front and rear lift arm pads should be centered under the reinforced lift plates on the inboard edge of the sill rail. The position of these plates is marked with arrows molded into the bottom of the sill rail. pg. 8:7 Servicing (cont.) Torque exhaust and intake manifold nuts A loose m[...]

1994 Volvo 850 For proper functioning of the vehicle and its emission control systems, Volvo recommends that the timing belt be replaced every 70,000 miles (112,000 km). Fuel system cap, tank and lines and connections The effectiveness of the fuel system to contain hydrocarbons is dependent largely on a leak-free system. Check for proper sealing of[...]

1994 Volvo 850 exhaust emissions. Heated oxygen sensor This is an emission control system designed to reduce emissions and improve fuel economy. The heated oxygen sensor monitors the composition of the exhaust gases leaving the engine. The exhaust gas analysis is fed into an electronic module. This adjusts the air-fuel ratio to provide optimum cond[...]

1994 Volvo 850 Crankcase ventilation The engine is provided with positive crankcase ventilation which prevents crankcase gases from being released into the atmosphere. Instead, the crankcase gases are admitted to the intake manifold and cylinders. PCV system The orifice nipple in the intake manifold and the filter at the end of the PCV hose in the [...]

1994 Volvo 850 1 Hood lock and latch Oil 6 Window winder (on inside of door) Oil, grease, low temperature grease 2 Door stop and hinges Oil 7 Front seat slide rail and latch Oil 3 Sun roof wind deflector Oil 8 Door locks Low temperature grease or Volvo teflon lock oil 4 Door lock catch plate Oil 5 Trunk/tailgate lid lock Low temperature grease To a[...]

1994 Volvo 850 Draining the oil Drain the oil after driving while it is still warm. WARNING! The oil may be very hot. If you change the engine oil and filter yourself, your Volvo retailer can assist you in disposing of the used oil. Engine oil can be harmful to your skin - gloves should worn when performing this work. To add or change oil Add oil o[...]

1994 Volvo 850 For best fuel economy and engine protection consult with your authorized Volvo retailer for recommended oils. Oils with a different quality rating may not provide adequate engine protection. Viscosity (stable ambient temperatures): Do not use oils with other viscosity ratings. The use of incorrect viscosity oil can shorten engine lif[...]

1994 Volvo 850 ● Primarily highway driving ● Frequent trips of longer than 7 miles = 11 km ● Normal driving EVERY 10,000 miles = 16,000 km 5,000 miles= 8,000 km * OR EVERY 12 MONTHS, WHICH EVER COMES FIRST * Turbo models American Petroleum Institute (API) labels. These labels certify the oil conforms to the applicable standards and specificat[...]

1994 Volvo 850 Specifications pg. 9:1 Specifications Specifications This chapter contains facts and figures pertaining to the technical specifications of your car. 9:2 Oil/Fluids specifications 9:3 Engine specifications 9:4 Cooling/fuel distributor ignition systems 9:4 Front/rear suspensions 9:5 Transmission, Capacities, Vehicle loading 9:6 Electri[...]

1994 Volvo 850 Engine oil Quality: Meeting API specification SG Capacity: 850 (5-cyl. engine) 5.6 US qts.(5.3 liters) (including filter) 850 Turbo - 5.6 US qts. (5.3 liters)* Automatic transmission fluid Quality: ATF Dexron IIE and Mercon Capacity: 8 US qts. (7.6 liters) Manual transmission fluid Quality: Volvo synthetic gearbox oil standard 97308 [...]

1994 Volvo 850 Engine lubrication is provided by an eccentric pump driven from the crankshaft. Full-flow type oil filter. Exhaust emission control accomplished by fuel injection, heated oxygen sensor(s) and three-way catalytic converter Designation Volvo B 5234Turbo Volvo B 5254 S Output 222 hp at 5280 rpm (166 km/88 rps)* 168 hp at 6200 rpm (125 k[...]

1994 Volvo 850 Firing order 1-2-4-5-3 Distributor ignition setting Not adjustable Spark plugs Bosch FR 6 DC (or equivalent) Turbo: Champion RC7GYC (or equivalent) Spark plug gap 0.028" (0.7 mm) Tightening torque 18.4 ft. lbs. +/- 3.7 ft. lbs. (25 Nm +/- 5 Nm) Front suspension Spring strut suspension with integrated shock absorbers and control [...]

1994 Volvo 850 5th gear 0.70:1 Reverse 3.30:1 Automatic transmission: AW 50-42 LE 4-speed automatic electronically controlled gearbox comprising a hydraulic torque converter with a lock- up function; planetary gear, integrated final drive. Operation via a floor mounted gear selector lever. Drive shafts with symmetrical joint location. Final drive r[...]

1994 Volvo 850 pg. 9:6 Specifications (cont.) Electrical system 12 Volt, negative ground. Voltage-controlled generator. Single-wire system with chassis and engine used as conductors. Battery Voltage 12 V Capacity 520 A/100 min (certain markets) 440 A/85 min The battery contains corrosive and poisonous acids. It is of the utmost importance that old [...]

1994 Volvo 850 License plate light 5 W W 2.1x9.5d 2 Door open warning light 3 W W 2.1x9.5d 4 Door step courtesy light 5W W 2.1x9.5d 2 Trunk light 10 W SV 8.5 1 Glove compartment light 2 W BA 9s 1 Vanity mirror lights 1.2 W – 2 Instrument lighting 3 W W 2.1x9.5d 3 Illumination, control panel gear selector (automatic trans.) rear ashtray seat belt [...]

1994 Volvo 850 pg. 9:7 Specifications (cont.) Dimensions and weights Length 183.4 in. (466 cm) Width 69.3 in. (176 cm) Height 55.9 in. (142 cm) Wheelbase 104.7 in. (266 cm) Track, front 59.8 in. (152 cm) Track, rear 57.9 in. (147 cm) Turning circle (between curbs) 33.5 ft. (10.2 m) Trunk capacity 14.7 cu. ft. (0.44 m³) WARNING! When adding accesso[...]

1994 Volvo 850 Permissible axle weight, rear 850 sedan 1980 lbs (898 kg) 900 kg 850 wagon 2220 lbs (1007 kg) 1010 kg 850 turbo engine sedan 1980 lbs (898 kg) 900 kg 850 turbo engine wagon 2220 lbs (1007 kg) 1010 kg Max. roof load 220 lbs (100 kg) 100 kg Max. trailer weight with brakes (2" ball) 3300 lbs (1500 kg) 1500 kg with brakes (1 7/8&quo[...]

1994 Volvo 850 Volvo supports Voluntary Mechanic Certification by the A.S.E. Certified mechanics have demonstrated a high degree of competence in specific areas. Besides passing exams each mechanic must also have worked in the field for two or more years before a certificate is issued. These professional mechanics are fully able to analyze vehicle [...]

1994 Volvo 850 Vehicle License Number _____________________________________ Vehicle Identification Number (VIN) ____________________________ Service Designation Number __________________________________ Engine Designation (see Specification" section) ____________________ Color code ________________________________________________ Upholstery __[...]

1994 Volvo 850 Back Cover The following should be checked regularly:* 1 Washer fluid reservoir should be filled with water and solvent (wintertime: windshield washer anti- freeze). See page 8:15. 2 Coolant level should be between the expansion tank marks. Mixture 50% anti-freeze and 50% water. See page 8:16. 3 Power steering - When cold, the level [...]

1994 Volvo 850 5 Brake fluid - check, without removing the cap, that the level is above the MIN mark. Use brake fluid DOT 4+. See page 8:12. * Engine oil should be checked each time the car is refuelled. UNLEADED FUEL ONLY VOLVO Octane rating, see p. 4:3. Tire pressure, see label located on inside of fuel filler flap. Bulbs Power Socket 1 HB2 9003 [...]

1994 Volvo 850 Volvo Car Corporation Goteborg, Sweden TP 3490/2 (Canada & USA) 56.000.10.93 Printed in Sweden, Graphic Systems AB, Goteborg 199 Contents | Top of Page file:///K|/ownersdocs/1994/1994_850/94850_9_7.html (7 of 7)12/30/2006 9:48:54 AM[...]