Zephyr ZRM-E36AS инструкция обслуживания

Use, Care, and Installation Guide www .zephyronline.com Model number: Serial Number: SEP07.0101 © Zephyr Corporation Roma Island ZRM-E36AS ZRM-E42AS[...]

www .zephyronline.com[...]

1 SAFETY NOTICE ................................................................. 2-3 LIST OF MA TERIALS ....................................................... 4 INST ALLA TION Ducting Calculation Sheet ....................................... 5 Mounting Height & Clearance ................................ 6 Ducting Options .....................[...]

Important Safety Notice READ AND SA VE THESE INSTRUCTIONS 2 www .zephyronline.com W ARNING TO REDUCE THE RISK OF FIRE OR ELECTRIC SHOCK, DO NOT USE THIS F AN WITH ANY SOLID-ST A TE CONTROL DEVICE. W ARNING TO REDUCE THE RISK OF FIRE ELECTRIC SHOCK, OR INJURY TO PERSONS, OBSER VE THE FOLLOWING: a. Use this unit only in the manner intended by the man[...]

Important Safety Notice 3 W ARNING TO REDUCE THE RISK OF FIRE, USE ONL Y MET AL DUCTWORK. CAUTION 7 RUHGXFHULVNRI¿UHDQGWRSURSHUOH[KDXVWDLURXWVLGH'RQRWYHQWH[KDXVWDLULQWRVSDFHVZLWKLQZDOOVFHLOLQJV attics, crawl spaces or garages. OPERA TION $OZDVOHDYHVDIHWJULOOHV[...]

List of Materials 4 www .zephyronline.com MODEL: ZRM-E36AS, ZRM-E42AS 2 Top Duct Covers 1 Top Support Frame 2 Bottom Duct Covers 1 Bottom Support Frame 2 Thin Trim Pieces 2 Thick Trim Pieces 1 Hood 4 Halogen Light Bulbs (pre-installed) 2 Metal Filters ( 3 - ZRM-E42AS) 3 Wire Nuts 4 ø14 OD / ø6.5 ID W ashers 4 M5 Wing Nuts 4 M6*50 Wood Screws 10 M[...]

5 Duct pieces To t a l Equivalent number length x used = 3-1/ 4” x 10” Rect., straight 1 F t. x ( ) = Ft. 8” Round, straight 1 F t. x ( ) = Ft. 3-1/ 4” x 10” Rect. 9 0 0 elb ow 15 F t. x ( ) = Ft. 3-1/ 4” x 10” Rect. 45 0 elb ow 9 F t. x ( ) = Ft. 3-1/ 4” x 10” Rect. 9 0 0 flat elb ow 24 F t. x ( ) = Ft. 3-1/ 4” x 10” Rect. wa[...]

Installation – Mounting Height & Clearance 6 www .zephyronline.com DUCTING A minimum of 6” round or 3-1/4 x 10” rectangular GXFWPXVWEHXVHGWRPDLQWDLQPD[LPXPDLUÀRZ HI¿FLHQF  Always use rigid type metal ducts only . Flexible GXFWVFRXOGUHVWULFWDLUÀRZEXSWR Use calculation w[...]

7 W ARNING FIRE HAZARD NEVER exhaust air or terminate duct work into spaces between walls, crawl spaces, ceiling, attics or garages. All exhaust must be ducted to the outside, unless using the recirculating option. Use single wall rigid Metal ductwork only . )DVWHQDOOFRQQHFWLRQVZLWKVKHHWPHWDOVFUHZVDQGWDSHDOOMRLQWVZ?[...]

8 www .zephyronline.com Installation – +RRG6SHFL¿FDWLRQV 3/4” 7 1/8 ” 10 3/4 ” 7 7/8 ” 10 1/8 ” 12 3/8 ” 8 3/4 ” FRONT 36” or 42” 27” 12” 14” 4” T op Support Frame (ceiling bracket) T op of Hood (blower housing) Side of Hood Front of Hood C/L 4 1/2 ” 3” 1 5/8 ” electrical K/O 1 1/8 ” 1/4” ø5 7/8” 11 5/8 [...]

9  $GGDQGVHFXUHZRRGEORFNLQJ minimum 2 x 4 RQWRFHLOLQJMRLVWV 2. Fasten top support frame to desired location on ceiling using 4 2” wood screws with washers. The wider section of the support bracket faces the front of the hood. 3. Determine height requirement and secure bottom support frame to top support f[...]

10 www .zephyronline.com 7 8 10 9 11 Top Duct Covers Top Support Frame Bottom Duct Covers Bottom Support Frame Thin Trim Piece Thick Trim Piece  $VVHPEOHWRSGXFWFRYHUV With louver holes RYHUVXSSRUWIUDPH8VH0VFUHZV 3 on each side WRVHFXUHGXFWFRYHUVWRHDFK[...]

11 Ductless recirculating is intended for applications where an exhaust duct work is not possible to be installed. When converted, the hood functions as a recirculating hood rather than an exhaust hood. Fumes and exhaust IURPFRRNLQJDUHGUDZQDQG¿OWHUHGEDVHWRIRSWLRQDOFKDUFRDO¿OWHUV7KHDLULVWKHQSX[...]

12 www .zephyronline.com Blower Off Lights On/Off Blower On/Speed Selection Blower Off Blower On/Speed Selection Lights On/Off The blower will be switched off by pressing: Switch blower on and select speeds 1 - 3 by pressing: Switch lights on and off by pressing: Controls[...]

13 SURF ACE MAINTENANCE: Clean periodically with hot soapy water and clean cotton cloth. Do not use corrosive or abrasive detergent , or steel wool/scouring pads which will scratch and damage surface. For heavier soil use liquid degreaser . After cleaning it is recommended that you use non-abrasive stainless steel polish/cleaners, to polish and buf[...]

14 www .zephyronline.com REPLACING LIGHT BULBS CAUTION: Light bulb becomes extremely hot when turned on. DO NOT touch bulb until switched off and cooled. T ouching hot bulbs could cause serious burns. Make sure all power is turned off and bulbs are not hot. 5HPRYHEWXUQLQJEXOEFRXQWHUFORFNZLVH1RWH%XOEGRHVQRWXQVFUH[...]

T roubleshooting 15 TROUBLESHOOTING PROCEDURES FOR ROMA Issue Cause What to do After installation, the unit doesn’t work. 1. The power source is not turned ON. 1. Make sure the circuit breaker and the unit’s power is ON. 2. The power line and the cable locking connector is not connecting properly . 2. Check the power connection with the unit is[...]

16 www .zephyronline.com DESCRIPTION P ART# Replacement Parts /LJKW%XOE05*8:HDFK =%6 0HWDO)LOWHUHDFK  Optional Accessories Recirculating Kit, ZRM-E36AS ZRC-0150 Recirculating Kit, ZRM-E42AS ZRC-0151 5HSODFHPHQW&KDUFRDO)LOWHUHDFK?[...]

1-888-880-8368 STAPLE YOUR RECEIPT HERE TO OBTAIN SERVICE UNDER WARRANTY OR FOR ANY SERVICE RELATED QUESTIONS, please call: Zephyr Corporation (referred to herein as “we” or “us”) warrants to the original consumer purchaser (referred to herein as “you” or “your”) of Zephyr products (the “Products”) that such Products will be fre[...]