Lenovo E30 Bedienungsanleitung

Har dwar e Maint enance Manual ThinkP ad Edge 13 ² , E30, and E31[...]

Note: Before using this information and the pr oduct it supports, be sur e to read the gener al information under Appendix A “Notices” on page 117. Sixth Edtion (March 2013) © Copyright Lenovo 2009, 2013. LIMITED AND RES TRICTED RIGHTS NO TICE: If data or softwar e is delivered pursuant a Gener al Services Administr ation “GSA ” contr act,[...]

Contents About this manual . . . . . . . . . . . iii Chapter 1. Safety information . . . . . . 1 General safety . . . . . . . . . . . . . . . . 1 Electrical safety . . . . . . . . . . . . . . . 1 Safety inspection guide . . . . . . . . . . . . 3 Handling devices that ar e sensitive t o electr ostatic discharge . . . . . . . . . . . . . . . . . . 3 [...]

2030 L CD panel and L CD cable . . . . . . . . 84 2040 Hinge kit . . . . . . . . . . . . . . . 86 2050 Wireless LAN ant enna assembly, wir eless WAN antenna assembly, and L CD r ear cover assembly . . . . . . . . . . . . . . . . . 87 Chapter 9. L ocations . . . . . . . . . 91 F ront view . . . . . . . . . . . . . . . . 91 Bottom view . . . . . . . [...]

About this manual This manual contains service and r eference information for the following ThinkPad ® pr oducts. ThinkPad Edge 13” MT 0196, 0197, 0217, 0221, 0250 and 0492 ThinkPad Edge E30 and E31 MT 0196 and 0250 Use this manual along with the advanced diagnostic tests to tr oubleshoot pr oblems. Important: This manual is intended only for tr[...]

iv Hardwar e Maintenance Manual[...]

Chapter 1. Safety information This chapter presents following safety information that you need t o be familiar with before you service a ThinkP ad Notebook. • “General safety” on page 1 • “Electrical safety” on page 1 • “Safety inspection guide” on page 3 • “Handling devices that are sensitive t o electr ostatic dischar ge” [...]

Important: Use only appr oved t ools and test equipment. Some hand tools have handles cover ed with a soft material that does not insulat e you when working with live electrical currents. Many customers have, near their equipment, rubber oor mats that contain small conductive bers t o decrease electr ostatic discharges. Do not use this type o[...]

Safety inspection guide The purpose of this inspection guide is t o assist you in identifying potentially unsafe conditions. As each machine was designed and built, requir ed safety items were installed t o protect users and service t echnicians from injury . This guide addresses only those items. Y ou should use good judgment to identify pot entia[...]

• K eep the parts in prot ective packages until they ar e insert ed into the product. • A void contact with other people. • W ear a gr ounded wrist str ap against your skin to eliminat e static on your body . • P revent the part from t ouching your clothing. Most clothing is insulative and r etains a charge even when you ar e wearing a wris[...]

DANGER DANGER DANGER DANGER DANGER Chapter 1 . Safety information 5[...]

DANGER 6 Hardwar e Maintenance Manual[...]

PERIGO PERIGO PERIGO Chapter 1 . Safety information 7[...]

PERIGO PERIGO PERIGO PERIGO PERIGO DANGER 8 Hardwar e Maintenance Manual[...]

DANGER DANGER DANGER DANGER DANGER Chapter 1 . Safety information 9[...]

DANGER DANGER VORSICHT VORSICHT VORSICHT 10 Hardwar e Maintenance Manual[...]

VORSICHT VORSICHT VORSICHT VORSICHT VORSICHT Chapter 1 . Safety information 11[...]

12 Hardwar e Maintenance Manual[...]

Chapter 1 . Safety information 13[...]

14 Hardwar e Maintenance Manual[...]

Chapter 1 . Safety information 15[...]

16 Hardwar e Maintenance Manual[...]

Chapter 1 . Safety information 17[...]

18 Hardwar e Maintenance Manual[...]

Chapter 2. Important service information This chapter pr esents following important service information that applies t o all machine types supported by this manual: • “Str ategy for r eplacing FRUs” on page 19 – “Str ategy for replacing a hard disk drive” on page 20 – “Important notice for r eplacing a system boar d” on page 20 ?[...]

Strat egy for replacing a hard disk drive Always try t o run a low-level format befor e r eplacing a hard disk drive. This will cause all customer data on the hard disk to be lost. Be sur e that the customer has a current backup of the data befor e doing this task. Attention: The drive startup sequence in the comput er you ar e servicing may have b[...]

“CT O” (Example: 1829-F1U). Also, PEW , eSupport, and the HMM will list these products under the same xed model number . FRU identication for C T O , CMV , and GA V products There are thr ee information r esources to identify which FRUs ar e used t o support C TO , CMV , and GA V products. These sources are PEW , eSupport, and the HMM. Us[...]

22 Hardwar e Maintenance Manual[...]

Chapter 3. Gener al check out This chapter pr esents following information: • “What to do rst” on page 23 • “Checkout guide” on page 24 – “Diagnostics using PC-Doctor for DOS” on page 24 – “L enovo ThinkV antage T oolbo x ” on page 29 – “FRU t ests” on page 29 • “P ower system check out” on page 30 The descrip[...]

Before checking pr oblems with the computer , determine whether the damage is covered under the warr anty by r eferring to the following list: The following are not covered under warr anty: • L CD panel cracked fr om the application of e xcessive for ce or from being dropped • Scr atched (cosmetic) parts • Dist ortion, deformation, or discolo[...]

On the BIOS Setup Utility screen, pr ess F9, Enter , F10, and then Enter . Note: When you initialize the computer congur ation, some devices are disabled, such as the serial port. If you test one of these devices, you will need t o enable it by using Congur ation utility for DOS. The utility is available on the following W eb site: http://sup[...]

Diagnostics Interactive T ests • Run Normal T est • Run Quick T est • CPU/Coprocessor • System boar d • Video Adapter • Fixed Disks • Diskette Drives • Other Devices • Wireless LAN • Advanced Memory T ests • Keyboar d • Video • Internal Speaker • Mouse • Diskette • System Load • Optical Drive T est • Intel WLAN R[...]

Lenovo Solution Center The Lenovo Solution Center pr ogram enables you to tr oubleshoot and resolve computer pr oblems. It combines diagnostic tests, system information collection, security status, and support information, along with hints and tips for maximum syst em performance. Note: The Lenovo Solution Cent er progr am is available only on mode[...]

4. Use the arr ow keys t o select Lenovo Diagnostics and then press Enter . The main screen of the UEFI diagnostic progr am is displayed. 5. F ollow the instructions on the screen to use the diagnostic pr ogram. The options on the main screen ar e as follows: T ests T ools • Quick Memory T est • Quick Stor age Device T est • Exit Application [...]

Lenovo ThinkV antage T oolbo x Lenovo ThinkV antage ® T oolbo x is a diagnostic progr am that works through the Windows oper ating system. It enables you t o view sympt oms of computer pr oblems and solutions for them, and includes aut omatic notication when action is r equired, computing assistance, advanced diagnostics, and diagnostic history[...]

T able 1. FRU tests (continued) FRU Applicable t est Memory 1. If two DIMMs are installed, remove one of them and run Diagnostics ➙ Advanced Memory T ests . 2. If the problem does not recur , return the DIMM to its place, remove the other one, and run the test again. T r ackP oint or pointing device If the T r ackP oint does not work, check the c[...]

Pin V oltage (V dc) 1 +20 2 0 3 Ground 1 2 3 (20V) Note: Output voltage of pin no.2 of the AC adapter may different fr om the one you are servicing. 3. If the voltage is not correct, r eplace the A C adapter . 4. If the voltage is acceptable, do the following: • Replace the system boar d. • If the problem persists, go to “FRU tests” on page[...]

T erminal V oltage (V dc) 1 + 0 to + 12.6 7 Ground (-) 1(+) 2(+) 6(-) 3 4 5 7(-) 3. If the voltage is less than +11.0 V dc, the batt ery pack has been dischar ged. Note: Recharging will take at least 3 hours, even if the indicator does not turn on. If the voltage is still less than +11.0 V dc after rechar ging, r eplace the battery . 4. If the volt[...]

Chapter 4. Relat ed service information This chapter pr esents following information: • “Restoring the fact ory contents by using Recovery Disc Set” on page 33 • “P asswords” on page 34 • “P ower management” on page 36 • “Symptom-t o-FRU inde x” on page 37 Service Web site: When the latest maintenance diskette and the system[...]

3. P ress F10 to save the Setup Utility conguration changes. F ollow the instructions on the scr een to begin the r ecovery pr ocess. 4. Select your language and click Ne xt . 5. Read the license. If you agr ee with the t erms and conditions, select I accept these terms and conditions and then click Ne xt . If you do not agree with the terms and[...]

service technicians provide any services to r eset either the user or the master HDP , or t o r ecover data fr om the har d disk drive. The hard disk drive can be r eplaced for a scheduled fee. F or how to remove the POP , see “How t o r emove the har d-disk passwor d” on page 35. Supervisor password A supervisor password (SVP) pr otects the sy[...]

2. When the ThinkP ad logo comes up, immediately pr ess F1 to enter BIOS Setup Utility .F or models supporting the P assphrase function, pr ess F1 while HDP icon is appearing on the scr een; then enter the master HDP . F or the other models, ent er the master HDP . Note: T o check whether the ThinkP ad Notebook you ar e servicing supports the P ass[...]

Symptom-to-FRU inde x This section contains following information: • “Numeric error codes” on page 37 • “Error messages” on page 39 • “No-beep symptoms” on page 39 • “L CD-relat ed sympt oms” on page 40 • “Intermitt ent pr oblems” on page 40 • “Undetermined pr oblems” on page 41 The symptom-to-FRU inde x in this [...]

T able 2. Numeric error codes (continued) Symptom or error (beeps, if any) FRU or action, in sequence 0230 Shadow RAM error—Shadow RAM fails at offset nnnn. (two short beeps) System board. 0231 System RAM err or—System RAM fails at offset nnnn. (two short beeps) 1. DIMM. 2. System boar d. 0232 Extended RAM error— Extended RAM fails at offset [...]

T able 2. Numeric error codes (continued) Symptom or error (beeps, if any) FRU or action, in sequence 02F7 F ail-safe timer NMI failed (two short beeps) 1. DIMM. 2. System boar d. 1802 Unauthorized network card is plugged in—T urn off and remove the miniPCI network car d. (two short beeps) 1. Remove the Mini PCI network card. 2. System boar d. 18[...]

T able 4. No-beep sympt oms (continued) Symptom or error FRU or action, in sequence The power -on passwor d prompt appears. A power-on passwor d or a supervisor password is set. T ype the passwor d and pr ess Enter . The har d-disk passwor d prompt appears. A hard-disk passwor d is set. T ype the password and press Enter . L CD-r elated symptoms Im[...]

Undetermined problems If the diagnostic tests did not identify the adapter or device that has failed, if wrong devices ar e installed, or if the system simply is not oper ating, follow these pr ocedures to isolate the failing FRU (do not isolate FRUs that have no defects). V erify that all attached devices are supported by the comput er . V erify t[...]

42 Hardwar e Maintenance Manual[...]

Chapter 5. Status indicators This chapter presents the system status indicators that show the status of the comput er . 1 2 3 4 T able 6. Status indicators Indicator Meaning 1 On-screen indicators Caps lock: Caps L ock mode is enabled. Y ou can enter all alphabetic char acters (A-Z) in uppercase without pr essing the Shift key . Wireless status: Pr[...]

T able 6. Status indicat ors (continued) Indicator Meaning Off: The AC adapt er is not connected. 3 Sleep (standby) status 4 Sleep (standby) status The illumination dot in the ThinkP ad logo on the outer lid of the computer and on the palm rest works as a system-status indicator: it shows whether the computer is in sleep (standby), hibernation, or [...]

Chapter 6. Special k eys This comput er has several special keys at the upper row of the keyboard. T o use each function, directly press the desired key . Note: T o use F1 - F12 functions, press Fn and the desir ed function key simultaneously; this is the default setting. The following table shows the function of each special key . T able 7. Fn key[...]

T able 7. Fn k ey combinations (continued) Special key Description Display brightness up (F8) The computer display becomes bright er . The purpose of this method is to change the brightness level temporarily . T o change the default brightness level, change the settings of the P ower Option in the Control P anel or use the P ower Manager . Wireless[...]

Chapter 7. FRU replacement notices External CRU statement to customers: Some problems with your pr oduct can be r esolved with a replacement part you can install yourself, called a “Cust omer Replaceable Unit” or “CRU . ” Some CRUs are designated as Self-service CRUs and others are designated as Optional-service CRUs. Installation of Self-s[...]

• T or que driver If you have a torque driver , r efer to the “T orque” in the scr ew information table for each st ep. • Make sure that you use the corr ect scr ew. It is r ecommended to use new scr ews for replacements. If you have a tor que scr ewdriver , tighten all scr ews rmly t o the tor que specied in the screw information tab[...]

MTM on rear label: TTTT -C TO S/N SSSSSSS Product ID on r ear label: TTTT -MMM (Use this number when setting Serial Number) In the example, the Serial Number to be input is '1S TTTTMMMSSSSSSS'. Retaining the UUID The Universally Unique Identier (UUID) is a 128-bit number uniquely assigned t o your comput er at production and stor ed in[...]

50 Hardwar e Maintenance Manual[...]

Chapter 8. Removing and replacing a FRU External CRU statement to customers: Some problems with your pr oduct can be r esolved with a replacement part you can install yourself, called a “Cust omer Replaceable Unit” or “CRU . ” Some CRUs are designated as Self-service CRUs and others are designated as Optional-service CRUs. Installation of S[...]

1010 Battery pack Important notice for replacing a battery pack: ThinkV antage T oolbo x has an automatic battery diagnostic that det ermines if the battery pack is defective. A battery pack FRU should not be replaced unless this diagnostic shows that the battery is defective. The only ex ception to this is if the batt ery pack is physically damage[...]

Removal steps of bottom slot cover Note: Loosen the screws 1 , but do not remove them. 2 1 1 1 1 1 When installing: Make sur e that all the pr ojections of the cover ar e attached rmly t o the fr ame. Then secure the scr ews. Applying label to the bottom slot cover When you replace the cover , following label needs t o be peeled off fr om the ol[...]

1 1030 DIMM F or access, remove these FRUs in or der: • “1010 Battery pack” on page 52 • “1020 Bottom slot cover” on page 52 Removal st eps of DIMM 1 a b 1 2 Note: If only one DIMM is used on the computer you are servicing, the car d must be installed in SL O T -0 ( a ), but not in SL OT -1 ( b ). When installing: Insert the notched end[...]

1040 Hard disk drive (HDD) F or access, remove these FRUs in or der: • “1010 Battery pack” on page 52 • “1020 Bottom slot cover” on page 52 Attention: • Do not drop the drive or apply any physical shock t o it. The drive is sensitive to physical shock. Improper handling can cause damage and permanent loss of data. • Befor e removing[...]

3 When installing: Make sure that the HDD connect or is attached rmly . 1050 PCI Express Mini Car d for wireless LAN F or access, remove these FRUs in or der: • “1010 Battery pack” on page 52 • “1020 Bottom slot cover” on page 52 Removal steps of PCI Expr ess Mini C ard for wir eless LAN In st ep 1 , unplug the jacks by using the rem[...]

1 2 2 Step Screw (quantity) Color T or que 2 M2 × 3 mm, at-head, nylon-coated (2) Black 0.181 Nm (1.85 kgfcm) 3 When installing: Plug the gr ay cable into the jack marked MAIN or M , and the black cable into the jack marked AUX or A on the car d. 1060 PCI Express Mini C ard for wireless W AN F or access, remove these FRUs in or der: Chapter 8 .[...]

• “1010 Battery pack” on page 52 • “1020 Bottom slot cover” on page 52 Removal steps of PCI Express Mini Card for wireless W AN In st ep 1 , unplug the jacks by using the removal t ool antenna RF connect or (P/N: 08K7159) or pick the connectors with your ngers and gently unplug them in dir ection of the arr ow. 1 2 2 Step Screw (quan[...]

When installing: Plug the red cable into the jack marked MAIN , and the blue cable into the jack marked AUX on the card. 1070 K eyboard F or access, remove these FRUs in or der: • “1010 Battery pack” on page 52 • “1020 Bottom slot cover” on page 52 Removal st eps of keyboar d 1 1 Step Screw (quantity) Color T or que 1 M2 × 5 mm, at-[...]

3 4 7 6 5 7 8 Installation st eps of keyboar d When installing the keyboar d, do as follows: 1. A ttach the keyboar d connect ors. 2. A ttach the keyboard so that the keyboar d front edges ar e under the fr ame as shown in this gure. 60 Hardwar e Maintenance Manual[...]

3. Secur e the k eyboard by tightening the screws from the bottom side of the computer . 1080 T op case assembly and microphone module F or access, remove these FRUs in or der: • “1010 Battery pack” on page 52 • “1020 Bottom slot cover” on page 52 • “1040 Har d disk drive (HDD)” on page 55 • “1070 Keyboar d” on page 59 Note:[...]

Removal steps of top case assembly and microphone module 2 2 2 2 2 2 Step Screw (quantity) Color T orque 2 M2 × 3 mm, at-head, nylon-coat ed (6) Black 0.181 Nm (1.85 kgfcm) 3 3 3 Step Screw (quantity) Color T orque 3 M2 × 3 mm, at-head, nylon-coat ed (3) Black 0.181 Nm (1.85 kgfcm) 62 Hardwar e Maintenance Manual[...]

4 5 6 7 8 When installing: Mak e sure that the connectors are attached rmly . In step 5 , push the t op case assembly out fr om the frame by using a plastic pry t ool as shown in this gur e. Chapter 8 . Removing and r eplacing a FRU 63[...]

9 9 9 9 9 9 9 9 9 9 10 11 12 12 14 13 1090 Backup battery F or access, remove these FRUs in or der: • “1010 Battery pack” on page 52 • “1020 Bottom slot cover” on page 52 • “1070 Keyboar d” on page 59 • “1080 T op case assembly and microphone module” on page 61 64 Hardwar e Maintenance Manual[...]

Removal steps of backup battery DANGER Use only the battery specied in the parts list for your computer . Any other battery could ignit e or e xplode. 1 2 When installing: Make sure that the connector is attached rmly . 1100 Bluetooth daught er card (BDC-2) F or access, remove these FRUs in or der: • “1010 Battery pack” on page 52 • ?[...]

Removal st eps of BDC-2 1 2 Step Screw (quantity) Color T or que 1 M2 × 3 mm, at-head, nylon-coated (1) Black 0.181 Nm (1.85 kgfcm) When installing: Make sure that the connector is attached rmly . 1110 Speak er assembly F or access, remove these FRUs in or der: • “1010 Battery pack” on page 52 • “1020 Bottom slot cover” on page 5[...]

Removal steps of speaker assembly 1 1 1 1 Step Screw (quantity) Color T or que 2 M2 × 3 mm, at-head, nylon-coated (4) Black 0.181 Nm (1.85 kgfcm) 2 3 3 Cable routing: Make sur e that the connect or is attached rmly and you r oute the cable as shown in this gure. Chapter 8 . Removing and r eplacing a FRU 67[...]

1120 Syst em board and fan assembly Important notices for handling the system board: When handling the syst em board, bear the following in mind. • The system board has an acceleromet er , which can be brok en by applying sever al thousands of G-forces. Note: Dr opping a syst em boar d from a height of as little as 6 inches so that it falls at[...]

F or CUL V (Customer Ultr a-Low V oltage) models (MT0196 and MT0492): a Accelerometer chip for the HDD Active P rotection System ™ c GMCH (Gr aphics Memory Controller Hub) b CPU d ICH (I/O Contr oller Hub) a b c d Chapter 8 . Removing and r eplacing a FRU 69[...]

F or CUL V models (MT0217 and MT0250): a Accelerometer chip for the HDD Active P rotection System c PCH (P eripher al Control Hub) b CPU a b c 70 Hardwar e Maintenance Manual[...]

F or AMD ® models (MT0197): a CPU c South Bridge b North Bridge d Accelerometer chip for the HDD Active P rotection System a b d c F or AMD models (MT0221): a Accelerometer chip for the HDD Active P rotection System c North Bridge b CPU d South Bridge b c a d Chapter 8 . Removing and r eplacing a FRU 71[...]

1 1 1 2 2 Step Screw (quantity) Color T or que 1 M2 × 3 mm, at-head, nylon-coated (3) Black 0.181 Nm (1.85 kgfcm) Note: Loosen the screws 2 , but do not remove them. 72 Hardwar e Maintenance Manual[...]

3 4 When installing: Mak e sure that the connectors are attached rmly . a 8 5 6 7 Chapter 8 . Removing and r eplacing a FRU 73[...]

When installing: Attach the system boar d so that the battery pins of the system boar d are attached rmly t o the guide hole of the base cover as shown in a in this. Make sur e that the connectors ar e attached rmly . Note: Loosen the screws 9 , but do not remove them. 9 9 11 10 When installing: • Befor e you attach the fan assembly to the [...]

F or MT0197: a a F or MT0217 and MT0250: a F or MT0221: a a When installing: Mak e sure that the fan connector is attached rmly . 1130 I/O card assembly, audio cable, and I/O cable F or access, remove these FRUs in or der: • “1010 Battery pack” on page 52 • “1020 Bottom slot cover” on page 52 • “1040 Har d disk drive (HDD)” on [...]

• “1110 Speaker assembly” on page 66 • “1120 S ystem board and fan assembly” on page 68 Removal steps of I/O card assembly, audio cable, and I/O cable 2 1 1 1 1 Step Screw (quantity) Color T or que 2 M2 × 3 mm, at-head, nylon-coated (1) Black 0.181 Nm (1.85 kgfcm) 3 4 5 6 76 Hardwar e Maintenance Manual[...]

Cable routing: Make sure that the connectors are attached rmly and you r oute the cables as shown in this gur e. 1140 L CD unit F or access, remove these FRUs in or der: • “1010 Battery pack” on page 52 • “1020 Bottom slot cover” on page 52 • “1040 Har d disk drive (HDD)” on page 55 • “1050 PCI Expr ess Mini C ard for wi[...]

Removal st eps of L CD unit 1 1 1 1 1 2 2 2 2 Step Screw (quantity) Color T or que 2 M2.5 × 5 mm, at-head, nylon-coat ed (4) Black 0.392Nm (4 kgfcm) 78 Hardwar e Maintenance Manual[...]

3 3 Cable routing: Make sur e that the cables ar e attached to the cable guides as shown in this gur e. When you rout e the cables, make sur e that they are not subject ed t o any tension. T ension could cause the cables to be damaged by the cable guides, or a wir e to be broken. Chapter 8 . Removing and r eplacing a FRU 79[...]

1150 Base cover assembly and DC-in cable F or access, remove these FRUs in or der: • “1010 Battery pack” on page 52 • “1020 Bottom slot cover” on page 52 • “1040 Har d disk drive (HDD)” on page 55 • “1050 PCI Expr ess Mini C ard for wireless LAN” on page 56 • “1060 PCI Expr ess Mini C ard for wireless WAN” on page 57 ?[...]

Applying labels to the base cover The new base cover FRU is shipped with a kit containing labels of sever al kinds. When you replace the base cover , you need to apply the following labels: If the Windows Certicate of Authentication label (COA) 2 is attached t o a part that is replaced, return the old part with the label attached to the customer[...]

F or the location of each label, refer to the following gure: 1 16 15 14 9 8 2 3 4 5 11 6 7 10 12 13 2010 L CD bez el assembly F or access, r emove this FRU: • “1010 Battery pack” on page 52 Removal steps of L CD bez el assembly 1 1 1 1 Step Screw cap Screw (quantity) Color T or que 1 M2 × 4 mm, at-head, nylon-coated (4) Silver 0.181 N[...]

2 2 2 2 2 2 2 2 2 2 2020 Integr ated camer a F or access, remove these FRUs in or der: • “1010 Battery pack” on page 52 • “2010 L CD bez el assembly” on page 82 Removal steps of integrat ed camer a 1 2 When installing: Make sur e that the connector of the integr ated camer a is attached rmly . Chapter 8 . Removing and r eplacing a FR[...]

2030 L CD panel and L CD cable F or access, remove these FRUs in or der: • “1010 Battery pack” on page 52 • “1020 Bottom slot cover” on page 52 • “1040 Har d disk drive (HDD)” on page 55 • “1050 PCI Expr ess Mini C ard for wireless LAN” on page 56 • “1060 PCI Expr ess Mini C ard for wireless WAN” on page 57 • “1070[...]

2 3 4 5 6 7 8 Chapter 8 . Removing and r eplacing a FRU 85[...]

10 2040 Hinge kit F or access, remove these FRUs in or der: • “1010 Battery pack” on page 52 • “1020 Bottom slot cover” on page 52 • “1040 Har d disk drive (HDD)” on page 55 • “1050 PCI Expr ess Mini C ard for wireless LAN” on page 56 • “1060 PCI Expr ess Mini C ard for wireless WAN” on page 57 • “1070 Keyboar d”[...]

Removal st eps of hinge kit 2 1 1 2 Step Screw (quantity) Color T or que 2 M2 × 3 mm, at-head, nylon-coated (2) Black 0.181 Nm (1.85 kgfcm) 3 3 2050 Wireless LAN antenna assembly, wir eless W AN ant enna assembly, and L CD r ear cover assembly F or access, remove these FRUs in or der: • “1010 Battery pack” on page 52 Chapter 8 . Removing [...]

• “1020 Bottom slot cover” on page 52 • “1040 Har d disk drive (HDD)” on page 55 • “1050 PCI Expr ess Mini C ard for wireless LAN” on page 56 • “1060 PCI Expr ess Mini C ard for wireless WAN” on page 57 • “1070 Keyboar d” on page 59 • “1080 T op case assembly and microphone module” on page 61 • “1110 Speaker [...]

Cable routing: When you install the antenna assembly, r oute the cables as shown in the gur es below . As you rout e the cables, make sur e that they ar e not subjected t o any tension. T ension could cause the cables t o be damaged by the cable guides, or a wire to be broken. a : Wir eless LAN MAIN ant enna (gr ay) b : Wir eless W AN MAIN anten[...]

90 Hardwar e Maintenance Manual[...]

Chapter 9. L ocations This chapt er pr esents the location of ThinkP ad Edge 13” featur es and hardwar e. F ront view 1 Integr ated camer a (for some models) 2 P ower switch 3 AC power connector 4 Status indicators Note: F or the description of each indicator , see Chapter 5 “Status indicat ors” on page 43. 5 P ower universal serial bus (USB)[...]

1 2 3 4 5 6 7 8 13 15 14 12 9 10 11 Bottom view 1 Battery pack latch 2 Battery pack 3 Security keyhole 4 External monitor connector 5 HDMI port 6 RJ-45 (E thernet) connect or 7 P ower USB connector (MT0196, MT0197, and MT0492) eSA T A/USB connector (MT0217, MT0221, and MT0250) 8 Built-in st ereo speakers 9 HDD slot door 1 1 2 3 4 5 6 7 8 9 92 Hardw[...]

Chapter 10. P arts list This chapter contains following lists of the service parts. • “Overall” on page 94 • “L CD FRUs” on page 102 • “Keyboar d” on page 105 • “ AC adapt ers” on page 106 • “Miscellaneous parts” on page 107 • “P ower cor ds” on page 107 • “Recovery discs” on page 108 • “Common service [...]

• FRUs marked with OP ar e available as options. Overall 1 2 5 3 4 6 7 9 8 10 11 12 13 14 15 16 17 18 19 20 21 94 Hardwar e Maintenance Manual[...]

T able 8. Parts list—Overall No. FRU (Over all) FRU no. CRU ID 1 L CD unit (see “L CD FRUs” on page 102.) 2 Keyboar d (see “K eyboard” on page 105.) 3 T op case assembly for 0196, 0197, and 0429 60Y5520 No 3 T op case assembly for 0217, 0221, and 0250 04W0342 No 4 Qualcom Gobi-2000 WWAN, WW SK U • 0196-C TO , • 0197-C TO • 0492-C TO[...]

T able 8. P arts list—Overall (continued) No. FRU (Over all) FRU no. CRU ID 5 ThinkP ad 2x2 11a/b/g/n Wir eless LAN PCI Express Half Mini Car d Adapter • 0217-C TO , 39x • 0221-C TO , 38x • 0250-C TO 60Y3251 ** 5 Intel ® Centrino ® Wireless-N 1000 • 0196-C TO , 23x, 24x, 25x, 26x, 2Ax, 2Bx, 57x, 2Dx, 2Ex, 2Fx, 2Gx, 2Kx, 2Lx, 2Px, 2Qx, 2[...]

T able 8. P arts list—Overall (continued) No. FRU (Over all) FRU no. CRU ID 6 2-GB DDR3-1067 SDRAM SO-DIMM (PC2-8500) car d • 0196-all • 0197-C TO • 0492-all 55Y3713 ** 6 2-GB DDR3-1333 SDRAM SO-DIMM (PC3-10600) car d • 0196-all • 0197-C TO • 0492-all • 0217-C TO , 31x, 22x, 29x, 2Ax, 2Bx, 2Hx, 2Px, 3Cx, 3Bx, 3Ex • 0221-C TO , 37x[...]

T able 8. P arts list—Overall (continued) No. FRU (Over all) FRU no. CRU ID 14 SA T A har d disk drive, 160 GB, 5,400 rpm • 0196-C TO , 3Qx, 4Qx • 0197-C TO , 2Kx, 2Lx, 2Sx, 39x, 3Fx • 0492-C TO , 2Gx, 2Hx, 43x, 44x, 45x, 46x, 47x, 48x, 49x, 4Ax • 0217-C TO • 0221-C TO • 0250-C TO 60Y4755 75Y5061 75Y5071 ** 14 SA T A har d disk drive,[...]

T able 8. P arts list—Overall (continued) No. FRU (Over all) FRU no. CRU ID 14 SA T A har d disk drive, 320 GB, 7,200 rpm • 0196-C TO , 24x, 25x, 26x, 3Kx, 4Xx, 4Yx, 5Qx • 0197-C TO , 22x 23x 29x, 2Ax, 2Cx, 73x, 2Zx, 6Zx, 78x • 0492-C TO , 42x, 4Cx 60Y4773 45N7281 ** 14 SA T A har d disk drive, 320 GB, 7,200 rpm • 0196-C TO , 24x, 25x, 26[...]

T able 8. P arts list—Overall (continued) No. FRU (Over all) FRU no. CRU ID 18 Syst em board assembly, Intel Core 2 Solo processor (SU4100) • 0196-C TO • 0492-C TO , 26x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Ux, 2Vx, 2Wx, 2Xx, 2Yx, 2Zx, 32x, 33x, 37x, 38x, 39x, 3Ax, 3Bx, 3Cx, 3Dx[...]

T able 8. P arts list—Overall (continued) No. FRU (Over all) FRU no. CRU ID 19 Bluet ooth daught er car d (BDC-2.1) • 0196-C TO , 22x, 23x, 24x, 25x, 26x, 27x, 28x, 29x, 2Ax, 2Bx, 2Cx, 57x, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx, 2Lx, 2Mx, 2Px, 2Qx, 2Rx, 2Wx, 2Xx, 2Yx, 2Zx, 32x, 33x, 34x, 35x, 36x, 37x, 38x, 39x, 3Ax, 3Bx, 3Cx, 3Dx, 3Ex, 3Fx, 3Gx, 3[...]

L CD FRUs 1 2 4 5 6 7 3 8 102 Hardwar e Maintenance Manual[...]

T able 9. P arts list—13.3-inch HD LED-backlight L CD No. FRU (13.3-inch HD LED-backlight L CD) FRU no. CRU ID 1 L CD bezel assembly for 0196, 0197, and 0492 60Y5527 No 1 L CD bezel assembly for 0217, 0221, and 0250 04W0348 No 2 Hinges, black • 0196-C TO , 22x, 24x, 25x, 26x, 27x, 28x, 2Ax, 2Bx, 57x, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx, 2Lx, 2Mx,[...]

T able 9. Parts list—13.3-inch HD LED-backlight L CD (continued) No. FRU (13.3-inch HD LED-backlight L CD) FRU no. CRU ID 3Kx, 52x, 3Qx, 3Rx, 3Sx, 3Tx, 3Ux, 3Vx, 3Wx, 3Xx, 3Yx, 3Zx, 42x, 43x, 44x, 45x, 46x, 47x, 48x, 49x, 4Ax, 4Bx, 4Cx, 4Dx • 0217-C TO , 31x, 22x, 29x, 2Ax, 2Bx, 2Hx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 2Ux, 39x, 3Cx, 3Bx, 3Ex • 0221-C T[...]

T able 9. Parts list—13.3-inch HD LED-backlight L CD (continued) No. FRU (13.3-inch HD LED-backlight L CD) FRU no. CRU ID 7 Wireless LAN/W AN ant enna cable set • 0196-C TO , 22x, 2Ex, 2Gx, 2Jx, 2Lx, 2Qx, 34x, 36x, 38x, 3Ax, 3Cx, 55x, 56x, 4Ux, 5Gx, 5Hx, 5Jx, 5Kx, 5Mx • 0197-C TO , 22x 23x 2Qx, 2Tx, 2Ux, 2Vx, 36x, 3Dx, 3Jx, 4Qx, 4Sx, 4Ux, 6Kx[...]

T able 10. Parts list—K eyboard (continued) Language FRU No. CRU ID Italian 60Y9455, 60Y9525 Japanese 60Y9469, 60Y9539 Kazakhstan 60Y9456, 60Y9526 Kor ean 60Y9470, 60Y9540 Latin American Spanish 60Y9441, 60Y9511 Norwegian 60Y9458, 60Y9528 P olish 60Y9459, 60Y9529 P ortuguese 60Y9460, 60Y9530 Russian 60Y9461, 60Y9531 Slovak 60Y9462, 60Y9532 Sloven[...]

Miscellaneous parts T able 13. P arts list—Miscellaneous parts FRU FRU no. CRU ID Microphone module 60Y5753 No P ower switch board for 0196, 0197, and 0492 75Y5539 No P ower switch board for 0217, 0221, and 0250 04W0356 No Screw kit: • M1.7 × 3 mm (silver), at-head (6) • M2 × 3 mm (black), at-head (38) • M2 × 4 mm (silver), at-h[...]

T able 15. P arts list—3-pin power cords (continued) Country or region FRU No. CRU ID Israel • models -CT O , xxG 42T5062, 42T5147 Italy • models -CT O , xxG 42T5047, 42T5132 Kor ea • models -CT O , xxK 42T5077, 42T5162 Switzerland • models -CT O , xxG 42T5044, 42T5129 T aiwan • models -CT O , xxV 42T5071, 42T5156 U.K./Hong Kong S.A.R. [...]

T able 17. Parts list—Windows 7 Home Basic (32 bit) recovery DVDs Language P/N (with MS 2010) CRU ID Arabic 04T1613 Brazilian P ortuguese 04T1614 F rench 04T1617 Indian English 04T1616 P ortuguese 04T1618 Russian 04T1620 Russian English 04T1619 Spanish 04T1621 Serbian-Latin 04T1622 Simplied Chinese 04T1615 T urkish 04T1623 US English 04T1624 *[...]

T able 19. P arts list—Windows 7 Home Premium (32 bit) recovery DVDs Language P/N (with MS 2010) CRU ID Indian English 04T1626 Simplied Chinese 04T1625 US English 04T1627 * Windows 7 Home Pr emium (64 bit) DVDs Windows 7 Home Pr emium (64 bit) is preinstalled as the oper ating system in the following models: • 0196-C T O, 33x, 34x, 35x, 36x,[...]

• 0217-C T O, 22x, 2Qx, 2Rx, 39x, 3Bx • 0221-C T O, 38x, 39x, 3Ax, 3Fx • 0250-C T O, 22x, 23x, 24x, 25x, 2Jx, 2Kx, 2Lx, 2Mx T able 21. P arts list—Windows 7 Home Premium (64 bit) recovery DVDs Language P/N CRU ID Arabic 04T1628 Brazilian P ortuguese 04T1629 C&L Croatia (Cr oatian/Slovenian/English) 04T1654 C&L EMEA (Dutch/F rench/Ge[...]

T able 22. Parts list—Windows 7 professional (32 bit) recovery DVDs Language P/N (with MS 2010) P/N (with MS 2007) CRU ID Arabic 03W6637 58Y4065 Brazilian P ortuguese 03W6638 58Y4066 C&L BelLux (English/F r ench/German/Dutch) 03W6665 58Y4092 C&L Hong Kong (Hong Kong/English/Simplied Chinese) 03W6668 03W6296 C&L Sweden (English/Finl[...]

• 0197-C T O, 22x 23x 25x 73x, 2Dx, 2Nx, 2Ux, 3Mx, 3Nx, 3Qx, 4Qx, 4Sx, 4Ux, 6Nx, 6Px, 6Wx, 7Gx, 7Hx, 7Kx, 7Lx, 7Nx, 7Zx, 82x, 83x, 85x • 0492-C T O T able 23. Parts list—Windows 7 Professional (64 bit) recovery DVDs Language P/N (with MS 2010) P/N (with MS 2007) CRU ID Arabic 03W6689 58Y4095 Brazilian P ortuguese 03W6690 58Y4096 C&L BelLu[...]

• 0217-C T O, 31x, 2Bx, 2Hx, 2Sx, 2Tx, 2Ux, 3Cx • 0221-C T O, 37x • 0250-C T O T able 24. Parts list—Windows 7 Professional (64 bit) recovery DVDs Language P/N CRU ID Arabic 04T1655 Brazilian P ortuguese 04T1656 C&L Croatia (Cr oatian/Slovenian/English) 04T1682 C&L EMEA (Dutch/F rench/German/English) 04T1680 C&L Hong Kong S.A.R.[...]

T able 25. P arts list—Common service tools (continued) T ool P/N 1/4" Sq. to 1/4" hex t orx adapt er 93F2838 TR7- TR-10 tamper resistant t orx bits 00P6967 Removal tool antenna RF connector 08K7159 USB 2.0 CD-RW/DVD-ROM combo drive II 40Y8687 USB cable 40Y8704 USB oppy diskette drive for maintenance disk ette 05K9283 USB oppy dis[...]

116 Hardwar e Maintenance Manual[...]

Appendix A. Notices Lenovo may not offer the pr oducts, services, or features discussed in this document in all countries. Consult your local Lenovo repr esentative for information on the pr oducts and services curr ently available in your area. Any refer ence to a L enovo pr oduct, progr am, or service is not int ended to state or imply that only [...]

T rademarks The following terms are tr ademarks of L enovo in the Unit ed Stat es, other countries or both: Active P rot ection System Lenovo ThinkP ad ThinkV antage T rackP oint UltraNav Microsoft and Windows ar e trademarks or register ed tr ademarks of the Microsoft gr oup of companies. The following terms ar e tr ademarks of Int el Corpor ation[...]

[...]

Part Number: 63Y0744_05 Printed in China (1P) P/N: 63Y0744_05 *1P63Y0744_05*[...]