Coleman 9422 Series manual

IMPORT ANT Read this manual carefully bef ore assembling, using or servicing these stoves . K eep this manual f or future reference . If you ha ve questions about assemb ly , operation, servicing or repair of these stoves, please call Coleman at 1-800-835-3278 or TDD: 316-832-8707. In Canada call 1-800-387-6161. Propane Sto ve Instructions for use [...]

English-1 If y ou smell gas: 1. Do not attempt to light appliance. 2. Extinguish any open flame. 3. Disconnect from fuel supply . FOR YOUR SAFETY Do not store or use gasoline or other liquids with flammable v apors in the vicinity of this or any other appliance. FOR YOUR SAFETY CARBON MONO XIDE HAZARD • This appliance can pr o- duce carbon mono x[...]

English-2 • This product is fueled by propane gas. Propane gas is invisible , odorless, and flammable. An odorant is normally added to help detect leaks and can be described as a ”rotten egg ” smell. The odorant can fade o ver time so leaking gas is not alwa ys detectable by smell alone . • Propane gas is heavier than air and leaking propan[...]

English-3 T o Set Up T echnical Characteristics Input: 30,000 BTU/H Category: Pressure regulated propane Fuel: 16.4 oz. disposable propane cylinders Regulator: 5430 DANGER • CARBON MONO XIDE HAZARD • For outdoor use only . • Nev er use inside house, camper , tent, vehicle or other unv entilated or enclosed areas. This stove consumes air (o xy[...]

Fig. 11 ■ Propane cylinder correctly installed (Fig. 10). ■ Never operate sto ve with propane cylinder in an inv er ted position (Fig. 11). Fig. 8 Fig. 8 Fig. 10 W ARNING • P erform leak test outdoors. • Extinguish all open flames. • NEVER leak test when smoking. • Do not use the outdoor stove until connection has been leak tested and d[...]

T o T urn Off ■ Close the burner valves firmly (Fig. 15). Fig. 15 T o Clean ■ Make sure stove is cool. ■ Move stov e awa y from flame (including pilot lights) and other ignition sources . ■ Remove propane cylinder from regulator and replace protective cap on cylinder (Fig. 16). ■ Remove regulator from stov e (Fig. 17). • MAINTENANCE •[...]

■ For storage or transport, the regulator may be located in the reservoir on the food prep side (Fig. 19). Fig. 19 Fig. 20 ■ T o carry the stove, check to make sure the latches on the side are snapped closed and secure, then firmly grasp the stove b y the handle (Fig. 20). Fuel Delivery System English-6 T o Set Up with a 20# Cylinder General Sa[...]

English-7 • A T ype 1 compatible cylinder with a T ype 1 cylinder valv e has a back-check v alve which does not permit gas flow , until a positive seal has been obtained. • The cylinder must be arranged in an upright position for v apor withdraw al. It must also include a collar to protect the cylinder valv e. A safety relief device ha ving dir[...]

English-8 1. 20 lb. Refillable Cylinder (purchase separately) 2. Fuel Hose 3. Regulator Attachment Kit Features Fig. 22 Connecting 20 lb. Pr opane Gas Cylinders NOTE: Y our 9422 Series stove is set up from the factory to use a 20 lb. refillable propane cylinder . Y ou may purchase a 20 lb . propane cylinder from the store where you bought your stov[...]

5. Set the LP Cylinder a flat and level surf ace with the outlet valv e facing to ward the back of the stove . 6. Check that the cylinder valv e is closed by turning the cylinder knob clockwise to a full stop (Fig. 26). Fig. 26 7. Check that both stove control knobs are in the off position (Fig. 27). 8. Remove the protective caps from the cylinder [...]

English-10 1. Make a soap y solution of equal par ts mild liquid dishwashing detergent and water . 2. T ur n off all burner control knobs. 3. T ur n on the fuel supply . T ur n the cylinder valv e knob counterclockwise (right to left) one rotation. 4. Apply a soap solution to the connections indicated with the arrows in Fig. 30. If bub bles appear [...]

English-11 CAUTION Be cer tain the gas is shut off at the L.P . cylinder valve anytime the sto ve is not in use. Follow These Steps: 1. Shut off the gas at the burner valv e(s) and stay a wa y! 2. Allow the fire to burn itself out. 3. Once the fire is out and the appliance has cooled, shut off the L.P . cylinder valve. 4. Clean all par ts and inspe[...]

TYPE 1 CONNECTION English-12 Y OUR NEW GAS ST O VE IS EQ UIPPED WITH A TYPE 1 CONNECTION DEVICE WHICH HAS 3 SAFETY FEA TURES (FIG. 32): 1. Proof of gas seal between the connector and the cylinder before gas flo w takes place. 2. A flow-limiting de vice designed to limit the flow of gas in the e vent of a regulator or hose failure . 3. The connectio[...]

Griddle Fig. 33 Griddle ■ Lay the griddle on the left or right side of the grate ov er the burner. The feet on the bottom side of the griddle must engage the grate (Fig. 33). Storing the Griddle and the Cutting Board ■ Inser t one edge of the griddle into the channel on the food prep side . Push the gr iddle into the channel against the foam ru[...]

English-14 Parts List 1 15 Accessory (sold separately) Item P ar t No. Description 17 R9422-100C Carry Case No. Part Number Description 1 9422-3161 P ot Suppor t / Grate 2 9422-1031 Cutting Board 3 9422-3151 Griddle 4 9422-5731 Pa r tition Kit (3 pk.) 5 9422-1011 Storage Bin 6 9422-1021 Reservoir / Basin 7 9422-1551 Cook T op 8 5430-5651 Regulator [...]

9422-050T (20070607) The Coleman Company , Inc. • 3600 North Hydraulic • Wichita, KS 67219 U .S.A. 1-800-835-3278 • TDD: 316-832-8707 Sunbeam Corporation (Canada) Limited • DBA Jarden Consumer Solutions 20B Herford Street • Brampton (Ontario) • L6Y 0M1 • 1 800 387-6161 © 2007 The Coleman Company , Inc. All rights reser ved. Coleman®[...]