Intel 3U Compact PCI manual

MIC-3321 3U Comp actPCI Pentium M 760 2.0G High-performance Controller User Manual[...]

MIC-3321 User Manual ii Copyright Notice This document is copyrighted, 200 4. All rights are reserved. The original manufacturer reserves the right to make improvements to the products described in this manual at any time wi thout notice. No part of this manual may be reproduced, cop ied, translated or transmitted in any form or by any means withou[...]

iii Product W arranty Advantech warrants to you, the orig inal purchaser , that each of its products will be free from defects in materials and workmanship for two years from the date of purchase. This warranty does not apply t o any products which have b een repaired or altered by persons other than repair perso nnel authorized by Advantech, or wh[...]

MIC-3321 User Manual iv T echnical Support and Assistance Step 1. V isit the Advantech web site at www .advantech.com/support where you can find the latest information about the product. Step 2. Contact your distrib utor , sales representative, or Advantech's cus- tomer service center for technical support if you need additional assistance. Pl[...]

v Table of Contents Contents Chapter 1 Hardware Co nfiguration ................................ 2 1.1 Introduction ............ ............................ ............ ........... ........ 2 1.2 Specifications ............ .............. .............. .............. .............. 3 1.2.1 Standa rd SBC Functions ........... ........... .........[...]

MIC-3321 User Manual vi 4.2.5 PNP /PCI Configuration Setup .. ............. ........... ........... 29 Figure 4.6:PNP/PCI c onfiguration screen ...... ............. 29 4.2.6 PC Hea lth Status ... ............. ........... .............. ........... ...... 30 Figure 4.7:PC Health Status set up screen ......... ........... 31 4.2.7 S pread Spectrum C[...]

22 CHAPTER 1 Hardware Configuration[...]

MIC-3321 User Manual 2 Chapter 1 Hardware Configuration 1.1 Introduction MIC-3321 is a 3U, all-in-one, controller board, complian t with PICMG 2.0 R2.1 CompactPC I specifications. For high com puting performance, MIC-3321 uses an Intel Pentium M 760 2.0G Hz CPU and Intel 915GM chipset. This CPU provides high performance wit h its on-chip 2 MB L2 ca[...]

3 Chapter 1 1.2 Specifications 1.2.1 St andard SBC Functions • CPU: MIC-3321 su pports Intel Pentium M 2.0 GHz • Optional: Celeron M 1.0GHz/ Celeron M 800MHz (non cache) • BIOS: A ward 4 Mb flash me mory • Chipset : Intel 915GM Graphics and Memory Cont roller Hub (GMCH) Intel 82801FBM I/O Controller Hub (ICH6M) • System Memory: Directed S[...]

MIC-3321 User Manual 4 1.2.2 Display • Controller: Intel Graphics Media Accelerator 900 • VRAM: DVMT3.0 128MB • Resolution: Up to 2048x1536 with 32-bit color at 75Hz 1.2.3 Mechanical and Environment al Specifications • Board Size (W x H) : 160 x 100 mm (3U) • Operating T emperature: 0 ~ 50° C (MIC-3321 Pentium M 2.0GHz) 0~50° C (MIC-332[...]

5 Chapter 1 1.4 Board Dimensions Figure 1.2: MIC-3321 Board Dimensions 1.5 Dip Switch Settings Since MIC-3321 is composed of one main board and on e daughter board, for ease of understanding and a convenient naming, we wil l use 1F (1st level) to represent the main board, an d 2F (2nd level) to represent the daughter board hereafter in this manual.[...]

MIC-3321 User Manual 6 1.5.1 Switch Locations T able 1.1 lists the switch functions of MIC-3321 (be sure that the switch is white one). Figure 1.3 and Figure 1. 4 show the location s of S1 and S2, respectively . Figure 1.3: MIC-3321 S1 Location (1F) T able 1.1: MIC-3321 Switch Descriptio ns DIP-SW Mode Setting Function 1F-S1 Mode Bit-1 : ON LAN1 on[...]

7 Chapter 1 Figure 1.4: MIC-3321 S2 Location (2F) 1.6 Safety Precautions Follow these simple precautions to protect yourself and the products. 1. T o avoid electrical shock, always disconnect the power from your PC chassis before you work on it. Don't touch any compo nents on the CPU card or other cards while the PC is on. 2. Disconnect power [...]

MIC-3321 User Manual 8[...]

22 CHAPTER 2 Connecting Peripherals[...]

MIC-3321 User Manual 10 Chapter 2 Connecting Peripherals 2.1 Connectors Figure 2.1 and 2.2 show MIC-3321 connector locations. Figure 2.3 shows MIC-3521 connector locat ion. Figure 2.1: MIC-3321 Connector Locations (1F) Figure 2.2: MIC-3321 Connector Locations (2F)[...]

11 Chapter 2 Figure 2.3: MIC-3521 Connectors[...]

MIC-3321 User Manual 12 T able 2.1: MIC-3321 Connectors Overview Number Function Description 1F-CN1 USB1 USB1 T ype -A Female on Front side panel. 1F-CN3 USB2 USB2 T ype -A Female on Front side panel. 1F-CN2 CF CompactFlash socket 1F-CN5 VGA D-Sub 15-pin (Female) on Front side panel. 1F-RJ1 LAN1 10/100/1000Base-TX Ethernet on Front side panel. 1F-S[...]

13 Chapter 2 2.2 Card Inst allation The CompactPCI connectors are firm and rigid, bu t require careful han- dling while plu gging and unpluggi ng. Improper instal lation of a card can easily damage the backplane of the chassis. The inject/eject handle of MIC -3321 helps you install and remove the card easily and safely . Follow the procedure below [...]

MIC-3321 User Manual 14 T o remove a card: 1. Unscrew the four screws on the front pan el. 2. Press the lower handle dow n to re lease the card from the backplane. 3. Slide the card out. Figure 2.4: Chassis Installation/Removal[...]

22 CHAPTER 3 Sof tware Configuration[...]

MIC-3321 User Manual 16 Chapter 3 Sof tware Configuration 3.1 Overview MIC-3321 has a CD-ROM with utilities and drivers. Please install the Chipset INF driver , VGA graphics driver, and LAN driver . 3.2 Utilities and Drivers The following utiliti es and drivers are provided with the MIC-3321 series. Y ou can also find updated descrip tion of the ut[...]

22 CHAPTER 4 Aw a r d B I O S S e t u p[...]

MIC-3321 User Manual 18 Chapter 4 A ward BIOS Setup 4.1 Introduction Once you enter the A ward BIOS CMOS Setup Utility , the Main Menu (Figure 4-1) will appear on the sc reen. The Main Menu allows you to select between nine setup functions and two exit choices. Use the arrow keys to select among the items and press <Enter> to accept or enter [...]

19 Chapter 4 4.2.1 St andard CMOS Setup Figure 4.2: S tandard CMOS Setup Screen. Date The date format is <week>, <month>, <day>, <year>. Time The time format is <hour> <minute> <seco nd>, based on the 24-hour clock. IDE Primary Master/ Secondar y Master/ Secondary Slave IDE HDD Auto-Detection: Press “Ente[...]

MIC-3321 User Manual 20 Halt On This category determines whether system start-up will halt when an error is detected during p ower up. The options are: No Errors/All Errors/All , But Keyboard/All, But Dis- kette/ All, B ut Disk/Key Memory This category display s base, extended, and t otal memory det ected during the POST (Power On Self T est). 4.2.[...]

21 Chapter 4 Hard Disk Boot Priority Set hard disk boot device priority . CPU Thermal Monitor The Intel Thermal MonitorAutomati c Mode. There are two Automatic modes called Intel Thermal Monit or 1 (TM1) and Intel Thermal Monitor 2 (TM2). And MIC-332 1 Auto dete C-M or P-M.When CPU was C-M BIOS running in TM 1,another runnin g TM2. TM1 : When Intel[...]

MIC-3321 User Manual 22 CPU L1 & L2 Cache Enabled (default) Enable cache Disabled Disable cache Note: The internal cache is built into the processor . Quick Power On Self T est This category speeds up Power On Self T est (POST) after you power on the computer . If this is set to Enab led, BIOS will shorten or skip some check items during PO ST [...]

23 Chapter 4 T ypematic Rate Setting Keystrokes repeat at a rate determin ed by the keyboard controller . When enabled, the typematic rate and type matic delay can be selected. The set- tings are: Enabled/Disabl ed. The default setting is Disabled. T ypematic Rate (Chars/Sec) Set the number of times a second to repeat a ke ystroke key d own. The se[...]

MIC-3321 User Manual 24 4.2.3 Advanced Chip set Features Setup The Advanced Chipset Features Setup opt ion is used to change the values of the chipset registers. These registers control most of the system options in the computer . Choose the "Advanced Chipset Features" from the main menu and the followi ng screen will appear . Figure 4.4:[...]

25 Chapter 4 DRAM RAS# to CAS# Delay This field is used to insert a timing delay between the CAS and RAS strobe signals, used when DRAM is written to, read fr om, or refreshed. Fast gives faster performance; and Sl ow gives more stable perfo rmance. This field applies only when synchronous DRAM have been instal led in the system. The settings are: [...]

MIC-3321 User Manual 26 Memory Hole At 15M -16M Y ou can reserve this area of system memory for ISA adapter ROM. When this area is reserved, it cannot be cach ed. The user information of periph- erals that need to use this area of system memory usually discuss es their memory requirements. The settings are: Enabled and Disabl ed (Default). PCI-E Co[...]

27 Chapter 4 IDE HDD Block Mode Block mode is also called bl ock transfer , multiple commands, or multip le sector read/write. If your IDE hard driv e supports block mode (most new drives do), select Enabled for automa tic detection of the optimal number of block read/w rites per sect or the drive can support. The settings are: Enable d (Default), [...]

MIC-3321 User Manual 28 USB Contr oller Select enabled if your system contains a Univ ersal Serial Bus (USB) 1.1 controller . The settings are: Enabled (Default), Disabled. USB 2.0 Controller Select enabled if your system contains a Univ ersal Serial Bus (USB) 2.0 controller . The settings are: Enabled (Default), Disabled. USB Keyboard Support Sele[...]

29 Chapter 4 4.2.5 PNP/PCI Configuration Setup This section describes confi guring the PCI bus system. PCI, or Personal Computer Interconnect, is a system that allows I/O devices to operate at speeds nearing the speed the CPU itse lf uses when co mmunicat ing with its own special components. This section covers some very technical items and it is s[...]

MIC-3321 User Manual 30 Resource Contr olled By The A ward Plug and Play BIOS has th e capacity to automatically config- ure all the boot and Plug and Play compatible devices. However, this capability means absolutely nothing unl ess you are using a Plug and Play operating system such as W indows 95/ 98. If you set this field to "man- ual,&quo[...]

31 Chapter 4 Figure 4.7: PC Health S tatus setup screen CPU W arning T emperature This item will prevent the CPU from overheating. The choices are “Dis- abled”, “50C/122F”, “53C/127F”, “56C/133F”, “60C/140F”, “63C/ 145F”, “66C/151F”, “70C /158F”, “75C/167F”, “8 0C/176F”, “85C/ 185F”, “90C/194 F”, and [...]

MIC-3321 User Manual 32 4.2.7 Sp read Spectrum Control Figure 4.8: PC Health S tatus setup screen Spread Spectru m This allows the enable spread spect rum function. Default is "Dis-abled." 4.2.8 Load Optimized Default s When you press <Enter> on this item, you get a confirmation dialog box with a message similar to: Load Optimi zed [...]

33 Chapter 4 4.2.9 Set Password T o change, confirm, o r disable the passw ord, choose the "P ASSWO RD SETTING" option form the Setup main menu and press [Enter]. The password can be at most 8 characters long. Remember , to enable this fea- ture. Y ou must first select the Security Option in the Advanced BIOS Features Setup to be either &[...]

MIC-3321 User Manual 34 4.2.10 Save & Exit Setup If you select this and press the [Enter ] key , the valu es entered in the setup utilities will be recorded in the CMOS memory of the chi pset. The micro- processor wil l check this every time you turn your system on and com- pare this to what it finds as it check s the system. This record is req[...]

2 APPENDIX A Programming the W atchdog T imer[...]

MIC-3321 User Manual 36 Appendix A W atchdog Ti mer Programming T o program the watchdog timer, you must write a program which writes a value to I/O port address 443 (hex). Thi s output value represents time interv al. The value range is from 01 (hex) to FF (h ex), and the related time interval is 0.25 sec. to 63.75sec. Data Time Interval 01 0.25 s[...]

2 APPENDIX B Pin Assignment[...]

MIC-3321 User Manual 38 Appendix B Pin Assignment This chapter shows the p in assignments of MIC-3321 series C PU cards. T able B.1: MIC-3321 Connectors Overview Number Functi on Description 1F-CN1 USB1 USB1 T ype-A Female on Front side panel. 1F-CN3 USB2 USB2 T ype-A Female on Front side panel. 1F-CN2 CF CompactFlash socket 1F-CN5 VGA D-Sub 15-pin[...]

39 Appendix B B.1 Comp actFlash Interface The socket accepts an IDE-compat ible CompactFlash memory card. *LOW ACTIVE T able B.2: CompactFlash Interface Pin Definiti ons Pin Signal Pin Signal 1 GND 26 N/C 2 PDD3 27 PDD1 1 3 PDD4 28 PDD 12 4 PDD5 29 PDD 13 5 PDD6 30 PDD 14 6 PDD7 31 PDD 15 7 PDCS* 32 PDCS* 8 GND 33 N/C 9G N D 3 4 P D I O R * 10 GND [...]

MIC-3321 User Manual 40 B.2 USB 2.0 Port s B.3 VGA Connector T able B.3: USB 1.1 Ports Pin Definitions Pin Signal 1V C C 2U S B _ P - 3U S B _ P + 4G N D Pin Signal 1R E D 2 GREEN 3B L U E 4N / C 5G N D 6G N D 7G N D 8G N D 9 N/C (VGA VCC) 10 GND 11 N / C 12 VGA_SDA 13 HSYNC 14 VSYNC 15 VGA_SCL[...]

41 Appendix B B.4 COM port B.5 PS/2 Keyboard and Mouse Connector PS/2 keyboard and mouse port pin defin itions T able B.4: COM Port Pin Definitions PIN RS-232 1 NDCD 2 NRX 3N T X 4 NDTR 5G N D 6 NDSR 7N R T S 8 NCTS 9 NRI T able B.5: PS/2 Keyboard & Mouse Port Pins Pin Signal 1 KB DA T A 2M S D A T A 3G N D 4V C C 5 KB CLOCK 6M S C L O C K[...]

MIC-3321 User Manual 42 B.6 Ethernet 10/100/ 1000Base-T RJ-45 Connector B.7 Secondary IDE 44-pin 2mm Conn. For direct installation of 2.5" IDE HDD (2F-CN17) For wiring out (2F-CN18) T able B.6: Ethernet Connector Definitions Pin Signal 1T D + 2T D - 3 RD+ 4N / C 5N / C 6 RD- 7N / C 8N / C[...]

43 Appendix B *LOW ACTIVE T able B.7: Secondary ID E Connectors (2.5" HDD) Pin Signal Pin Signal 1 IDERST* 2 GND 3 SDD7 4 SDD8 5 SDD6 6 SDD9 7 SDD5 8 SDD10 9 SDD4 10 SDD1 1 1 1 SDD3 12 SDD12 13 SDD2 14 SDD13 15 SDD1 16 SDD14 17 SDD0 18 SDD15 19 GND 20 N/C 21 SDDREQ 22 GND 23 SDIOW* 24 GND 25 SDIOR* 26 GND 27 SDIORDY 28 GND 29 SDDACK* 30 GND 31[...]

MIC-3321 User Manual 44 B.8 Serial A T A0 (7pin connector) Pin Signal 1G N D 2T X + 3T X - 4G N D 5R X - 6R X + 7G N D[...]