Regency C33-LP3 manual

W ARNING: If the information in these instructions are not followed ex- actly , a fi re or explosion may result causing property damage, personal injury or loss of life. FOR YOUR SAFETY Do not store or use gasoline or other fl ammable vapors and liquids in the vicinity of this or any other appliance. Installation and service must be performed by [...]

2 Regency ® CLASSIC C33-3 Freestanding Gas Stove T o the New Owner: Congratulations! Y ou are the owner of a state-of-the-art Gas Stove by Fireplace Products International Ltd. The Regency ® Gas Series of hand crafted appliances has been designed to provide you with all the warmth and charm of a woodstove, at the fl ick of a switch. The models C[...]

Regency ® CLASSIC C33-3 Freestanding Gas Stove 3 T ABLE OF CONTENTS SAFETY LABEL Serial No. Decal ............................................................ 4 REQUIREMENTS MA Code - CO Detector (for state of Massachusetts only) .................................. 5 INST ALLA TION Before Y ou Start .................................................[...]

4 Regency ® CLASSIC C33-3 Freestanding Gas Stove This is a copy of the label that accompanies each CLASSIC Freestanding Gas Stove - Natural Gas and Propane . We have printed a copy of the contents here for your review . The safety label is located on the back panel. NOTE: Regency ® units are constantly being improved. Check the label on the unit [...]

Regency ® CLASSIC C33-3 Freestanding Gas Stove 5 REQUIREMENTS 5.08: Modifica tions to NFPA-54, Chapte r 10 (2) Revise 10.8. 3 by adding the fo llowing additio nal requireme nts: (a) For all side wall hor izontally vente d gas fueled equipm ent installed in e very dwelling, building o r structure used in whole or in part for residential pu rposes, [...]

6 Regency ® CLASSIC C33-3 Freestanding Gas Stove INST ALLA TION IMPORT ANT MESSAGE The CLASSIC Freestanding Gas Stove must be installed in accordance with these instructions. Carefully read all the instructions in this manual fi rst. Consult the "authority having jurisdiction" to determine the need for a permit prior to starting the ins[...]

Regency ® CLASSIC C33-3 Freestanding Gas Stove 7 Diagram 4 9) Lift the fan assembly in through the pedestal and up through the cut out as shown in diagrams 3 and 4. 10) Put the insulation gasket on the back of the fan. Line up the keyhole slots with the matching screws and pull back slightly to lock into place. While holding fan assembly in place,[...]

8 Regency ® CLASSIC C33-3 Freestanding Gas Stove INST ALLA TION PEDEST AL ASSEMBL Y 1) For easier assembly , tip the stove on its back (preferably onto a soft surface to prevent scratching). 2) Unscrew the 4 bolts in the underside of the stove. Align the holes in the corners of the pedestal top with the corresponding holes in the base of the stove[...]

Regency ® CLASSIC C33-3 Freestanding Gas Stove 9 VENTING This heater is a vented appliance and must be connected to a chimney/fl ue in accordance with installation codes. Note: The rear cover plate is only attached when outside air is being used. Do not install it when using room air for combustion. For your safety this heater is equipped with a [...]

10 Regency ® CLASSIC C33-3 Freestanding Gas Stove HIGH ELEV A TION This unit is approved in Canada for altitude 0 to 4500 ft. (CAN1 2.17-M90) with the orifi ce supplied. GAS PIPE PRESSURE TESTING The appliance must be isolated from the gas supply piping system by closing its individual manual shut-off valve during any pressure testing of the gas [...]

Regency ® CLASSIC C33-3 Freestanding Gas Stove 11 VA LV E DESCRIPTION 1) Gas on/off knob 2) Manual high/low adjustment 3) Pilot Adjustment 4) Thermocouple Connection 5) Main Operator 6) Outlet Pressure T ap 7) Inlet Pressure T ap 8) Pilot Outlet 9) Main Gas Outlet 10) Flange Securing Screw Holes 11 ) Alternative TC Connection Point 12) Thermoelect[...]

12 Regency ® CLASSIC C33-3 Freestanding Gas Stove Diagram 2 LOG SET INST ALLA TION W ARNING: Dangerous operating condi- tions may occur if these logs are not po- sitioned in their approved locations. Read the instructions below carefully and refer to the diagrams. If logs are broken do not use the unit until they are replaced. Broken logs can inte[...]

Regency ® CLASSIC C33-3 Freestanding Gas Stove 13 FINAL CHECK Before leaving this unit with the customer , the installer must ensure that the appliance is fi ring correctly . This includes: 1) Clocking the appliance to ensure the cor- rect fi ring rate (rate noted on label) after 15 minutes. 2) If required, adjusting the primary air to ensure th[...]

14 Regency ® CLASSIC C33-3 Freestanding Gas Stove WIRING DIAGRAMS This heater does not require a 120V A.C. sup- ply for operation. In case of a power failure, the burner switch and the optional remote control/ thermostat will continue to operate. However , a 120V A.C. power supply is needed for the fan/blower operation. Caution: Ensure that the wi[...]

Regency ® CLASSIC C33-3 Freestanding Gas Stove 15 It is possible that you will hear some sounds from your gas appliance. This is perfectly normal due to the fact that there are various gauges and types of steel used within your appliance. Listed below are some examples. All are normal op- erating sounds and should not be considered as defects in y[...]

16 Regency ® CLASSIC C33-3 Freestanding Gas Stove OPERA TING INSTRUCTIONS LIGHTING PROCEDURE NOTE: For all propane units and units equipped with electric spark boxes, see "Copy of Lighting Plate Instruc- tions" section for more details. IMPORT ANT : Gas on/off knob cannot be turned from "PILOT" to "OFF" unless it is p[...]

Regency ® CLASSIC C33-3 Freestanding Gas Stove 17 COPY OF THE LIGHTING PLA TE INSTRUCTIONS OPERA TING INSTRUCTIONS 1) Push in gas control knob slightly and turn to “PILOT” position. 2) Push in control knob all the way and hold in until the pilot lights up. Continue to hold the control knob in for about 20 seconds after the pilot is lit. Releas[...]

18 Regency ® CLASSIC C33-3 Freestanding Gas Stove PILOT ADJUSTMENT Periodically check the pilot fl ames. Correct fl ame pattern has three strong blue fl ames: 1 fl owing around the thermopile, 1 around the thermocouple and 1 fl owing across the burner (it does not have to be touching the burner). Note: If you have an incorrect fl ame pat- te[...]

Regency ® CLASSIC C33-3 Freestanding Gas Stove 19 7) Install the replacement glass. When placing the replacement glass in the door , make sure that the glass gasketing will properly seal your unit. 8) Put glass in place and then position glass retainer rod. Note: Do not use substitute materials. If your glass does break, do not con- tinue to use y[...]

20 Regency ® CLASSIC C33-3 Freestanding Gas Stove MAINTENANCE 8) If optional fan is installed, remove thermodisc to bracket by removing three (3) phillips head M5 screws. 9) Remove front cover with Piezo Igniter by removing two (2) sheet metal screws. 10) Loosen four (4) phillips head M5 valve mounting screws from underside of fi rebox. Push valv[...]

Regency ® CLASSIC C33-3 Freestanding Gas Stove 21 MAIN ASSEMBL Y P ARTS LIST Part # Description 1) 850-141 Small Door - Black 850-142 Small Door - Gold 850-143 Small Door - Nickel Accent 850-144 Small Door - Gold Accent 850-151 Large Door - Black 850-152 Large Door - Gold 850-153 Large Door - Nickel Accent 850-154 Large Door - Gold Accent 3) 846-3[...]

22 Regency ® CLASSIC C33-3 Freestanding Gas Stove P ARTS LIST BURNER & LOGS Part # Description 52) 910-190 Piezo Ignitor & Nut 53) * Control Panel 908-672 Control Panel Decal 462-560/P V alve Assembly - S.I.T . - NG 462-561/P V alve Assembly - S.I.T . - LP 63) 910-478 V alve S.I.T . - NG/LPG 66) 910-034 Pilot Assembly-3 fl ame-S.I.T . -NG[...]

Regency ® CLASSIC C33-3 Freestanding Gas Stove 23 BASE OPTIONS P ARTS LIST 490-921 Complete Floor Shield 100) 948-216 Regency ® Logo (Gold) 948-223 Regency ® Logo (Silver) 102) 904-257 Magnetic Catch (Large) 103) * 1 1" Pedestal Hinge 108) 910-246 Burner ON/OFF Switch (2-way) 109) 910-272 L T . Dummy Plug 1 10) * Strain Relief for power cor[...]

24 Regency ® CLASSIC C33-3 Freestanding Gas Stove ___________________________________________________ ___________________________________________________ ___________________________________________________ ___________________________________________________ ___________________________________________________ _______________________________________[...]

Regency ® CLASSIC C33-3 Freestanding Gas Stove 25 ___________________________________________________ ___________________________________________________ ___________________________________________________ ___________________________________________________ ___________________________________________________ _______________________________________[...]

26 Regency ® CLASSIC C33-3 Freestanding Gas Stove ___________________________________________________ ___________________________________________________ ___________________________________________________ ___________________________________________________ ___________________________________________________ _______________________________________[...]

Regency ® CLASSIC C33-3 Freestanding Gas Stove 27 W ARRANTY Regency Fireplace Products are designed with reliability and simplicity in mind. In addition, our internal Quality Assurance T e am carefully inspects each unit thoroughly before it leaves our facility . FPI Fireplace Products International Ltd. is pleased to extend this limited lifetime [...]

Installer: Please complete the following information Dealer Name & Address: ______________________________________________ ___________________________________________________________________ Installer: ___________________________________________________________ Phone #: ___________________________________________________________ Date Installed:[...]