U-Line CO2175FF manual

Use and Car e Guide CO2175FF 2 175RF Combo ® Ice Maker/Refriger ator Model: CO2175FF Refri gera tor/F r ee zer Model: 2175RF ULI N _0 16357 _3009 2.fm Pag e 1 Thurs da y, Marc h 23, 20 06 2:58 PM[...]

2 CO2175FF , 2175RF Congratulation s on your purchase of a U-Line refrigeration product. A pioneer in the f ield for more than 40 yea r s, U-L ine Corporation is the world’ s number one manufacturer of buil t -in, under- counter , specialty refrige ration and ice making products. U-Li ne dedicates 100% of its researc h and deve lopment to these p[...]

CO2175FF , 2175RF 3 Introduction ...... ...................... ....................... ...................... ....................... .................. .............2 Warranty Registra t ion ............... ....................... ...................... ....................... ....................2 Please Rec ord Your Model Information .... ......[...]

4 CO2175FF , 2175RF This page intentionally left blank[...]

CO2175FF , 2175RF 5 IMPORT ANT IMPORT ANT PLEASE READ all instructions completely befo r e attempting to install, operate, or serv ice your unit. • Pro p er installation pr ocedures must be followed if this unit is being initially installed, or is moved to a new lo catio n afte r bei ng in se rvice . An INST ALLA TION GUIDE for your unit, pr ovid[...]

6 CO2175FF , 2175RF Échelon Model 21 75RF Refrigerator/ Freezer , Model CO2 175FF Ice Maker/ Refrigerator Exclusive Featur es of Échelon • Both mod els feature Frost Free technology and a 5.7 cu ft (161 L) capacity . • An electronic contro l panel with digita l display allows you to display the in t erior temperatur e a nd adjust the settin g[...]

CO2175FF , 2175RF 7 Figure 2 IMPORT ANT IMPORT ANT Proper air flow (Figure 2) is r equired for your unit to operate at its highest efficiently . A grille, located in the base of the unit, must not be blocked at any time, or your unit will not perform as expected. Initial Startup All U-Line units are sh ipped with controls that are preset. No initia[...]

8 CO2175FF , 2175RF Interior Lighting The LIGHT icon (Figure 3, 5) on the control pa nel is used to control an additional lighting fu nction. The blackout/ Sabbath mode (not Star K certified) will tu r n the interior light and di splay (Figure 3, 3) of f. T o acces s t he blackout/Sa bbath mode (not Star K certified): 1. T o uch an d hol d the LI G[...]

CO2175FF , 2175RF 9 Ice Maker When the ice bu cket is full, the ice making mecha nism will shut of f. Howe ver , the refrigeration system will continue to cool and maintain the cube supply . Frost-free icemaker units have lower ice production t han manu al defrost units. IMPORT ANT IMPORT ANT Do not place cans or bot tles in the ice compartment bec[...]

10 CO2175FF , 2175RF Food Storage Crisper Y our models may have a lower cri sper drawer for storage. Figure 8 T o open, grasp the crisper handle (F ig ur e 8) and slowly pull out to access the drawer contents. The crisper may be completely removed for cleaning. IMPORT ANT IMPORT ANT If the drawer is pulled out too far , it will come out of the cabi[...]

CO2175FF , 2175RF 11 Product Disposal If the unit is be ing removed from service for d isposal, check and ob ey all Federal, Stat e and/or Local regulations regarding the disposal and recycling of r efrigeratio n appliances, a nd follow these steps completely: 1. Disc onnect power to the un it and unplug the po wer cord from its outlet. 2. Shut off[...]

12 CO2175FF , 2175RF Maintenance Proper main t enan c e of y our U-Line product will ensure ef ficiency , top performance and long life. The maintenance intervals listed are based on normal conditions. Y ou may want to shorten the intervals if you have pe t s o r other special considera t ions. Defrost ing Frost-Fr ee Models Frost-free models do no[...]

CO2175FF , 2175RF 13 Ice Cube Thick ness Adjustment Interval - As Requir ed On ice ma ker equipped mod els, the cube size may be adjusted by c hang ing the amount of wa ter injected into the ice maker assembly as follows: Fig ure 11 1. Remo ve the i ce make r assem bly co ver (Figure 11) . Fig ure 12 2. Locate the adjusting screw on t he i ce make [...]

14 CO2175FF , 2175RF Door Alignment Check and Adjustment IMPORT ANT IMPORT ANT When pr operly aligned: • The door will not be flush with the top of the cabinet. The top edge of the door will be 1/8 in. (3.175 mm) below the cabinet top. • The door gasket will be firmly in contact with the perimeter of the cabinet and not pinched on the hinge sid[...]

CO2175FF , 2175RF 15 Door Reversal Fig ure 19 Black a nd white units may be left- or rig ht-hand opening. Stainless steel unit doors cannot be reve rs ed. T he doors are easily reversed by moving the hinge hardware to the opposite side. The top hinge hardware will be u sed on the bottom of the other side and the bottom hinge hardware will be u s ed[...]

16 CO2175FF , 2175RF 5. Remove the two do or closer inserts (Figure 23, 1) from the existing bottom hinge and install as shown on the new bottom hinge (Fi gur e 22, 1) . 6. Remove existing bottom hinge (three screws) and remount on oppos ite side TOP . Remove hinge screw pin. 7. Remove the plastic hole plug from the top of the door to allow the piv[...]

CO2175FF , 2175RF 17 Glass Shelf Removal /Installation Remove the shelves as follows: Fig ure 26 1. Pull shelf out ab out 6" (Fi gur e 26) until back of sh elf clears the “hum p” on the right hand si de. 2. T ilt r ight hand edge of shelf up. 3. Remove shelf from unit by pulling out. Insert the shelves as follows: 1. Inse rt shel f at an a[...]

18 CO2175FF , 2175RF Before Calling for Service If your U-Line produc t appears to be malfunctionin g, read through the OPERA TION section of this guide to ensure that the functio n of all controls are clearly und erstood. If the malfunction persists, the TR OUBLESHOOTING GUIDE in this guide will a s sist you in qui ckly identifying common problems[...]

CO2175FF , 2175RF 19 T roubleshooting Guide DANGER ELECTROCUTION HA ZARD Never attempt to repair or perform maintenance on the unit until the main electrical power has bee n disconnected. T roubleshooting - What to check when pr oblems occur: PROBLE M POSSIBL E CAUSE REMEDY Unit does not operate and electronic display is bl ank. No electrical suppl[...]

20 CO2175FF , 2175RF ICE MAKER EQUI PPED MODELS ONL Y Water is leaking out the back of the unit. Water supply connection leaking Tighten fitting as required. Ice cubes sticking to g ether Infrequent use of cubes Break apart cubes. No ice Bin arm loc ked in upright pos ition Lower bi n arm. No water to unit T urn o n water or contact plumber . Not e[...]

CO2175FF , 2175RF 21 Electronic Contr ol Quick Guide NOTE: 38°F is an exam ple; the display will vary with actual set-po int. IMPORT ANT Factory recommende d set-point is 38°F for refrigerators and beverage centers, and 50°F for wine coolers. All M odels T ask T ouch T ouch Dis play Comment T urn O N/OFF Hold 10 secon ds Release when °F fl ashe[...]

22 CO2175FF , 2175RF This page intentionally left blank[...]

CO2175FF , 2175RF 23 U-Line Corpora tion Limi ted Warranty U-Line Corpo r ation w arrants each U-Line prod uct to be free from defe c ts in materials and workmanship for a period of one year from the date of purchas e ; and warrants the sealed system (consisting of the compre ssor , the condenser , the evaporator , the hot gas bypass valve, the d r[...]

For General Inquiries: P .O. Box 245 040 Milwa ukee, Wiscons in 53224-95 40 U.S.A. Phone (80 0) 779-2547 F AX (414) 354-5696 www .U-Line.com For Service and Parts Assist ance : Phone (80 0) 779-2547 (414) 354-030 0 F AX (414) 354-5696 Ema il: OnLine Service @U-Line .com www .U-Li neService. com E-mai l: OnlinePa rts @u-line .com For more than four [...]