Weber S-640 - NG manual

YOU MUST READ THIS O WNER’S GUIDE BEF ORE OPERA TING YOUR G A S GRILL  DANGER If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open fl ames. 3. Open lid. 4. If odor continues, keep away from the appliance and immediately call your gas supplier or your fi re department. Leaking gas may cause a fi re or explosion which ca[...]

2 WWW . WEBER.COM ® DANGERS AND W ARNINGS  DANGER Failure to follow the Dangers, W arnings and Cautions contained in this Owner ’ s Manual may result in serious bodily injury or death, or in a fi re or an explosion causing damage to property .  W ARNINGS  Do not store a spare or disconnected liquid propane cylinder under or near this b[...]

3 WWW . WEBER.COM ® 3 Weber-Stephen Products Co. (Weber) hereby warrants to the ORIGINAL PURCHASER of this Weber ® gas grill that it will be free of defects in material and workmanship from the date of purchase as follows: Aluminum castings -2 year on paint excludes fading, 25-years Stainless steel Shroud, 25-years Porcelain-enameled shroud, 25-y[...]

4 WWW . WEBER.COM ® + , $$ $% &* &, '# '$ '% '& * &$ &% && &' &( &) % & ' ( ) $ $# &+ S640_NG_US $& $' $( $) $* $+ '' $, %# %$ %% %& %' %( %) %* %+ %, &# '( ') '* '+ (# ', ($ (% EXPL ODED VIEW S-640[...]

5 WWW . WEBER.COM ® 5 Shroud Hardware Shroud Thermometer Thermometer Bezel Handle Qrill Out TM Handle Light Rotisserie Motor Rotisserie Bracket W arming Rack Cooking Grates Flavorizer ® Bars Burner T ubes Manifold Control Panel Small Knob Bezel Small Knob Large Knob Large Knob Bezel W ater Baffl e / Heat Shield 1. 2. 3. 4. 5. 6. 7. 8. 9. 10. 11.[...]

6 WWW . WEBER.COM ® OPERA TING The natural gas supply is easy to use and gives you more cooking control than charcoal fuel. • These instructions will give you the minimum requirements for assembling your Weber ® gas barbecue. Please read the instructions carefully before using your Weber ® gas barbecue. Improper assembly can be dangerous. • [...]

7 WWW . WEBER.COM ® 7 Slide out Bottom tray - Remove excess grease, then wash with warm soapy water , then rinse. Flavorizer ® bars and Cooking grates - Clean with a suitable brass bristle brush. As needed, remove from grill and wash with warm soapy water , then rinse with water . Catch pan - Disposable foil trays are available, or you can line t[...]

8 WWW . WEBER.COM ® GAS INSTRUC TIONS CHECK F OR GAS LEAKS  W ARNING: The gas connections of your Summit ® gas grill have been factory tested. We do however recommend that you leak check all gas connections before operating your Summit ® gas grill. REMOVE CONTROL P ANEL Part required: Phillips Screwdriver . 1) Remove the burner control knobs.[...]

9 WWW . WEBER.COM ® 9 2) Remove the two screws that secure the control panel to the frame. 3) Remove the control panel. T ilt panel forward and lift up and away from grill. Completely remove the control panel (3) from the cooking box assembly exposing the valves, burners, igniter , and manifold. 1 3 2 GAS INSTRUC TIONS CHECK F OR GAS LEAKS  DAN[...]

10 WWW . WEBER.COM ® 6 3 4 5 2 7 1 * The grill illustrated may have slight differences than the model purchased. Check: 1) Main gas line to manifold connection. 2) Rotisserie (I.R. Burner) gas line connection. 3) Bulkhead and gas supply hose connection. 4) Bulkhead to regulator connection. 5) Regulator to hose connection.  W ARNING: If there is[...]

11 WWW . WEBER.COM ® 11 OPERA TING INSTRUC TIONS GRILLING METHODS Note: If grill looses heat while cooking refer to the troubleshooting section of this manual. Y ou can adjust the individual burners as desired. The control settings are ST ART/HI , MEDIUM , LOW , or OFF . If burners go out during cooking, turn off all burners and wait 5 minutes bef[...]

12 WWW . WEBER.COM ® OPERA TING INSTRUC TIONS GRILLING TIPS & HELPFUL HINTS • Always preheat the grill before cooking. Set all burners on “HI” heat and close lid; heat for 10 minutes, or until thermometer registers 500˚-550˚F (260˚-288˚C). • Sear meats and cook with the lid down for perfectly grilled food every time. • Grilling t[...]

13 WWW . WEBER.COM ® 13 OPERA TING INSTRUC TIONS 6 1 3 2 5 * The grill illustrated may have slight differences than the model purchased. 2 5 1 3 2 4 5 * The grill illustrated may have slight differences than the model purchased. 2 4 LIGHTING Summary lighting instructions are inside the left hand cabinet door .  DANGER Failure to open the lid wh[...]

14 WWW . WEBER.COM ® OPERA TING INSTRUC TIONS USING THE SMOKER The smoker uses presoaked wood chips. For best results with faster cooking foods like steaks, burgers and chops, etc., we recommend using fi ner wood chips because they ignite and create smoke faster . For longer cooking foods such as roasts, chicken and turkeys, etc., we recommend us[...]

15 WWW . WEBER.COM ® 15 OPERA TING INSTRUC TIONS 2 3 10 5 1 8 9 4 7 MANU ALL Y LIGHTING THE SMOKER BURNER 1) Open the lid.  DANGER Failure to open the lid while igniting the grill, or not waiting 5 minutes to allow the gas to clear if the grill does not light, may result in an explosive fl are-up which can cause serious bodily injury or death.[...]

16 WWW . WEBER.COM ® OPERA TING INSTRUC TIONS  W ARNING: Setup up the rotisserie with food before lighting rotisserie burner . OPERA TING 1) Remove rotisserie shaft from grill. Remove one spit fork. 2) Push the rotisserie shaft through the center of the food. 3) Slide the spit fork onto the shaft. Insert the tines of both spit forks into the fo[...]

17 WWW . WEBER.COM ® 17 OPERA TING INSTRUC TIONS MANU ALL Y LIGHTING THE ROTISSERIE BURNER  A TTENTION: READ BEFORE LIGHTING ROTISSERIE BURNER After a period of non-use, before lighting the Rotisserie Burner , a few seconds must pass for the gas supply line to fi ll. When holding a match to the rotisserie burner you will see a fl ash of fl a[...]

18 WWW . WEBER.COM ® OPERA TING THE HANDLE LIGHT The Weber Grill Out™ Handle Light has a built-in “T ilt Sensor .” With the power button (a) activated, the light will come on when the grill lid is open. The light will turn off when the lid is closed. For daytime use, deactivate the sensor by pressing power button (a) . HANDLE LIGHT TROUBLESH[...]

19 WWW . WEBER.COM ® 19 PROBLEM CHECK CURE Rotisserie burner does not light. Did you hold the burner control knob in and hold in for 20 seconds until after burner ignited? T ry to relight burner by holding burner control knob in and continue holding in until 20 seconds after burner has ignited. Did you wait to see the entire ceramic surface become[...]

20 WWW . WEBER.COM ® MAINTENANCE MAIN BURNER CLEANING PROCEDURE T urn off the gas supply . Remove the manifold (See “Replace Main Burners”). Look inside each burner with a fl ashlight. Clean the inside of the burners with a wire (a straightened-out coat hanger will work). Check and clean the air shutter opening at the ends of the burners. Che[...]

21 WWW . WEBER.COM ® 21 AnnnNNUAL MAINTENANCE Inspection and cleaning of the Spider/Insect screens T o inspect the Spider/Insect screens, remove the control panel. If there is dust or dirt on the screens, remove the burners for cleaning the screens. Brush the Spider/Insect screens lightly with a soft bristle brush (i.e. an old toothbrush).  CAU[...]

©2007 The following trademarks are registered in the name of W eber-Stephen Products Co., an Illinois corporation, located at 200 East Daniels Road, Palatine, Illinois 60067 U.S.A. Australia; Smokey Joe, Weber , Kettle Silhouette ® , Genesis, Austria; Kettle Silhouette ® , Smokey Joe, Weber , Benelux; Kettle Silhouette ® , Smokey Joe, Weber , C[...]

Spring. Summer . Fall. Winter . Four FREE issues o f W eber Nation™ , our ho t e-mail newsle tter all about grilling, will be coming y our w ay . Each issue is pack ed with grilling tips and advice, triple-tested recipes, an d everything you need to kn ow to become a bo na fide W eber Grilling Guru. All y ou hav e to do to activ ate yo ur subscri[...]

Knowing more about wh o buys our grills helps the crew back i n R&D come up with new cutting edge Weber products. Please fill i n the answers you feel comfortable shari ng with us, and pass by any question you prefer to leave bl ank. Thank you for being so generous. Saber más sobre quién compra nuestros asadores ayud a al equipo de Investiga [...]