Hearth and Home Technologies BE-36-C manuale d’uso

Hearth & Home T echnologies • BE-36-C, BE-36-CIPI • 397-981 Rev . R • 2/05 1 - Do not store or use gasoline or other flam- mable vapors and liquids in the vicinity of this or any other appliance. - What to do if you smell gas • Do not try to light any appliance. • Do not touch any electrical switch. • Do not use any phone in your bu[...]

Hearth & Home T echnologies • BE-36-C, BE-36-CIPI • 397-981 Rev . R • 2/05 2 These units MUST use one of the vent systems described in the Installing the Fireplace section of the Installers Guide . NO OTHER vent systems or component s MA Y BE USED . This gas fireplace and vent assembly MUST be vented directly to the outside and MUST NEVER[...]

Hearth & Home T echnologies • BE-36-C, BE-36-CIPI • 397-981 Rev . R • 2/05 3 TABLE OF CONTENTS Safety and W arning Information ................................................ 2 Service Parts Lists ..................................................................... 4 Section 1: Approvals and Codes .......................................[...]

Hearth & Home T echnologies • BE-36-C, BE-36-CIPI • 397-981 Rev . R • 2/05 4 * Part number list on following page. * La liste des numéros de pièce se trouve à la page suivante. 10 11 12 9 Log Set Assembly (NG , LP) Exploded Part s Diagram (GN, PL) Vue éclatée des pièces Service Parts BE-36-C, BE-36-CIPI Beginning Manufacturing Date:[...]

Hearth & Home T echnologies • BE-36-C, BE-36-CIPI • 397-981 Rev . R • 2/05 5 (NG , LP) Service Parts List / Liste des pièces de rechange IMPORT ANT : THIS IS DA TED INFORMA TION. The most current information is located on your dealers VIP site. When ordering, supply serial and model numbers to ensure correct service part s. / IMPORT ANT [...]

Hearth & Home T echnologies • BE-36-C, BE-36-CIPI • 397-981 Rev . R • 2/05 6 (NG , LP) Exploded Part s Diagram (GN, PL) Vue éclatée des pièces Service Parts Beginning Manufacturing Date: 4-01 Ending Manufacturing Date: ______ BE-36-CIPI Intermittent Pilot Ignition V alve Assembly IT E M / PI ÈCE DESCRIP TI ON SER I A L # / N° DE SÉR[...]

Hearth & Home T echnologies • BE-36-C, BE-36-CIPI • 397-981 Rev . R • 2/05 7 BE-36-C (NG , LP) Exploded Part s Diagram (GN, PL) Vue éclatée des pièces Service Parts Beginning Manufacturing Date: 4-01 Ending Manufacturing Date: _____ Standing Pilot Ignition V alve Assembly ITE M / PI ÈCE DESCRI PTI O N SERIA L # / N° DE SÉRI E P A RT[...]

Hearth & Home T echnologies • BE-36-C, BE-36-CIPI • 397-981 Rev . R • 2/05 8 Appliance Certification The fireplace model discussed in this Installers Guide has been tested to certification standards and listed by the applicable laboratories. Certification MODELS: BE-36-C, BE-36-CIPI LABORA TOR Y : Underwriters Laboratories TYPE: Direct V [...]

Hearth & Home T echnologies • BE-36-C, BE-36-CIPI • 397-981 Rev . R • 2/05 9 2 Getting St arted Introducing the Hearth & Home T echnologies G as Fireplaces Hearth & Home T echnologies direct vent gas fireplaces are designed to operate with all combustion air siphoned from outside of the building and all exhaust gases expelled to t[...]

Hearth & Home T echnologies • BE-36-C, BE-36-CIPI • 397-981 Rev . R • 2/05 10 Figure 1. Diagram of model BE-36-C HOOD VENT COL LA R S RA TING PLA TES & LABE LS BOTT OM GRILLE COVER ELEC T RIC A L ACCES S GAS CONTROLS GAS LINE ACCES S 5-1 /16 129 [] 2-1 /4 56 [] 32- 1/2 830 [] 36 913 [] 31 790 [] 31 792 [] 18-1/2 468 [] 3-1 /2 91 [] 8 [...]

Hearth & Home T echnologies • BE-36-C, BE-36-CIPI • 397-981 Rev . R • 2/05 11 3 Inst alling the Fireplace Step 1. Locating the Fireplace The following diagram shows space and clearance require- ments for locating a fireplace within a room. Minimum Clearances from the Fireplace to Combustible Materials Inches mm Glass Front ...............[...]

Hearth & Home T echnologies • BE-36-C, BE-36-CIPI • 397-981 Rev . R • 2/05 12 Figure 3. Framing Dimensions for SL D-Series and DVP-Series Pipe A B C D* E * 3 7 ” 3 3 ” 16 1/4” 36 1/2” 24 3/8 Framing should be constructed of 2 X 4 lumber or heavier . The framing headers may rest on the fireplace stand-offs. W ARNING: T o ensure pro[...]

Hearth & Home T echnologies • BE-36-C, BE-36-CIPI • 397-981 Rev . R • 2/05 13 NOTE: PIPES OVERLAP 1-3/8 INCHES (34.93mm) A T EACH JOINT . Figure 4 . SL D -Series Direct V ent Component Specifications (4-inch inner pipe / 6 5/8-inch outer pipe) 120” (3048mm) 24” (610mm) 36” (914mm) 60” (1524mm) 9 1/4 6 5/8 6 1/2 6 3/8 6 1/2 9 5/8 9[...]

Hearth & Home T echnologies • BE-36-C, BE-36-CIPI • 397-981 Rev . R • 2/05 14 NOTE: PIPES OVERLAP 1-3/8 INCHES (34.93mm) A T EACH JOINT . Figure 5 . DV P -Series Direct V ent Component Specifications (5 -inch inner pipe / 8 inch outer pipe) D V P 9 0 S T 12-9/1 6 11- 1 / 4 7-1/4 1-1/4 TYP 1/2 TY P 8-9/16 DVP36 DV P48 48 24 36 4 6 DVP4 DV [...]

Hearth & Home T echnologies • BE-36-C, BE-36-CIPI • 397-981 Rev . R • 2/05 15 Step 3. Inst alling the V ent System A. V ent System Approvals This model has vent starting collars on both the top and the back of the unit. Depending upon the installation, decide which ONE set of starting collars will be used to attach the vent system. The st[...]

Hearth & Home T echnologies • BE-36-C, BE-36-CIPI • 397-981 Rev . R • 2/05 16 STRAIGHT UP VERTICAL VENTING V (FT .) 45' MAX. Figure 8. Straight up V ertical V enting Use SL D-Series component s only . NOTE: For vertical venting over 20 feet an Extended V ertical Baffle Kit is recommended for improved flame appearance. V CAP Figure 7.[...]

Hearth & Home T echnologies • BE-36-C, BE-36-CIPI • 397-981 Rev . R • 2/05 17 Figure 1 1. V enting with One 90° Elbow V (MIN.) H (MAX.) 90 o Elbow on T op 2.5' (863mm) 1' (305mm) 3 ' (914mm) 2' (610mm) 4' (1.22m) 3' (914mm) 6' (1.86m) 4' (1.22m) 8' (2.48m) 5' (1.52m) 16' (4.8m) H MAX[...]

Hearth & Home T echnologies • BE-36-C, BE-36-CIPI • 397-981 Rev . R • 2/05 18 V H H + H 1 1' MIN. (305 mm) 2' MAX. (610 mm) 4' MAX. (1.22m) 2' MIN. (610 mm) 4' MAX. (1.22 m) 8' MAX. (2.4m) 3' MIN. (914 mm) 6' MAX. (1.86 m) 12' MAX. (3.6m) 4' MIN. (1.22 m) 8' MAX. (2.48 m) 16' MAX[...]

Hearth & Home T echnologies • BE-36-C, BE-36-CIPI • 397-981 Rev . R • 2/05 19 Figure 13. V enting with T wo 90° Elbows BE-36-C V (MIN.) H + H 1 (MAX.) 90 o Elbow on T op 2.5' (863mm) 1' (305mm) 3' (914mm) 2' (610mm) 4' (1.22m) 3' (914mm) 6' (1.86m) 4' (1.22m) 8' (2.48m) 5' (1.52m) 16&apos[...]

Hearth & Home T echnologies • BE-36-C, BE-36-CIPI • 397-981 Rev . R • 2/05 20 Figure 14. V enting with Three 90° elbows 1' MIN. (305 mm) 2' MAX. (610mm) 4' MAX. (1.22m) 2' MIN. (610 mm) 4' MAX. (1.22m) 8' MAX. (2.48m) 3' MIN. (914 mm) 6' MAX. (1.86m) 12' MAX. (3.72m) 4' MIN. (1.22 m) 8&ap[...]

Hearth & Home T echnologies • BE-36-C, BE-36-CIPI • 397-981 Rev . R • 2/05 21 Use SL D-Series components only . BE-36-C H + H 1 (MAX.) 4' (1.22m) 6' (1.86m) 8' (2.48m) 12' (3.72m) 16' (4.8m) 16' (4.8m) Figure 15. V enting with Three 90° elbows H + H 1 MAX. = 16' (4.8m) V + H + V 1 + H 1 MAX. = 40' [...]

Hearth & Home T echnologies • BE-36-C, BE-36-CIPI • 397-981 Rev . R • 2/05 22 Figure 16. V enting with Four 90° elbows VENTING WITH FOUR (4) 90° ELBOWS NA TURAL AND PROP ANE GAS V (MIN.) H (MAX.) 2' (609mm) 5' (1.52m) V 1 (MIN.) H 1 (MAX.) V 2 (MIN.) 5' (1.52m) 5' (1.52m) 4.5' (1.37m) V + V 1 + V 2 + H + H 1 MAX[...]

Hearth & Home T echnologies • BE-36-C, BE-36-CIPI • 397-981 Rev . R • 2/05 23 B. Installing V ent Components After determining which set of starting collars will be used (top or rear), follow venting instructions accordingly . V enting Out the Rear V ent (See Figure 17) Remove the installed rear seal cap from the rear starting collars by [...]

Hearth & Home T echnologies • BE-36-C, BE-36-CIPI • 397-981 Rev . R • 2/05 24 For V ertical Runs - The vent system must be supported every eight (8) feet (2.4m) above the fireplace flue outlet by wall brackets. T o install support brackets for vertical runs: • Attach wall brackets to the vent pipe and secure the wall bracket to the fram[...]

Hearth & Home T echnologies • BE-36-C, BE-36-CIPI • 397-981 Rev . R • 2/05 25 For V ertical Runs - One ceiling firestop is REQUIRED at the hole in each ceiling through which the vent passes. T o inst all firestops for vertical runs that pass through ceilings: • Position a plumb bob directly over the center of the verti- cal vent compone[...]

Hearth & Home T echnologies • BE-36-C, BE-36-CIPI • 397-981 Rev . R • 2/05 26 C. V ent T ermination SL-Series V enting Only: For Horizont al T erminations - T o attach and secure the termination to the last section of horizontal vent: • Rotate and interlock the ends as described at the begin- ning of the Installing V ent Component s sec[...]

Hearth & Home T echnologies • BE-36-C, BE-36-CIPI • 397-981 Rev . R • 2/05 27 V = VENT TERMINAL X = AIR SUPPL Y INLET = AREA WHERE TERMINAL IS NOT PERMITTED Figure 26. V ent T ermination Minimum Clearances A = 12" ....................... clearances above grade, veran- da, porch, deck or balcony B = 12" ....................... cl[...]

Hearth & Home T echnologies • BE-36-C, BE-36-CIPI • 397-981 Rev . R • 2/05 28 For V ertical T erminations - T o locate the vent and install the vent sections: • Locate and mark the vent centerpoint on the underside of the roof, and drive a nail through the centerpoint. • Make the outline of the roof hole around the centerpoint nail. ?[...]

Hearth & Home T echnologies • BE-36-C, BE-36-CIPI • 397-981 Rev . R • 2/05 29 ! Step 4. Positioning, Leveling, and Securing the Fireplace • Place the fireplace into position. • Level the fireplace from side to side and from front to back. • Shim the fireplace with non-combustible material, such as sheet metal, as necessary . • Sec[...]

Hearth & Home T echnologies • BE-36-C, BE-36-CIPI • 397-981 Rev . R • 2/05 30 Figure 30. Gas Supply Line Step 6. The Gas Supply Line NOTE: Have the gas supply line installed by a qualified service technician in accordance with all building codes. (In the Commonwealth of Massachusetts installation must be performed by a licensed plumber or[...]

Hearth & Home T echnologies • BE-36-C, BE-36-CIPI • 397-981 Rev . R • 2/05 31 Step 8. Wiring the Fireplace NOTE: Electrical wiring must be installed by a licensed electrician. CAUTION: DISCONNECT REMOTE CONTROLS IF AB- SENT FOR EXTENDED TIME PERIODS. THIS WILL PRE- VENT ACCIDENT AL FIREPLACE OPERA TION. For Standing Pilot Ignition Wiring [...]

Hearth & Home T echnologies • BE-36-C, BE-36-CIPI • 397-981 Rev . R • 2/05 32 Figure 32. Remote Wiring Diagram (IPI) Figure 33. Remote Wiring Diagram (Standing Pilot) ORANGE GREEN V AL VE ORANGE WHIT E GR OUND T O FIR EPLA CE CHASSIS REMOTE RECE I VER IG NITION MODULE 3 V AC INTE RMITTE NT PILOT IGNITOR TRANSFORME R 3 V AC PLUG IN JUMPER [...]

Hearth & Home T echnologies • BE-36-C, BE-36-CIPI • 397-981 Rev . R • 2/05 33 Figure 35. Fan Wiring Diagram FAN TEMP ERA TURE SEN SOR SW I TCH SPEED CONTROL (RHEOST A T) JUNC TIO N BOX Figure 34. Intermittent Pilot Ignition (IPI) Wiring Diagram NOTE 1: Ignition module, valve, pilot and wall switch operate on 3 volts. 120 V AC is required [...]

Hearth & Home T echnologies • BE-36-C, BE-36-CIPI • 397-981 Rev . R • 2/05 34 Step 9. Finishing Figure 36 shows the minimum vertical and corresponding maximum horizontal dimensions of fireplace mantels or other combustible projections above the top front edge of the fireplace. See Figures 2 and 3 for other fireplace clearances. Only non-c[...]

Hearth & Home T echnologies • BE-36-C, BE-36-CIPI • 397-981 Rev . R • 2/05 35 Placing the Ember Material Ember material is shipped with this gas fireplace. The bag labeled Glowing Ember (050-721) is standard glowing ember material. T o place the ember material: • Remove the top louver by lifting it up and away from the unit. • Unlatch[...]

Hearth & Home T echnologies • BE-36-C, BE-36-CIPI • 397-981 Rev . R • 2/05 36 Step 1 1. Before Lighting the Fireplace Before lighting the fireplace, be sure to do the following: Remove all paperwork from underneath the fireplace. Review safety warnings and cautions • Read the Safety and Warning Information section at the beginning of th[...]

Hearth & Home T echnologies • BE-36-C, BE-36-CIPI • 397-981 Rev . R • 2/05 37 4 Maint aining and Servicing Y our Fireplace Fireplace Maintenance Although the frequency of your fireplace servicing and main- tenance will depend on use and the type of installation, you should have a qualified service technician perform an appli- ance check-u[...]