Coleman 9947A726 manual

Gas Barbecue Use, Care & Assembl y Manual With Grill Lighting Instructions Model 9947A726 ASSEMBLER/INST ALLER: Leave these instructions with the consumer . CONSUMER/USER: Read all instructions and keep in a safe place f or future reference . For Outdoor Use Only IMPORT ANT Read this manual carefully bef ore assembling, using or ser vicing this[...]

2 DANGER • FOR OUTDOOR USE ONL Y . NEVER operate grill in enclosed areas, as this could lead to gas accumulating from a leak, causing an e xplosion or a carbon mono xide buildup which could result in injur y or death. DO NO T use in garages, breeze wa ys, sheds or any enclosed area. (Fig. 1) • NO T FOR USE BY CHILDREN. (Fig. 2) • If these ins[...]

3 1 3 2 24 " 8 7 24" (60cm) 24" (60cm) 24" (60cm) Clear REPRESENT A TIVE ILLUSTRA TION • Installation must conf or m with local codes or , in the absence of local codes, with either the National Fuel Gas Code , ANSI Z223.1 (USA), CAN/CGA-B149.1, Natural Gas Installation Code or CAN/CGA-B149.2, Propane Installation Code (Canada[...]

A B C E D F G 4 Longer detachable po wer-supply cords or extension cords must be used with care. The marked electrical rating of the cord set or e xtension cord must be at least as great as the electrical rating of the appliance. If the appliance is of the grounded type, the e xten- sion cord should be a grounding-type 3-wire cord. Use outdoor e xt[...]

5 DANGER • DO NO T inser t any foreign objects into the v alve outlet. Y ou ma y damage the valve . A damaged v alve can cause a leak, which could result in e xplosion, fire, se vere per- sonal injur y or death. W ARNING • Cylinders must be stored outdoors out of the reach of children and must not be stored in a b uilding, garage or any other e[...]

6 W ARNING Handle a full cylinder with care. Gas is under high pressure. DANGER • NEVER store a spare L.P . gas supply cylinder under the grill body or inside grill enclosure or in the vicinity of any heat producing appliance. (Fig. 12) • NEVER fill the cylinder bey ond 80% full. F ailure to follo w this information exactly could result in an e[...]

Assembly/Set up ■ Remov e components from package. 7 Lid HVR Assembly W ar ming Rack Tr i v e t Right Side T able Side Bur ner Grates Bur ner Heat T ent TM Rotisserie Brack ets Rotisserie Spit Rotisserie Motor Bottom P anel T op P anel Back P anel Right Leg P anel Middle Divider Left Door Right Door Grease T ra y Grease Pa n Casters Door Magnets [...]

Assembly/Set up (cont.) 8 STEP 1 BO TT OM & SIDE P ANELS ■ Install three screws from the top and three He x nuts from below as shown f or each side panel. ■ Tighten screws . STEP 3 MIDDLE DIVIDER ■ T ur n ov er assembly so wheels are down. ■ Install Middle Divider as shown. STEP 2 CASTERS ■ Carefully tu r n o v er assembly . ■ Insta[...]

Assembly/Set up (cont.) 9 STEP 7 RIGHT SIDE T ABLE ■ Remov e preinstalled screws from Right Suppor ts. ■ Install Right Side T able. NO TE: Side T able Suppor ts have slots f or easy assembly . ■ Tighten securely . STEP 8 LEFT SIDE BURNER ■ Remov e preinstalled screws from Left Suppor ts. ■ Install Left Side Burner T ab le. NO TE: Side T a[...]

Assembly/Set up (cont.) 10 STEP 12 BURNER TENTS & GRA TES STEP 13 W ARMING RACK ■ Install Warming Rack as sho wn. ■ Place Burner Heat T ents TM over Burners as shown. ■ Install three (3) Grates. STEP 10 HOSE ROUTING Orifice T ube STEP 11 GREASE P AN & GREASE TRA Y ■ Slide Grease T ray into Grill. Grease P an Grease T ray ■ Route B[...]

Assembly/Set up (cont.) ■ Open Left Side Burner Lid and place T r ivet on Burner . STEP 16 LO WER DOOR MAGNETS STEP 18 DOORS ■ Install Left and Right Doors. ■ Inser t Bottom Door Pin into hole on Bottom F rame. ■ Hinge Pins are spring-loaded. Pull down to insert Hinge Pin into T op F rame Hole. NO TE: Make sure the 2 holes on each Door are [...]

12 STEP 21 PROP ANE CYLINDER SETUP ■ Install Propane T ank Base as shown. ■ Secure the T ank Base to the gr ill with one self-tapping screw . The hole location is in the front of the T ank Base Flange. STEP 22 INST ALLING IGNITION BO X ■ Install Rotisserie Motor & Rotisser ie Spit as shown. ■ Make sure Rotisserie Motor is placed on the [...]

13 W ARNING THE FOLLOWING RULES MUST AL W A YS BE FOLLOWED IN THIS ORDER (Fig. 18): 1. OPEN GRILL LID! Any attempt to light the grill with the lid down could cause an e xplosion. 2. Check that the b ur ner control knobs are tur ned to “OFF”. 3. T ur n on fuel supply . F or an L.P . gas cylinder , turn the top cylinder valv e knob counterclockwi[...]

CAUTION DO NO T touch hot grill par ts with bare hands! Y ou MUST use protective glo ves. Shutting Off the Grill 14 1. T urn on any or all burner gas control knobs. (Fig. 19) 2. Press the Igniter switch until the flame ignites . 3. If the flame doesn’t immediately light, tur n off control knob and wait fiv e minutes for gas to clear . 4. Repeat s[...]

15 Condition The Grill • Bef ore using the grill for the first time or after stor age, operate grill 15 minutes on high setting, with lid closed, to b ur n aw ay oil. • Once the oil has burned aw a y , check the b ur ner flame per ne xt step . The Burner Flame • K eep the grill lid closed and the cooking surfaces in place. • Obser ve the b [...]

16 DANGER NEVER attempt to operate y our grill without orifices in the valv es. A ser ious and immediate fire hazard would result. Steps For Cleaning V enturi: 1. Remove b ur ner from grill bottom. 2. Look inside lower end of v entur i tubes for nests , webs or mud. 3. T o remo ve the abo ve obstructions, use an accessor y fle xible venturi brush o[...]

17 T roubleshooting CAUTION A collision with the grill, as with any metal object, could cause injur y . Use care when moving a por table gas grill. Moving the grill: • Mov e grill slowly . DO NO T r un with or pull the grill behind you; it could hit you from behind causing injury . • DO NO T move the g rill while it is lit or hot, or with objec[...]

18 Y OUR NEW GAS GRILL IS EQ UIPPED WITH A TYPE 1 CONNECTION DEVICE WHICH HAS 3 SAFETY FEA TURES: (SEE TYPE 1 CONNECTION ILLUSTRA TION) 1. Proof of gas seal between the connector and the cylinder bef ore gas flow tak es place. 2. A flow-limiting de vice designed to limit the flow of gas in the e vent of a regulator or hose f ailure. 3. The connecti[...]

19 Replacement P ar ts List Item P ar t No. Description 1 9947-2321 Left Side Bur ner T able , Stainless 2 9947-6561 Cast Brass Side Burner 3 9947-1471 Side Bur ner Control Knob 4 9947-3271 Side Bur ner Electrode (Not Shown) 5 9947-1271 3 Black Control Knobs 6 9947-1591 3 Bezels 7 9947-2071 Right Side T able , Stainless 8 9947-5261 Hardware Kit - C[...]

® The Coleman Co ., Inc. • 3600 N. Hydraulic • Wichita, KS 67219 U .S.A. 1-800-835-3278 • TDD: 316-832-8707 9947-057 (01/04) © 2004 The Coleman Compan y , Inc. All rights reser ved. Coleman ® is a registered trademark of The Coleman Company , Inc. COLEMAN GAS B ARBECUE GRILL LIMITED W ARRANTY FOR 6000 SERIES GRILLS The Coleman Company , In[...]