Field Controls S2000 manual

MODELS S2000 AND S2020 FOR GAS OR OIL FORCED AIR FURNACES, HEA T PUMPS AND ELECTRIC FURNACES has been designed to be simple to Install, Operate and Maintain. Read this manual before you install the Humidifier . Parts included in the Steam Humidifier package ar e: 1. Self Piercing Saddle V alve 2. Installation Instructions and Owners Manual 3. Mount[...]

SIMPLIFIED INST ALLA TION INSTRUCTIONS DET AILED INST ALLA TION INSTRUCTIONS 1. Insulate the water reservoir . See figure 3. 2. Select the mounting location on the duct and tape on the mounting template. 3. Drill the (8) 1/8" mountings holes. 4. Cut out the humidifier opening in the duct. 5. Insert the humidifier into the opening and screw in [...]

6. W A TER SUPPL Y - Required Criteria 9. WIRING THE STEAM HUMIDIFIER 7. M O U N T I N G T H E S T E A M H U M I D I F I E R 8. STEAM OPERA TION - Required Criteria A. W A TER SUPPL Y USING THE SADDLE V AL VE FURNISHED WITH UNIT . Important! See page 14. A. INST ALLING AND WIRING THE HUMIDIST A T B. OVERFLOW & DRAIN LINES - Required Criteria In[...]

Typi ca l Furnace S2000 & S2020 Humidifier Low V oltage T erminal Block G1 R G2 H H Heat only Thermostat W R G W R Heat Only System and Steam Humidifier with standard dry contact Humidistat Dry Contact Humidistat A A FIG. 6 Factory Jumper will stay in place unless a field installed Air Proving Device is used. FIG. 8 Bryant Evolution Furnace SPS[...]

8 . 0 0 ” 6 . 00 ” 7.50” 8 . 2 5 ” 1 0 . 5 0 ” 1 1 . 6 0 ” the room needed to install the unit in a certain location. The data can also be used to determine the minimum duct size the Steam Humidifier can be inserted into. The Steam Humidifier should not obstruct more than 25% of the cross sectional area of the selected duct. For Example[...]

F o r R e p l a c e m e n t P a r t s C a l l ( 8 0 0 ) 4 4 6 - 3 1 1 0 0 9 0 2 1 A 0 1 1 8 U . S . P A T E N T N U M B E R 5 7 5 8 0 1 8 s e r i a l n u m b e r E w c 3 8 5 H i g h w a y 3 3 , E n g l i s h t o w n , N J 0 7 7 2 6 C O N T R O L S , I N C . U L ® C U S L I S T E D 1 4 1 V P O W E R D R A I N F I L L H E A T E R B L O W E R T h e r[...]

It is recommended that humidistat settings of 30-45% not be exceeded. If condensation is noticed on windows during very cold outside temperatures, the humidistat setting should be lowered. RELA TIVE HUMIDITY CHAR T The maximum recommended relative humidity for your home depends upon many factors such as outdoor air temperature, type and placement o[...]

INITIAL ST AR T -UP * SEQUENCE OF OPERA TION * SER VICE “LED” INDICA TORS 1 1. ST AR T -UP & OPERA TING SEQUENCE Once the Steam Humidifier has been installed and the w a t e r, d r a i n , h u m i d i s t a t a n d b l o w e r i n t e r l o c k connections completed, the humidifier may be started. A. Disconnect the water line. Turn on the w[...]

14. SERVICE INDICA T ORS Seven LED lamps provided on the front panel indicate the functional status of the humidifier as shown in Figure 7 below . 9 A. L. M. N. O. B. C. D. E. F . G. H. I. J. K. Unplug the power cord from the 120 volt source for S2000 (240 volt for S2020) and allow the water to cool for at least 30 minutes prior to removal. T urn o[...]

10 A. G. B. C. D. E. F . The green "Power" light does not blink off and on. 1. The S2000 is not connected to an active 120 V AC 15 Amp power source. (S2020, 240 V AC, 10 AMP). 2. Call the T echnical Support Hotline. The "HEA TER" LED does not illuminate. 1. The humidistat is not closed, calling for humidity or the humidistat is [...]

SERVICE AND REPLACEMENT P ARTS 11 ITEM 1 120 VOL T HEA TER A SSEMBL Y 240 VOL T HEA TER A SSEMBL Y 24 VOL T SOLENOID V AL VE A SSEMBL Y W A TER LEVEL PROBE A SSEMBL Y THERMISTOR PROBE A SSEMBL Y CIRCUIT BOARD A SSEMBL Y DRAIN V AL VE ASSEMBL Y T ANK BAFFLE W A TER HAMMER ARRESTER (not shown) ANODE INSULA TION KIT (not shown) 2002 2003 2007 2008 WH [...]

Figure 18 12 DRAIN COCK V AL VE "T" ADAPTER, 1/4" NPT OVERFLOW TUBE, .50 ID x 6" LG. BARBED TEE, 1/4-18 NPT TO ½ " JUMPER WIRE, 20GA. X 1.50" LONG MOLEX PLUG BLACK WIRES 18GA. X 18" LONG SOLENOID V AL VE, 24/60 V AC 2 63 0 A irp o rt Ro a d K in s t on , N C 28 5 04 P H : 2 52 . 52 2 . 30 31 FA X : 25 2 . 52 2.02[...]

Smart Digital Humidistat Installation and Owner's Manual The 072000 is a digital humidifier control that can automatically adjust the indoor humidity set point as the outside air t em p e r a tu r e c h an g e s . T h is i n t e ll i g e n t control will maintain accurate humidity levels and a more comfortable indoor environment. The actual in[...]

Z100 A SSEMBL Y INST ALL A TION INSTRUCTIONS & OWNER'S MANUAL Z100 REPL ACEMENT INSTRUCTIONS ELECTRONIC STEAM POWER HUMIDIFIERS MODEL # S2000 AND S2020 APPLICA TION NOTE AN 131 C o p yr igh t © 2 0 1 1 Fi e ld Co n trols A l l Ri g h t s Rese rved . S U P P L E ME N T T O T H E T h e F i el d Co n trol s St e a m H u mi d i fie r no w co[...]

APPLICA TION NOTE P ART # 2009 AN 151 SC100 - P AR T # 2009 DECORA TIVE COVER S2000/S2020 STEAM HUMIDIFIER SC100 Installation Instructions P/ N 09 0 3 76 A0 15 1 R EV. A Co p yrig h t 2 01 1 © F ie l d Co n t rol s I n c. , Al l Ri g hts Re se rve d S U P P LEM E NT TO TH E ELECTR ON IC S TE A M P OWE R HU M ID IFI E RS M ODEL # S 2 0 0 0 A N D S [...]

16 Model Number:____________________Serial Number:____________________Date Code:_____________________ Date Purchased:_________________________________________________________________________________ Date Installed: __________________________________________________________________________________ Date Inspected:_____________________________________[...]