hussman IGHT-ESH/ESHS-0010 manual

/Chino ESH/ESHS Hot F ood F amily Single-Deck Ser vice Hot F ood Case Re v . 0010 Installation & Operation Manual ESH/ESHS Hot F ood F amily Single-Deck Ser vice Hot F ood Case p/n IGHT -ESH/ESHS-0010 INST ALLA TION & OPERA TION GUIDE ESH Combo with pedestal option[...]

IGHT-ESH/ESHS-0010 2 /Chino A publication of Hussmann ® Chino 13770 Ramona A v enue • Chino, California 91710 (909) 628-8942 F AX (909) 590-4910 (800) 395-9229 K eep this booklet with the case at all times for futur e r eference. THIS BOOKLET CONT AINS INFORMA TION ON: ESH / ESHS: Hot Food Cases SHIPPING D AMA GE All equipment should be thorough[...]

Rev. 0010 3 UNCRA TING THE ST AND Place the fixtur e as close to its permanent position as possible . Remov e the top of the crate. Detach the walls fr om each other and remo ve fr om the skid. Unbolt the case fr om the skid. The fixture can no w be lifted off the crate skid. Lift only at base of stand! EXTERIOR LO ADING These models ha ve not been[...]

IGHT-ESH/ESHS-0010 4 LEVELING IMPOR T ANT! IT IS IMPERA TIVE THA T CASES BE LEVELED FROM FR ONT T O BA CK AND SIDE T O SIDE PRIOR T O JOINING. A LEVEL CASE IS NECESSAR Y T O INSURE PROPER OPERA TION, W A TER DRAINAGE, GLASS ALIGNMENT , AND OPERA TION OF THE HINGES SUPPOR TING THE GLASS. LEVELING THE CASE CORRECTL Y WILL SOL VE MOST HINGE OPERA TION[...]

Rev. 0010 5 FINISHING TOUCHES (PERFORM AFTER PLUMBING AND ELECTRICAL) A CCESS P ANELS All electrical and drain access panels ar e clearly labeled on the deck of the stand. . INST ALLING SPLASHGU ARD After mer chandisers ha ve been le veled and joined and all electrical and plumbing w ork has been completed, install the splashguards. After adjusting[...]

IGHT-ESH/ESHS-0010 6 BEFORE SER VICING Alwa ys Disconnect Electrical P o wer at the Main Disconnect when ser vicing or replacing an y electrical component. This includes (but not limited to) Fans, Heaters, Thermostats, and Lights. WIRING COLOR CODE L1 BLA CK L2 ORANGE L3 BLUE NEUTRAL WHITE NO TE: High Leg Connection Orange Only CASE MUST BE GROUNDE[...]

Rev. 0010 7 guide for the use of this equipment. The local health agency for y our area can pr ovide specific temperature requir ements. Critical attention must be giv en to the heat contr ols for these hot tables. Both the upper and lower heat contr ols must be adjusted to achie ve pr oper food temperatures. Hot foods should be held at a minimum t[...]

IGHT-ESH/ESHS-0010 8 is heating. The pilot lamp beside the contr ol knob indi- cates when the well heater is heating. AUT O-FILL OPERA TION Hussmann hot cases are equipped with an internal auto fill system that allows automatic filling of the heating pans. The water lev el is pr eset and automatically r egulated. The pr oper water lev el is 1 inch.[...]

Rev. 0010 9 User Information cont. 1. Scrub thoroughl y , cleaning all surfaces, with soap and hot water . 2. Rinse with hot water , but do not flood. 3 . Apply the sanitizing solution accor ding to the manufactur er’ s dir ections. 4. Rinse thor oughly . 5. Dr y completely befor e resuming operation. CLEANING GLASS & MIRRORS Only use a soft [...]

IGHT-ESH/ESHS-0010 10 IMPOR T ANT ! READ BEFORE RAISING FRONT GLASS : The top cylinders, which allow the raising and low ering of the glass, ha ve been car efully tested f or pr oper ten- sion. Howe ver , during shipment, the clamshell scre ws can work themselv es out and/or the lubricant inside may ha v e settled. This settling ma y cause excessiv[...]

Rev. 0010 11 PIST ON REPLA CEMENT 1. OPEN GLASS. Glass m ust remain open thr oughout procedur e . 2. Loosen Allen set Scr ew (1). 3. While holding onto piston, remov e and sav e pin (2). 4. Slide piston out. 5. Slide new piston in making sure the U-sha ped end fits around pin at bottom of arm (3). 6. Line up upper pin with arm, arm with strut, and [...]

IGHT-ESH/ESHS-0010 12 RECOMMENDED ADJUSTMENTS, VERIFY THA T THE CASE(S) HA VE BEEN LEVELED PROPERL Y .TIPS & TROUBLESHOO TING Befor e calling for ser vice if something seems wr ong, check the follo wing: 1. INSPECT THE GAP BETWEEN THE GLASS PANELS A. If pinched at the top: Gap is mor e narr ow at the top than at the bottom. Then see Item 4 / Un[...]

Rev. 0010 13 3. CHECK OPENING ACTION OF GLASS PANELS A. Lift up adjacent glass panels at the same time and note the follo wing: B. Do the corners of the glass maintain an ev en gap throughout the tra vel of the panels? And do the corners touch or ov erlap at an y point? T o correct pr oblem Go to items 4 & 5. 4. STRATEGIES FOR CORRECTING UNEVEN[...]

IGHT-ESH/ESHS-0010 14 5. STRATEGIES FOR CORRECTING GLASS BOUNCE AND OPENING OVERLAP PROBLEMS ADJUST HINGES FRONT – BACK. A. Adjust center Hinge (Outer hinges stationar y) As this diagram indicates, pulling the middle hinge further back, pulls the inside edges closer to the surface or edge which the glass rests upon. And pushing the middle hinge t[...]

Rev. 0010 15 6. VERTICAL AND FRONT TO BACK ADJUSTMENT AND OPENING OVERLAP PROBLEMS • V ER TICAL A DJUSTMENT 1. Remove 2. Lift open 3. Loosen hex screw 4. Add or remove 5. Close glass panel(s) top glass glass panel(s) (1/4" allen). shims as needed. and check alignment and panel and relieve Remove chrome (see note on shims Retighten hex screw [...]

IGHT-ESH/ESHS-0010 16 TIPS & TROUBLESHOO TING Befor e calling for ser vice if something seems wrong, check the follo wing: 1. Check electrical pow er supply to the equipment for connection. 2. Check fixtur e loading. Ov erstocking case will affect its pr oper operation. SERIAL NUMBER HANDY. Case Specifications WELLS GRIDDLES SHELF CIRCUIT 1 CIR[...]

Rev. 0010 17 WELLS GRIDDLES SHELF CIRCUIT 1 CIRCUIT 2 WIRING Remarks MODEL LENGTH P ANS QTY . SIZE LEVELS VOL TS PHASE Loads PHASE Loads Diagram Number Individual W ells Ser vice ESH, ESHS 4' 3 208 3Ø 17 W6000019 240 3Ø 19 W6000019 6' 5 208 3Ø 21 W6000021 240 3Ø 25 W6000021 8' 6 208 3Ø 30 W6000022 240 3Ø 35 W6000022 10' 8 [...]

IGHT-ESH/ESHS-0010 18 Sheet 1 of 1 final BK Boris Kasrel Date: Project Title: Drawing No.: Drawn By: Next Assembly: Drawing Title: Date: Hussmann Corporation 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 Revisions: No. Description: Checked By: By: 10.21.99 Ballast Power #125-01-0311 LIGHTS #125-01-0311 S L1 L2 L3 N G Contactor 4[...]

Rev. 0010 19 ASH, ESH-S, RGSH-L/S, OSH Sheet 1 of 1 final BK Boris Kasrel Date: Pro ject Title: Drawing N o.: Drawn By: Next Assembly: Drawing Title: Date: Hussmann Corporation 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 Revisions: No. Description: Checked By: By: 10.21.9 9 W H2-120-135 Ballast POW ER #125-01-0311 LIGHT #125-0[...]

IGHT-ESH/ESHS-0010 20 ASH, ESH-S, RGSH-L/S, OSH Sheet 1 o f 1 final BK Boris Kasrel Date: Project Title: Drawing No.: Drawn By: Next Assembly: Drawing Title: Date: Hussmann Corporation 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 Revisions: No. Description: Checked By: By: 02.03.2000 W H3-120-164 Ballast POW ER #125-01-0311 LIG[...]

Rev. 0010 21 ASH, ESH-S, RGSH-L/S, OSH Common W ell Remov able Pans Hot Food S ervice Counter Sheet 1 of 1 final BK Boris Kasrel Date: Project Title: Drawing No.: Drawn By: Next Assembly: Drawing Title: Date: Hussmann Corp oratio n 137 70 Ramona Avenue Chino , CA . 91710 (909)- 590- 491 0 Lic.#: 64440 6 Revisions: No. Descripti on: Checked By: By: [...]

IGHT-ESH/ESHS-0010 22 Electrical Schematics ASH, ESH-S, RGSH-L/S, OSH Hot Food Service Counters Sheet 1 of 1 final BK Boris Kasrel Date: Project Title: Drawing No.: Drawn By: Next Assembly: Drawing Title: Date: Hussmann Corporation 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 Revisions: No. Description: Checked By: By: W H3-120[...]

Rev. 0010 23 Electrical Schematics ASH, ESH-S, RGSH-L/S, OSH Sheet 1 of 1 final BK Boris Kasrel Date: Project Title: Drawi ng N o.: Drawn By: Next Assembly: Drawing Title: Date: Hussmann Corporation 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 Revisions: No. Description: Checked By: By: 01.20.2000 W H2-120-135 Ballast POW ER #1[...]

IGHT-ESH/ESHS-0010 24 Sheet 1 of 1 final BK Boris Kasrel Date: Project Title: Drawing No.: Drawn By: Next Assembly: Drawing Title: Date: Hussmann Corporation 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 Revisions: No. Description: Checked By: By: 11.29.99 W H2-120-135 Ballast POW ER #125-01-0311 LIGHT #125-01-0311 S L Control P[...]

Rev. 0010 25 Electrical Schematics ASH, ESH-S, RGSH-L/S, OSH Sheet 1 of 1 final BK Boris Kasrel Date: Project Title: Drawing No.: Drawn By: Next Assembly: Drawing Title: Date: Hussmann Corporation 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 Revisions: No. Description: Checked By: By: 01.20.2000 W H2-120-135 Ballast POW ER #125[...]

IGHT-ESH/ESHS-0010 26 ASH, ESH-S, RGSH-L/S, OSH Sheet 1 of 1 final BK Boris Kasrel Date: Project Title: Drawing No.: Drawn By: Next Assembly: Drawing Title: Date: Hussmann Corporation 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 Revisions: No. Description: Checked By: By: 06.29.00 W H3-120-164 Ballast POW ER #125-01-0311 LIGHT [...]

Rev. 0010 27 Electrical Schematics ASH, ESH, ESHS, RGSHL, RGSHS, OSH-SS Sheet 1 of 1 final BK Date: Project Title: Drawing N o.: Drawn By: Next Assembly: Dra wing Title: Date: Hussmann Corporation 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 Revisions: No. Description: Checked By: By: 5' Plain Griddle Hot Food Self Servi c[...]

IGHT-ESH/ESHS-0010 28 ASH, ESH, ESHS, RGSHL, RGSHS, OSH-SS Sheet 1 of 1 final BK Boris Kasrel Date: Project Title: Drawing No.: Drawn By: Next Assembly: Drawing Title: Date: Hussmann Corporation 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 Revisions: No. Description: Checked By: By: 6' Plain Griddle Hot Food Self-Service C[...]

Rev. 0010 29 ASH, ESH, ESHS, RGSHL, RGSHS, OSH-SS Sheet 1 of 1 final BK Boris Kasrel Date: Project Title: Drawing N o.: Drawn By: Next Assembly: Drawing Title: Date: Hussmann Corp oratio n 137 70 Ramona Avenue Chino , CA . 91710 (909)- 590- 491 0 Lic.#: 64440 6 W 6000013 Revisions: No. Descripti on: Checked By: By: 8' Plain Griddle Hot Food Se[...]

IGHT-ESH/ESHS-0010 30 By: Checked By: No. Descripti on: Revisions: W6000014 Hussmann Corp oratio n 137 70 Ramona Avenue Chino , CA . 91710 (909)- 590- 491 0 Lic.#: 64440 6 Date: Drawing Title: Next Assembly: Drawn By: Drawing N o.: Pro ject Title: Date: Boris Kasrel BK 01.25.2 000 final Sheet 1 of 1 ASH, ESH/S, RGSH-S/L, RGSHS 6' Combo, 3 Pan [...]

Rev. 0010 31 ASH, ESH, ESHS, RGSHL, RGSHS, OSH-SS Plain Griddle Self-Service Display Sheet 1 of 1 final BK Boris Kasrel Date: Project Title: Drawing No.: Drawn By: Next Assembly: Drawing Title: Date: Hussmann Corporation 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 W6000015 Revisions: No. Description: Checked By: By: 12'-2[...]

IGHT-ESH/ESHS-0010 32 By: Checked By: No. Descripti on: Revisions: W 6000016 Hussmann Corporation 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 Date: Drawing Title: Next Assembly: Drawn By: Drawing N o.: Project Title: Date: Boris Kasrel BK 04.14.2000 final Sheet 1 of 1 ASH, ESH/S, RGSH-S/L, RGSHS Hot Food Service/ Self -Servi c[...]

Rev. 0010 33 ASH, ESH/S, RGSH-L/S, RGSHS Multipurpose Combo Counters Sheet 1 of 1 final BK Boris Kasrel Date: Project Title: Drawing No.: Drawn By: Next Assembly: Drawing Title: Date: Hussmann Corporation 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 Revisions: No. Description: Checked By: By: 02.25.2000 10' Combo, 5 Remova[...]

IGHT-ESH/ESHS-0010 34 ASH, ESH/S, RGSH-L/S, RGSHS Multipurpose Combo Counters Sheet 1 of 1 final BK Boris Kasrel Date: Project Title: Drawing No.: Drawn By: Next Assembly: Drawing Title: Date: Hussmann Corporation 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 Revisions: No. Description: Checked By: By: 12' Combo, 7 Rem ova [...]

Rev. 0010 35 Date: Project Title: Drawing N o.: Drawn By : Assembly: Drawin g Title: Date: Hussmann Corp oratio n, Int'l. 137 70 Ramona Avenue , Ch ino , CA . 91710 (909)- 590- 491 0 Lic.#: 644406 Revisions: No. Descri ption: Checked By: By: File Loc ation: Adrián E. Crisci AEC Sheet of 1 1 06/07/00 LIGHT #125-01-0311 orange blue black whit e[...]

IGHT-ESH/ESHS-0010 36 6', (5) 12x27 Hot Food W ell ASH, ESH/S, RGSH-L/S, RGSHS Individual W ells Hot Food Self-Service Counter final BK Boris Kasrel Date: Project Title: Drawing No.: Drawn By: Next Assembly: Drawing Title: Date: Hussmann Corporation 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 Revisio ns: No. Description: [...]

Rev. 0010 37 RGSHS8'-6 Individual W ells Wirin g Diagram ASH, ESH/S-SS, RGSHS/L-SS Hot Food Individual W ells Service Case Sheet 1 o f 1 final BK Boris Kasrel Date: Project Title: Drawing No.: Drawn By: Next Assembly: Drawing Title: Date: Hussmann Corporation 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 Revisions: No. Desc[...]

IGHT-ESH/ESHS-0010 38 ESH/S-RGSHL/S 10'- 8 Individual W ells Individual W ells Hot Food Self Service Cou nters Sheet 1 of 1 final Boris Kasrel Date: Project Title: Drawing No.: Drawn By: Next Assembly: Drawing T itle: Date: Hussmann Corporation 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 W6000025 Revisions: No. Descriptio[...]

Rev. 0010 39 final BK Boris Kasrel Date: Project Title: Drawing No.: Drawn By: Next Assembly: Drawing Titl e: Date: Hussmann Corporation 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 Revisions: No. Description: Checked By: By: L1 L2 L3 L1 L2 L3 ~208V ~240V LOADS, Amps 27.6 31.9 G Contac tor 1 #125- 01-1001 s 24.8 28.6 18.2 21.0 [...]

IGHT-ESH/ESHS-0010 40 Sheet 1 of 1 final BK Boris Kasrel Date: Project Title: Dr awin g No .: Drawn By: Next Assembly: Drawing T itle: Date: Hussmann Corporation 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 Revisio ns: No. Description: Checked By: By: LIGHT #125-01-0311 orange blue black white Optional Left ~ 1 1 5 V / 5 A m p&[...]

Rev. 0010 41 Sheet 1 of 1 final BK Boris Kasrel Date: Project Title: Dr awin g No .: Drawn By: Next Assembly: Drawing T itle: Date: Hussmann Corporation 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 Revisio ns: No. Description: Checked By: By: 01.24.2 000 LIGHT #125-01-0311 orange blue black whit e Optional Left ~ 1 1 5 V / 5 A [...]

IGHT-ESH/ESHS-0010 42 ASH, ESH/S, RGSH-L/S, RGSHS Combo Hot Food Self-Service Counters Sheet 1 of 1 final BK Boris Kasrel Date: Project Title: Dr awin g No .: Drawn By: Next Assembly: Drawing T itle: Date: Hussmann Corporation 13770 Ramona Avenue Chino, CA. 91710 (909)-590-4910 Lic.#: 644406 Revisio ns: No. Description: Checked By: By: 01.24.2 000 [...]

Rev. 0010 43 ASH, ESH/S, RGSH-L/S,RGSHS Combo Hot Food Self-Service Counter Sheet 2 of 2 final BK Boris Kasrel Date: Project Title: Drawing No.: Drawn By: Next Assembly: Drawing T itle: Date: Hussmann Corp oratio n 137 70 Ramona Avenue Chino , CA . 91710 (909)- 590- 491 0 Lic.#: 64440 6 Revisions: No. Descripti on: Checked By: By: 12' Combo, 6[...]

IGHT-ESH/ESHS-0010 44 APPENDIX A. – Temperature Guidelines 1.0 Hot cases are tested to maintain all hot food at 140 ° - 150 ° . These cases are not designed to heat up or cook food. It is the user’s responsibility to stock the hot food cases immediately after the cooking of the food with a pulp temperature of at least 150 ° to 160 ° . APPEN[...]

Rev. 0010 45 13. Turn the equipment off and allow to cool before cleaning. 14. To remove “baked-on” splatter from Stainless Steel, the following may be used Grade F Italian Pumice Scour or rub with a damp cloth Liquid Nusteel Scour with a small amount of a dry cloth Paste NuSteel Household Cleaners Rub with a damp cloth Coopers Stainless Steel [...]

IGHT-ESH/ESHS-0010 46 Limited W arranty This warranty is made to the original user at the original installation site and is not transf erable . Hussmann mer chandisers are war ranted to be free fr om def ect in material and workmanship under normal use and ser vice for a period of one (1) y ear fr om the date of original installation (not to exceed[...]

Rev. 0010 47 The MODEL NAME and SERIAL NUMBER is required in or der to pr ovide you with the correct parts and information f or y our particular unit. They can be found on a small metal plate on the unit. Please note them below for futur e refer ence. MODEL: SERIAL NUMBER: /Chino Additional copies of this publication ma y be obtained b y contacting[...]