Razor 15130760 manual

O W N E R S M A N U A L R ead and understand this entire manual bef or e riding ! R e bellion Elect ric Chopper Mini Elect ric Chopper Item Numbers Mini Electric Chopper Black 15555 -BK Red 15555-RD Blue 15555-BL Re bellion Electric Chopp er 15130760 Mini TM[...]

WARNING: Riding the electric chopper can be a hazardous activity . Certain conditions may cause the equipment to fail without fault of the manufacturer . Like other electric vehicles, the electric chopper can and is intended to move, and it is therefore possible to lose control, fall off and/or get into dangerous situations that no amount of care, [...]

Remove contents from box. Remove the foam separators that protect the components from damage during shipping. Inspect the contents of the box for scratches in the paint, dents or kinked cables that may have occurred during shipping. Because the electric chopper was 95 percent assembled and packed at the factory , there should not be any problems, e[...]

3 ASSEMBL Y AND SET -UP Attac hing the F ront F or ks 1 Insert the spacer sleeves on the top and bottom of the frame. 2 Slide the fork into position and insert the steering bolt. The bolt must go through the washer and spacer sleeve and between the steering bearings inside the frame . WARNING: Failing to properly adjust and tighten the clamps and r[...]

1 Press the spring buttons on each side of the handlebars and tap the bars until the spring buttons slide inside and engage the corresponding holes in the fork. 2 When correctly engaged, the handlebars will not disengage from the fork. 3 T ighten all four pinch clamp screws (two in the upper and two in the lower crown). Attac hing the Handleba r s [...]

5 REP AIR AND M AINTENANC E Chain and Sprock et Adjustment – Mini Chopper Note : Late model Mini Electric Choppers and Rebellion Electric Choppers are equipped with a chain tensioner , are self adjusting and will not use this method to adjust the chain. The chain will typically have a “loose spot” and “tight spot” corresponding with a par[...]

6 REP AIR AND M AINTENANC E Chain and Tire R eplacement – Mini Chopper WARNING: T o avoid a pinch or injury , keep fi ngers away from moving sprockets and chain. WARNING: Increasing the tension too much can snap the chain or bend the motor output shaft. T o avoid this, use caution where tightening and carefully check the tension after each 1/8 t[...]

7 REP AIR AND M AINTENANC E Ba tter y Care and Disposal Do not store the battery in temperatures above 75° or below -10° F . CONT AINS SEALED LEAD BA TTERY . BA TTERY M UST B E RECYCLED. Disposal: Y our Razor product uses sealed lead-acid batteries which must be recycled or disposed of in an environmentally sound manner . Do not dispose of a lead[...]

8 SB 1918 (CALIFORNIA) DECLARA TION YOUR INSURANCE POLICIES MA Y NOT PROVIDE COVERAGE FOR ACCIDENTS INVOL VING THE USE OF THIS SCOOTER/ELECTRIC VEHICLE. T O DETERMINE IF COVERAGE IS PROVIDED, YOU SHOULD CONT ACT YOUR INSURANCE COM- P ANY OR AGENT .[...]

9 V ehicle does not run V ehicle was running but suddenly stopped Short run time (less than 30 minutes per charge) V ehicle runs sluggishly Problem P ossible Cause Solution Undercharged battery Charger is not working Loose wires or connectors Burned out fuse Motor or electrical switch damage Undercharged battery Battery is old and will not accept f[...]

10 Sometimes the vehicle doesn’t run, but other times it does Charger gets warm during use V ehicle does not stop when applying the brake V ehicle makes loud noises or grinding sounds Problem P ossible Cause Solution Loose wires or connectors Motor or electrical switch damage Normal response to charger use Brakes are not adjusted properly Chain a[...]

Keep your Mini Electric Chopper running for years with genuine Razor parts. Visit our web site or e-mail us for more information on spare part availability . (Specifi cations subject to change without notice.) MINI ELE CTRIC CHOPPER P ARTS 1. Handlebar , drag-style 2. V alve stem extender/infl ator 3. Handlebar end cap, extender holder 4. Grip, h[...]

MINI ELE CTRIC CHOPPER P ARTS 1 2 3 4 5 2 1 6 7 8 9 10 16 17 20 18 15 14 73 34 35 37 37 38 22 23 24 25 26 27 28 29 29 54 51 50 49 48 47 70 53 59 52 56 55 57A 57 58 45 30 31 32 33 44 12 43 42 1 1 13 39 40 72 72 71 21 19 41 74 69 68 67 66 65 64 63 62 61 60 36 46[...]

Keep your Rebellion Electric Chopper running for years with genuine Razor parts. Visit our web site or e-mail us for more information on spare part availability . (Specifi cations subject to change without notice.) REBELLIO N ELECTRIC CHO PPER P ARTS 13 1. Front wheel, tire, tube, axle, nut 2. Front fender w/screws 3. Fork legs (2) with both clamp[...]

14 REBELLIO N ELECTRIC CHO PPER P ARTS 1 2 3 4 6 4 13 14 6 7 9 8 10 1 1 12 13 14 15 16 17 18 19 20 23 25 26 27 28 29 30 31 28 21 22 24 5[...]

Tire Infl ation Periodically inspect the t ires for excess wear and replace as required, and regularly check the tire pressure and re- infl ate as necessary . If you get a fl at tire, the inner tube can be patched or a new tube c an be purchased from Razor or an authorized repair cente r . Safe ty Gear Always wear proper protec tive equipment su[...]

US DESIGN P A TENT NO: US D504 846 S EC COMMUNITY DESIGN NO: 000236781-0001&0002[...]