Windsor 10061090 manual

Operating Instructions (ENG) MODELS: CSX24 10061090 CSX26SP 10061160 Read these instructions before using the machine iScrub 86317500-A 11/15/08[...]

MACHINE DATA LOG/OVERVIEW 86317500 CHARIOT SCRUBBE R 11/15/08 2 OVERVIEW The Chariot Scrubber is a battery powered, stand-on, hard floor scrubber intended for commercial use. The appliance applies a cleaning solution o nto a hard floor, scrubs the floor with brushes or pads, and then vacuums the soiled water back into the recovery tank .[...]

TABLE OF CONTENTS 86317500 CHARIOT SCRUBBER 11/15/08 3 Machine Data Log/ Overview . ............................... 2 Table Of Contents ................................................ 3 HOW TO USE THIS MANUAL How To Use This Manual. .................................... 1-1 SAFETY Important Safety Instructions ............................ 2-1 Hazar[...]

HOW TO USE THIS MANUAL 86317500 CHARIOT SCRUBBER 11/15/08 1-1 This manual contains the f ollowing sections: - HOW TO USE THIS MANUAL - SAFETY - OPERATIONS - MAINTENANCE - PARTS LIST The HOW TO USE THIS MANUAL section will tell you how to find important information for ordering correct repair parts. Parts may be ordered from authori zed Windsor deal[...]

86317500 CHARIOT SCRUBBE R 11/15/08 2-1 IMPORTANT SAFETY INSTRUCTIONS When using an battery powered appliance, basic precaution must always be followed, including the following: READ ALL INSTRUCTIONS BEFORE USING THIS MACHINE. To reduce the risk of fire, electric sho ck, or injury : Use only indoors. Do not use o utdoors or expose to rain. Use only[...]

HAZARD INTENSITY LEVEL 86317500 CHARIOT SCRUBBER 11/15/08 2-2 The following symbols are use d throu ghout this guide as indicated in their descri ptions: HAZARD INTENSITY LEVEL There are three levels of hazard intensit y identified by signal words - WARNING an d CAUTION and FOR SAFETY. The level of hazard intensity is determined by the following de[...]

SAFETY LABEL LOCATION 86317500 CHARIOT SCRUBBER 11/15/08 2-3 NOTE: These drawings indicate the location of safet y labels on the machine. If at any time the labels becom e illegible, promptly replace them. PRV NO. 80885 86252520 BATTER Y CAUTI ON PRV NO. 500955 86244300 WARNING LABEL[...]

TECHNICAL SPECIFICATIONS 86317500 CHARIOT SC RUBBE R 11/15/08 3-1 ITEM DIMENSION/CAPACITY Nominal power 1800 W Rated Voltage 36 Volts DC Rated Amperage 50 amps Batteries 3 X12 Volt 195-215 AH @ 20 hr. rate Battery Compartment Dimensions 21 in. x 16 in. x 17 in. tall (533mm x 406mm x 432mm) Scrub Brush Motors - Disk Machin e 2 x .3 HP (190 W) Scrub [...]

TECHNICAL SPECIFICATIONS 86317500 CHARIOT SCRUBBE R 11/15/08 3-2 WIDTH LENGTH HEIGHT ITEM MEASURE Height 50.6 inches (1285 mm) Length 52.5 inches (1330 mm) Width without squeegee 26.5 inches (670 mm) Width of squeegee - Disk Machi ne 32.7 inches (830 mm) Width of squeegee - Cylindrical M achine 37 inches (970 mm) Width of scrub path - Disk Machi ne[...]

HOW THIS MACHINE WORKS 86317500 CHARIOT SCRUBBE R 11/15/08 3-3 The Chariot® is a battery powered, self-prop elled, hard floor scrubber intended for com mercial use. The appliance applies a cl eaning solution onto a hard floor, scrubs the floor with brushes, and then vacuums the soiled water back into the recovery tank. The machine's primary s[...]

COMPONENTS 86317500 CHARIOT SCUBBER 11/15/08 3-4 1. Control Panel-Drive 2. Control Panel-Scrub 3. Control Housing 4. Pedal Platform 5. Rear Cover 6. Tank 7. Recovery Dome 8. Recovery Drain Hose 9. Scrub Deck Aqua-Mizer™ 10. Scrub Deck Skirts/Side Squeegees 11. Solution Cover 12. Solution Drain Hose 1 2 3 4 5 6 7 8 9 10 12 11[...]

DRIVE CONTROLS 86317500 CHARIOT SCRUBBE R 11/15/08 3-5 1 2 3 4 5 6 8 9 7[...]

DRIVE CONTROLS 86317500 CHARIOT SCRUBBE R 11/15/08 3-6 1. Key Switch 2. Emergency Stop/Brake Switch 3. Directional Control / Drive Reset Switch 4. Throttle Pedal 5. Horn Button 6. Steering Wheel 7. Speed Control 8. Battery Discharge Indicator 9. Hour Meter 1. KEY SWITCH Controls the power for machine functions. To turn the machine power on, rotate [...]

DRIVE CONTROLS 86317500 CHARIOT SCRUBBE R 11/15/08 3-7 SLOW FAST 5. HORN BUTT ON The horn is activated by pressing the horn button. 6. STEERING WHEEL The steering wheel turns the front wh eel causing the machine to change dire cti on. 7. SPEED CONTROL Controls the maximum speed of the machine. Ther e are two transport setting s, slow and fast. To c[...]

DRIVE CONTROLS 86317500 CHARIOT SCRUBBE R 11/15/08 3-8 8. BATTERY CHARGE LEVEL INDICATOR Indicates the charge level of the batterie s. The meter display is divided into 10 vertical bars. Bars illuminated on the fa r right indicate full charge. Bars flashing near the left side indicate the batteries sho u ld be re charged. Further operation of the m[...]

SCRUB CONTROLS 86317500 CHARIOT SCRUBBE R 11/15/08 3-9 A1 A2 A3 B C 1 1. FUNCTION MODE SWITCH The first two positions are for tran spo r t only. See drive controls section. A1 – Daytime cleaning/light cleaning This mode is used for light cleaning. In this mode the machine will propel at a maximum of medium speed. The scrub deck will automatically[...]

SCRUB CONTROLS 86317500 CHARIOT SCRUBBER 11/15/08 3-10 A3 – Heavy scrub level cleaning This mode is used for heavy level cleani ng. In this mode the machine will propel at a maximum of slow speed. The scrub deck will lower to a heavy down pressure. The water will flow at a high rate. The vacuum will flow at a high rate. B – Vacuum only mode Thi[...]

SCRUB CONTRO LS-SQUEEGEE 86317500 CHARIOT SCRUBBER 11/15/08 3-11 1 2 1. Squeegee Deflection Adjustment Knobs 2. Squeegee Pitch Adjustment Rod[...]

SCRUB CONTRO LS-SQUEEGEE 86317500 CHARIOT SCRUBBE R 11/15/08 3-12 1. SQUEEGEE DEFLECTION ADJUSTMENT KNOBS (DISK SCRU BBE R) Adjusts the deflection along the entire length of the squeegee. To increase squeegee blad e deflectio n, turn the two knobs at the ends of the squeeg ee counterclock wis e. To decrease squeegee def lection, turn t he two knobs[...]

MACHINE OPERATION 86317500 CHARIOT SCRUBBE R 11/15/08 3 - 1 3 PRE-RUN MACHINE INSPECTION Do a pre-run inspection to find possi ble problems that could cause poor perf ormance or lost time from breakdown. Follow the same pro cedure each time to avoid missing steps. NOTE: See maintenance section for pr e-run machine inspection che cklist items. START[...]

MACHINE OPERATION 86317500 CHARIOT SCRUBBE R 11/15/08 3-14 FILLING SOLUTION TANK FOR SAFETY: Before le av ing or servicing machine; stop on level surfac e, turn off machine and remove key. 1. Turn the machine power off. 2. Remove solution cover. 3. Fill the solution tank with clean water, leaving enough room for the requi red amou nt of cleaning so[...]

MACHINE OPERATION 86317500 CHARIOT SCRUBBE R 11/15/08 3-15 TO BEGIN SCRUBBI NG When operating the machine around people, pay close attention for unexpecte d movement. Use extra caution around children. Flammable liquids and/or reactive metals can cause explosions or fire! Do not pick up. 1. Stand on the operator platform. Throttle pedal must be in [...]

MACHINE OPERATION 86317500 CHARIOT SCRUBBE R 11/15/08 3-16 TO STOP SCRUBBING 1. Rotate the function knob to either transport position. The brush mo tors will stop and the scrub deck will rise to the park position. After 10 seconds the squeeg ee will raise, and 10 seconds later the vacuum motor will turn off. This delay is to clear the vacuum hose o[...]

MACHINE OPERATION 86317500 CHARIOT SCRUBBE R 11/15/08 3-17 TANK DOME RECOVERY DRAIN HOSE SOLUTION DRAIN HOSE RECOVERY EMPTYING AND CLEANING TAN KS 1. Park the machine next to a floor drain. Drain hoses are at the front of the machine. 2. Turn the machine power off. RECOVERY TANK 1. Remove the recovery tank dome. Pull the large drain hose from the m[...]

NOTES: 86317500 CHARIOT SCRUBBER 11/15/08 3-18[...]

MAINTENANCE 86317500 CHARIOT SCRUBBER 11/15/08 4-1 SERVICE SCHEDULE MAINTENANCE BEFORE EACH WORK PERIOD AFTER EACH WORK PERIOD 50 HRS 100 HRS 200 HRS Check water level of batteries after charging; add distilled water if necessary. (Wet cell only) * Check that dome and cover se al tightly. * Visually check for damaged or wo rn tire s. * Check brushe[...]

MAINTENANCE-BATTERIES 86317500 CHARIOT SCRUBBE R 11/15/08 4-2 1 2 3 4 5 6 1. Rear Cover Retainer Knob 2. Rear Cover 3. Battery Connector-Machine 4. Batteries 5. Battery Tray 6. Battery Tray Latch[...]

MAINTENANCE-BATTERIES 86317500 CHARIOT SCRUBBE R 11/15/08 4-3 BATTERIES (WET CELL ONLY) The batteries provide the power to ope rate the machine. The batteries require regul ar maintenance to keep them operating at peak efficiency. The machine batteries will hold their charge for long periods of time, but they can only be charged a certain number of[...]

MAINTENANCE-BATTERIES 86317500 CHARIOT SCRUBBER 11/15/08 4-4 CHECKING BATTERY SPECIFIC GRAVITY Use a hydrometer to chec k the battery spe cific gravity. CHECKING GRAVITY A. Hydrometer B. Battery NOTE: Do not take readings im mediately after adding distilled water, if the water and acid are not thoroughly mixed, the readi ng may not be accurate. Che[...]

MAINTENANCE-BATTERIES 86317500 CHARIOT SCRUBBER 11/15/08 4-5 5. Replace the battery caps, and leave them in place while charging. 6. Unplug the battery connector from the machine. FOR SAFETY: When charging, conn ect the charger to the batteries before conne cting the charger to the AC wall outlet. Never connect the charger to the AC wall outlet fir[...]

MAINTENANCE-SQUEEGEE 86317500 CHARIOT SCRUBBE R 11/15/08 4-6 1 2 3 4 5 6 1. Squeegee 2. Squeegee Deflection Adjustment Knobs 3. Squeegee Level Indicator 4. Squeegee Pitch Adjustment Rod 5. Squeegee Pitch Adjustment Lock Nut 6. Squeegee Retainer Knob[...]

MAINTENANCE-SQUEEGEE 86317500 CHARIOT SCRUBBE R 11/15/08 4-7 SQUEEGEE BLADES The front squeegee blade allows solution to pass through channels in the blade into the squee gee assembly while maintaining vacuum to provide lift. The front blade has four wear surfaces and can be rotated for extended life. The front blade shoul d not require regular rep[...]

MAINTENANCE-SQUEEGEE 86317500 CHARIOT SCRUBBE R 11/15/08 4-8 TO ADJUST SQUEEGEE PITCH 1. Choose a smooth, level surface. Turn “ON” the key switch. Lower the squeege e and drive forward at least 2 feet (60cm.). 2. With the squeegee down, stop the machine. Do not allow machine to roll back. FOR SAFETY: Before leavi ng or serv icing the machine; s[...]

MAINTENANCE-SCRUB BRUSHES 86317500 CHARIOT SCRUBBE R 11/15/08 4-9 SCRUB BRUSHES There are four different types of brushes available to cover applications from cle aning heavily soiled floors to polishing. A pad driver is also available to take advantage of the many cleaning pads on the market. Please refer to the following to assi st in sele cting [...]

MAINTENANCE-SCRUB DECK 86317500 CHARIOT SCRUBBE R 11/15/08 4-10 1 2 3 4 6 5 1. Scrub deck Aqua-Mizer™ 2. Aqua-Mizer™ retainer knob 3. Scrub deck skirt 4. Scrub deck skirt stop 5. Scrub brush motor 6. Scrub deck lift actuator[...]

MAINTENANCE-SCRUB DECK 86317500 CHARIOT SCRUBBE R 11/15/08 4-11 Do not use a pressure washer to clean around the brush motors. Use tap pressure only. TO REPLACE SCRUB BRUS H MOTORS 1. With the scrub deck in the raised position, disconnect brush motor wiring co nnector from harness. 2. Remove skirts from scrub deck to access and remove scrub brushes[...]

MAINTENANCE-SCRUB DECK 86317500 CHARIOT SCRUBBER 11/15/08 4-12 ACTUATOR SCRUB DECK REMOVAL/REPLACEMENT FOR SAFETY: Before leaving or servicing machine, stop on a level surface. Turn off machine. 1. Remove the two screws that secure actuator spring plate and pull actuat or ba rrel from stud on actuator spring bracket. 2. Remove clevis pin from upper[...]

MAINTENANCE-CIRCUIT PROTECTION 86317500 CHARIOT SCRUBBER 11/15/08 4-13 1 1. CIRCUIT BREAKERS Circuit breakers interrupt the flow of power in the event of an electrical overload. When a circuit breaker is tripped, reset it by pressing th e exposed button. If a circuit breaker cont inues to trip, the cause of the electrical overload sho uld be found [...]

MAINTENANCE-SOLUTION ST RAINER & PUMP-DISK 86317500 CHARIOT SCRUBBER 11/15/08 4-14 3 4 5 1 6 2 1. Solution Strainer-Coarse 2. Solution Strainer-Fine 3. Pump 4. Pump Mounting Plate 5. Solenoid Valve 6. Shut-off Valve[...]

MAINTENANCE-SOLUTION STRA INER & PUMP-CYLINDRICAL 86317500 CHARIOT SCRUBBE R 11/15/08 4-15 1 2 3 4 5 6 1. Solution Strainer-Coarse 2. Solution Strainer-Fine 3. Pump 4. Solenoid Valve 5. Jets 6. Shut-off Valve[...]

MAINTENANCE-SOLUTION STRAINER & PUMP 86317500 CHARIOT SCRUBBER 11/15/08 4-16 1. SOLUTION STRAINER-COARSE Located in bottom of tank. The coarse strainer protects the finer strainer from larg e deb ris. If the fine strainer is clean and the pump a nd solenoid valve are not working, then check the coarse strainer for debris. Drain the sol ution ta[...]

MAINTENANCE-VACUUM & FLOAT SHUT-OFF 86317500 CHARIOT SCRUBBE R 11/15/08 4-17 1 2 1. Recovery tank float shut-off 2. Vacuum motor[...]

MAINTENANCE-VACUUM & FLOAT SHUT-OFF 86317500 CHARIOT SCRUBBE R 11/15/08 4-18 RECOVERY TANK FLOAT S HUT- OFF When water is no longer being vacuum ed from the floor and the vacuum fan is operating, the ball float has engaged. The vacuum mo tor will not vacuum water with recovery tank full. The recovery tank must be drained. 1. The float shut-off [...]

MAINTENANCE-DRIVE MOTOR & BRAKE 86317500 CHARIOT SCRUBBE R 11/15/08 4-19 1 2 1. Drive motor 2. Parking brake[...]

MAINTENANCE-DRIVE MOTOR & BRAKE 86317500 CHARIOT SCRUBBE R 11/15/08 4-20 ELECTRIC PARKING BRAKE ENGA GE MEN T FOR SAFETY: Before leaving or servicing machine, stop on a level surface, turn off machine and remove key. Electric Brake Engagement This machine is equipped with an electric parking brake. The brake automatically engages and ke eps the[...]

MAINTENANCE-DRIVE MOTOR & BRAKE 86317500 CHARIOT SCRUBBE R 11/15/08 4-21 DRIVE MOTOR CARBON B RUSH REPLACEMENT Do not use a pressure washer to clean around the motors. Use tap pressure only . FOR SAFETY: Before leaving or servicing machine, stop on a level surface, turn off machine and remove key. 1. Disconnect batteries from machi ne. 2. Disco[...]

MAINTENANCE-BAG REPLACEMENT 86317500 CHARIOT SCRUBBER 11/15/08 4-22 REMOVING OR REPLACING BAG 1. Disconnect batteries a nd make sure parking brake is not overridden. 2. Remove Dome and set aside. 3. Drain all solution from both side s of the bag and rinse well. 4. Remove float cage, loosen screw on elbow and remove elbow. (You can remove the bag by[...]

MAINTENANCE-BAG TRANSPORTING 86317500 CHARIOT SCRUBBER 11/15/08 4-23 TIE DOW N POINTS PUSHING MACHINE The machine may be pushed for short distan ces at speeds not to exceed 5 mph. Be careful to avoid damaging machine. The machi ne may be pushed by hand from the rear. NOTE: To avoid damage caused by regenerative voltage, disconnect traction m otor b[...]

MAINTENANCE-TROUBLESHOOTING 86317500 CHARIOT SCRUBBE R 11/15/08 4-24 PROBLEM CAUSE SOLUTION Battery disconnected Check all battery cable connections Emergency shut-off activated Reset Battery cables corroded Clean connections No power to machine Faulty key switch Replace switch Low battery charge Charge batteries Machine turned on with pedal not in[...]

MACHINE TROUBLESHOOTING 86307500 CHARIOT SCRUBBE R 11/15/08 4-25 PROBLEM CAU SE SOLUTION Faulty vacuum circuit or switch Check wires & connections Vacuum motor does not run, or runs slowly Worn vacuum motor brushes Replace brushes, check commutator Faulty circuit or actuator Check wires, connectors and actuator Squeegee will not go up/down Faul[...]

MACHINE TROUBLESHOOTING- CONTROLLER FAULT CODES 86317500 CHARIOT SC RUBBE R 11/15/08 4-26 ERRO R CODE DELUXE PROBLEM SOLUTION LOW BATTERY VOL TAGE THE BATTERY NEEDS CHARGI NG OR THE RE IS A BAD CONNECTI ON TO THE BA TTERY TRACTION MOTOR DISCONNECTED TH E TR A CTI ON MOTOR HA S A BAD CON NECTION , CHECK CONNECTIONS TO MOTOR BRUSH MOTOR DISCONNECTED [...]

NOTES: 86317500 CHARIOT SC RUBBE R 11/15/08 4-27[...]

86317500 CHARIOT SCRUBBER 11/15/08 PARTS[...]

BUMPER 86317500 CHARIOT SCRUBBER 11/15/08 5-1 1 2 3 4 5 6 7 8 9 10 1 4[...]

BUMPER 86317500 CHARIOT SCRUBBER 11/15/08 5-2 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES 1 86270830 57023 4 NUT, 5/16-18 HEX NYLOCK SS 2 86197040 57264 4 NUT, 5/16-18 HEX ACORN 3 86276070 70593 2 SCR, 5/16-18 X 3/4 CARRIAGE SS 4 86276890 70752 6 SCR, 5/16-18X3/4 PTHMS SS 5 86010670 87029 4 WASHER, 5/16 X 3/4 SS 6 86279130 87083 4 WA[...]

CONTROL PANEL 86317500 CHARIOT SCRUBBER 11/15/08 5-3 2 3 4 6 7 8 10 12 13 14 15 16 17 18 19A 20 21 23 25 26 9 CONTROLLER SUPPLED WITH 11 27 22 5 HARNESS SUPPLED WITH 1 28 19B 30 29 10 24[...]

CONTROL PANEL 86317500 CHARIOT SCRUBBER 11/15/08 5-4 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES 1 86315470 1 METER, HOUR ICD 2 86005810 57245 2 NUT, 1/4-20 HEX NYLOCK SS 3 86271840 57285 3 NUT, 5/16-18 HEX NYLOCK THN SS 4 86271910 57295 1 NUT, 5/16-18 FLEXLOCK 5 86313900 - 2 RELAY, 5A, 24V, 4PDT 6 86273820 70019 2 SCR, 1/4-20 X 1.25[...]

CONTROL PANEL HOUSING 86317500 CHARIOT SCRUBBER 11/15/08 5-5 5 10 9 8 2 3 3 6 1 11 4 7[...]

CONTROL PANEL HOUSING 86317500 CHARIOT SCRUBBER 11/15/08 5-6 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86005810 57245 4 NUT, 1/4-20 HEX NYLOCK SS 2 86290540 - 6 SCR, 10-32 X 1/2 TORX SS BLK NP 3 86277480 70850 6 SCR, 5/16-18 X1/2 PTHMS SS 4 86317890 - 1 BRKT, LEFT CONSOLE MOUNT 5 86237900 35278 3 GASKET, .125 X .25W X 23L 6 8603[...]

DECAL 86317500 CHARIOT SCRUBBER 11/15/08 5-7 1 2 3 5 4 6[...]

DECAL 86317500 CHARIOT SCRUBBER 11/15/08 5-8 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1A 86318570 - 1 LABEL, CHAR, ISCURB 24, LEFT 1B 86318590 - 1 LABEL, CHA R, ISCRUB 26C, LEFT 2A 86318580 - 1 LABEL, CHAR, ISCRUB 24, RIGHT 2B 86318600 - 1 LABEL, CHAR, ISCRUB 26C, RIGHT 3 86317040 - 1 LABEL, PANEL, RIGHT 4 86017030 - 1 LABEL, PAN[...]

FRAME-LOWER 86317500 CHARIOT SCRUBBER 11/15/08 5-9 15 12 19 21 13 11 3 8 5 17 16A 20 18 7 2 6 1 14 9 4 2 2 2 2 2 3 11 5 2 10 12 15 5 10 16B 22[...]

FRAME - LOWER 86317500 CHARIOT SCRUBBER 11/15/08 5-10 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES 1 86091420 05251 1 AXLE, REAR, WELDMENT 2 86270830 57023 24 NUT, 5/16-18 HEX NYLOCK SS 3 86197040 57264 4 NUT, 5/16-18 HEX ACORN 4 86271870 57290 4 NUT, 1/4-20 HEX NYLOCK THIN SS 5 86276070 70593 20 SCR, 5/16-18 X 3/4 CARRIAGE SS 6 86276[...]

FRAME-UPPER 86317500 CHARIOT SCRUBBER 11/15/08 5-11 2 3 4 5 6 7 3 2 2 2 2 1[...]

FRAME-UPPER 86317500 CHARIOT SCRUBBER 11/15/08 5-12 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86074160 270101 1 BRKT, SIDE CHANNEL R 2 86270830 57023 10 NUT, 5-16 -18 HEX NYLOCK SS 3 86276070 70593 12 SCR, 5-16-18 X 3/4 CARRI AGE SS 4 86314760 - 1 TRAY, CABLE 5 86073500 270090 1 BRKT, SIDE CHANNEL L 6 86314770 - 2 BRKT, STEERING[...]

PEDAL PLATFORM 86317500 CHARIOT SCRUBBER 11/15/08 5-13 1 2 3 4 5 7 8 9 10 12 13 14 15 16 18 19 21 22 25 26 27 28 24 23 17 6 11 20 11 15 22[...]

PEDAL PLATFORM 86317500 CHARIOT SCRUBBER 11/15/08 5-14 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES 1 86233170 20054 2 CLAMP, 3/8 NYLON UL/C SA 2 86264920 27049 1 CABLE TIE, .19 X 7 UL/CSA 3 86222510 34430 1 PEDAL, THROTTLE 4 86221850 34433 1 LINK, THROTTLE 5 86136310 57086 1 NUT, M5 HEX 6 86312820 - 1 BRACKET, POT, SPEED 7 86288720 5[...]

PEDAL PLATFORM 86317500 CHARIOT SCRUBBER 11/15/08 5-15 8 3 9 12 5 1 10 7 8 6 4 14 11 2 13 15 6 5[...]

PEDAL PLATFORM 86317500 CHARIOT SCRUBBER 11/15/08 5-16 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86008680 80607 1 COTTER, 1/2” RING 2 86274690 70258 2 SCR, 5/16-18 X 1.5 HHCS GR5PLT 3 86264920 27049 3 CABLE TIE, 7” UL/CSA 4 86231070 730328 2 BUMPER, 1 X 1.375 RUBBER 5 86010670 87029 5 WASHER, 5/16 FLAT SS 6 86259430 87485 4 [...]

REAR COVER 86317500 CHARIOT SCRUBBER 11/15/08 5-17 13 1 2 3 8 9 10 7 5 6 9 11 12 14 4 16 3 2 15[...]

REAR COVER 86317500 CHARIOT SCRUBBER 11/15/08 5-18 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86276780 70728 3 SCR, 5/16-18 X 3/4 HHCS SS 2 86279130 87083 5 WASHER, 5/16 SPLIT LOCK PLTD 3 86010670 87029 5 WASHER, 5/16 FLAT SS 4 86031780 270082 1 COVER, REAR, DELUXE 5 86005860 57273 2 NUT, 1/4-20 X 12MM HEX BARREL 6 86228980 09152[...]

SCRUB BRUSH/PAD DRIVER-DISK 86317500 CHARIOT SCRUBBER 11/15/08 5-19 8 4 9 6 5 7 2D 5 3 2C 2A 2B 7 5 8 4 9 6 1[...]

SCRUB BRUSH/PAD DRIVER-DISK 86317500 CHARIOT SCRUBBER 11/15/08 5-20 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86000170 02400 2 PAD DRIVER, 12” SD 2A 86000180 02401 2 BRUSH, 12” POLYPROPYLENE SD 2B 86000190 02402 2 BRUSH, 12” NYLON SD 2C 86000200 02404 2 BRUSH, 12” MILD G RIT SD 2D 86283820 02405 2 BRUSH, 12” SUPER AGG [...]

SCRUB BRUSH/PAD-CYLINDRICAL 86317500 CHARIOT SCRUBBER 11/15/08 5-21[...]

SCRUB BRUSH/PAD-CYLINDRICAL 86317500 CHARIOT SCRUBBER 11/15/08 5-22 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 41150040 - 1 WASHER CLOSURE 2 74010050 - 1 BALL BEARING 6302-2RS-DIN6 3 51128230 - 1 BRUSH TORX 4 50052670 - 1 RONDE 5 73430370 - 1 LOCKING RING 50X2-FST-RF DIN 47 1 6A 63693890 - - 105MM WHITE PAD 6B 63694540 - - PAD YE[...]

SCRUB DECK – DISK 86317500 CHARIOT SCRUBBER 11/15/08 5-23 18 17 14 15 16 12 13 11 10 8 9 7 6 5 4 3 2 1 8 8 19 19 20 20 FROM PUMP[...]

SCRUB DECK-DISK 86317500 CHARIOT SCRUBBE R 11/15/08 5-24 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86281100 39274 1 HOSE, 1/2ID WIRE BOUND X 8” 2 86003580 34327 1 FITTING, 1/2”X3/8”X3/8” RED 3 86005490 53808 2 MOTOR ASM, 36VDC300RPM GEAR - 86216200 14739 - BRUSH SET MOTOR 53808 4 86004810 48040 2 KEY, 1/4 SQ X 1.00 5 860[...]

SCRUB DECK-CYLINDRICAL 86217500 CHARIOT SCRUBBER 11/15/08 5-25[...]

SCRUB DECK-CYLINDRICAL 86217500 CHARIOT SCRUBBER 11/15/08 5-26 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 50448660 - 2 RETAINER PLATE TRANSMISSION 2 73060310 - 10 SCREW M 6X16-A2-70 DIN 7984 3 73120260 - 10 WASHER 6-A2 ISO 7090 4 73130030 - 10 SPRING WASHER B 6FST-A3E DIN 127 5 50448580 - 2 HOLDER-UP 6 50560100 - 2 ROCKER BR-VS 7[...]

SCRUB DECK MOUNTING-CYLINDRICAL 86217500 CHARIOT SCRUBBER 11/15/08 5-27 1 2 3 4 5 6 7 8 9[...]

SCRUB DECK MOUNTING-CYLINDRICAL 86317500 CHARIOT SCRUBBER 11/15/08 5-28 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86315230 - 1 PIN, BALL LOCK 2 86274660 70255 2 SCR, 3/8-16 X 1.5 HHCS GR5 PLT 3 86224370 730335 2 SPACER, 1 OD X .391 ID X .500 4 86008460 80102 2 SPACER, .500OD X .391ID X .400 5 86009050 81324 2 BEARING, 1/2 ID X 1[...]

SCRUB DECK LIFT-DISK 86317500 CHARIOT SCRUBBER 11/15/08 5-29 20 4 29 7 1 SEE DETAI L 'A' 16 16 8 13 2 9 6 DETAIL 'A' 20 24 25 26 23 22 21 19 21 22 11 12 3 19 18 14 19 15 16 5 10 17 28 27[...]

SCRUB DECK LIFT-DISK 86317500 CHARIOT SCRUBBER 11/15/08 5-30 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86276920 70755 2 SCR, 3/8-16 X 1 HHCS SS NP 2 86008810 80697 2 BALL JOIN T ASY, 3/8-24 RH 3 86273850 70022 2 SCR, 1/4-20 X 2 HHCS 4 86010780 87162 2 WASHER, 1/4 SPILT LOCK PLTD 5 8607 9030 620058 1 PLATE, ACTUATOR SPR, SCRUBDEC[...]

SCRUB DECK ACTUATOR-CYLINDRICAL 86317500 CHARIOT SCRUBBER 11/15/08 5-31 26 17 26 17 16 19 18 23 17 9 1 3 5 6 15 24 27 8 17 2 18 21 22 4 7 28 17 18 16 19 18 23 17 25 14 28 28 1 2 20 12 27 13 11 21 10[...]

SCRUB DECK ACTUATOR-CYLINDRICAL 86317500 CHARIOT SCRUBBER 11/15/08 5-32 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86317340 - 3 SPACER, .498 X.313 X.500 2 86317330 - 3 PULLEY, 2 IN. 3 86316550 - 1 ACTUATOR, 36VDC, 4.5" STROKE 4 86315290 - 1 SPACER 5 86315260 - 1 BRKT ASSY, ACTUATOR 6 86315250 - 1 YOKE, CABLE 7 86315240 - 1 G[...]

SCRUB DECK SKIRTS-DISK 86317500 CHARIOT SCRUBBER 11/15/08 5-33 7 7 20 19 18 22 17 16 15 14 13 9 10 11 12 5 21 5 8 6 5 4 3 2 1 24 23[...]

SCRUB DECK SKIRTS-DISK 86317500 CHARIOT SCRUBBER 11/15/08 5-34 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86270830 57023 4 NUT, 5/16-18 HEX NYLO CK SS 2 86070960 140773 2 BRKT, SKIRT STOP, SCRUBDECK 3 86276070 70593 4 SCR, 5/16-18 X 3/4 CARRI AGE SS 4 86228900 09138 2 BEARING FL ANGED, .252IDX.503OD 5 86005810 57245 6 NUT, 1/4-20[...]

SCRUB DECK AQUA-MIZER™ 86317500 CHARIOT SCRUBBER 11/15/08 5-35 2 8 7 6 3 4 9 9 10 12 3 1 16 15 14 13 17 18 11B 11A 5A 5B[...]

SCRUB DECK AQUA-MIZER™ 86317500 CHARIOT SCRUBBER 11/15/08 5-36 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86270830 57023 4 NUT, 5/16-18 HEX NYLOCK SS 2 86277050 70782 2 SCR, 5/16-18 X 3/4 SHCS 3 86276950 70772 9 SCR, 1/4-20 X 3/4 CARRIAGE SS 4 86066430 140747 1 BAND, RIGHT AQUAMIZER 5A 8600 1540 140753 1 BLADE, AQUAMIZER, 12IN [...]

SOLUTION-DISK 86317500 CHARIOT SCRUBBER 11/15/08 5-37 5 20 18 20 13 14 4 16 15 17 5 SOLENO ID TO TANK TO 7 26 10 5 8 9 34 19 22 24 5 28 11 21 25 6 12 27 28 30 32 29 2 33 31 3 1 23 5[...]

SOLUTION-DISK 86317500 CHARIOT SCRUBBER 11/15/08 5-38 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86248010 57312 1 NUT, 8/32 ACORN CAP, PLATED 2 86226950 40109 1 1” HOSE BARB X 3/4” GHT NYLON 3 86073960 22104 1 CAP, 3/4” GHT W/.17 HOLE 4 86235450 31068 1 ELBOW, 3/8 FPT PVC SCH 80 5 86233150 20042 5 CLAMP, 3/8 HOSE (D-SLOT) 6[...]

SOLUTION-CYLINDRICAL 86317500 CHARIOT SCRUBBER 11/15/08 5-39 36 35 34 SOLENOID TO 7 23 5 22 24 5 28 21 25 6 28 1 18 5 20 5 16 15 14 3 17 2 TANK TO 10 5 8 33 19 11 12 30 32 29 26 31 27 4 9 13 37 38[...]

SOLUTION-CYLINDRICAL 86317500 CHARIOT SCRUBBER 11/15/08 5-40 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. NOTES: 1 86270830 5702 3 2 NUT, 5/16-18 HEX NYLOCK SS 2 86001530 4003 9 1 HOSE BARB, 1/2 MPT X 1/2 HOSE 90 3 86188210 11-800354 1 NIP, 1/2 X 3/8 HEX BR 4 86248010 57312 1 NUT, 8/32 ACORN CAP, PLATED 5 86233150 20042 5 CLAMP, 3/8 HOSE (D-SLOT[...]

SQUEEGEE-DISK 86317500 CHARIOT SCRUBBER 11/15/08 5-41 11 5 11 5 37 2 3 10 7 8 9 35 36 17 16 15 14 15 13 12 9 8 7 6 5 4 1 38 34 33 27A 32 31 30 29 28 25 18 19A 20 21 22 23 24 26 27B 19B 6 40 39[...]

SQUEEGEE-DISK 86317500 CHARIOT SCRUBBER 11/15/08 5-42 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86004890 48095 2 KNOB, ALUM 3/8-16 NYLOCK NUT SS 2 86070920 140759 2 BRKT, SQG WHEEL 3 86006270 66276 2 PIN, CLEVIS 5/16 X 1.63 PLTD 4 86007780 73576 2 SPRING, COMP .60D X 2.0L X .045 W 5 86005630 57022 2 NUT, 3/8-16 HEX NYLOCK THIN S[...]

SQUEEGEE-CYLINDRICAL 86317500 CHARIOT SCRUBBER 11/15/08 5-43[...]

SQUEEGEE-CYLINDRICAL 86317500 CHARIOT SCRUBBER 11/15/08 5-44 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 73120040 - 2 WASHER 8-00HV-A3E ISO 7090 2 63212110 - 2 STAR GRIP VA 3 50942310 - 2 SLEEVE SUCTION BAR IN VA 4 55152670 - 2 DEFECTOR ROLL SUCTION BAR 5 86137310 87098 2 WASHER, M8 SPLIT LOCK 6 86274860 70311 2 SCR, M8X20 HHMS 7 [...]

SQUEEGEE LIFT-DISK 86317500 CHARIOT SCRUBBER 11/15/08 5-45 14 7 6 10 10 16 13 10 3 20 8 2 12 11 10 9 2 5 1 15 25 15 16 26 27 21 17 16 4 16 17 22 13 20 19 18 17 13 13 13 23 24[...]

SQUEEGEE LIFT-DISK 86317500 CHARIOT SCRUBBER 11/15/08 5-46 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86068190 140793 1 BRACKET, ACTUATOR MOUNT 2 86273820 70019 1 SCR, 1/4-20 X 1.25 HHCS 3 86000870 05254 1 ACTUATOR, 36VDC, 4.5” STROKE 4 86083490 66831 1 PLATE, PULLEY MOUNT, CORNER 5 86068230 140840 1 BRACKET, SQG LIFT PULLEY MO[...]

SQUEEGEE LIFT- CYLINDRICAL 86317500 CHARIOT SCRUBBER 11/15/08 5-47[...]

SQUEEGEE LIFT- CYLINDRICAL 86317500 CHARIOT SCRUBBER 11/15/08 5-48 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86316550 - 1 ACTUATOR, 36VDC, 4.5" STROKE 2 86315270 - 1 BRKT ASSY, ACTUATOR MOUNT 3 86315250 - 1 YOKE, CABLE 4 86315000 - 1 SQUEEGEE MOUNT ASSY 5 86314820 - 1 CABLE ASSY, SQUEEGEE 6 86273740 70010 1 SCR, 1/4-20 X 1.[...]

SQUEEGEE SWING 86317500 CHARIOT SCRUBBER 11/15/08 5-49 1 24 23 22 21 20 3 6 19 18 16 15 14 13 17 11 6 9 10 8 6 7 7 6 5 4 25 2 1 6 12[...]

SQUEEGEE SWING 86317500 CHARIOT SCRUBBER 11/15/08 5-50 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86276690 70715 7 SCR, 5/16-18 X 1.75 CARR SS 2 86091530 140787 1 BRACKET, SQUEEGEE SIDE PIVOT 3 86090300 87247 2 WASHER, 1.25 ID X .075 OCTAGON 4 86083370 66475 2 PLATE, SQG SWING SPACER 5 86091540 140800 1 BRACKET, H PIVOT MOUNT 6 8[...]

STEERING 86317500 CHARIOT SCRUBBER 11/15/08 5-51 28 14 22 20 19 19 15 24 13 11 9 6 1 4 5 3 2 27 26 25 16 30 23 21 18 12 10 8 17 29 7[...]

STEERING 86317500 CHARIOT SCRUBBER 11/15/08 5-52 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86271610 57228 1 NUT, 5/8-16 HEX NYLOCK THN 2 86234810 27945 1 COVER, STEERING WHEEL 3 86259610 730117 1 WHEEL, STEERING 40 SPLINE HUB INCLUDES 27945 4 86224050 730318 1 SHAFT, UPPER STEERING 5 86228790 09111 1 BEARING, FLAN GE .88ODX.75ID[...]

TANK 86317500 CHARIOT SCRUBBER 11/15/08 5-53[...]

TANK 86317500 CHARIOT SCRUBBER 11/15/08 5-54 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86313100 - 1 DOME, TANK, 20 X 21 2 86310190 - 1 BASKET, STRAINER, DOME 3 86014530 5 SCR, KA50X16, PT, WN1412, PLT 4 86290540 - 4 SCR, 10-32 X 1/2 TORX SS BLK NP 5 86315530 - 1 COLLAR, BAG 6 86025200 31377 1 ELBOW ASM, FLOAT 7 86199840 090-12A [...]

VACUUM 86317500 CHARIOT SCRUBBER 11/15/08 5-55 1 2 3 4 5 6 7 8 9 7 11 10[...]

VACUUM 86317500 CHARIOT SCRUBBER 11/15/08 5-56 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86314790 - 3 ISOLATOR, RUBBER, 1/4-20 UNC M 2 86314780 - 1 PLATE, VAC MOTOR 3 86012210 - 1 VAC MOTOR, 36VDC 2ST TD 4 86279630 87212 1 WASHER, .344IDX1.130ODX.09T PLT 5 86010630 87013 3 WASHER, 1/4 X 5/8 FLAT SS 6 86006760 70305 1 SCR, 5/16-1[...]

WHEEL-FRONT DRIVE 86317500 CHARIOT SCRUBBER 11/15/08 5-57 1 2 17B 6 3 7 11 15 14 10 9 13 4 16 12 17A 8 18 19 20 21 22 23 24 25 26 27 28 29 30 5 19[...]

WHEEL-FRONT DRIVE 86317500 CHARIOT SCRUBBER 11/15/08 5-58 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86275190 70377 4 SCR, 3/8-16 X 1.25 HHCS SS 2 86010790 87163 4 WASHER, 3/8 SPLIT LOCK PLTD 3 86002830 27196 1 CABLE TIE, .375 X 24.7 4 86006170 66031 1 PIN, ROLL 1/8” X 3/4”L 5 86224440 730387 1 SPACER, 25.51 ID X 45 OD X 39.1[...]

WHEEL-REAR 86317500 CHARIOT SCRUBBER 11/15/08 5-59 1B 1A 2 3[...]

WHEEL-REAR 86317500 CHARIOT SCRUBBER 11/15/08 5-60 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1A 86011110 89261 2 WHEEL, 10X2.5X.787ID BEARINGS 1B 86259930 89274 - WHEEL, 10X2.5, W/BEARINGS, GRY OPTIONAL 2 86008710 80623 2 RING, ¾” EXT SNAP H-D 3 86232130 17309 2 CAP, 2.75 ID X 1.0 L BLK VINYL[...]

WIRING-BATTERIES 86317500 CHARIOT SCRUBBER 11/15/08 5-61 17 18 19 5 7A 1A 4 3 2 6A 8 10 9 11 12 22 13 14 16 15 20A 20B 24 23 20C 1B 6B 7B 26 25[...]

WIRING-BATTERIES 86317500 CHARIOT SCRUBBER 11/ 15/08 5-62 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1A 86260200 80872 2 WIRE, 4X14.5BK 3/8RINGX3/8RING 1B 86002510 23125 2 CABLE ASM, BAT. JUMPER X 15” EURO 2 86008920 80889 6 BOOT, RUBBER TERM. ISOLATOR 3 86271910 57295 6 NUT, 5/16-18 FLEXLOCK 4 86010670 87029 6 WASHER, 5/16 FLAT [...]

WIRING-COMPONENTS 86317500 CHARIOT SCRUBBER 11/15/08 5-63 1 2 3 4 5 6 6[...]

WIRING-COMPONENTS 86317500 CHARIOT SCRUBBER 11/15/08 5-64 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86008920 80889 2 BOOT, RUBBER TERM. ISOLATOR 2 86270830 57023 2 NUT, 5/16-18 HEX NYLOCK SS 3 86229770 140805 1 BLOCK, SHUNT MOUNT 4 86273980 70066 2 SCR, 10-32 X 3/4 PPHMS 5 86238500 81427 1 GROMMET, 1.703 ID X 2.5 OD X .125 GRV 6[...]

WIRING-CONTROL PANEL 86317500 CHARIOT SCRUBBER 11/15/08 5-65 65-WHT 67-GRN 63-BRN 37-WHT 61-WHT 32-GR Y 19-PUR 66-YEL 31-BLK 38-YEL 62-WH T K2 K1 72-BRN 73-BLU 64-BLU 7 C 1 PIN 6 K1-PIN 6 K2 PIN 8 K1-PIN 4 K2 PIN 9 K1-PIN 1 K2 PIN 4 K1-PIN 8 K2 PIN 10 K1-PIN 10 K2 PIN 12 K1-PIN 12 K2 PIN 13 K1-PIN 13 K2 PIN 14 K1-PIN 9 K2 PIN 11 K2-PIN 14 K2 1 2 3 [...]

WIRING-CONTROL PANEL 86317500 CHARIOT SCRUBBER 11/15/08 5-66 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86313700 - 1 HARNESS, PANEL 2 STAGE 2 86010860 880353 1 WIRE, 4X20 BK CTERM C5/16RING 3 86010850 880352 1 WIRE, 4X2ORD CTERM C3/8RING[...]

WIRING-DISK 86317500 CHARIOT SCRUBBER 11/15/08 5-67 KSI-18 AUXsupplyPIN 1 -TO AUX4 / / OPTIONAL -FLASHER OPTIONAL -REAR FLASHER -FRONT FLASH ER -FLASHER UNIT -FLASHER GND -FLASHER POWER 54/ORG 52/YE L 41/BRN 43/BRN 45/BRN 61/WHT 55/VIO 53/GRN 48/BRN 51/WH T 42/BR N 47/BR N 46/BRN 60/WHT 72/BRN 63/BRN 19/VIO -ESTOP -K1 -K2 -K1 -K2 -LED2 -LED1 -K1. -[...]

WIRING-DISK 86317500 CHARIOT SCRUBBER 11/15/08 5-68 LED B+ INHIBIT OPTIONAL -10K -HM -BRAKE/SW ROTARY -X11 -F1.6A -X17 -HORN/ SW -X14 -K1 -X13 -HORN -ESTOP -KEY -R1/5KPOT -K2 -K1 -X6 -X12 -X5 -X3 -X2 -X1 -X15 -X19 -X7 -X16 -X8 -X 18 -X9 -X 10 -X 20 CONNEC TOR C LOW MID HIGH HIGH LOW CHARGER HOURS THROTTLE KEY REV E-STOP & HORN REVERSE ALARM VAC[...]

WIRING-DISK 86317500 CHARIOT SCRUBBER 11/15/08 5-69 / / M -SQUEGE E TRACTION/SOLENOID -WATER -X14 -X12 -18A -18A M -BRUSHR M -BRUSHL -BRAKE M -TRACT ION M -VACUUM B+ B- 24V FOR RELAYS M -SOLUT ION M -DECK -X2 -X1 -X9 -X 8 -X3 -X10 -X4 -X11 AUX4 AUX3 AUX2 AUX1 -U4 +Ubatt CONNECTOR B[...]

WIRING-CYLINDRICAL 86317500 CHARIOT SCRUBBER 11/15/08 5-70 KSI-18 AUXsupplyPIN1 -TO AUX4 / / OPTION AL -FLASHER OPTIONAL -REAR FLAS HER -FRONT FLASHE R -FLASHER UNIT -FLASHER GN D -FLASHER PO WER -ESTOP -K1 -K2 -K1 -K2 -LED2 -LED1 -K1. -REV(K2) -FWRSW -KSI -K2 -K1 -K2. -REV -FWR -PLATFO RM -GND +Ubatt REV FWR[...]

WIRING-CYLINDRICAL 86317500 CHARIOT SCRUBBER 11/15/08 5-71 LED B+ INHIBIT OPTIONAL 38/YEL 67/GR N -10K -HM -BRAKE/SW ROTARY -X11 -F1.6A -X17 -HORN/SW -X14 -K1 -X13 -HORN -ESTOP -KEY -R1/5KP OT -K2 -K1 -X6 -X12 -X5 -X3 -X2 -X1 -X15 -X19 -X7 -X16 -X8 -X18 -X9 -X10 -X20 CONNECTOR C LOW MID HIGH HIGH LOW CHARGER HOURS THROTTLE KEY REV E-STOP & HORN[...]

WIRING-CYLINDRICAL 86317500 CHARIOT SCRUBBER 11/15/08 5-72 / / M -SQUEGEE -WATER -X14 -X12 -18A -18A M -BRUSHR M -BRUSHL -BRAKE M -TRACTION M -VACUUM B+ B- 24V FOR RE LAYS M -SOLUTION M -DECK -X2 -X1 -X9 -X8 -X3 -X10 -X4 -X11 AUX4 AUX3 AUX2 AUX1 CONNECTOR B -U4 +Ubatt -GND[...]

WIRING-DRIVE MOTOR 86317500 CHARIOT SCRUBBER 11/15/08 5-73 1 RED BLK 2 BLK 1 WHT BLK WHT 1 WHT 2 BLK 2 BLK CONTROL PANEL HARNESS[...]

WIRING-DRIVE MOTOR 86317500 CHARIOT SCRUBBER 11/15/08 5-74 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86239120 41522 1 HARNESS, CHARIOT PROPEL[...]

WIRING-MAIN HARNESS 86317500 CHARIOT SCRUBBER 11/15/08 5-75 1 DIAGRAM B DIAGRAM C DIAGRAM D BRUSH RIGHT MOTOR MOTOR BRUSH LEFT SQUEEGEE L IFT ACTUATOR VAC MOTOR ACTUATOR SCRUB LIF T SOLENOID VALVE DRIVE MOTOR PUMP BRAKE A B C HORN 13 O RG 14 BLK 19 WHT 20 BLK 6 BRN 6 BRN 15 YLW 16 BLK 11 RED 10 BLK 17 LT BLU 18 WHT/Y LW 21 WHT/ORG 22 WHT/B LK 12 RE[...]

WIRING-MAIN HARNESS 86317500 CHARIOT SCRUBBER 11/15/08 5-76 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86313710 - 1 HARNESS, MAIN 2 86318640 - 1 HARNESS, PUMP JUMPER CYL ONLY 3 86318650 - 1 HARNESS, BRUSH MOTOR CYL ONLY 4 86318660 - 1 HARNESS BRUSH ACTUATOR CYL ONLY 5 86319780 - 1 HARNESS, WARNING LIGHTS OPTION OPTION[...]

WIRING-PEDAL PLATFORM 86317500 CHARIOT SCRUBBER 11/15/08 5-77 8 BLU 9 RED A 5 GRN 7 BRN 6 ORG DIAGRAM A[...]

WIRING-PEDAL PLATFORM 86317500 CHARIOT SCRUBBER 11/15/08 5-78 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86315100 - 1 HARNESS, PEDAL[...]

HOSE DIAGRAM-DISK 86317500 CHARIOT SCRUBBER 11/15/08 5-79 86282190 (13") PRV 395 41 PRV 39540 SCRUB DECK 86281100 (8") 86281310 (8") 86281310 (8") PRV 39326 SOLENOID PUMP VALVE DRAIN HOSE STRAIN ER (F INE) STRAINER (COARSE) VALVE PRV 39326 PRV 39274 86281940 (40") 86281950 (32") 86315510 PRV 396 16 TANK SHUT-OFF[...]

HOSE DIAGRAM-CYLINDRICAL 86317500 CHARIOT SCRUBBER 11/15/08 5-80 63908920 QUICK DISCONNECT SOLENOID VALVE 86315510 TANK SHUT-OF F PRV 39541 86281950 (32) PRV 39734 86282360 (28") VALVE DRAIN HOSE STRAINER (FINE) STARINER (COARSE) 86281940 (40") PRV 39540 PUMP[...]

SUGGESTED SPARE PARTS 86317500 CHARIOT SCRUBBER 11/15/08 5-81 PART NO. PRV NO. DESCRIPTION SERIAL NO. FROM NOTES 86316160 - BREAKER, 18A, 250VAC, 32VDC 86008900 80845 BOOT, 7/16 CIRCUIT BREAKER 86004440 39717 CAP DRAIN HOSE 86199840 090-12A FLOAT, SHUT OFF 86317770 - GASKET, DOME EDGE 86305960 - HOSE ASM., 1.5” BLK PVC VAC X 67 86004860 48073 KEY[...]

OPTIONS[...]

BATTERY CART - OPTION 86317500 CHARIOT SCRUBBER 11/15/08 6-1 3 3 15 16 3 3 8 3 3 3 3 3 5 5 5 9 24 8 6 30 29 28 27 26 25 2 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1[...]

BATTERY CART - OPTION 86317500 CHARIOT SCRUBBER 11/15/08 6-2 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86006930 70514 2 SCR, 5/16-18 X 1.00 BSHCS SS 2 86254290 730338 4 SPACER, 10D X .343ID, .5 LG 3 86270830 57023 33 NUT, 5/16-18 HEX NYLOCK SS 4 86077010 41517 1 HOUSING, BATTERY CART 5 86010670 87029 7 WASHER, 5/16 FLAT SS 6 862[...]

BATTERY CART - OPTION 86317500 CHARIOT SCRUBBER 11/15/08 6-3 11 13 14 15 6 3 10 12 9 17 3 3 10 10 6 6 8 5 7 7 5 4 3 2 1 10 3 16[...]

BATTERY CART - OPTION 86317500 CHARIOT SCRUBBE R 11/15/08 6-4 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86078330 66478 1 PEDAL, BATTERY CART 2 86276070 70593 2 SCR, 5/16-18 X 3/4 CARRIAGE SS 3 86270830 57023 12 NUT, 5/16-18 HEX NYLOCK SS 4 86087800 730307 2 STIFFENER, PEDAL, BATTERY CART 5 86228840 09124 4 BEARING, FLAN GED .314[...]

SEAT - OPTION 86317500 CHARIOT SCRUBBE R 11/15/08 6-5 2 14 13 12 11 10 9 7 8 6 5 4 3 1 15 17 16 18 19 22 21 20 23 24[...]

SEAT - OPTION 86317500 CHARIOT SCRUBBE R 11/15/08 6-6 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 86248390 730324 1 PAD, REAR REST 2 86082640 629995 1 PLATE, SEAT COVER 3 86276890 70752 4 SCR, 5/16-18 X 3/4 PTHMS SS 4 86279460 87164 2 WASHER, 1/2 SPLIT LOCK 5 86270710 01-000277 1 NUT, WING 3/8-16 6 86271930 57297 1 NUT, 3/8-16 HEX[...]

WARNING LIGHTS - OPTION 86317500 CHARIOT SCRUBBE R 11/15/08 6-7 REAR FRONT 1 6 3 4 3 2 5 1 2 6 7 3[...]

WARNING LIGHTS - OPTION 86317500 CHARIOT SCRUBBE R 11/15/08 6-8 REF PART NO. PRV NO. QTY DESCRIPTION SERIAL NO. FROM NOTES: 1 8627 0990 57090 4 NUT, 10-32 HEX NYLOCK SS 2 8601 0650 87018 4 WASHER, #10 X 6/16 OD 3 8627 6820 70740 4 SCR, 10-32 X 1/2 PTHMS BLK 4 86071490 140871 1 BRKT, UPPER WARNING LIGHT 5 8627 0990 57090 2 NUT, 10-32 HEX NYLOCK SS 6[...]

SERIAL NUMBERS 86317500 CHARIOT SCRUBBE R 11/15/08 6-9 REF. NO. MODEL: SERIAL # 1 N/A[...]